2001 FORD F-150 Power Trainautomatic Transmission Problems

TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED WHILE THE VEHICLE WAS SLOWING DOWN TO STOP, THE ENGINE RPMS WOULD INCREASE, THE GEAR ENGAGED AND THE VEHICLE LUNGED FORWARD. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE TRANSMISSION WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE REMEDY DID NOT REPAIR THE FAILURE. THE FAILURE RECURRED AT 11,000 MILES AND THE DEALER STATED THAT THE TRANSMISSION WAS DEFECTIVE AND NEEDED TO BE REPLACED AGAIN. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED HIM TO NHTSA. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 37,000 AND THE CURRENT MILEAGE WAS 48,000.

(FORD F150 XLT V-8 / 4.6 LIT.) PARKED IN PARKING SPACE AT WAL-MART CAME OUT OF STORE CRANKED UP MY TRUCK PUT IT INTO REVERSE AND IT WOULD NOT MOVE FORWARD OR BACK UP. THE TRANSMISSION WITHOUT WARNING COMPLETELY BAD NEEDED TO BE REPLACED. NEVER PULLED A TRAILER OR TREATED HARD IN ANYWAY. BOUGHT THE TRUCK NEW AND HAD IT 9 YEARS 49,000 MILES. I HAVE HEARD OF THIS PROBLEM WITH OTHER F-150 OWNERS. FORD NEEDS TO OWN UP TO A DEFECT. *TR

THERE AREN'T ANY REAL EVENTS LEADING TO THE FAILURE. I TOOK MY TRUCK INTO THE LOCAL DEALERSHIP (GARY CROSSLEY FORD) TO HAVE THE SPEED CONTROL RECALL WORK DONE. WHILE THERE I ASKED TO HAVE A STATE INSPECTION DONE AS WELL. I WAS TOLD BY THE SERVICE ADVISOR THAT THE LOWER BALL JOINT WERE SOMEWHAT LOOSE AND WOULD NEED REPLACING - SO I HAD THEM DO THAT AS WELL AS FLUSH THE TRANSMISSION AS WELL (THIS TRUCK ONLY HAD 62,000 MILES ON IT). FOLLOWING THAT IT PASSED INSPECTIONS - ALL WAS WELL. NOT EVEN ONE MONTH LATER (POSSIBLY ONLY 3 WEEKS) I TRIED BACKING FROM MY PARKING SPOT AT WORK AND HEARD A *THUNK* FROM THE REAR END. NOT SURE WHAT IT WAS I BACKED UP MORE AND HEARD IT AGAIN. PUT THE TRUCK IN DRIVE AND THERE WAS A RUBBING NOISE FROM UNDERNEATH. I PARKED IT AND CALLED A TOW...

I OWN A 2001 FORD F150 IT HAS 36,000 MILES ON IT. I'VE TAKEN GREAT CARE OF THE TRUCK, BUT AS OF LAST WEEK AFTER TAKING IT TO THE DEALER BECAUSE OF THE TRUCK NOT STARTING. I WAS INFORMED THE COMPUTER NEEDED REPLACED AND TWO COIL PACKS. AND QUOTE" DOES HAVE A TRANSMISSION CONCERN." AFTER WAITING 13 DAYS TO GET MY TRUCK I DIDN'T WANT THEM TO DO ANYMORE AND I WOULD PICK THE TRUCK UP. I DIDN'T GET TWO BLOCKS AND THERE WAS AN OBVIOUS PROBLEM WITH THE TRANSMISSION. I TOOK IT TO A INDEPENDENT TRANSMISSION REPAIR SHOP AND ASKED THEM TO CHANGE THE FLUID AND FILTER AND IF THEY SAW ANY PROBLEMS TO GIVE ME A CALL. A FEW HOURS LATER THEY CALLED AND SAID THEY FOUND BALL BEARINGS AND DEBRIS IN THE TRANSMISSION PAN, INFORMED ME THAT IT SHOULD BE REBUILT. I INFORMED THEM TO GO AHEAD...

2/28/07 WHILE DRIVING ON RT 3 @ 60 MPH MY TRANSMISSION DOWN SHIFTED & THE O.D. OFF LIGHT FLASHED ON & OFF CONTINUOUSLY. I STOPPED & LOOKED IT UP IN THE OWNERS MANUAL AND FOUND THAT MY TRANSMISSION SHOULD BE SERVICED. TOOK TO FORD DEALER AND I WAS TOLD TRANSMISSION NEEDED WORK AND THAT WARRANTY PLAN EXPIRED 2 DAYS EARLIER. BROUGHT TO TRANS SHOP WAS SHOWN TRANSMISSION PAN FULL OF METAL FROM GEARS NEEDED TO B REBUILT @ 41000 MILES AND NEVER TOWED OR PLOWED,@ A COST OF OVER $2000.00. *JB

I BROUGHT THIS CAR FROM THE DEALERSHIP BILL EARD. THIS CAR HAS GAVE ME PLENTY OF PROBLEMS WITH ITS TRANSMISSION. I HAVE TOOK THE CAR TO THE DEALERSHIP BUT THEY DON'T WANT TO HELP ME WITH ANYTHING . SO I HAVE TOOK THE CAR TO A MECHANIC AND THEY HAVE INFORMED ME THAT THIS CAR IS NO GOOD. THAT IS THE REASON I WANT TO CANCEL THE PURCHASED OF THIS CAR. *NM

DT*: THE CONTACT STATED WHILE ATTEMPTING TO PUT THE VEHICLE IN REVERSE IT WOULD NOT MOVE BACKWARD. ADDITIONALLY, WHEN PUT IN PARK THE VEHICLE WOULD ROLL. THE DEALER INSPECTED THE VEHICLE AND NOTED THE PLANETARY GEAR IN THE TRANSMISSION NEEDED TO BE REPLACED. THE DEALER REBUILT THE TRANSMISSION AND CORRECTED THE PROBLEM. UPDATED 05/03/06. *JB

TRANSMISSION LOCKED UP AND WOULD NOT MOVE IN REVERSE HAD TO BE TOWED TO TRANSMISSION SHOP TOTAL REBUILD COST OF $2000 SHOP SAID HE SEES 2 A WEEK WITH THIS PROBLEM 2001 FORD F150 46000 MILES AUTOMATIC TRANSMISSION. *JB

TAKE A LOOK A MY VEHICLE HISTORY, I BABY MY TRUCK - NEVER USED OFF-ROAD. I HAVE REPLACED SEVERAL ITEMS THAT I FEEL SHOULD HAVE BEEN FIXED BY FORD. I HAD TO BUY A WARRANTY THAT COVER MOST OF THE STUFF. SOME PARTS WITH DEFECTS THAT WERE REPLACED. MOST REPLACED AT 40,000-80,000 MILES 1.) TRANSMISSION COMPLETELY REPLACED 2.) REAREND REPLACED 3.) I'M ON MY THIRD SET OF ALL 4 BALL JOINTS 4.) TIE RODS, TIE ROD ENDS (REPLACED TWICE NOW) 5.) COIL 6.) HEADLIGHT HOUSING (3-4 TIMES) 7.) BRAKES, NUMEROUS THINGS WORKED ON AND REPLACED DEALERSHIP WAS NEVER ABLE TO STOP THE THUMPING NOISE THAT IS STILL THERE, SAID IT WAS NORMAL (NOT) 8.) IDLER ARM (REPLACED TWICE) 9.) SUNROOF SWITCH REPLACED TWICE, REPORTED LOUD BANG WHEN OPENING. A&B KIA SAID IT WAS NORMAL - NO, NOW IT IS COMPLETELY BROKE AND WILL BARELY OPEN AND HAVE TO FORCE CLOSED....

THE VEHICLE'S AUTOMATIC TRANSMISSION FAILED. *NM THE TRANSMISSION CONTINUED TO BREAK DOWN. THERE WAS NO REVERSE DUE TO THE LOW IN REVERSE CLUTCH BEING INOPERATIVE. THERE WAS SLIPPAGE AS WELL DUE TO THE REVERSE SUN GEAR WELD BEING BROKEN. *SC *JB

VEHICLE IS 2001 F150 SUPERCREW 4X4 PURCHASED NEW IN 2001. VEHICLE HAS 81,500 MILES AND HAS NEVER BEEN USED FOR TOWING OR HAULING HEAVY LOADS. AUTOMATIC TRANSMISSION WILL NOT ENGAGE RIGHT AWAY IN FORWARD GEARS. THERE IS A DELAY OF SEVERAL SECONDS BEFORE ENGAGEMENT. WORKS ALRIGHT IN REVERSE AND ONCE VEHICLE STARTS MOVING. SEEMS TO BE SIMILAR TO PROBLEM NOTED IN TSB 01-11-7. BROUGHT TO STATELINE FORD IN PHILLIPSBURG, NJ TO INVESTIGATE. WAS TOLD THAT THERE WAS INTERNAL PROBLEM WITH TRANSMISSION AND THAT REPLACEMENT IS RECOMMENDED. ASKED IF THIS WAS NORMAL FOR THIS TRANSMISSION TO FAIL AT 81,000 MILES AND I WAS TOLD IT WAS NOT. CALLED FORD CUSTOMER RELATIONS CENTER TO EXPLAIN PROBLEM AND SEE IF FORD WOULD PARTICIPATE IN PART OF COST FOR REPLACEMENT. WAS TOLD THEY WOULD NOT. CALLED DEALER TO SEE IF THIS COULD BE DISCUSSED WITH FIELD REP AND WAS TOLD THEY COULDN'T. *NM

WHILE DRIVING TRANSMISSION DISENGAGED AND EXPLODED INTERNALLY. THIS CAUSED DAMAGE TO THE THIRD/FOURTH, AND REVERSE GEARS. VEHICLE DECELERATED, IT WOULD NOT GO OVER 40 MPH. CONSUMER CONTACTED THE MANUFACTURER, WHO SAID THERE WAS NOTHING THEY COULD DO. *AK

AUTOMATIC OVERDRIVE TRANSMISSION FAILURE WITH 65877 HIGHWAY MILES. COULD NOT BE REBUILT,HAD TO BUY NEW TRANS.VEHICLE UNDER 3 YEARS OLD AND FACTORY WOULD ONLY HELP WITH $700.00 OF $3000.00 PLUS BILL.*AK

FORD GAVE NO REASON FOR COMPLETE TRASMISSION FAILURE. FORTUNATELY SLLIPPING AND FAILURE OCCURED DURING TRANSMISSION WARM UP IN DRIVE WAY. COMPLETE TRANSMISSION REPLACEMENT AT 40,000 MI AT OWNER EXPENSE.*AK

AUTOMATIC TRANSMISSION FAILED WHILE DRIVING. PRIOR TO THIS INCIDENT WHEN CHANGING GEARS TRANSMISSION MADE A WHINING NOISE BEFORE IT WENT INTO GEAR. THIS MAINLY OCCURRED WHILE REVERSING. A MECHANIC SERVICED VEHICLE SEVERAL TIMES FOR THIS ISSUE, BUT NO CAUSE WAS FOUND. CURRENTLY, VEHICLE IS AT THE DEALERSHIP FOR REPAIRS. *AK THE TRANSMISSION ALSO HESITATED WHEN SHIFTED INTO ANY GEAR. *NM

WHEN GEAR SHIFTER IS PUT INTO REVERSE THERE IS A THUMPING NOISE. WHEN VEHICLE STOPS THERE IS A THUMPING NOISE. *AK

TRANSMISSION WOULD NOT SHIFT FROM A DEAD START. I WOULD ATTEMPT TO CROSS AN INTERSECTION AND THE TRANSMISSION WOULD NOT ENGAGE. WHEN IT DID IT WAS WITH A VIOLENT JERK OF THE VEHICLE. THE FORCE OF THE JERK WAS SIMILAR TO BEING IN A ROLLERCOASTER. TOOK VEHICLE TO LOCAL FORD DEALERSHIP AND THE ONLY EXPLANATION I WAS GIVEN WAS THAT THE TRANSMISSION WAS RUNNING HOT AND FORD NOW REQUIRED AN IN-LINE COOLER FILTER BE INSTALLED ON THE TRANSMISSION AT MY COST SINCE THE INLINE COOLER FILTER WAS NOT ORIGINAL.*AK

WHILE DRIVING 45 MPH OVERDRIVE LIGHT ILLUMINATED, TRANSMISSION SLIPPED WHILE SHIFTING FROM SECOND GEAR TO THIRD GEAR AND FROM THIRD GEAR TO FOURTH GEAR. ALSO, THERE WAS HESITATION AND RPMS INCREASED. DEALER REPLACED TRANSMISSION WITH A REBUILT ONE.*AK

CONSUMER STATES WHILE TRAVELING AT 75 MPH LOST COMPLETE ACCELERATION. VEHICLE WOULD ONLY FUNCTION IN FIRST GEAR. DEALER WAS NOT ABLE TO DUPLICATE PROBLEM. *AK

WHILE DRIVING THE TRANSMISSION EMITTED A NOISE AND THE GEARS MOVED BETWEEN FIRST AND THIRD GEAR. *NLM

CONSUMER STATES WHILE DRIVING THE VEHICLE AT ANY SPEED, THE AUTOMATIC TRANSMISSION BEGINS SEVERELY SLIP FROM GEAR TO GEAR. FORCING TO PULL OUT OF THE ROAD. DEALER WAS NOTIFIED. PLEASE PROVIDE FURTHER INFORMATION. TS

SIGNIFICANT AUTOMATIC TRANSMISSION SLIPPAGE, ALMOST AS IF THE TRANSMISSION IS SLIPPING INTO NEUTRAL. THIS HAPPENED YESTERDAY WHEN I WAS MAKING A LEFT TURN AND WAS NEARLY STOPPED IN THE MIDDLE OF THE INTERSECTION. THIS PROBLEM STARTED AFTER ABOUT 20 MINUTES OF FREEWAY DRIVING, AND 10 MINUTES OF IN-TOWN DRIVING. IT WAS PROMINENT IN ALL AUTO TRANSMISSION GEARS: REVERSE, 1, 2, AND 3/DRIVE. I HAD THE VEHICLE TOWED TO THE CLOSEST DEALERSHIP IN ARROYO GRANDE, CA 93420.

PURCHASED 2001 FORD F150 LARIETSUPER CREW CAB PU ON 4/01/2000, 26 MILES ON ODOMETER, AT TIME OF PURCHASE ALSO PURCHASED ROADSIDE ASSISTANCE PKG AND EXTENDED WARRANTY, ESP, FROM FORD , HAVE HAD SERIOUS BRAKING PROBLEMS WITH VEHICLE, VEHICLE WAS REPEATEDLY SERVICED AT FORD DEALERSHIP FOR THESE REPAIRS, NONE OF WHICH WERE COVERED, IN MAY 2002 ENTIRE ENGINE FAILED AND HAD TO BE REP[LACED, WAS INFORMED BY DEALERSHIP THAT THE PROBLEM WAS THAT ONE OF THE ELEECTRONIC BRAINS THAT CONTROL /OPERATE THIS COMPONENT FAILED, ON DEC 27, 2002 THE TRANSMISSION GAVE OUT ENTIRELY, LUCKILY THE VEHICLE WAS NOT ON THE FREEWAY AT THE TIME, WAS TOWED TO DEALERSHIP WHERE IT STILL SITS, HAVE CALLED, E-MAILED AND MAILED INFO TO FORD CUSTOMER CARE WITHOUT ANY RESULTS OTHER THEN FROM PHONE REP SAYING THAT THERE IS NOTHING THAT FORD WILL DO...THIS VEHICLE HAS BEEN VERY COSTLY TO MAINTAIN AND FOR A FORD IS...

WHILE VEHICLE WAS DOWNSHIFTING TRANSMISSION WAS MAKING A NOISE . VEHICLE WAS SERVICED. CONSUMER IS NOW ON THIRD TRANSMISSION. PLEASE PROVIDE FURTHER INFORMATION.*AK

AN ONGOING PROBELEM TRANSMISSION NOT SHIFTING INTO GEAR AFTER STOPPING VEHICLE. VEHICLE BEEN TO THE DEALER ON THREE OCCASIONS; BUT, PROBLEM STILL REOCCURRING. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK

GEAR SHIFT STICKS AND IS SOMETIMES IMPOSSIBLE TO SHIFT GEARS.*AK

THE TRANSMISSION HESITATES AS IT SHIFTS FROM 1ST GEAR TO SECOND GEAR. I WAS TOLD IT IS NORMAL BY THE DEALER WHERE I BOUGHT THE TRUCK AND OTHER DEALERSHIPS AS WELL. I HAVE FOUND OUT THERE IS A DEFECT IN THE TRANSMISSION WHICH CAUSES THIS DELAY IN THE SHIFTING OF THE TRANSMISSION. THIS PROBLEM HAS BEEN FOUND IN 4R100 TRANSMISSIONS BUILT FROM 7/27/2000 TO 3/23/2001. I BELIEVE THIS TRANSMISSION TO BE UNSAFE AND FORD DENIES THERE IS A PROBLEM. I WANT THIS TRANSMISSION REPLACED WITH A NEW TRANSMISSION. I HAVE HAD THIS PROBLEM SINCE THE TRUCK WAS NEW AND ALL FORD DOES IS DENY, DENY, DENY.

THE TRANSMISSION HESITATES AS IT SHIFTS FROM 1ST GEAR TO SECOND GEAR. I WAS TOLD IT IS NORMAL BY THE DEALER WHERE I BOUGHT THE TRUCK AND OTHER DEALERSHIPS AS WELL. I HAVE FOUND OUT THERE IS A DEFECT IN THE TRANSMISSION WHICH CAUSES THIS DELAY IN THE SHIFTING OF THE TRANSMISSION. THIS PROBLEM HAS BEEN FOUND IN 4R100 TRANSMISSIONS BUILT FROM 7/27/2000 TO 3/23/2001. I BELIEVE THIS TRANSMISSION TO BE UNSAFE AND FORD DENIES THERE IS A PROBLEM. I WANT THIS TRANSMISSION REPLACED WITH A NEW TRANSMISSION. I HAVE HAD THIS PROBLEM SINCE THE TRUCK WAS NEW AND ALL FORD DOES IS DENY, DENY, DENY.

INTERMITTENTLY WHEN COMING DOWN AN INCLINE IT WOULD COME OUT OF OVERDRIVE; DEALER NOTIFIED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION. *AK

TWO DAYS AFTER TRUCK PURCHASE, REPORTED TO DEALER TRUCK HAS BAD VIBRATION, ROUGH IDLE, PULLS TO THE RIGHT, TRUCK HESITATES TO GO INTO GEAR, TRUCK HESITATES BEFORE SHIFTING, ENGINE KNOCK AND CLUNK IN T-CASE AREA. TRANSMISSION HAS BEEN REPLACED TWICE,ROAD FORCED BALANCE 4 TIRES,SWITCHED TIRES AND WHEELS,FRONT END ALIGNMENT THREE TIMES,TORQUE CONVERTER REPLACED,CRANKSHAFT PULLY REPLACED,DAMPERS INSTALLED FOR VIBRATION. ALL PROBLEMS STILL EXIST. FORD HAS OFFERED TO BUY BACK THE TRUCK BUT THEY WILL NOT GIVE ME ALL OF MY MONEY BACK.

WHILE DRIVING AT 10 TO 15 MPH VEHICLE WOULD NOT GO INTO ANY GEARS. CONSUMER TURNED TRUCK OFF AND PUT IN GEAR. THEN, CONSUMER WAS ABLE TO DRIVE HOME SLOWLY AND PARK VEHICLE. ABOUT 5 MINUTES LATER, STARTED VEHICLE, AND IT JUMPED FORWARD, IT WAS NOT IN GEAR, SOMEONE COULD HAVE BEEN SERIOUSLY INJURED. VEHICLE WAS TOWED TO DEALER. PLEASE PROVIDE ANY FURTHER INFORMATION. *AK

THIS WAS 2ND TRANSMISSION FAILURE; BOTH TIMES THE TRANSMISSION FLUID SPRAYED UNDER VEHICLE & TIRES, MAKING VEHICLE SLIDE ON ROAD. BOTH TRANSMISSION AND DRIVE SHAFT WERE REPLACED; TECH STATED THE REAR SEAL HAD BLOWN.*AK

WHEN DRIVING AND STOPPING TRANSMISSION SLIPS. IT TAKES A TWO SECONND DELAY FOR TRUCK TO MOVE. DEALERSHIP IS AWARE OF PROBLEM.*AK THE TRANSMISSION SLIPPING OCCURS DURING STOP AND GO TRAFFIC. IT WAS UNPREDICTABLE WHEN IT WOULD HAPPEN, AND IT WAS A POSSIBLE SAFETY HAZARD. *YH

2 TRANSMISSION FAILURES; REPLACED WITH NEW TRANSMISSION & DRIVE SHAFT; PER SECOND TECH NOTES: FOUND DAMAGED EXTENSION HOUSING BUSHING SPUN AND WAS ON DRIVE SHAFT, CLUTCHS BURNED, BAND BURNED, SOLENOID WAS STUCK IN BORECONVERTER HUB WORN, DRIVE SHAFT WORN, BACK FLUSHED COOLER INST FOR REPAIR WAS OVER 1400 FLOW TEST. *AK

I JUST WANTED TO INFORM YOU OF A PROBLEM THAT I HAD WITH MY 2001 FL50 SUPERCREW. MY TRUCK WAS EQUIPPED WITH A 4X4, 5.4 LITER, AUTOMATIC TRANSMISSION, TOWING PACKAGE, AND IT WAS AN XLT LARIAT. ALL THE BELLS AND WHISTLES! MY REPORTED CONCERN IS THAT THE SUSPENSION IS NOT STRONG ENOUGH FOR THE RATED TOWING CAPACITY. I WAS TRAVELING ON THE INTERSTATE AT ABOUT 60 MPH. A CAR CUT IN FRONT OF ME AND I MOVED TO THE LEFT LANE TO AVOID RUNNING INTO THE CAR IN FRONT OF ME. MY TRAILER'S EMPTY WEIGHT WAS 5000 LBS AND I ESTIMATE THAT I HAD ANOTHER 1000-1500 LBS INSIDE. THE TRUCK WAS EQUIPPED WITH WEIGHT DISTRIBUTION BARS AND AN ANTI-SWAY BAR(REESE MFG.). WHEN I CHANGED LANES THE TRUCK SWAYED/LEANED HARD TO THE LEFT, THEN SWAYED HARD TO THE RIGHT. THE TRUCK THEN ROLLED OVER SEVERAL TIMES AND LANDED ON THE DRIVER'S...