2003 HONDA PILOT Suspension Problems

severe erosion of my undecarriage, metal just falls off from under the car. My fuel tank leaks and gas pours out. It has been deemed unsafe to drive by my Honda dealer, but has a good engine and other parts. It has been severely impacted by rust and erosion. The previous owner was a resident of Chicago, where salt is used, which I believe influenced this defect.

My 2003 Honda pilot rear subframe suspension is rusting and causing control issues. This is a common problem on the 2003-2008 Honda Pilots. In Honda TSB 21-019 Honda states " The subframe mounts may pull away from the body of the vehicle (see images below), but extensive testing has concluded that vehicle stability will be maintained." This is NOT true. Other Honda's have experienced similar issues and Honda has issued a safety recall. There should be a safety recall for the 2003-2008 Honda pilots for this subframe rust issue. Please see: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Honda did not contact me for a year and a half I have been waiting for them to replace my air bag, no response!!! I’ve left numerous messages and still no response I gave a 1 year old daughter, we almost got hit by a car and if it had hit us something could’ve happened! Because I had to swerve off road my suspension and power steering are messed up because of pot holes,Just so I wouldn’t hit and impact the passenger side of me my car where airbag is bad and nothing would’ve happened to us, not that it was our fault the driver was driving almost right into us!I blame Honda for this disaster would could have been very bad! Of course the other driver drove away like nothing happened! So now I am stuck at home not able to go to work and bring my daughter to...

REAR SUSPENSION MOUNTING LOCATIONS HAVE RUSTED THROUGH ALLOWING THE REAR SUSPENSION TO HANG DOWN. THE FRONT MOUNTING POINTS OF THE REAR SUSPENSION ARE NOT DAMAGED YET. WAS NOTICED AS A NOISE WHILE DRIVING AND FOUND DURING TIRE INSPECTION.

THE REAR SUB-FRAME ON THE DRIVER'S SIDE OF THIS 2003 HONDA PILOT IS EXTREMELY RUSTED EXPOSING THE SUSPENSION CROSS-MEMBER BOLT WHICH IS SIMILARLY RUSTED. AN INTERNET SEARCH INDICATES THIS IS A COMMON PROBLEM WITH HONDA PILOTS AND A POTENTIAL HIGH-RISK POINT OF FAILURE.

SUSPENSION IS COMPLETED RUSTED OUT FROM FRAME

USING 4 WHEEL DRIVE TO PULL MY BOAT THROUGH THE WOODS, 2 OF THE 4 REAR AXEL MOUNTS PULLED OUT OF THE UNIBODY FRAME AFTER A LOUD CLUNK. CAR WAS ALWAYS MAINTAINED AT THE DEALERSHIP. THE VEHICLE IS NOT REPAIRABLE, THIS SEEMS TO BE A DESIGN FLAW.

THE TRUCK HESITATES IN ORDER TO GET IT TO MOVE YOU HAVE TO TAKE FOOT OFF THE GAS PEDAL.HAPPENS A LOT WHEN DRIVING.SOMETIMES IT STALLS....DRIVER SIDE REAR BODY MOUNT IS RUSTED OUT

WE WERE DRIVING STRAIGHT ON THE HIGHWAY AT ~65 MPH, FULLY LOADED FOR A WEEK-LONG CAMPING TRIP, AND HIT A LARGE POTHOLE. THE REAR WHEEL ASSEMBLY OF MY HONDA PILOT BROKE SO THAT IT WAS ONLY PARTIALLY ATTACHED TO THE FRAME BECAUSE THE FRAME OF THE CAR RUSTED THROUGH. THE 2 BACK BOLTS WERE STILL IN PLACE, BUT THE FRAME ITSELF WAS CRUMBLING APART; THE 2 FRONT BOLTS WERE THE ONLY THINGS HOLDING THE REAR WHEEL AND AXLE TO THE CAR. THE PHOTO SHOWS THE STEEP ANGLE OF THE WHEELS, AND HOW LOW TO THE GROUND THE BACK OF THE CAR WAS. I DROVE THE CAR TO OUR MECHANIC, THEY PUT IT UP ON THE LIFT, AND THEN SHOWED US. THEY TOLD US IT WAS UNFIXABLE. THE CAR IS 14 YEARS OLD AND OTHERWISE IN GOOD SHAPE. IT HAS RECEIVED REGULAR MAINTENANCE (I HAVE 9 YEARS OF MAINTENANCE RECORDS). THE...

LAST MONTH WHILE DRIVING VEHICLE SEEMED A LITTLE LOOSE WHILE GOING DOWN THE ROAD, LOOKED OVER FRONT END AND COULD FIND NO PROBLEMS. DAUGHTER (WHO HAD DRIVEN DAILY) COMPLAINED THAT PROBLEM WAS GETTING WORSE. WHILE BACKING UP SLOWLY MONDAY (3/20/17) , VEHICLE BECAME UNCONTROLLABLE AND SHIFTED LANES. UPON INSPECTION IT HAS BEEN FOUND BOTH REAR SUSPENSION MOUNTING POINTS (REAR MOST 2 OF 4) HAVE RUSTED LOOSE FROM UNIBODY ( COMPLETELY DETACHED). BOUGHT THIS PILOT NEW IN 2003, ALWAYS KEPT UP ON ALL SERVICE AND MAINTENANCE.

FIRST, DOOR LOCKS AUTOMATIC NOW HAVE TO UNLOCK MYSELF, ALONG WITS THE OUTSIDE DOORS.ALARM BUTTON NO LONGER WORKS TO UNLOCK. DOOR HANDLES INSIDE HAVE BEEN PEELING AND ACTUALLY CUT YOUR FINGERS WHEN OPENING THE DOOR, I HAVE MASWING TAPE IN THEM AND IT'S UGLY, FINALLY..LIGHTS INSIDE ARE GOING OUT ON RADIO, DIMMING ON INTERIOR ALSO.

REAR SUSPENSION RUSTED OUT FROM THE FRAME. ONLY ONE SIDE AS OF RIGHT NOW.

OF THE FOUR POSTS WHERE THE COMPLETE REAR AXLE MOUNTS TO THE UNDER BODY OF THE CHASSIS, TWO OF THE POSTS HAVE RUSTED AWAY FROM THE FRAME, LEAVING THE REAR AXLE ONLY HALF ATTACHED TO THE MAIN BODY OF THE CAR. THE VEHICLE HAS VERY LIMITED RUST ANYWHERE, SO FOR THE UNDER BODY TO RUST TO A POINT OF SEPARATION FROM THE REAR WHEEL ASSEMBLY IS DISCONCERTING. WE HAD NO WARNING AND HAD THE VEHICLE PROPERLY/ROUTINELY MAINTAINED. IF THE REAR AXLE ASSEMBLY HAD COMPLETELY BROKEN AWAY, THE RESULTING CRASH WOULD HAVE BEEN DISASTROUS. CERTIFIED MECHANICS CONFIRM THAT THEY HAD NEVER SEEN SUCH A SERIOUS DETERIORATION OF A SIGNIFICANT STRUCTURAL COMPONENT.

I OWN A 2003 HONDA PILOT MY RACK AND PINION IS IN BAD CONDITION SO IS THEIR A RECALL ON THIS YEAR MAKE AND MODEL? MY NUMBER IS [XXX]. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

WHILE MY WIFE WAS DRIVING MY 2003 HONDA PILOT SHE ALMOST LOST CONTROL WITHOUT ANY WARNING. SHE DRIVE IT THE FEW REMAINING MILES HOME AND ASKED ME TO EXAMINE IT FOR A POSSIBLE LOOSE WHEEL. UPON INSPECTION I FOUND THAT THE ENTIRE REAR SUSPENSION HAD SEPARATED FROM THE BODY AND THAT ONLY THE ABS BRAKE WIRES WAS HOLDING IT IN PLACE. THERE WAS NO APPARENT REASON FOR THIS. THERE WAS NOTHING TO EXPLAIN WHY THIS HAD OCCURED

TL* THE CONTACT OWNS A 2003 HONDA PILOT. WHILE MAKING A LEFT TURN AT VARIOUS SPEEDS, THE CONTACT HEARD A NOISE COMING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE BOLT CONNECTING THE SUSPENSION TO THE FRAME HAD CORRODED AND THAT THE SUSPENSION NEEDED TO BE WELDED TO THE FRAME OF THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 160,000.

I AM THE ORIGINAL OWNER OF A 2003 HONDA PILOT. I AM AN OLDER, CAUTIOUS DRIVER AND HAVE BABIED THIS VEHICLE, DOING ALL REGULAR SERVICE AT THE DEALER'S, SO IT WOULD RUN IN TOP SHAPE FOR MANY YEARS TO COME. AROUND SIX MONTHS AGO I NOTICED AT LOWER SPEEDS (20-30 M.P.H.) THE VEHICLE SHUDDERS. TO COUNTER THE PROBLEM I HAVE TO ACCELERATE AND THEN IT GOES AWAY. I HAVE HAD THE DEALER CHECK IT THREE TIMES AND EACH TIME THEY SAY THEY CANNOT REPLICATE THE PROBLEM, WHICH IS HARD TO BELIEVE. LAST WEEK THE D LIGHT STARTED TO FLASH. I TOOK IT INTO THE DEALER RIGHT AWAY AND THEY SAID IT WAS A SENSOR. I ASKED IF THAT COULD BE MAKING THE CAR SHUDDER AND THEY SAID PROBABLY. I HAD THEM CHANGE IT AND THE SHUDDER HAS NOT GONE AWAY. THIS MORNING IT WAS PARTICULARLY HEAVY SO I CALLED THE...

I TOOK MY PILOT IN FOR A SLIPPING TRANSMISSION. I WAS TOLD I HAD BAD MOTOR MOUNTS AND THAT WAS ALLOWING THE TRANSMISSION TO SLIP. I SPENT APPROX. $3600.00 TO HAVE THE MOTOR MOUNTS FIXED, TIMING BELT AND WATER PUMP, FRONT STRUTS, ETC. FIXED. THE PROBLEM STARTED AGAIN, THIS TIME, GETTING A FLASHING "D" LIGHT. TOOK IT BACK IN FOR FAILURE TO FIX THE PROBLEM. HAD 4TH GEAR PRESSURE GEAR REPLACED FOR COST. I NOW HAVE A CHECK ENGINE LIGHT ON POSTING A CODE OF P0730, "INCORRECT GEAR RATIO". I HAVE BEEN INTO HONDA 4 TIMES FOR THIS ISSUE INCLUDING TODAY, AND I WAS TOLD I NEED A NEW TRANSMISSION. I AM OUT OF WARRANTY OF COURSE, BUT I KNOW THERE ARE MANY, MANY COMPLAINTS REGARDING THIS PARTICULAR ISSUE. I DO NOT HAVE THE MONEY TO REPLACE A FAULTY TRANSMISSION THAT WAS BUILT POORLY. I AM WORRIED I MIGHT GET...

2003 HONDA PILOT. CONSUMER STATES MECHANICAL PROBLEMS WITH THE VEHICLE *TGW THE CONSUMER STATED THE DRIVE LIGHT BEGAN TO FLASH INTERMITTENTLY FROM THE BEGINNING OF OWNERSHIP. THE DEALER TOLD THE CONSUMER IT WAS RELATED TO THE GAS CAP NOT BEING SECURED PROPERLY. HOWEVER, ONCE THE TRANSMISSION WAS REPLACED THE LIGHT NO LONGER FLASHED. ON AUGUST 19, 2003 THE VEHICLE WAS TAKEN TO THE DEALER DUE TO A HESITATION ISSUE, BUT THE DEALER WAS UNABLE TO DUPLICATE THE PROBLEM. FOUR MONTHS LATER, THE CHECK ENGINE AND SRS LIGHTS ILLUMINATED. ALSO, THE VTM LIGHTS WERE FLASHING. ON SEPTEMBER 8, 2005 THE TRANSMISSION LIGHT BEGAN FLASHING. THE CONSUMER WAS INFORMED THAT A SPECIAL PART HAD TO ORDERED. THE CONSUMER ALSO STATED THE POWER STEERING PUMP AND GEAR BOX HAD TO BE REPLACED. ALSO, THE EGR, V-TEC SEALS AND O-RING WERE ALL REPLACED TO RECTIFY THE ENGINE LIGHT PROBLEM. THE TIMING BELT AND LEFT...

OUR 2003 HONDA PILOT LOCKED UP ON THE HIGHWAY DUE TO TRANSMISSION FAILURE OF THE 2ND GEAR. WE WERE TRAVELING IN THE 3RD LANE OVER 60 MPH WHEN BOTH FRONT TIRES LOCKED AND WE SKIDDED TO A HALT IN LESS THAN 200 YARDS ON THE HIGHWAY. PRIOR TO OUR VEHICLE BREAKING DOWN, THERE WERE NO SIGNS OF DANGER, NO UNUSUAL SOUNDS, NO BLINKING LIGHTS OR ANY HESITATION WITH THE CAR. OUR VEHICLE HAD 138,400+ MILES AND HAS BEEN SERVICED REGULARLY ACCORDING TO HONDA'S RECOMMENDED MAINTENANCE SCHEDULES, INCLUDING ALL TRANSMISSION FLUID CHANGES. ON MAY 7, 2004 WITH 36,384 MILES, OUR VEHICLE HAD RECEIVED A RETROFIT OF THE A/T OIL JET KIT DUE TO HONDA'S 04-021B SAFETY RECALL ON THE AUTOMATIC TRANSMISSION SECOND GEAR. LUCKILY NO ONE WAS INJURED AND THERE WERE NO OTHER VEHICLES INVOLVED IN THE INCIDENT. THE CAR BEHIND US STOPPED JUST IN TIME TO AVOID A COLLISION. OUR...

HAD TO REPLACE FRONT AND SIDE MOTOR MOUNTS ON MY 2003 HONDA PILOT. THIS WAS AFTER ONLY 67,118 MILES. MECHANIC SAID THIS IS A COMMON PROBLEM WITH THE ORIGINAL MOTOR MOUNTS. THIS COULD BE VERY DANGEROUS. *TR

MY VEHICLE VIBRATES AT HIGHWAY SPEEDS BETWEEN 70-80 MPH. I HAVE TAKEN THE CAR INTO THE DEALER NO LESS THAN 5 TIMES FOR THE PROBLEM AND JUST RECENTLY WAS TOLD THAT HONDA IS AWARE OF THE PROBLEM AND THAT THE VIBRATION IS A CHARACTERISTIC OF THE VEHICLE. UP TO THIS POINT THE DEALER HAS RE-BALANCED THE TIRES OVER AND OVER AND REDONE THE ALIGNMENT. I EVEN PURCHASED BRAND NEW TIRES AND STILL THERE IS THE VIBRATION. THE DEALER ROAD FORCE BALANCED THE TIRES AND STILL THE VIBRATION PROBLEM. THERE ARE MANY PEOPLE COMPLAINING ABOUT THIS PROBLEM ON THE HONDAPILOT.ORG WEBSITE AND THERE APPEARS TO BE NO RESOLUTION. *JB

SINCE OWNING THE VEHICLE IN 8/2002, THERE HAS BEEN A SLIGHT VIBRATION AT SPEEDS AROUND 70 MPH. SINCE CHSNGING THE TIRES RECENTLY, THE PROBLEM IS MORE PRONOUNCED, BUT ONLY WHEN COLD. THE VIBRATION BORDERS ON A SHAKE, AND YOU CAN FEEL IT IN THE STEERING WHEEL AS WELL AS THE FLOORBOARDS.

THE PROBLEM HAS BEEN TRACED TO THE UPPER SHOCK MOUNTS. THEIR DESIGN CAUSES A RATTLE ON SMALL TO MODERATE ROAD IRREGULARITIES. I WAS FORCED TO MAKE A PERSONAL MODIFICATION TO THE MOUNT AS HONDA WOULD NOT ACKNOWLEDGE THE PROBLEM. OTHERS (NATIONAL WEB SITE) HAVE EXPERIENCED THE SAME SYMPTOMS, BUT HONDA SAYS THIS IS CHARASTIC OF VEHICLE. I HAVE BEEN A MAJOR SUPPORTER OF HONDA IN PURCHASES AND THEIR CUSTOMER SERVICE IS INCREDIBILY INSENSITIVE. MY NEXT PURCHASE MAY BE A VW OR VOLVO. SINCE I MODIFIED THE BRACKET, THE SOUND IS NOT THE ISSUE. THE VALUE HONDA HAS PLACED ON MY BUSINESS IS. I CAN DOCUMENT ALL EFFORTS TO RESOLVE THE ISSUE, HOWEVER HONDA DOES NOT WANT TO ADMIT THERE IS A PROBLEM. SURELY I CAN NOT BE THE ONLY ONE TO HAVE THIS ISSUE WITH HONDA AS I HAVE REMAINED PROFESSIONAL AT ALL TIMES. I WILL NOT LET THE ISSUE...

MY HONDA PILOT BECOMES UNSTABLE AT SPEEDS ABOVE 60 MPH, IT RESPONDS AS THOUGH THERE IS PLAY IN THE STEERING AND ANY SMALL ROAD IMPERFECTIONS CAUSE THE VEHICLE TO VEER LEFT OR RIGHT, I TOOK IT TO CUSH HONDA WHERE I PURCHASED THE VEHICLE AND THEY SAID THREE OF FOUR TIRES HAD 52 POUNDS OF AIR IN THE TIRES, WHICH HAD TO HAVE BEEN THERE ON DELIVERY SINCE I HAVE LESS THAN 700 MILES ON THE VEHICLE AND IT HAS NEVER BEEN SERVICED OR HAD AIR PUT IN THE TIRES, THE PROBLEM STILL EXISTS AND IS UNSAFE AT HIGHWAY SPEEDS IN TRAFFIC, THE SERVICE MANAGER CLAIMS ALL PILOTS DO IT AND IT IS A DESIGN PROBLEM? PLEASE ADVISE. *JB