2001 FORD F-150 Structurebody Problems

TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT AFTER PULLING INTO THE DRIVEWAY AT THE RESIDENCE, THE SPARE TIRE DETACHED FROM THE VEHICLE. THE CONTACT BECAME AWARE THAT THE SPARE TIRE CABLE WAS FRACTURED. THE VEHICLE WAS NOT TAKEN TO A DEALER TO BE INSPECTED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 173,000.

HELLO: MY FORD 150 EXTENDED CAB REAR DOOR DO NOT OPEN. I TOOK IT TO A FORD DEALERSHIP AND THEY TOLD ME THE LATCHES ARE BROKEN. I DID NOT HAVE IT FIXED DUE TO A POSSIBLE RECALL ISSUE. THANK YOU. *TR

DEAR NHTSA: RE: VIN# [XXX] MY FORD 150 EXTENDED CAB BACK DOORS LATCHES HAVE FAILED. THE TWO BACK DOORS DO NOT OPEN. AT FIRST, I THOUGHT THE RUBBER THAT RUNS ALONG SIDE THE TRIM WAS CAUGHT, BUT WHEN THE SECOND DOOR STOPPED OPENING I TOOK IT TO A FORD DEALERSHIP AND HE SAID THERE ARE TWO LATCHES ON EACH DOOR , A BOTTOM LATCH AND A TOP LATCH. BOTH TOP LATCHES HAVE FAILED AND NOW I CANNOT OPEN THE TWO BACK DOORS TO MY FORD TRUCK. THE FIRST DOOR(DRIVER SIDE DOOR) WENT OUT IN NOVEMBER OF 2019, AND THE SECOND DOOR STOPPED OPENING LAST WEEK. WHO IS RESPONSIBLE FOR THIS? I AM SURE IT WILL BE EXPENSIVE TO TAKE THE DOORS OFF AND REPLACE THE LATCHES. THANK YOU FOR YOUR TIME AND HELP. SINCERELY, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

FRAME BENT DUE TO UNSEEN CORROSION. THIS HAPPEN WHEN TRUCK WAS ON A LIFT FOR REPAIRS TO THE TRANSMISSION LINES. MECHANIC HAD NO WAY OF KNOWING. VEHICLE SPENT HALF ITS LIFE IN ARIZONA WHERE NO SALT IS USED ON THE ROADS

ON 9/4/2018 I BOUGHT 4 BRAND NEW DESTINATION LE2 P-METRIC OWL P265/75R16 TIRES WITH A 60000 WARRANTY FROM FIRESTONE IN HESPERIA CA. MY DAUGHTER JUST BOUGHT THE TRUCK AND I WANTED HER TO BE SAFE WITH NEW TIRES.ON NOVEMBER 14, 2018 ON HER WAY TO WORK AT 5:00 A.M SHE HAD A TERRIBLE ROLL OVER. SHE IS CURRENTLY IN ICU. SHE JUST HAD A CRANIOPLASTY 15 DAYS AGO. SHE HAS A SEVERE TBI. SHE HASN'T WALKED SINCE THE DAY OF ROLLOVER. SHE WAS ON LIFE SUPPORT. STILL ON TRACHEOSTOMY. SHE WILL BE DISABLED ALL IF HER LIFE. SHE IS 22 YEARS OLD. SHE WAS DRIVING APPROX. 55 MPH. SHE WAS OUT OF CONTROL WHEN ALL THREE WITNESSES SAW HER COMING AT THEM. THIS HAPPENED ON SUMMIT VALLEY RD IN HESPERIA CA. IT IS ONE LANE EACH DIRECTION. SHE WAS APPROACHING TH TOP OF A HILL. WHEN SHE GOT OVER THE...

GAS TANK FELL OUT OF VEHICLE,TEARING FILLER HOSE. TANK STRAPS AND SUPPORTING STRUCTURES RUST THRU, FAILURE. DRIVERS' SIDE REAR SHOCK DROPPED FROM VEHICLE BECAUSE METAL BRACKET IT WAS ATTACHED TO ROTTED THRU. BED RAILS COMPLETELY RUSTED THRU. FRAME HAS RUSTED THRU HOLES. COMPLETE RUST FAILURE. VEHICLE HAS ONLY 90K MILES ALWAYS MAINTAINED, WASHED UNDERNEATH WEEKLY IN WINTER. VEHICLE IN MOTION WHEN PARTS FELL ON RTE 58 AND THE SHOCK ON TOWN STREET..$900 TO REPAIR GAS TANK. SHOCK INCIDENT HAPPENED TODAY 11/26/2017, GAS TANK 9/12/2016

PAINT IS PEELING OFF OF THE ROOF, THE REAR OF THE CAB, THE PASSENGER REAR DOOR, AND FROM THE FUEL DOOR.

THERE HAS BEEN NO INCIDENT AS YET BUT THE FRAME OF THIS VEHICLE HAS SUCH EXTREME CORROSION THAT CERTIFIED MECHANICS ARE RELUCTANT TO WORK ON THIS VEHICLE SINCE THEY ARE CONCERNED ABOUT A FAILURE OCCURRING AT CONNECTION POINT WHERE THE STEERING AND SUSPENSION CONNECTS TO THE FRAME OF THE VEHICLE. THEIR CONCERN IS A LOSS OF CONTROL OF THE VEHICLE IF ANY OF THE STEERING OR SUSPENSION CONNECTION POINTS FAIL DUE TO THE SEVERELY CORRODED FRAME. THIS IS NOT SURFACE CORROSION, THE METAL IS FLAKED AND SEPARATED AND IT IS THE ENTIRE FRAME OF THE VEHICLE. I HAD JUST SPENT $4,000 TO REPLACE THE ENTIRE EXHAUST SYSTEM FROM THE EXHAUST MANIFOLD BACK TO THE TAIL PIPE AND THE MECHANIC IS WARNING ME ABOUT THE SAFETY OF THE SUSPENSION AND STEERING COMPONENTS BECAUSE OF THE EXTREME CORROSION. THE VEHICLE ONLY HAS 77, 000 ORIGINAL MILES AND HAS NEVER BEEN IN SEVERE...

THE FRAME RAILS JUST IN FRONT OF THE REAR WHEELS RUST/ROTTED AND THE VEHICLE SNAPPED IN TWO PIECES. SIMILAR TO THE FAILURES COVERED BY TOYOTA RECALL FOR THE TUNDRA OF THE SAME MODEL YEAR. THE VEHICLE WAS BEING RAISED ON A LIFT FOR AN OIL CHANGE. NOT A SPEC OF RUST ON THE BODY ANYWHERE.

TL* THE CONTACT OWNS A 2001 FORD F-150. WHILE DRIVING AT ANY SPEED, THE VEHICLE MADE AN ABNORMAL NOISE. THE VEHICLE WAS TAKEN TO A MECHANIC WHERE IT WAS DIAGNOSED THAT THE PANEL RADIATOR SUPPORT WAS RUSTED AND FRACTURED. THE DEALER WAS NOT ABLE TO REPAIR THE VEHICLE AND RECOMMENDED IT BE TAKEN TO A BODY SHOP. THE CONTACT TOOK THE VEHICLE TO THE BODY SHOP, BUT THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 133,000.

DOOR RELEASE HANDLES ON BOTH REAR DOORS FAILED TO OPEN WITHIN A MONTH APART WHICH WOULD HAVE TRAPPED THE REAR SEAT PASSENGERS. THE CABLE AND LATCH ASSEMBLIES HAD TO BE REPLACED.

I PARKED, WALKED INSIDE...MOMENTS LATER THE TRUCK WAS ON FIRE.. *TR

WOKE UP THIS MORNING TO A COUPLE OF LOUD "BOOMS". MY HUSBAND WENT TO CHECK IT OUT AND DISCOVERED HIS TRUCK (WHICH WE JUST PURCHASED IN MAY) WAS ON FIRE. THE FIRE DESTROYED THE TRUCK, MELTED THE SIDING ON OUR HOUSE AND GARAGE, AND EVEN CRACKED THREE OF OUR NEIGHBOR'S WINDOWS. WE ARE SO GRATEFUL THE FIREFIGHTERS ARRIVED WHEN THEY DID OR THIS FIRE WOULD'VE KEPT BURNING OUR HOUSE. THE TRUCK HADN'T MOVED SINCE LAST NIGHT...DON'T KNOW WHAT HAPPENED BUT WE WILL NOT BE PURCHASING A FORD AGAIN. *JS

SEVERE CORROSION ISSUES. *TR

I WAS DRIVING NORTHBOUND ON I-95 WHEN THE DRIVER OF AN ADJACENT VEHICLE ALERTED ME THAT THERE WAS FIRE SHOOTING OUT FROM THE AREA OF THE FUEL FILLER DOOR. I IMMEDIATELY PULLED OVER ONTO THE HIGHWAY MEDIAN AND JUMPED OUT. THE TRUCK WAS ENGULFED IN FLAMES, AND THE CAB WAS ON FIRE. I BURNED MYSELF ON THE MELTING STEERING WHEEL AND WAS SINGED BY MELTING PLASTIC. *TR

TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT THE INSTRUMENT PANEL LIGHTING AND HEADLIGHTS WOULD NOT ILLUMINATE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE THE TECHNICIAN STATED THAT WATER WAS ENTERING THE VEHICLE THROUGH THE A-PILLER AND WAS LEAKING ONTO THE ECM. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 59,900. *TR

TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT THE ROCKER PANEL WAS SEVERELY RUSTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 86,000.

TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT WHEN DRIVING AT VARIOUS SPEEDS, ATTEMPTING A TURN OR TRAVELING OVER A ROAD BUMP, THE VEHICLE WOULD SPORADICALLY EMIT A METAL-TO-METAL DRAGGING NOISE. THE CONTACT INSPECTED THE VEHICLE AND FOUND THAT THE SUPPORT FOR THE RADIATOR WAS FRACTURED, CAUSING THE RADIATOR TO SWAY WHILE DRIVING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO CONFIRMED THE DIAGNOSIS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 201,000. UPDATED 07/23/13*LJ

AT APPROXIMATELY 50+ MPH THE FRONT OF THE CAR SHAKES. THIS HAS BEEN GOING ON FOR ALMOST OVER AN YEAR. I TOOK IT TO THE DEALERSHIP, SAID NOTHING IS WRONG. IT STARTS TO SHAKE SO BAD THAT YOU HAVE TO LET UP ON THE ACCELERATOR AND ALMOST STOP, BEFORE YOU FEEL SAFE ENOUGH TO CONTINUE ON. SHAKING IS THE WORSE FOR THE FIRST 3 MILES AT THE START OF THE DAY BUT NEVER SEEMS TO COMPLETELY GOES AWAY. *TR

CAR WAS SITTING IN DRIVEWAY FOR AROUND 30 -45 MINUTES THEN JUST SET FIRE. *TR

THE RADIATOR SUPPORT BRACKET BENEATH THE RADIATOR RUSTED THROUGH LEAVING THE RADIATOR WITH VIRTUALLY NO SUPPORT. THE SUPPORT BRACKET HAD TO BE REPLACED AND WELDED IN PLACE... *TR

THE TRUCK STARTED ON FIRE WHILE SITTING IN THE DRIVEWAY HOURS AFTER BEING PARKED. BY THE TIME WE REALIZED IT WAS ON FIRE, IT WAS TOTALLY OUT OF CONTROL AND THE TRUCK WELL BEYOND SAVING. IT BURNED SO HOT IT MELTED THE TIRES, THE SIDING OF THE HOUSE AND DESTROYED PART OF A PRIVACY FENCE. WE KEPT WATER ON THE FIRE UNTIL IT WENT OUT ABOUT AN HOUR AND A HALF LATER. THE FIRE STARTED UNDER THE HOOD AND THE WHOLE FRONT OF THE TRUCK IS ALMOST UNRECOGNIZABLE. THE OWNER ( [XXX] ) IS AN AUTO MECHANIC AND HAS BEEN FOR FORTY PLUS YEARS. WE RUN AN AUTO REPAIR BUSINESS. WE HAD HEARD VAGUE THINGS ABOUT FORDS AND FIRES BUT DID NOT LOOK INTO IT UNTIL AFTER THE INCIDENT. WE PURCHASED THE TRUCK THIS WINTER AND NEVER GOT ANY RECALL NOTICES FOR THE CRUISE CONTROL SWITCH PROBLEM. THE PRIOR OWNER...

TL* THE CONTACT OWNS A 2001 FORD F150. THE CONTACT WAS DRIVING APPROXIMATELY 25 MPH AND HEARD A LOUD, ABNORMAL NOISE OUTSIDE OF THE VEHICLE. THE CONTACT IMMEDIATELY PULLED OVER AND NOTICED THAT THE SPARE TIRE THAT WAS MOUNTED UNDER THE TRUCK HAD DETACHED FROM THE CARRIAGE AS A RESULT OF A FRACTURED CABLE. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

MY COMPLAINT IS IN REGARDS TO A FORD F150 SERIES TRUCK. THE UNDERCARRIAGE AND ALL PARTS UNDER THE TRUCK ARE RUSTING OUT. BRAKES/ROTORS JUST REPLACED AND DEALERSHIP STATED THAT THE THUMPING NOISE WAS DUE TO THE BRAKE FALLING OFF OF THE TRUCK. THIS IS A VERY BIG SAFETY ISSUE AND WHEN CONTACTING FORD, THEY STATED THAT THERE WAS NO RECALL AND THERE WAS NOTHING THAT THEY COULD DO ABOUT IT. THIS IS ALSO ALONG WITH THE RUSTING OF THE DOORS AND DOOR FRAMES AND PEELING PAINT ISSUE THAT FORD HAS YET TO TAKE CARE OF CUSTOMERS FOR THIS KNOWN ISSUE. WHEN CALLING FORD DIRECTLY, THEY STATE THEY ARE VERY SORRY, BUT YET THEY DO NOTHING ABOUT IT. DOES SOMEONE NEED TO DIE FIRST BEFORE A RECALL IS DONE LIKE THE ISSUE WITH THE CRUISE CONTROL DEACTIVATION SWITCH THAT CAUSED FIRES AND AN EDERLY WOMAN AND CHILD WERE KILLED? *TT

2001 F-150 SUPERCREW 4X4 LARIAT 5.4 TRITON 136000 MILES. GREAT TRUCK HOWEVER THE UNDER SIDE OF THIS TRUCK IS LITERALLY RUSTING OUT FROM UNDERNEATH. ROCKER PANELS ARE GONE, BUT A LARGER ISSUE AT THIS TIME IS THE FUEL TANK STRAP HAS RUSTED AND BROKE. PATHETIC RUSTING ON THIS BEAUTIFUL TRUCK. *TT

PAINT PEELING OFF ON BODY. WHITE IN COLOR,NEVER NEGLECTED, ALWAYS WASHED, WAXED ETC. WELL KNOWN AND DOCUMENTED PROBLEM. CONTACTED FORD MANY TIMES AND ALWAYS GET TOLD THEY WILL DO NOTHING BECAUSE IT IS OUT OF WARRANTY. THEY THEN TOLD ME THEY HAVE UPGRADED MANY THINGS ON THEIR NEW TRUCKS AND SHOULD CONSIDER GETTING A NEW ONE. I DOUBT I WILL EVER GET ANOTHER FORD IF THEY CAN MESS UP SOMETHING AS SIMPLE AS PAINT. THIS IS A FORD DEFECT AND THEY SHOULD BE FORCED TO FIX IT. I HAVE A CAR THAT IS 10 YEARS OLDER THAN MY FORD AND THE PAINT LOOKS BETTER. *TR

PAINT IS PEELING OFF THE ROOF OF MY TRUCK. I WROTE A LETTER TO FORD AND THEY WILL NOT FIX THIS EVEN THOUGH THEY KNOW THIS IS A COMMON PROBLEM WITH MANY OF THERE VEHICLES. *TR

2001 FORD F-150: PAINT IS PEELING OFF THE ROOF, HOOD, AND TAILGATE AREAS. TWO BODY SHOPS ADVISE THAT THIS IS A KNOWN DEFECT WITH THE FORD PAINTING PROCESSES USED FOR THIS YEAR VEHICLE. ALSO EXPERIENCING INTERIOR RUSTING PROBLEMS. FORD ADVISES THAT THEY WILL NOT REMEDY THIS PROBLEM. I AM THE ORIGINAL PURCHASER OF THIS VEHICLE. VEHICLE HAS BEEN WELL MAINTAINED. I HAVE NEVER EXPERIENCED PAINT ISSUES LIKE THIS WITH ANY OTHER VEHICLE. *TR

I PURCHASED A USED 2001 FORD F-150 CREW CAB FEBRUARY 2006 WITH 59K MILES ON IT. SHORTLY THEREAFTER THE PAINT OR CLEAR COAT ON THE HOOD, QUARTER PANELS, AND DOORS STARTED TO CRACK. THE CRACKING HAS CONTINUED TO GET WORSE. BEFORE PURCHASE THE TITLE WAS CHECKED AND THIS VEHICLE HAS NEVER BEEN IN AN ACCIDENT. THE PAINT FROM FORD IS DEFECTIVE AND IS WELL DOCUMENTED ON THE WEB. FORD CUSTOMER SERVICE HAS BEEN ABSOLUTELY TERRIBLE. *TR

PAINT STARTED TO SHOW SMALL CRACKING MARKS ON HOOD, FRONT FENDERS AND ROOF.*AK

THIS MAY BE A MOOT POINT BECAUSE THE TRUCK (2001 F-150 SUPERCREW XLT 4WD) I HAD OWNED (TRADED IT IN FOR A 2003 FORD SUPERCREW WHICH ALSO EXHIBITS VERY SIMILAR PROBLEMS) HAD SERIOUS PROBLEMS WITH THE STEERING IN ADDITION TO THE DRIVER SEATBELT BECOMING DISENGAGED WHILE DRIVING NORMALLY. I COULD NOT UNDERSTAND WHY THE SEATBELT WOULD DISENGAGE ALL BY ITSELF. I EVEN HAD WITNESSES TO THE FACT. I ASKED FOR THE SERVICE TO ADDRESS IT; HOWEVER, THEY COULD NOT DUPLICATE THE PROBLEM. THIS IS SERIOUS AS WHAT ARE SEATBELTS FOR IN THE FIRST PLACE. ALSO HAD SOME PROBLEMS WITH THE PAINT CRACKING OR SPIDERING. FORD REGIONAL PERSONNEL FROM DENVER WANTED TO REPAINT THE VEHICLE. HOWEVER, THEY COULD NOT DETERMINE HOW IT WOULD BE ACCOMPLISHED. THIS WENT ON FOR OVER 4 MONTHS. THAT IS ONE OF THE MAIN REASONS IN ADDITION TO THE STEERING PROBLEMS DESCRIBED PREVIOUSLY I HAD GET RID...