2000 FORD F-350 SD Power Train Problems

MANUAL TRANSMISSION KEEPING HANGING UP AND IS HARD SHIFTING INTO GEARS

DRIVING DOWN THE ROAD THE OTHER DAY IN ARE 2000 F-350 7.3 DIESEL REG CAB CHASSIS TRUCK PULLING 25,000 LB GOOSENECK TRAILER WAS DIS ENGAGING THE CLUTCH WHEN THE CLUTCH ASSEMBLY BROKE THE BUSHINGS WENT OUT AND BROKE LEAVING THE CLUTCH USELESS DRIVING IN BUSY TRAFFIC CLUTCH STAYED STICKING CAUSED A FIRE UNDER VEHICLE. *TR

THE SPARK PLUG LOCATED AT THE REAR OF THE RIGHT CYLINDER BANK OF A 6.8 LITER GASOLINE ENGINE WAS EJECTED. THE SPARK PLUGS IN THIS ENGINE HAVE NEVER BEEN CHANGED TO MY KNOWLEDGE SO THIS IS NOT A RESULT OF IMPROPER TORQUING PROCEDURES. THE ENGINE HAD BEEN OPERATING PROPERLY AND VERY SELDOM HAS GONE OVER 70 MPH. ACCELERATION AT THE TIME OF FAILURE WAS LIGHT AND THE VEHICLE WAS NOT TOWING. NO FIRE ENSUED ALTHOUGH THERE WAS A FAINT GASOLINE ODOR UNDER THE HOOD RIGHT AFTER I SHUT THE ENGINE DOWN. THE FAILURE WAS OBVIOUS BECAUSE THE SPARK PLUG AND ATTACHED COIL PACK WAS LYING ON TOP OF THE CYLINDER HEAD. THE FORD DEALER ACKNOWLEDGED THAT THIS HAS BEEN A PROBLEM IN THESE ENGINES. *TR

TL* THE CONTACT OWNS A 2000 FORD F350 SUPER DUTY. THE CONTACT STATED THAT THE CLUTCH ARM BROKE WHILE THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH. THE VEHICLE WAS REPAIRED BY THE CONTACT. THE MANUFACTURER AND DEALER WERE CONTACTED TO REPORT THE FAILURE. THE FAILURE MILEAGE WAS 151,000 AND THE CURRENT MILEAGE WAS 154,000. UPDATED 08/31/11*LJ UPDATED 2/9/12 *CN

SPARK PLUG SHOOTING OUT OF HEAD AND RAPID LOSS OF POWER AND LOSING CONTROL OF VEHICLE DUE TO SPEED AND HAULING CAMPER GOING UP HILL SPARK PLUG BLOWS OUT OF HEAD AND YOU GOT NOTHING ENGINE STALL AFTER CALLING DEALER WAS TOLD THIS IS NOT A SAFETY ISSUE I SAY WHAT HAPPENS WHEN SPARK PLUG GOES THROUGH HOOD THROUGH WINDSHIELD AND CAUSE ACCIDENT OR DEATH ???? AFTER FURTHER LOOKING IN TO THIS I KNOW OF AT LEAST 12 OTHERS WITH SAME PROBLEM WHY CANT FORD PUT CAST IRON HEADS ON. *TR