2019 FORD FUSION Engine Problems

May 16, 2023-check engine light activated reading code P0302 Cylinder 2 misfire May 27, 2023-warning light appeared reading engine overheating, and the car would not start. May 27, 2023-took it to the dealership and they advised me I had an internal engine coolant leak and that I needed to replace the short block and head gasket. I was quoted $7600! After doing some research I discovered it is an unaddressed recall from Ford and that NHTSA issued Bulletin# 21N12. Letters went out June 20, 2022 for a one-time no cost repair. The program ended five months later on November 30,2022. I never received the letter. I called Ford Customer service and they stated they cannot cover the repairs because I'm past the November 30, 2022 deadline.

The contact owns a 2019 Ford Fusion. The contact stated while attempting to start the vehicle, the vehicle hesitated to start. Additionally, the contact stated that the vehicle hesitated to respond while depressing the accelerator pedal. The check engine warning light was illuminated. The contact stated that the failure reoccurred while driving at various speeds and depressing the accelerator pedal. The dealer was contacted and informed the contact that they could not assist as the VIN was not included in a recall. The vehicle was not diagnosed nor repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 92,770.

The contact owns a 2019 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle made abnormal sounds. Additionally, the check engine warning light was illuminated along with several unknown misfire codes. The vehicle was taken to the dealer, who informed the contact that the engine needed to be replaced due to coolant leaking into cylinder #4. The contact related the failure to Technical Service Bulletin: 19-2375 (EcoBoost). The manufacturer was made aware of the failure and referred the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 104,195.

The contact owns a 2019 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power. The vehicle was taken to the dealer, where the contact was informed that coolant was leaking into cylinder #4 and that the engine needed to be replaced. The contact related the failure to Technical Service Bulletin: 19-2208 (Coolant in Cylinders). The manufacturer was made aware of the failure. The failure mileage was 71,353.

The contact owns a 2019 Ford Fusion. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. Additionally, the contact stated that the vehicle was taken to an independent mechanic for routine maintenance where the oil and spark plugs were changed; however, the vehicle was diagnosed and produced code: P0302. The contact was advised to take the vehicle to the dealer. The vehicle was then taken to the dealer where it was diagnosed that the engine needed to be replaced. The technician informed the contact of Customer Satisfaction Program 19B37 and REF: Technical Service Bulletin (TSB) 22-2134. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was provided a case number. The failure mileage was approximately 90,000.

Unknown, I have had to refill my antifreeze 2 times in one month. Took it to the mechanic and they believe that the problem is with the gasket leading to the engine.

*Upon check engine light, oriellys advised of misfire on p0301- installed following day due to part shipping to store. Day after coil ignition and spark plug replacement, engine light came back on which mechanic said not to worry as long as car isnt shaking. The following day after taking kids to school, the battery died at the school. With only the check engine light on I waited 10 minutes and the car started. On my way home on the highway, the car just stalled in the middle of the highway. There was a brief alarm stating coolant temperature high turn off car. Several dealerships advised soonest availability was December. I needed my car asap. I had it towed to pepboys who did a full diagnostic and provided documentation saying I'd need a new engine. 78250 miles, premium gas, annual premium treatment at oil changes with royal purple, schedule a tuneup...

I have 69,400 miles on my car. Last week, out of no where, the engine started shaking and clicking very loud. The repair shop said the flex plate is cracked and it’s a common issue with Ford. I went to the dealership and they even said it happens all the time. This is nearly a $2000 job. Why isn’t there a recall?!

The contact owns a 2019 Ford Fusion. The contact stated while driving approximately 10 MPH and decelerating at a stop light, the vehicle hesitated and stalled. No warning light was illuminated. The vehicle was towed to the dealer where it was diagnosed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was advised to call the NHTSA Hotline, but no further assistance was provided. The failure mileage was approximately 28,000.

2019 Ford Fusion SE. Car kept stalling and running hot. I took it in and there’s coolant in the cylinders, which means new engine. Haven’t had the car a year and a half. Chevy sent me to Ford, Ford wants my extended warranty to pay for it. If it does, I’ll be capped off and still have to come up with $1000!!

A few months ago, I began to notice that my engine would shake a little upon startup but would stop and run normally after a few seconds. This wouldn't happen every time I started my vehicle so I didn't pay much attention to it until my check engine light eventually came on one day after startup. I brought my car to an auto parts shop to have the OBII read and it came up as a misfire in cylinder 4. I contacted my Ford dealer and made an appointment for the following day. Upon taking my car to the dealer, they informed me that my car is leaking coolant into cylinder 4 and that is why it was misfiring. They told me that this was an issue that Ford was aware of but did not have a fix for, aside from replacing the engine. I was told that I could...

2019 Ford Fusion Titanium coolant infusion into cylinder #2. I Took the car to the dealer because the coolant reservoir was always low. I always had to add coolant in a weekly bases but I never notice any leaks. The dealer told me that since there was no check engine lights on it was something normal. I continued to add coolant every now and then. About six(6) months later, the engine stopped. My father came to help and after checking my car told me there was coolant mixing with the motor oil. He asked me if there was a check engine light on or if the car heated up at any moment. No, my car never heated up and there was never a check light on. He towed the car to Tropical Ford, Orlando Fl. The Ford dealer told me I need a new engine and the repair was gonna...

I bought this vehicle in 2019 and one of the engines cylinders was crack and now I need a new engine and I heard that this a very common problem with this vehicle

Car has been blowing excessive smoke from the exhaust only on start up after car has been parked for a few hours. Ford acknowledged new engine was needed however a week after my car had been waiting for the engine ford said it didn't need an engine. Started after the first oil change at about 9000 miles car stalled immediately after I left the dealership from getting an oil change.

The contact owns a 2019 Ford Fusion. The contact stated that while operating the vehicle, there was an abnormal noise coming from under the dashboard. In addition, there was excessive tailpipe smoke along with a strong fuel odor when the vehicle was idled. The vehicle was taken to the local dealer who diagnosed that the engine small block was damaged due to low coolant. As a result, the engine needed to be replaced. The vehicle was not repaired. The contact was informed that the damage was caused due to improper manufacturing of the engine in which two different types of metals were used causing the engine to cool down at different rates. The vehicle was previously serviced under Customer Satisfaction Program: 19B37. The manufacturer was not notified of the failure. The failure mileage was 28,000.

Coolant leaking into motor

The contact owns a 2019 Ford Fusion. The contact stated that the vehicle was making a rattling noise coming from the engine compartment while idling. The vehicle was taken to a local mechanic where it was diagnosed with needing the flex plate replaced. The vehicle was repaired however, the failure persisted. The manufacturer was informed of the failure and the contact was awaiting a response. The failure mileage was approximately 52,500.

Vehicle stalls after getting gas. This is due to the canister purge valve not working correctly. It’s a common problem amongst fusion owners.

The contact owns a 2019 Ford Fusion. The contact stated that after starting the vehicle, the check engine warning light remained illuminated. The vehicle was taken to the local unknown dealer who diagnosed that the engine was faulty and needed to be replaced. No further information was available. The vehicle was not yet repaired. The manufacturer was not notified of the failure. The failure mileage was 80,000.

The contact owns a 2019 Ford Fusion. The contact stated that the check engine warning lights was illuminated. The vehicle was taken to a local dealer where it was diagnosed with needing the engine replaced. The vehicle was not repaired. The manufacturer was informed of the failure and told the contact to call NHTSA for assistance. The failure mileage was 25,841.

Cracked flex plate requiring new engine (out of warranty)

Was told by mechanic that new engine was needed. We have had this same issue happen to three of our 2019 Fusion's (company cars).

About a week or so ago I went out to crank my car and it sounded awful It was shuttering, sounded like it was going to shut off and the engine light came on, it's a 2019 Ford Fusion. I notice it does this every morning, well I took it to the dealer ship today, they said I have coolant leaking into the Engine.

Started the car with 24,007 miles on ODO and check eng light came on running real rough looked into ford pass app and it stated that it had a power train issue and misfire of cylinder. Took to dealership and was told that the short block had to be replaced to to coolant leaking into #2 cylinder from a crack.

CAR SHUDDERS/SHAKES INTERMITTENTLY ON COLD STARTS. CHECK ENGINE LIGHT CAME ON MAY 3 AT 11AM. TAKEN TO DEALER ON MAY 3 AT 4PM. AFTER DEALER INSPECTION, ADVISED ON MAY 5 THAT COOLANT LEAK INTO CYLINDERS IS REQUIRING A NEW ENGINE AT 28,700 MILES. DEALER ADVISED THERE IS A TSB ON THIS AND IT IS A COMMON PROBLEM WITH THE ENGINE.

COMING TO STOP AT A PARKING LOT AND ALL OF SUDDEN THE CAR ACCELERATED (SEEM LIKED 90 MPH) ON IT'S OWN JUMPED THE CURB WENT UP ON THE LAWN BEFORE I COULD REACT AND APPLIED THE BRAKES! I WAS PROBABLY ALMOST STOPPED BEFORE THE CAR RAPIDLY ACCELERATED FOR NO REASON!

T O WHOM IT MAY CONCERN, THANK YOU FOR ASSISTING ME DURING THIS PROCESS. MY CAR I PURCHASED NEW AND I WOULD LIKE TO SAY A FEW MONTH INTO OWNING MY CAR IVE HAD SERVAL INCIDENCE WHERE MY CAR WOULD COMPLETELY SHUT OFF WHILE I'M A RED LIGHT FOR AWHILE DUE TO TRAFFICS. MY CAR HAS AN ECO BUTTON WHERE I CAN TURN IT OFF AND ON SO IT DOESN'T 'SHUT DOWN' WHEN I COME TO A STOP. THE REASON I'M SO UPSET WITH THIS IS BECAUSE 2-3 TIMES IT'S HAPPENED TO I'VE HAD MY TODDLER WITH ME AND IN ORDER FOR ME TO GO (WHEN THE CAR SHOULD AUTOMATICALLY TURN ON ONCE I REMOVE MY FOOT FROM THE BREAK), I HAVE TO TURN OFF MY CAR AND TURN IT BACK ON AND IT'S HAPPENED DURING TRAFFIC AND BUG INTERACTIONS. I DON'T FEEL SAFE IN MY CAR AND MOST IMPORTANTLY...

ON MY 2019 FORD FUSION THE CHECK ENGINE LIGHT CAME ON FOR MY FUEL SYSTEM. IT IS READING THAT I HAVE A FAULTY PURGE VALVE. THE CODE WAS P0456.

I WAS DRIVING OUT OF A STORE AND ALL OF A SUDDEN THE VEHICLE HAD THE BATTERY ENGINE COME OUT AND OTHER WEIRD VERBIAGE IVE NEVER SEEN. ALL OF A SUDDEN MY VEHICLE JUST STOP , BRAKES BECAME TOO STIFF TO TURN BACK THE VEHICLE AS YOU ARE SUPPOSE TO PRESS THE BRAKE AND PUSH THE START BUTTON. I WAIT WITH MY 9 YEAR OLD DAUGHTER ON A BUSY STREET AND IT WAS OVER 100 DEGREE WEATHER. WE WAITED MAYB 10MINS AND THE BRAKE BECAME SOMEONE MANAGEABLE TO PUSH AND THE VEHICLE STARTED AS SOON AS IT DID START SMOKE STARTED COMING OUT FROM THE HOOD DROVE TO A NEAR BY BUSINESS AND HAD TO WAIT OVER W HOURS FOR A TOW TRUCK. THIS IS SUCH A SAFETY HAZARD AS A MOTHER YOU WANT THE VEHICLE YOU DRIVE TO BE AS SAFE AS POSSIBLE BUT FOR A BRAND NEW VEHICLE...

I HAD A RECALL REGARDING A COOLANT RELATED ISSUE. THIS WOULD CAUSE A MISFIRE, DAMAGING THE ENGINE AND CAT CONVERTER. I TOOK THE CAR DEALERSHIP. THEY SAID THEY FIXED. FOLLOWING DAY ENGINE LIGHT CAME ON. TOOK IT THE DEALERSHIP AGAIN. I AM TOLD ENGINE NEED TO BE REPLACED. THE CAR IS SITTING THERE. IT WOULD TAKE COUPLE MONTHS TO REPAIR THEY SAID. CAR HAS 18K MILEAGE ON IT. 2019 FORD FUSION.

SO WHEN I'M DRIVING DOWN THE ROAD IT WILL START DOING WEIRD STUFF .. LIKE JERKING AND APPLYING THE BREAKS AND THEN THE CAR JUST SHUTS OFF AND THEN IT TAKE ABOUT A COUPLE MINS FOR IT TO COME BACK ON SO I THINK THIS IS A DANGER & SAFETY HAZARD

PRIOR TO RECALL NOTICE; ON 12-20-19 HUSBAND NOTICED COOLANT L LEVEL DOWN AT APPROXIMATELY 7,000 MILES. WENT TO LOCAL FORD DEALER TO PURCHASE COOLANT. WHILE THERE DEALER ASKED SEVERAL QUESTIONS CONCERNING SPECIFICS; LIKE, IS COOLANT LEAKING FROM YOUR ENGINE AND IS IT VISIBLE ON THE GROUND; HUSBAND SAID NO. RETUNED HOME WITH COOLANT AND FILLED THE RESERVOIR. JANUARY 18TH, 2020, RECEIVE RECALL NOTICE FROM FORD ADVISING COOLANT MAY BE INTRUDING INTO THE CYLINDERS; ADVISING TO CONTACT LOCAL DEALER FOR SERVICE. JANUARY 21ST, CAR INTO SERVICE TO REPROGRAM POWER TRAIN /CLEARED ALL CODES. JANUARY 22ST, 2020 TOOK AN 81 MILE TRIP TO LAKE AND BACK; HOURS LATER CHECKED THE COOLANT AND IT WAS DOWN AGAIN 5/8 'S INCH FROM MAX. JANUARY 23RD CALLED THE SCHEDULED ANOTHER APPT FOR JANUARY 29TH. JANUARY 29TH 2020, MCSPADDEN FORD HAD VEHICLE FOR 4.5 HOURS TO CONTINUE INVESTIGATION INTO EXCESSIVE COOLANT USE. UPON PICK UP OF...

STARTED THE CAR MANUAL AND A POWER TRAIN MALFUNCTION WILL COME ON MY FORD PASS APP. ALSO ON THE DASHBOARD IT WILL SAY SHIFT SYSTEM FAULT. ONCE I PUT THE CAR IN DRIVE THE SERVICE LIGHT DISAPPEARS. THE VEHICLE WAS IN MY DRIVEWAY STATIONARY. ON 1 OTHER OCCASIONS JANUARY 1ST 2020 THE CAR WAS IN MY DRIVEWAY STATIONARY. I STARTED THE CAR MANUALLY CAR WOULD NOT START (NO ENGINE TURN OVER) BUT CAR START STOP BUTTON WOULD BE GREEN AS IF CAR WAS RUNNING.

STARTED THE CAR WHETHER MANUAL OR BY REMOTE START A POWERTRAIN MALFUNCTION WILL COME ON MY FORD PASS APP. ALSO ON THE DASHBOARD IT WILL SAY SHIFT SYSTEM FAULT. ONCE I PUT THE CAR IN DRIVE THE SERVICE LIGHT DISAPPEARS. THE VEHICLE WAS IN MY DRIVEWAY STATIONARY. ON 2 OTHER OCCASIONS SEPTEMBER 18 2019 AND SEPTEMBER 25 2019 THE CAR WAS IN MY DRIVEWAY STATIONARY. I STARTED THE CAR MANUALLY CAR WOULD NOT START (NO ENGINE TURN OVER) BUT CAR START STOP BUTTON WOULD BE GREEN AS IF CAR WAS RUNNING. THE DASHBOARD WOULD SAY FULL ACCESSORY MODE ACTIVE, TRANSMISSION NOT IN PARK, SHIFT SYSTEM MALFUNCTION. THE CAR DASHBOARD WOULD SAY THE CAR WAS IN DRIVE BUT THE TURN DIAL GEAR WOULD SHOW PARK. THE CAR GEAR DIAL WAS ALSO LOCKED AND WOULD NOT TURN. IF I TOOK OFF THE EMERGENCY BRAKE THE CAR WOULD ROLL BACKWARDS. ALSO I COULD...