2021 HYUNDAI PALISADE Structurebody Problems

Tried to open sunroof and it came off its track and twisted which caused some pieces to break. It is stuck in an open position. The vehicle has 144,000 miles so it no longer has any warranty coverage. We had to gorilla tape it down otherwise it could fly off while going down the road. I’ve read there has been many of the same incident happening to others.

I tried opening my sunroof and it made a clicking noise and is now stuck partially open. The dealership said that there is a set of Hyundai vehicles that are being covered by this malfunction but that my particular VIN isn't included. A Hyundai dealership is looking at it on Monday 03/17/2025 and is unsure if Hyundai will cover the repair since my VIN isn't included and I am past the bumper to bumper warranty. I only have the powertrain warranty left.

Sunroof shattered without object impact during cold weather.

Paint started chipping… Dealer stated it was from a rock, however a rock chip doesn’t cause a whole section of paint bigger than a quarter to just flake off.. ironically there was another vehicle on the lot having the same issues . Picture is included.. Second issue is the engine It makes a grinding noise when driving almost like the cams or transmission is going to go bad, but i think it’s the timing chain. Lasty the suspension it has clicking noises that cannot be resolved.

While driving down the interstate heard a loud sound, sounding like a shot gun. Looked and the sunroof shattered. Immediately took it into the dealership and they determined it was not hit by anything and they have been seeing a rise of this happening. They are fixing under warranty and had to give me rental car because they don’t know how long it will take. It was extremely scary and thankfully my sunroof cover was closed. I can easily see this causing a car accident.

The sunroof on our 2021 Hyundai Palisade spontaneously shattered while driving. There were no other vehicles around, it just exploded. Fortunately the shade cover was closed so no glass flew into the vehicle.

1) While I was driving, the “Rear passenger door trim” started to come off of my car. My car was not hit and I did not hit anything. Upon further evaluation, the plastic pieces holding the trim on were broken. How they became broken is unknown. I was able to reattach trim to my car, but it is still loose because the plastic pieces holding the trim on are still broken. 2) It was a safety hazard to others while driving on the road. If it flew off my car while driving on the highway, it could hit other cars, potentially causing an accident. In addition, it was difficult for my child to climb out of the car without getting cut by the trim. 3) my dealer has verified that the trim is broken and loose on my car. 4) the Hyundai dealer has inspected to problem. $550 was the...

Sun roof glass spontaneously shattered while driving on the freeway without hitting anything else with glass falling on to the Sun shade

While driving our Palisade on the freeway, the sunroof exploded without warning. Fortunately, the sunroof was closed and we had the internal compartment closed and no one was behind us on the freeway. So the glass did not enter the vehicle or hit another vehicle. But if the indoor compartment was open then glass would have entered into the vehicle and striking individuals in the car. The shattered glass did do damage to the top of our car (i.e. scratches deep enough to take off the paint completely). Based on online forums, and one law firm’s (based in Connecticut) website, this is a known problem with the Hyundai Palisade. It also appears that the NHTSA is investigating the Kia Sorento for this same problem. Thus, the problem has been replicated in other vehicles and Kia/Hyundai are aware of the problem. Our vehicle has not yet been inspected by anyone (we...

When i was driving on an interstate suddenly the Sunroof glass bursted and shattered in to pieces. There was nothing fell on to us only because I had the sunroof cover closed. I just heard a huge noise like shotgun fired and found out that the glass shattered and blew out a hole in the sunroof glass about 18" across. I was 6 hours from home and took it the the local dealer for review the following day. The dealer did promptly and professionally address the matter and they are covering it under warranty. Many owners of Palisades reported this issue as well

DRIVER SIDE GLASS HAS DEVELOPED A HAIRLINE CRACK APPROXIMATELY 8 INCHES LONG, WHILE VEHICLE WAS PARKED OVERNIGHT IN MY GARAGE.

WE WERE DRIVING AT HIGHWAY SPEED WHEN THE SUNROOF SPONTANEOUSLY EXPLODED. DEALER VERIFIED THAT THERE WAS NO EVIDENCE OF ANY IMPACT.

THE DESIGN OF THE SHIFTING MECHANISM IS BACKWARDS SO THAT DRIVERS MEANING TO PUT THE VEHICLE INTO DRIVE (AND GO FORWARD) WILL EASILY CONFUSE THE BUTTONS AND PUT THE VEHICLE INTO REVERSE (SENDING THE VEHICLE BACKWARDS). THINKING ABOUT A SHIFT KNOB ON A STANDARD VEHICLE, ONE THINKS OF THE KNOB IN "REVERSE" AS BEING BACK TOWARDS THE REAR WINDSHIELD. SAME WITH A MOTORIZED WHEELCHAIR: TO GO FORWARD YOU SELECT THE POSITION IN THE FRONT, AND TO GO BACK, YOU SELECT THE POSITION IN THE BACK. THE CONFUSION HAPPENED TO ME OFTEN ENOUGH THAT I ALWAYS LOOK AT THE BUTTONS CAREFULLY BEFORE GOING FORWARD TO MAKE SURE"D" HAS LIT UP. MY HUSBAND, WHO USUALLY DRIVES ANOTHER CAR, DROVE THIS VEHICLE AND PRESSED "" BY ACCIDENT TWICE AND THE CAR OBVIOUSLY WENT BACKWARDS WHEN HE MEANT TO GO FORWARDS. EVERYONE I ASK HAS AGREED WITH US THAT THE NATURAL (AND THEREFORE MOST...

TOXIC GASEOUS CONTAMINANTS,. DEALER UNDER THE DIRECT GUIDANCE OF THE HYUNDAI CORPORATE TECHNICAL DEPARTMENT. DEALER AND HYUNDAI CORPORATION HAS MADE NUMEROUS ATTEMPTS TO REPAIR THE GASEOUS TOXIC SMELL FROM THIS VEHICLE AND SOLUTIONS ARE NOT CORRECTING THE PROBLEM. I MUST SAY I AM DISAPPOINTED HYUNDAI CORPORATION AND STIVERS HYUNDAI OWNER AND REPRESENTATIVES FAILED TO INFORM US OF THE ONGOING GASEOUS ODOR DILEMMA OF THE PALISADE LIMITED PURCHASED /DEL DAT 11AUG2020 'SICK HOUSE SYNDROME', NAUSEA, OR FATIGUE FROM EXPOSURE TO VOCS. SOME VOCS MAY EVEN CAUSE CANCER WITH A HIGH EXPOSURE CONCENTRATION. AFTER THE VEHICLE HAD BEEN CLOSED UP FOR OVER 24HOURS WE OPENED THE PALISADE AND RECEIVED A GASEOUS CHEMICAL ODOR EMANATING FROM ALL FOUR DOORS AND THE REAR HATCH WHICH WAS BOTH DEBILITATING AND FRIGHTENING. MY WIFE IMMEDIATELY HAD AN ASTHMATIC ATTACK AND CAUSED A HEADACHE WITH BOTH EVENTS REQUIRING MEDICATION . I PERSONALLY WAS CHOKED BY THE ODOR...