2000 FORD F-250 Engine And Engine Cooling Problems

SPARK PLUG BLOW-OUT ON #4 CYL, POTENTIAL FIRE HAZARD. *TR

I WAS DRIVING MY 2000 FORD F-250 SUPER DUTY PICK UP TRUCK AT 35 MPH, WHEN I HEARD A LOUD BANG, I PULLED OVER RIGHT AWAY , WHEN I POPPED THE HOOD, I SEEN THE COIL WITH THE SPARK PLUG ON THE OTHER END ! IT HAD BLOWN RIGHT OUT OF THE ENGINE ! I HAVE READ A LOT OF BLOGS OUT THEIR AND I WAS VERY LUCKY, BECAUSE SOME PEOPLE HAVE HAD THIS HAPPEN AND THE PLUG BLEW OUT WITH SUCH FORCE IT HIT THE FUEL INJECTORS AND CAUSE AN ENGINE FIRE ! I DO NOT HAVE THE AMOUNT OF MONEY THAT FORD IS CHARGING TO FIX THIS ISSUES THAT THEY HAVE KNOWN FOR YEARS THAT I HAVE BEEN READING ! THEIR HAS BEEN PEOPLE THAT ARE RETAPPING WHERE THE PLUGS ARE GOING INTO ONLY TO HAVE THIS HAPPEN TO ANOTHER SPARK PLUG ! SOMEONE IS GOING TO GET...

THE SAME PLUG BLEW OUT AGAIN. *TR

THIS IS THE THIRD TIME THE SAME SPARK PLUG HAS BLOWN OUT!!! *TR

I BOUGHT A NEW ENGINE ABOUT 5 YEARS AGO AND THE SPARK PLUG BLEW OUT. GOT IT "FIXED" FOR $200. *TR

BLEW #2 PLUG OUT OF CYLINDER HEAD ON A FORD F 250 V10 TRITON ENGINE AT 36K MILES AND THEN RECENTLY AT 85 K MILES. PROBLEM LIES IN THE MANUFACTURING/DESIGN BY FORD. SPARK PLUGS HAVE FEW THREADS TO HOLD THEM IN THE CYLINDERS. ALSO ALUMINUM HEADS WON'T HOLD THE PLUGS. THOUSANDS ARE HAVING THIS SAME PROBLEM WITH THEIR FORDS. WHY NO RECALL????? I HAVE TO REPLACE THE HEAD TOTALING NEARLY $ 4000.00 TO FIX THIS! TALKED TO 3 OTHER FORD TRUCK OWNERS LOCALLY, AND THEY ALL HAVE HAD PLUGS BLOW OUT OF THEIR FORD TRUCKS TOO! WHAT GIVES????? THIS IS SAD AS THIS HAS BEEN HAPPENING FOR SEVERAL YEARS NOW AND FORD STILL FEELS LIKE THEY ARE NOT RESPONSIBLE!!! *TR

TL*THE CONTACT OWNS A 2000 FORD F250. THE CONTACT STATED THE VEHICLE CAUGHT FIRE WHILE PARKED AND THE FIRE SPREAD TO THE CAB AND TIRES. THE FIRE DEPARTMENT STATED THAT THE FIRE ORIGINATED UNDER THE HOOD. THE CONTACT PLANNED TO SPEAK WITH THE MANUFACTURER. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 207,000. UPDATED 07/28/10. *LJ ACCORDING TO THE INVESTIGATOR, THE FIR ORIGINATED WITHIN THE LEFT OR DRIVERS SIDE REAR OF THE ENGINE COMPARTMENT, IN THE IMMEDIATE AREA OF THE MASTER CYLINDER AND BRAKE FLUID RESERVOIR. THE FIRE WAS BEING CLASSIFIED AS ELECTRICAL IN NATURE. IT WAS NOTED THAT THE SPEED CONTROL DEACTIVATION SWITCH WAS LOCATED WITHIN THE AREA AND HAS BEEN RECALLED. 10/14/10*JB

TL* THE CONTACT OWNS A 2000 FORD F-250. WHILE DRIVING 50 MPH THE ENGINE MISFIRED AND CAUGHT FIRE. THE VEHICLE WAS COMPLETELY DESTROYED. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES. THERE WERE NO INJURIES. HE WAS IN THE PROCESS OF OBTAINING A FIRE REPORT. THE MANUFACTURER WAS NOTIFIED AND STATED THAT HE WOULD RECEIVE A RESPONSE WITHIN 15 DAYS. THE FAILURE AND CURRENT MILEAGES WERE 120,000.

DT: CONTACT STATED WHEN STARTING HER HUSBAND'S VEHICLE HEARD A NOISE. HE DIDN'T KNOW WHAT IT WAS. HE TOOK THE VEHICLE TO A FORD DEALERSHIP. WHEN HE CRANKED THE VEHICLE AND IT MADE NOISES WHILE CRANKING. IT MADE A POPPING NOISE IN THE BACK. THE BUTTERFLY PISTON WAS THE SAFETY DEFECT. *AK

DT: CONSUMER STATES AFTER HAVING DRIVEN ABOUT 300 MILES HIS VEHICLE IT DIED IN TRAFFIC. AT ONE TIME HE HAD A FUEL SENSOR GO OUT, BUT DEALER HAS NOT FOUND OUT WHY THE VEHICLE CUT OFF LIKE IT DID. IT HAS BEEN DOING THIS SINCE HE BOUGHT IT BRAND NEW. IT HAS DIED OUT COMPLETELY ABOUT A DOZEN TIMES. IF IT SITS ABOUT 2 DAYS, IT WILL START. THE VEHICLE WAS TAKEN TO THE DEALER LAST ON 12-03. THE CAR ONLY HAS 40,000 MILES ON IT.*AK

DT: WHILE DRIVING A SPARK PLUG CAME OUT OF VEHICLE. HAD TO AWAIT FOR PART TO BE ORDERED. TOOK VEHICLE TO A TRUCK STOP FOR REPAIRS. WHEN PLUG WAS TO BE REPLACED THEY DISCOVERED THAT TREADS WERE ALL GONE OUT OF THE HEAD. CALLED FORD DEALERSHIP, AND SAID A WHOLE NEW HEAD WOULD BE NEEDED. HAD TOWED VEHICLE TO DEALERSHIP, AND WOUND COST OVER $3,000 FOR REPAIRS AN A PROBLEM THAT BEGAN WITH A SPARK PLUG. *AK

VEHICLE WILL NOT ACCELERATE WHEN TRYING TO TAKE OFF. IT IS DIFFICULT TO GAIN SPEED. DEALER FINDS NO DEFECTS.*AK MANUFACTURER NOTIFIED. CONSUMER STATED THAT A PUSH ROD BROKE IN THE ENGINE ONE MONTH PRIOR. *TT

WHILE TURNING RIGHT, THE VEHICLE STALLED WITHOUT WARNING. THE DRIVER TRIED TO RESTART THE VEHICLE AND WAS ABLE TO DO SO. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. THE MECHANIC INFORMED THE DRIVER THAT THE CAMSHAFT POSITION SENSOR NEEDED TO BE REPLACED. PLEASE PROVIDE FURTHER DETAILS. *JB WHILE MAKING A RIGHT TURN THE VEHICLE DIED WITHOUT WARNING. THE VEHICLE STARTED AFTER SEVERAL ATTEMPTS. *TC

WHILE DRIVING AT 70 MPH, VEHICLE STALLED. THE DEALERSHIP INDICATED THAT THE CAMP POSITION SENOR HAD GONE BAD WHICH CAUSED THE PROBLEM. THE DEALERSHIP REPLACED THE PART, BUT THE PROBLEM RECURRED. TS