2005 FORD F-350 SD Electrical System Problems

VEHICLE STALL/DIE WHILE DRIVING WITHOUT ANY WARNING. WHEN THE VEHICLE DIES, UNABLE TO TURN THE STEERING WHEEL AND NO POWER AT ALL. HAVE A RECALL NUMBER 05S34, BUT FORD DEALERSHIP WON'T REPAIR IT BECAUSE MY VIN ISN'T ON RECALL. WHAT SHOULD I DO NEXT?

TL* THE CONTACT OWNS A 2005 FORD F-350SD. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS RESTARTED AND RESUMED NORMALLY. THE FAILURE RECURRED AND THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 05V27000 (ELECTRICAL SYSTEM) HOWEVER, THE VIN WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 137,000. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2005 FORD F-350 SD. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. AFTER SEVERAL ATTEMPTS THE CONTACT WAS ABLE TO START THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN STATED THE FUEL INJECTION CONTROL MODULE WOULD HAVE TO BE REPLACED. THERE WAS A RECALL UNDER NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM) HOWEVER, THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 97,300.

TL* THE CONTACT OWNS A 2005 FORD F-350 SD. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE, STATING THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 170,000 AND THE CURRENT MILEAGE WAS 180,000. *TR

TL* THE CONTACT OWNS A 2005 FORD F-350 SD. THE CONTACT STATED THAT THE VEHICLE LUNGED FORWARD AND STALLED. THIS FAILURE OCCURRED ON MORE THAN ONE OCCASION. THE CONTACT STATED THAT THE VEHICLE WOULD NOT ALWAYS RESTART. THE CONTACT FOUND NHTSA RECALL CAMPAIGN ID NUMBER: 05V270000 (ELECTRICAL SYSTEM) BUT THE MANUFACTURER STATED THE VEHICLE WAS NOT INCLUDED. THE DEALER TOLD THE CONTACT THEY WERE NOT SURE OF WHAT CAUSED THE FAILURE. THE FAILURE MILEAGE AND CURRENT MILEAGES WAS 70,000. *TR

TL* THE CONTACT OWNS A 2005 FORD F-350 SD. THE CONTACT STATED THAT WHILE TRAVELING 30 MPH, THE VEHICLE STALLED WITHOUT ANY WARNINGS. THE VEHICLE RESTARTED IMMEDIATELY AFTER THE FAILURE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 05V270000 (ELECTRICAL SYSTEM: WIRING). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 160,000 AND THE CURRENT MILEAGE WAS 166,000.

TL* THE CONTACT OWNS A 2005 FORD F-350 SUPER DUTY. THE CONTACT STATED THAT AFTER REFUELING, THE VEHICLE WOULD NOT RESTART. THE CONTACT HAD TO APPLY STARTING FLUID IN ORDER TO START THE VEHICLE. THE FAILURE WAS EXPERIENCED APPROXIMATELY THREE TIMES. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 05V270000 (ELECTRICAL SYSTEM: WIRING) BUT DID NOT CONFIRM WITH THE MANUFACTURER IF THE VEHICLE WAS INCLUDED IN THE RECALL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ELECTRICAL SYSTEM WIRING HAD MALFUNCTIONED. THE VEHICLE WAS REPAIRED WITH A NEW WIRING HARNESS. THE FAILURE AND THE CURRENT MILEAGE WAS 120,000.

TL* THE CONTACT OWNS A 2005 FORD F350 SD. WHILE DRIVING IN REVERSE AT 2 MPH, THE CONTACT STATED THAT THE VEHICLE SUDDENLY STALLED WITHOUT WARNING. HE REFERENCED THE SIMILARITY TO NHTSA CAMPAIGN ID NUMBER: 05V270000 (ELECTRICAL SYSTEM:WIRING). THE VEHICLE WAS TOWED TO A LOCAL DEALER WHO INSPECTED THE VEHICLE, AND INFORMED THE CONTACT THAT THE FUEL INJECTOR CONTROL MODULE NEEDED TO BE REPLACED. THE MANUFACTURER WAS AWARE OF THE FAILURE. THE VEHICLE HAD NOT BEEN REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 33,000.

TL* THE CONTACT OWNS A 2005 FORD F-350 SD. THE CONTACT STATED THAT THE VEHICLE WOULD OFTEN FAIL TO START AND ONCE STARTED, BLACK SMOKE WOULD EMIT FROM THE EXHAUST PIPE AS THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE PROBLEM BUT REPLACED THE FUEL INJECTION CONTROL MODULE AND FUEL INJECTOR NUMBER FOUR BUT TO NO AVAIL. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHO DIAGNOSED THAT THE SHORT BLOCK WAS CRACKED. THE MANUFACTURER WAS CONTACTED WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 05V270000 (ELECTRICAL SYSTEM:WIRING). THE VEHICLE WAS REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE WAS 75,000.

PULLING INTO DRIVEWAY, MOTOR STARTED RUNNING VERY ROUGH, VEHICLE STALLED AND WOULD NOT RESTART. TOWED TO FORD. REPLACED ENGINE CONTROL MODULE. *TR

DRIVING OVER A MOUNTAIN PASS IN THE SNOW, COMING DOWNHILL AT APPROXIMATELY 5% GRADE WHEN THE THROTTLE BECAME NON-RESPONSIVE. VERY SOON AFTER THE TRUCK DIED COMPLETELY-NO POWER STEERING AND NO POWER BRAKES IN SNOWY CONDITIONS. I MANAGED TO GET THE TRUCK TO THE SIDE OF THE ROAD BUT WASN'T ABLE TO GET MORE THAN 6" OFF THE FOG LINE DUE TO THE SNOW. I WAS VERY LUCKY THAT AN ACCIDENT DID NOT OCCUR BECAUSE ROADWAY CONDITIONS WERE NOT GOOD AND THE SITUATION COULD HAVE HAD DRASTIC CONSEQUENCES. I WAS ALSO VERY LUCKY THAT MY WIFE WAS FOLLOWING CLOSE BEHIND ME AND WE WERE ABLE TO 1) GET CELL PHONE SERVICE ON THE PASS AND 2) WAIT FOR THE TOW TRUCK IN THE OTHER VEHICLE. WE ENDED UP WAITING ON THE SIDE OF THE ROAD FOR 2 HRS IN THE DARK WAITING FOR A TOW TRUCK WITH MY WIFE AND THREE...

THE PAST THREE YEARS WE HAVE HAD OUR FORD 350 SUPERDUTY TRUCK IN THE SHOP DUE TO THE "TOW HAUL" LIGHT WOULD COME ON. LAST YEAR IT HAD STALLED ON ME WHILE CROSSING INTERSECTION AT A FOUR WAY STOP. IT DID NOT HAPPEN UNTIL APPROX. THREE WEEKS AGO, THE TRUCK HAS STALLED SEVERAL TIMES WHILE DRIVING WITHOUT WARNING. IT TOOK THE LOCAL DEALER A WEEK TO FIND OUT THAT IT WAS THE FUEL INJECTION CONTROL MODULE WIRE HARNESS. IF THERE WAS A RECALL ON THE 2003-2004 WHY IS FORD NOT FIXING OUR 2005 THAT IS ALSO STALLING WHILE DRIVING IT. AND THEY COULD NOT REALLY FIND THE PROBLEM WHY THE TOW HAUL LIGHT WAS COMING ON OFTEN. FORD COMPANY TOLD THE LOCAL FORD SERVICE THAT THEY WILL NOT REPLACE THE PARTS FREE AND THE LOCAL FORD SERVICE TOLD US THAT THEY WOULD CUT $400 OFF OF $1700. *TR

I WAS DRIVING AND THE 2005 F350 SHUT OFF AND THE BRAKES AND STEERING BECAME HARD, WHICH MADE IT DIFFICULT TO GET OUT OF THE WAY; WHILE ON THE FREEWAY GOING AT 85 MPH. LUCKILY I WAS PASSING A FORD DEALER AND TOOK THE TRUCK IN. THIS PROBLEM STARTED ABOUT 2 MONTHS AGO AND CONTINUED OFF AND ON.

TL*THE CONTACT OWNS A 2005 FORD F-350 SUPERDUTY. THE CONTACT STATED THAT THE TOW COMMAND WORKS INTERMITTENTLY AND PROVIDES FALSE DATA. THE FAILURE CAUSES THE TRAILER BRAKES TO ENGAGE WHEN THEY SHOULD NOT. THE WARNING MESSAGE INDICATED THAT THE TRAILER WAS DISCONNECTED. THE FORD DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE. THE CURRENT MILEAGE IS 30,000 AND FAILURE MILEAGE WAS 25,000.

I HAVE AN F-350 SUPER DUTY DIESEL. THE TRUCK WAS PARKED IN THE DRIVEWAY @ 7:30 PM. AROUND 12:15 AM, MY WIFE HEARD A LOUD POPPING NOISE AND WHAT SOUNDED LIKE A BANGING TYPE CRASH. SHE THOUGHT A CAR HAD CRASHED OUT IN FRONT OF THE HOUSE, SO SHE LOOKED OUT THE WINDOW AND SAW THE TRUCK WITH FLAMES COMING OUT FROM UNDER THE HOOD. WE CALLED THE FIRE DEPT. AND SPRAYED WATER ON OUR EAVES UNTIL THEY ARRIVED. I WILL NEED TO REPLACE THE EAVES ABOVE THE GARAGE, GARAGE DOORS, SEVERAL ITEMS IN THE GARAGE THAT MELTED OR BURNED AS WELL AS WORK TOOLS AND ALL PERSONAL ITEMS FROM THE TRUCK. I WILL ALSO HAVE TO RE-PAINT MY HOUSE DUE TO THE FIRE AND SMOKE FROM THE TRUCK GOING ACROSS THE FRONT OF MY HOUSE ABOVE THE GARAGE. THE FIRE INVESTIGATOR REPORTS THAT THE FIRE STARTED UNDER THE HOOD....

DT: THE CONTACT STATES THE BRAKES WILL NOT STOP THE VEHICLE WHEN HAULING A TRAILER. HE TOOK THE VEHICLE TO FORD DEALERSHIP TO HAVE THE BRAKES INSPECTED. THERE WAS NOT ENOUGH VOLTAGE GOING TO THE BRAKES TO MAKE THE VEHICLE STOP. THE VEHICLE NEEDED A NEW BRAIN BOX WITH EIGHT VOLTS INSTEAD OF THREE AND ONE HALF VOLTS. THE REPAIRS WILL BE MADE AT THE CONTACT'S EXPENSE. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. *AK