2021 FORD F-350 Power Train Problems

Ongoing Fuel System Failures Related to Recall 24S78 – Request for Escalated Review To Whom It May Concern, My name is [XXX] , and I am the owner of two 2021 Ford F-350 6.7L Power Stroke Diesel trucks, both of which are affected by Recall 24S78 / NHTSA Campaign 24V957 concerning biodiesel deposit accumulation in the fuel system and a pending PCM software update. Vehicle Information: VIN [XXX] VIN [XXX] Both vehicles have already experienced critical failures that directly align with the described defect in the recall, including: Failure of the CP4 high-pressure fuel pump Repeated clogging of the water/fuel separator filter Loss of power, extended crank times, and intermittent no-start conditions These issues occurred prior to the recall remedy being available and have compromised vehicle performance and safety. I am requesting: A full inspection and evaluation of the fuel systems under the scope of Recall 24S78 once the software...

Ford knew there was an issue back in 2021 as they so filed with your agency. Yet waited. Then warranty claims continued. Now, four years later they file as a safety issue, BUT have told me twice in phone calls that I can drive the truck, despite it could shut down on it's own while driving. I tow donated RV trailers to the North Carolina disaster, now I cannot as my dealership advised I not go on long trips. Ford refuses a like loaner, or any loaner at all. This is a Ford issue, not mine nor the dealership and Ford needs to either replace all suspected parts, have a resolution now or proved no charge loaners of like kind to all owners. This approach by Ford is totally unacceptable as they in two phone calls to corporate never once said to not drive the truck and the letter I...

Transmission lunges forward at times even when putting into park position and starting vehicle. Also, when driving down the road vehicle jerks or bucks and throws you forward. Periodically, there is a complete loss of transmission function then you hear large bang and truck jerks forward. This has been reported to Fenton Ford Camden, NY several times and they cannot seem to find issue and stated if it doesnt duplicate happening when they have vehicle there is nothing they can do about it. This has become a serious safety concern when truck jerks forward when starting and park position and lunges forward in traffic. Thank you for your anticipated, cooperation and help resolving this serious safety matter. Thank You, [XXX] - Vehicle Owner INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Transmission shifts erratically and sometimes completely doesn’t work. Has left me in traffic with no ability to negotiate vehicle and was almost hit on multiple occasions. There is a recall on vehicles built before 8-20 Kentucky but my vehicle build date is 11-20. The local dealer said nothing they can do until my 11-20 Kentucky build date truck is included. No offer of loaner and truck is NOT SAFE TO DRIVE !!!!! This has left me without.... transportation..... faith in Ford trucks Also. ..... same vehicle has the 7.3 ( Godzilla ). Dead miss in 1 cylinder. Internet information says not common but it has happened on multiple occasions. Stuck lifter which causes loss of oil pressure and scoring of cylinder walls. Local Ford dealership said replace 1 head with remanned parts and new pistons. My F350 has 58000 miles one would think it should last longer than that My...

The contact owns a 2021 Ford F-350. The contact received notification of NHTSA Campaign Number: 21V536000 (Power Train) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The rear axle repair was not completed and yet they reported that the dealer fixed it. Not true. The truck was taken in for repairs but the dealer was not able to fix it and told me that. They said I will have to get it fixed on my own. The rear axle is a known flaw and was required to repair or replace by the NHTSA. I wonder how many other trucks have also had incomplete repairs and then reported as fixed?

I have owned the truck for just over a year and in that time occasionally when I put my vehicle in park and get out of the truck it will start moving without me touching it. It has happen 5 or 6 times within the year. I took it to the dealer and they told me there is nothing they can do unless the could recreate the problem. This situation is extremely dangerous especially if someone is in the way. One time when it did it the truck ran into my camper and broke the tongue jack. Another time it took off and ran into my hunting camp gate severely bending a solid steel gate. I was just about to step in front of the truck to go unlock the gate when it happened. One second longer I would have probably been killed. The last time it happened was about...

I was recently informed by Ford that my vehicle is subject to a recall (21S31) because the rear axle may deform and detach from the vehicle. I believe the Ford Safety Recall Report (and NHTSA Recall Number) is 21V-536. My concern is related to the proposed remedy. Ford States that additional welds will be applied to the axle. Based on the information provided, I believe this will only mask the symptoms of a failure (detachment of the axle), and not the problem itself (crushing of the axle tubes due to insufficient tube wall thickness). I am a licensed professional engineer, which is to say that I have a basic understanding of material behaviour. With this in mind, I would respectfully ask you to consider the following: 1) Primary: Outright replacement of the defect axle housing with a unit that is manufactured with the "old design" axle tubes. If item 1...