2005 FORD F-350 SD Power Trainautomatic Transmission Problems

MY 2005 FORD 350 4X4 CRACKED THE TRANS CASE BECAUSE OR THE LOW/REVERSE SNAP RING CAME LOOSE & BROKE THE TRANS CASE AT 55000 MI. TALKED TO FORD ABOUT THIS & THEY SAID THERE IS NOTHING THEY COULD DO &THERE HAS NOT BEEN A PROBLEM WITH THIS, BUT I FOUND OUT THAT THEY HAVE HAD A PROBLEM & HAD A RECALL ON THIS (RECALL #05B27). FORD DEALER SAID THAT THIS WOULD COST ME $4622.00. THEY FIXED THIS PROBLEM I THINK IN THE 2006 MODELS THEREFORE THEY KNEW THEY HAD A PROBLEM. MY WARRANTY RAN OUT ON THIS TRUCK ABOUT 1 MONTH AGO. *TR

ABOUT A MILE AFTER I TURNED OFF OF HWY 101 ONTO HWY 166 GOING EAST WHILE HAULING MY 32' TOYHAULER WITH MY 2005 FORD F350 SUPERDUTY 4X4 DRW CREW CAB TRUCK WHEN SMOKE STARTED BILLOWING OUT THE REAR OF MY TRUCK, A FRIEND THAT WAS FOLLOWING ME THOUGHT MY TRUCK WAS ON FIRE AS FLUID SPRINKLED ON HIS WINDSHIELD. I WAS NOT ABLE TO SAFELY PULL OVER FOR A COUPLE OF MILES. WHEN I STOPPED I FOUND THAT MY TRANSMISSION FLUID HAD SPEWED OUT ONTO THE TAIL PIPE OF THE TRUCK THAT CAUSED THE SMOKE AND ALL OVER THE HIGHWAY. I HAD THE TRUCK AND TRAILER TOWED TO SANTA MARIA FORD AND HAD TO WAIT A DAY FOR THEM TO OPEN. WHEN THEY INSPECTED THE TRANSMISSION, THE MECHANIC TOLD ME THAT THE PROBLEM WAS A FAULTY RETAINER (SNAP) RING THAT CAME OFF (UNSEATED) THE LOW/REVERSE CLUTCH THAT CAUSED THE CRACK...

TL*THE CONTACT OWNS A 2005 FORD F-350 SUPERDUTY. WHEN THE VEHICLE WAS PLACED INTO REVERSE, IT WOULD NOT BACK UP. THE VEHICLE WAS DRIVEN TO THE DEALER AND THEY STATED THAT THE REVERSE CLUTCH RETAINER RING, THE REVERSE PISTON RETAINER RING, THE CLUTCH HOUSING, AND THE TRANSMISSION CASE NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS 63,726.

08/2007 AT 27,127 MILES FORD F350 SUPERDUTY WAS TAKEN IN TO DEALER FOR REPAIR DUE TO THE FOLLOWING: HESITATION UPON ACCELERATION AND TRANSMISSION CATCHING AND LOUD BANG, LIKE IT IS JERKING INTO GEAR. DEALER REPAIRED UNDER WARRANTY. 08/2008 AT 36,800 MILES (JUST OUT OF WARRANTY) TAKEN IN AGAIN FOR SAME PROBLEM AND DEALER WANT TO CHARGE US TO REPLACE TRANSMISSION. THE VEHICLE HAS NEVER BEEN USED TO PULL TRAILERS OR HEAVY EQUIPMENT SO THERE IS NO REASON FOR THE TRANSMISSION TO BE FAILING WITH SO LITTLE MILEAGE. *TR

I'VE HAD MY 05 'F-350 DIESEL IN THE SHOP FOR MORE THAN A TOTAL OF 10 WEEKS BLOWN HEAD GASKETS BLOWN HEADS AND TRANSMISSION PROBLEMS WHICH NO ONE CAN SEEM TO FIX CORRECTLY I PERSONALLY THINK FOR SHOULD HAVE A RECALL ON THESE TRUCKS. *JB

DT: THE CONTACT STATED THE VEHICLE STALLED INTERMITTENTLY. THE FIRST TIME THE VEHICLE STALLED IT IMMEDIATELY RESTARTED. THE SECOND TIME THE VEHICLE STALLED IT WAS TOWED TO THE DEALERSHIP. DURING BOTH INCIDENTS THE VEHICLE WAS TRAVELING AT 70 MPH. THE DEALERSHIP REPLACED THE FUEL SYSTEM INJECTORS AND MODULES. AFTER THE REPLACEMENTS THE ENGINE BLEW OUT. ADDITIONALLY, THE DEALER DIAGNOSED A PROBLEM WITH THE TRANSMISSION AT 8,000 MILES, AND REPAIRS WERE MADE. BASED ON ALL THE PROBLEMS WITH THIS VEHICLE, IT HAS BEEN AT THE DEALERSHIP FOR THREE MONTHS. *AK

DT: THE CONTACT STATED WHILE MAKING A RIGHT HAND TURN THE VEHICLE HESITATED. THE TRANSMISSION WILL CATCH, AND THERE IS A LOUD BANG , AND THEN THE VEHICLE WILL LUNGE FORWARD. WHEN THE VEHICLE IS IN REVERSE THE TRANSMISSION HESITATES AS WELL. IT SEEMS AS THOUGH THERE MAY BE SOMETHING BROKEN IN THE TRANSMISSION OR IN THE REAR SUSPENSION. THE DEALERSHIP WHERE THE VEHICLE WAS PURCHASED REFERRED THE CONTACT TO A LOCAL DEALER TO HAVE THE VEHICLE INSPECTED. THE VEHICLE WAS NOT INSPECTED TO DETERMINE THE EXACT CAUSE OF THE PROBLEM. *AK THE CONSUMER HAD DIFFICULTY PLACING THE VEHICLE INTO PARK. UPDATED 11/16/105. *JB

2005 FORD F350 EXPERIENCED SOLENOID TRANSMISSION PROBLEMS. *MR THE SOLENOID TRANSMISSION PROBLEM OCCURRED 50 DAYS AFTER THE PURCHASE OF THE VEHICLE. THE BRAKE BOOSTER FAILED AND THE HIGH PRESSURE ENGINE OIL PUMP HAD BROKEN DOWN. *SC *JB

2005, F350 TORQUE CONVERTER/SHIFT TRANSMISSION SNAP RING FAILED. TRUCK HAS BEEN AT DEALER FOR SEVEN DAYS, AND FORD ZONE REPRESENTATIVE SAYS THERE IS NO SILUTIONFOR THE DEFECTIVE SNAP RING. WILL NOT GIVE ANY REPAIR DATE.*AK