2003 HONDA PILOT — Problems, Recalls & Safety Data

I am the original owner of my 2003 Honda pilot and had to replace the front driver side door actuator years ago. Now all the remaining 3 doors need to have the door actuators replaced. If you're outside the car you cannot open the door. Using the key remote or putting the key into the front door keyhole will NOT unlock or lock the door. You have to be inside the car and lift or depress the lock button to get them to open or to lock it. This is a very dangerous situation for if an emergency should occur and it's necessary to either exit the vehicle or enter you won't be able to. I know the later year Honda's has had recalls on door actuators.

The contact owns a 2003 Honda Pilot. The contact stated that while driving at 60 MPH, the vehicle stalled. The contact stated that the vehicle violently jolted forward with several unknown warning lights illuminated. The contact drove the vehicle to the shoulder of the road. The failure had occurred while driving on a major highway. The vehicle was driven to the residence. The vehicle was taken to an independent mechanic, where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was being repaired. The dealer was made aware of the failure. The manufacturer was made aware of the failure but provided no assistance. The contact referenced Technical Service Bulletin: 04-021; however, the contact was informed that the repair had been performed on the vehicle in 2004. The failure mileage was approximately 131,000.

The contact owns a 2003 Honda Pilot. The contact stated that while starting the vehicle, the vehicle failed to shift into gear properly, with the check engine warning light illuminated. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 148,118.

The contact owns a 2003 Honda Pilot. The contact stated that while starting the vehicle, the vehicle failed to shift into gear properly, with the check engine warning light illuminated. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 148,118.

Reporting an important safety issue I experienced due to random engine stalling on my 2003 Honda Pilot, typically after driving for a few minutes. The engine would crank for several seconds or sometimes start immediately after stalling, but no diagnostic trouble codes were ever stored. The vehicle had stable fuel trims and idle, and multiple components including the EGR valve and valve clearance were serviced without resolving the issue. Ultimately, the root cause was traced to a failing PGM-FI (fuel pump) relay located under the driver’s dash. After replacing the relay close to two months ago, the stalling stopped completely. This issue could pose a safety risk if the engine stalls in traffic, especially in a hazardous area where there’s no breakdown lane (construction zone, etc.) , and I believe this factor should consider this a known failure point in aging vehicles of this model. Attached are two images of the new relay zip tied under the driver’s footwell (could not remove the bad relay since it was too difficult to remove from its bracket).