2001 FORD F-150 Engine And Engine Cooling Problems

VEHICLE WAS PARKED AND MOTOR WAS OFF. VEHICLE CATCH ON FIRE AND FIRE DEPARTMENTS HAD TO GO TURN IT OFF BUT WE COULD NOT SAVE ANYTHING FROM THIS TRUCK IT GOT VERY DAMAGED. *TR

WHILE DRIVING DOWN THE INTERSTATE, THE VEHICLE CAUGHT ON FIRE. EVERYTHING UNDER THE HOOD WAS DESTROYED. *TR

PULLED OUT OF SIDE ROAD ONTO MAJOR HIGHWAY AND SUDDENLY A LOUD FLAPPING NOISE FROM ENGINE WAS HEARD. IMMEDIATELY PULLED TO SHOULDER OF ROAD AND TURN VEHICLE OFF AND CALLED FOR ASSISTANCE. WAS TOLD THAT A SPARK PLUG WAS THE CAUSE OF THE PROBLEM AND THAT IT SHOULD BE A EASY FIX, THIS WAS NOT THE CASE BECAUSE THE HEAD HAD TO BE REMOVED TO EXTRACTED TO DAMAGED PLUG. OUR FIX IS COSTING UPWARDS OF $700. *JS

TL* THE CONTACT OWNS A 2001 FORD F-150 TRITON. THE VEHICLE WAS TAKEN FOR STATE INSPECTION WHEN THE CONTACT WAS ADVISED THAT THE ENGINE, ENGINE MANIFOLD AND BOLTS WERE CORRODED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE WAS CONFIRMED. THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 68,000 AND THE CURRENT MILEAGE WAS 71,000. UPDATED 05/21/12 *BF THE CONSUMER WAS INFORMED THE MATERIAL USED WERE DEFECTIVE.

TL* THE CONTACT OWNS A 2001 FORD F-150. WHILE PARKED, THE CONTACT NOTICED SMOKE COMING FROM UNDER THE HOOD. AFTER OPENING THE HOOD THE CONTACT NOTICED THAT THE MANIFOLD AND THE WIRING HARNESS WAS ON FIRE. THE CONTACT STATED THAT THE VEHICLE HAD BEEN SHUT OFF AND HAD NOT BEEN DRIVEN PRIOR TO THE FIRE. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE WITH A FIRE EXTINGUISHER. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTICS OR REPAIRS. THE APPROXIMATE FAILURE MILEAGE WAS 28,000.

I'M IN THE LARGE GROWING NUMBER OF OWNERS THAT HAVE HAD A SPARKPLUG BLOW OUT. FORD KNOWS THIS IS A PROBLEM AND HAVE COME UP WITH A SPECIAL TOOL TO HELP IN THE REPAIR OF THIS. IT RETHREADS THE HOLE THEN THEY HAVE AN INSERT THAT GOES IN IT. THE PROBLEM IS THERE'S NOT ENOUGH THREADS TO HOLD THE PLUG. THE THING IS, IF THEY DON'T WANT TO DO A TOTAL RECALL THEN THEY SHOULD AT LEAST COVER THE EXPENSE WHEN IT HAPPENS. I GUESS LIKE EVERYTHING ELSE, IT'S GOING TO TAKE A DEATH OR SERIOUS INJURY BEFORE THEY WILL STEP UP TO THE PLATE AND DO THE RIGHT THING. *TR

SPARK PLUG BLOW OUT CAUSED EXCESSIVE DAMAGE TO ENGINE. ENGINE HAD TO BE REPLACED AT A COST OF $6200.00. THIS IS A KNOWN PROBLEM FOR 1999 TO 2005 ENGINES. *TR

I WAS GETTING ON THE INTERSTATE THIS AM AND HEARD A NOISE, THE TRUCK LOST POWER AND STARTED RUNNING EXTREMELY ROUGH. I TURNED AROUND AND BARELY MADE IT HOME (ONLY A FEW MILES). WHEN I RAISED THE HOOD, A SPARK PLUG WAS LAYING ON TOP OF THE ENGINE. THE COIL PACK WAS ALSO BROKEN WHEN THE SPARK PLUG BLEW OUT. THERE WAS A VERY STRONG SMELL OF GAS. I RESEARCHED THE INTERNET AND FOUND THAT THIS IS A MAJOR PROBLEM WITH FORD ENGINES BUILT FROM 1997 - 2003. IF I HAD BEEN IN A CENTER OR LEFT LANE, BEING RUSH HOUR TRAFFIC, THIS COULD HAVE CAUSED A MAJOR WRECK. THIS PROBLEM SHOULD NOT BE IGNORED AND SHOULD BECOME A RECALL FOR FORD. *TR

ATTEMPTING TO PARK VEHICLE IN PARKING STALL WITH FOOT ON BRAKE STOPPING THE VEHICLE. THE VEHICLE, FOR NO APPARENT REASON, ABRUPTLY ACCELERATED FORWARD STRIKNIG THE VEHICLE ON THE OTHER SIDE OF THE PARKING STALL. THE RESULTING CRASH CAUSED DAMAGE TO THE FRONT OF THE 2011 GMC SPORT UTILITY VEHICLE AND TO THE FRONT OF THE 2001 FORD F-150. THIS IS THE SECOND TIME AN INCIDENT SIMILAR TO THIS HAS OCCURRED. THE FIRST TIME WAS IN AUGUST 2011. THE FIRST TIME THE VEHICLE DEMONSTRATED A SIMILAR PHENOMENA OCCURRED WHEN THE OWNER WAS PARKING THE VEHICLE IN A PARKING STALL. THE VEHICLE WAS STOPPED IN THE PARKING STALL, THE DRIVER'S FOOT ON THE BRAKE AND THE VEHICLE ABRUPTLY ACCELERATED, FOR NO APPARENT REASON, OVER A CONCRETE PARKING BLOCK. THE VEHICLE CONTINUED INTO THE STREET AS THE DRIVER CONTINUED TO APPLY THE BRAKE, ATTEMPTING TO STOP THE FORD F-150. THE DRIVER WAS UNABLE...

I WAS DRIVING TO WORK AND HEARD A LOUD POP AND STOPPED THE TRUCK AND CALLED THE TOW TRUCK. THE MECHANIC INFORMED ME THAT A SPARK PLUG BLEW OUT OF THE HEAD OF THE ENGINE AND IT WAS GOING TO COST $550.00 TO FIX, HE ALSO SAID THAT IT WOULD BE A TEMPORARY FIX AND THAT I WOULD NEED A NEW ENGINE BECAUSE OF THE DAMAGE. I DID SOME RESEARCH AND FOUND THAT THIS HAS BEEN A PROBLEM FOR SOME TIME WITH THESE ENGINES BECAUSE OF THE ALUMINUM HEADS AND THERE WERE ONLY 3-4 THREADS ACTUALLY HOLDING THE SPARK PLUG. A FORD MOTOR CO. WARRANTY INSPECTOR SAYS THE FORD TRITON V-8 ENGINES ARE "DROPPING LIKE FLIES" BECAUSE OF BLOWN SPARK PLUGS. I WOULD LIKE TO ADDRESS THE FORD SPARK PLUG BLOWOUT ISSUE. FORD TRITON ENGINES FROM 1997 TO 2003 HAD A PROBLEM WHERE SPARK PLUGS WOULD RANDOMLY FLY OUT THE...

TL* THE CONTACT OWNED A 2001 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS PARKED FOR A FEW DAYS WHEN IT SUDDENLY CAUGHT ON FIRE AND BURNED TO THE GROUND. THE CONTACT SUFFERED MINOR BURN INJURIES AS A RESULT. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 249,000.

TL* THE CONTACT OWNS 2001 FORD F-150. THE CONTACT STATED THAT THE VEHICLE EXHIBITED AN ABNORMALLY LOUD KNOCKING NOISE FROM THE FRONT END OF THE VEHICLE. THE CONTACT INSPECTED UNDER THE HOOD AND NOTICED THAT THE SPARK PLUG LOCATED NEAREST TO THE DRIVER SIDE HAD DISENGAGED FROM THE COIL HEAD WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE A COIL KIT WAS INSTALLED. A FEW MONTHS LATER, THE SAME FAILURE RECURRED AND THE ENGINE WAS REPLACED BY THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 98,000. CONSUMER IS STILL HAVING PROBLEMS WITH THE ALUMINUM HEAD. UPDATED 11/10/2011 *LN *TR

2001 FORD F-150. THE TRUCK HAD AN UNDER HOOD FIRE WHILE IT WAS IN A PARKING LOT. THE BUSINESS OWNER FOUND ME AFTER THE FIRE WAS STARTED AND PUT OUT. THE TRUCK WAS TOTALED. *TR

2001 FORD F-150. CONSUMER STATES VEHICLE CAUGHT FIRE AND THEN EXPLODED *TGW THE CONSUMER STATED SHE SAW A REPORT ON T.V. REGARDING PROBLEMS WITH FUEL TANKS AND NHTSA WAS INVESTIGATING. *JB

I OWN A 2001 F-150 FORD TRUCK. I HAVE EXPERIENCED 3X NOW IN A YEAR THE SPARK PLUGS BLOWING OUT OF THE HEADS. THE FIRST 2X IT SCARED ME HALF TO DEATH TO THE POINT I LOST CONTROL FOR A FEW SECONDS ( THANK GOD NO ONE WAS ON THE ROAD AT THE TIME). I HAVE HAD THE PLUGS HELI-COILED IN TWICE AND WAITING ON THE 3RD ONE NOW. THE FORD DEALERSHIP I TAKE THE TRUCK TO SAYS, "IT IS A POOR DESIGN IN THE HEADS OF THIS MOTOR THAT CAUSES THE PLUGS TO BLOW OUT AND FORD MOTOR COMPANY KNOWS ABOUT THE PROBLEM." I AM CONCERNED THAT IT WILL HAPPEN TO SOMEONE ELSE AND CAUSE SERIOUS INJURY OR EVEN DEATH DUE TO THE "EXPLOSION" SOUND AT FIRST AND THE EXTREMELY LOUD KNOCKING NOISE. *TR

SPARK PLUG BLOWN OUT OF ENGINE TWICE. FIRST TIME CHEAP FIX SECOND TIME IT WAS OVER $700. SEEMS TO BE A PRETTY COMMON PROBLEM. NEEDS A RECALL DONE. *TR

TL*THE CONTACT OWNS A 2001 FORD F-150. THE VEHICLE WAS PARKED AND SHUT OFF WHEN A FIRE BEGAN ON THE DRIVER'S SIDE OF THE HOOD. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS NOT MOVED FROM THE LOCATION AND WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 209,000.

STARTED TRUCK HEARD A LOUD POP ENGINE RUNNING ROUGH CHECKED,SPARK PLUG BLEW OUT DESTROYING COIL PACK NOW CALLED FORD DEALER THEY SAID NO RECALL CHECKED ON INTERNET NOTICED A LOT OF PEOPLE SAME PROBLEM. A LOT MONEY TO REPAIR. I HAD JUST GOT BACK FROM A 600 MILE TRIP IF THIS HAD HAPPENED DURING TRIP WOULD HAVE COST ME UP TO $4.000 TO GET ON ROAD AGAIN, THIS SHOULD BE A RECALL! AND IF I GET IT FIXED I WILL HAVE TO GET RID OF IT BECAUSE PEOPLE ARE COMPLAINING 2 OR MORE PLUGS ARE BLOWING OUT AND I CAN NOT AFFORD THE FIX .

TL* THE CONTACT OWNS A 2001 FORD F150. THE CONTACT WAS DRIVING APPROXIMATELY 46 MPH WHEN THE ENGINE BEGAN TO SPUTTER WITH LOW ENGINE POWER. IN ADDITION, THE ENGINE EXHIBITED A ROUGH IDLE WHEN SITTING IDLE AT A COMPLETE STOP. THE FAILURE OCCURRED FREQUENTLY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 128,098.

TL* THE CONTACT OWNS A 2001 FORD F150. THE CONTACT STATED THAT THE VEHICLE CAUGHT FIRE WHILE PARKED. THE VEHICLE WAS NOT OCCUPIED WHEN THE FIRE ERUPTED. THE VEHICLE WAS DESTROYED. THE VEHICLE THAT WAS PARKED NEXT TO THE CONTACT'S VEHICLE WAS ALSO EXTREMELY BURNED ON THE PASSENGER SIDE. THE MANUFACTURER WAS CONTACTED AND ADVISED THE CONTACT TO SEND PHOTOS AND SUPPORTING DOCUMENTATION IN REGARDS TO THE FAILURE BEFORE A DETERMINATION WAS MADE REGARDING ASSISTANCE. THE FAILURE AND CURRENT MILEAGE WAS 135,000.

WHILE DRIVING MY 2001 FORD F150 DOWN THE HIGHWAY, A SPARK PLUG BLEW OUT OF THE HEAD AND DAMAGED THE IGNITION COIL. GAS/AIR MIXTURE WAS SENT INTO THE ENGINE COMPARTMENT, AND IF THE PLUG HAD NOT DAMAGED THE COIL, IT COULD HAVE IGNITED THE GAS. THE FUEL LINE IS ALSO JUST ABOVE THE PUG, AND COULD ALSO HAVE EASILY BEEN DAMAGED. *TR

TL* THE CONTACT OWNS A 2001 FORD F150. THE CONTACT STATED THAT FOUR SPARK PLUGS FAILED AND WERE BLOWN INTO THE COIL PACK. THE CONTACT STATED THAT THE FAILURE CAUSED THE VEHICLE TO STALL WITHOUT WARNING. THE MANUFACTURER WAS CONTACTED BUT PROVIDED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE CURRENT AND FAILURE MILEAGE WAS 113,000.

MY HUSBANDS' FORD F150 TRUCK CAUGHT ON FIRE AND WAS TOTALED. THE TRUCK HAD BEEN IDLE FOR 2 DAYS AND NOT DRIVEN MORE THEN 500 FEET OVER THE LAST 2 MONTHS. I WAS AWAKED FROM SLEEP WHEN MY HUSBAND HAPPENED TO GLANCE OUT THE WINDOW AND SEE THE FIRE. THE VEHICLE WAS ON THE STREET. WE CALLED 911 BUT BY THE TIME THEY ARRIVED THE ENTIRE KING CAB PORTION OF THE TRUCK WAS TOTALED. *TR

2001 FORD F150 WAS PARKED FOR 4-5 DAYS IN DRIVEWAY. WOKE UP EARLY A.M. TO LOUD THUMB NOISE. LOOKED OUT, TRUCK WAS ENGULFED IN FLAMES. FIRE DEPTS SAYS IT LOOKS LIKE IT WAS ELECTRICAL AND FROM UNDER HOOD. TRUCK IS A TOTAL LOSS. INSURANCE CO. HAS YET TO LOOK AT TRUCK. *TR

2001 FORD F-150 WITH A 4.6 TRITON-2 SPARK PLUGS BLEW OUT OF THE HEAD ON THE DRIVER'S SIDE. HAD THEM REPAIRED AND THEY BLEW OUT AGAIN A MONTH LATER. *TR

TL*THE CONTACT OWNS A 2001 FORD F150. THE CONTACT STATED WHEN STARTING THE VEHICLE THE ENGINE WOULD EXHIBIT A CONTINUOUS INCREASE AND DECREASE IN ENGINE RPMS. WHILE DRIVING AT SPEEDS OF AT LEAST 20 MPH, THE ENGINE WOULD IDLE TREMENDOUSLY LOUD AND THE CHECK ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC HE PERFORMED AN OIL CHANGE. THE FAILURE PERSISTED AND THE VEHICLE WAS TAKEN TO A SECOND MECHANIC. THE MECHANIC REPLACED THE MASS SENSOR HOWEVER; THE REPAIR DID NOT CORRECT THE FAILURE. THE MECHANIC THEN ADVISED CYLINDER THREE HAD MISFIRED. THE FAILURE HAD NOT YET BEEN CORRECTED TO DATE. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE WAS 62,052.

TWICE, THREE WEEK APART I HAVE HAD ORIGINALL FACTORY INSTALLED SPARK PLUGS EJECTED FROM THE HEAD ON MY 2001 FORD F150 TRITON 5.7 LITER ENGINE. NUMBER 2 PLUG WAS FIRST AND NUMBER 3 PLUG WAS NEXT ALONG WITH THE CD COIL PACKS. *TR

FORD F150 SPARK PLUG # 8 BLOW OUT WHILE DRIVING TO WORK. THERE WERE NOXIOUS FUMES THAT EVENTUALLY BECOME VERY STRONG. I HAVE READ NUMEROUS COMPLAINTS ABOUT THIS AND FEEL THAT THIS MUST BE A SAFETY HAZARD DUE TO OBVIOUS RAW FUEL, HEAT AND POTENTIAL SPARKS. *TR

2001 FORD F-150 LARIAT..5.4 CU .IM ENGINE. MULTIPLE SPARK PLUGS SELF EXTRACT ..AFTER 50,000 MILES, CREATING POSSIBLE FIRE HAZARD. NO WARNING WHEN IT WILL OCCUR. THIS HAPPENS IN SPITE OF ROUTINE NORMAL MAINTENANCE BEING PERFORMED. WHEN THE PLUG POPS OUT IT ALSO BREAKS THE IGNITION COIL TAB FOR THIS CYLINDER THUS MAKING THE CYLINDER INOPERATIVE WITH THE POSSIBILITY OF RAW GASOLINE/ETHANOL BEING EJECTED NEXT TO A UNCONTROLLED SPARK FROM THE LOOSE COIL. VERY DANGEROUS,ESPECIALLY WITH MY WIFE AND KIDS IN THE VEHICLE. THERE HAS BEEN NO NOTIFICATION FROM FORD OF THIS POSSIBILITY. THIS HAS HAPPENED TO AT LEAST A FEW DOZEN TIMES TO VEHICLES IN MY LOCAL AREA. IN FACT, IT MUST BE A FREQUENT SITUATION BECAUSE THERE ARE AFTER MARKET REPAIR KITS.. HELI-COIL INSTALLATION (NOT A PERMANENT REPAIR). THE REPAIR FROM FORD IS TO REPLACE THE ENGINE HEADS...A $5,000.00 PLUS REPAIR COST IF PAST THE WARRANTY PERIOD. FORD WILL...

TL*THE CONTACT OWNS A 2001 FORD F-150. WHILE DRIVING 40 MPH THE CONTACT HEARD A BANGING NOISE IN THE ENGINE AND THE VEHICLE STARTED TO LOSE POWER. THE CONTACT WAS ABLE TO SAFELY DRIVE ONTO THE EMERGENCY LANE AND AFTER LOOKING UNDER THE HOOD, HE OBSERVED THAT A SPARK PLUG WAS MISSING. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC TO HAVE THE VEHICLE REPAIRED. THE CONTACT IS CONCERNED THAT A CRASH COULD HAVE OCCURRED WHEN THE SPARK PLUGGED POPPED OUT OF THE ENGINE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 98,000.

I HAD AN ORIGINAL SPARK PLUG BLOW OUT OF MY FORD F-150 V-8 TRITON MOTOR WHILE I WAS DRIVING ON THE FREEWAY. IT MADE A LOUD POP NOISE AND THEN I SEEN A FLAME I PULLED OVER RIGHT AWAY AND SHUT OFF THE TRUCK AND CALLED FOR HELP. THANKFULLY I WAS NOT HURT AND THE FIRE WENT OUT AND DID NOT BURN THE TRUCK TO THE GROUND. FORD REFUSED TO FIX IT THEY SAID IT WAS NOT A LUBRICATED PART AND MY WARRANTY DIDN'T COVER THE $2000-3000.00 REPAIR. IT IS A DEFECTIVE DESIGN AND THEY KNOW IT BUT ARE NOT ALLOWED TO FIX IT UNDER THE WARRANTY'S. *TR

I OWN A FORD F150 TRITION TRUCK IN MAY OF 2008 I BLEW MY FIRST SPARK PLUG WHILE DRIVING HOME. I TOOK IT TO A LOCAL DEALER, AND THE SERVICE DEPARTMENT INFORMED ME THAT IT WAS A DEFAULT IN THE DESIGN OF THE ENGINE AND THAT FORD WOULD NOT COVER THE APPROXIMATE COST OF $700. FOUR MONTHS LATER, I THREW ANOTHER ONE WHILE SIMPLY STARTING MY TRUCK IN A PARKING LOT. I PAID ANOTHER $700. IT HAS BEEN THREE MONTHS. ON CHRISTMAS EVE, WHILE PULLING OUT INTO TRAFFIC FROM A COMPLETE STOP, I THREW MY 3RD. SPARK PLUG. THIS IS A DEFECT! *TR

SPARK PLUG BLEW OUT OF 2001 FORD F150. *TR

2001 FORD F-150 THE ENGINE ON THE TRUCK CAUGHT ON FIRE CAME TO WORK AT 6AM AROUND 10:15AM FIRE DEPARTMENT WAS CALL TRUCK WAS ON FIRE, THE RADIATOR AND FRONT END WAS ALL MELTED ENGINE COMPLETELY BURN THERE WAS A HOLE IN THE MIDDLE OF THE DASH BOARD AND ALL THE WIRES LOOK BURN. *TR

FORD 5.4 LITERS HAVE THE SPARKPLUG BLOW OUT OF THE CYLINDER HEAD VERY OFTEN 4 HAVE HAPPEN TO MY 2001 FORD F150 WITH THE 5.4 THEY WANT YOU TO USE A THREAD INSERT TO REPAIR THE DAMAGE BUT EVEN THEN IT STILL HAPPENS NOT TO MENTION PRETTY EXPENSIVE TO BOOT IT IS A WELL KNOWN PROBLEM WITH THESE MOTORS THEY ALSO BREAK THE COIL PACKS ON TOP OF THE SPARK PLUG FORD KNOWS OF THE PROBLEM BUT WILL NOT FIX. *TR

TL* THE CONTACT OWNS A 2001 FORD F150. THE CONTACT STATED THAT WHILE EATING DINNER, THE FIRE DEPARTMENT INFORMED HER THAT HER VEHICLE CAUGHT ON FIRE. THE FLAMES WERE EXTINGUISHED, AND SHE HAS A COPY OF THE REPORT. THE INSURANCE COMPANY WAS IN THE PROCESS OF INVESTIGATING THE CAUSE OF THE FAILURE. SHE WAS IN THE PROCESS OF CONTACTING THE MANUFACTURER. THE FAILURE AND CURRENT MILEAGES WERE 147,300.

DRIVING HOME IN MY 2001 F150 SUPERCREW AND WHEN I TURNED ON THE A/C FAN, SMOKE STARTED COMING OUT FROM UNDER THE GLOVE BOX. I PULLED OVER AND LOOK UNDER THE BOX AND NOTICED THE CONNECTOR TO THE FAN SPEED PACK WAS BURNING. I BLEW IT OUT BEFORE IT DID ANY FURTHER DAMAGE, THEN UNPLUGGED IT. NO ISSUES SINCE THEN. *TR

MY 4.6L ENGINE ON MY 2001 FORD F150 PICKUP TRUCK NEEDED NEW SPARK PLUGS. I HAVE CHANGED PLUGS ON MANY MOTORS BEFORE SO IT IS NOT NEW TO ME. I READ THE SERVICE MANUAL AND LEARNED MORE ABOUT THIS PARTICULAR MODEL BY READING INFORMATION OFF THE NET. I WAS VERY CAREFUL AND DID EVERYTHING THE SERVICE MANUAL AND NET INFO TOLD ME TO DO. EVEN SO, THE VERY FIRST PLUG I REMOVED FROM THE ENGINE BLOCK BROKE. THE PORCELAIN AND HEX NUT CAME OUT IN ONE PIECE BUT THE BOTTOM THREADS AND GROUND ELECTRODE REMAINED IN THE ENGINE BLOCK. I WENT BACK TO THE NET TO SEARCH FOR SOLUTIONS TO THE PROBLEM ONLY TO FIND THAT MORE OFTEN THAN NOT THE SPARK PLUGS ON THESE MODELS WILL BREAK APART WHEN REMOVING THEM. I BELIEVE THIS FALLS UNDER THE CATEGORY OF A RECALL. THIS WILL BE A COSTLY REPAIR THAT I...

I OWN A 2001 FORD F150 PICKUP. I'VE HAD TO CHANGE A COIL (ABOVE SPARK PLUG) ON THIS TRUCK SEVERAL TIMES (AT LEAST 5 FAILURES) SINCE I'VE OWNED THIS TRUCK. WHEN A COIL GOES OUT THE TRUCK MISSES A LOT AND AT TIMES WHEN YOU SLOW DOWN TO TURN A CORNER THE TRUCK WILL DIE, CAUSING ME TO BRAKE TO AN IMMEDIATE STOP BECAUSE THE POWER STEARING GOES OUT. VERY DANGEROUS. *TR

SPARK PLUG BLOWN OUT OF ENGINE. 2 YEARS AFTER DEALER INSTALLED. *TR

I HAVE A 2001 FORD F150 WITH THE 4.6L TRITON. DRIVING HOME FROM WORK ON THE EVENING OF APRIL 27TH, IM AT A RED LIGHT. AS SOON AS IT TURNS GREEN I PUSH THE PEDAL TO GO. OUT COMES THE SPARK PLUG FROM THE BLOCK. I HAVE READ NUMEROUS COMPLAINTS ABOUT THIS ISSUE ON THE INTERNET. I CANNOT BELIEVE FORD HAS NOT ISSUED A RECALL OVER THIS. NOT ONLY IS IT DANGEROUS, BUT ITS A SILLY PROBLEM TO HAVE. I HAVE HAD 5 ESTIMATES TO FIX THIS PROBLEM ALL OVER $2000. THERE'S NO WAY I CAN AFFORD THIS, I AM LOOKING FOR A CLASS ACTION LAWSUIT TO JOIN. VERY DISAPPOINTED IN FORD AND WHEN I GET THIS FIXED I WILL NEVER OWN ANOTHER FORD VEHICLE. *TR

ONE MORNING UPON STARTING MY 2001 FORD F-150, I HEARD A LOUD POP AND KNOCKING COMING FROM MY ENGINE COMPARTMENT. THE #3 SPARK PLUG ON THE PASSENGER SIDE, SHOT OUT OF THE CYLINDER HEAD AND BROKE THE #3 CYLINDER IGNITION COIL, STRIPPING THE THREADING ON THE CYLINDER HEAD. IGNITION COIL, SPARK PLUG, AND STEEL INSERT THREADING WERE REPLACED. MILEAGE = 124515 5.4 V8 THIS IS APPEARS TO BE A WELL-KNOWN PROBLEM: HTTP://ABCLOCAL.GO.COM/KGO/STORY?SECTION=NEWS/7_ON_YOUR_SIDE&ID=4757786 HTTP://WWW.CONSUMERAFFAIRS.COM/NEWS04/2007/03/FORD_SPARK_PLUG_FIRE.HTML HTTP://EZINEARTICLES.COM/?FORD-SPARK-PLUG-PROBLEMS---SPARK-PLUGS-BROKEN-AND-BLOWING-OUT&ID=1107803. *TR

FIRE F 150. *TR

TL*THE CONTACT OWNS A 2001 FORD F-150. THE VEHICLE CAUGHT FIRE WHILE PARKED OUTSIDE THE CONTACT'S PLACE OF WORK. THE FIRE DEPARTMENT WAS NOTIFIED, BUT DID NOT STATE WHAT CAUSED THE FIRE. THE FIRE BURNED THE MOTOR, CREATED A HOLE THROUGH THE HOOD OF THE VEHICLE, AND SCORCHED THE ENTIRE DASHBOARD. THE WINDSHIELD GLASS BURST INTO PIECES AND THE VEHICLE WAS TOWED TO HIS RESIDENCE. THE FORD DEALER FILED A CASE AND FOLLOWED-UP WITH THE CONTACT WITHIN 15 BUSINESS DAYS AND INFORMED HIM THAT SOMEONE WOULD DIAGNOSE THE VEHICLE. THE CONTACT WAS ALSO INFORMED THAT THERE WAS A RECALL FOR THE CRUISE CONTROL. THE VIN AND NHTSA CAMPAIGN ID NUMBER WERE UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 197,000. UPDATED 04/17/09. *LJ UPDATED 04/20/09.*JB

2001 FORD F-150 BLEW OUT A SPARK PLUG FOR THE 2ND TIME. CAUSED THE TRUCK TO GO OFF THE ROAD SINCE IT IMMEDIATELY LOST POWER WHILE GOING 65MPH. THIS IS THE 2ND ONE THAT HAS BLOWN AND WILL LIKELY COST A FEW THOUSAND DOLLARS TO FIX. THERE IS A FORUM ON CONSUMER AFFAIRS WITH HUNDREDS OF PEOPLE WITH THE SAME EXACT PROBLEM WITH THEIR FORD VEHICLE. THE WEBSITE LINK IS HTTP://WWW.CONSUMERAFFAIRS.COM/AUTOMOTIVE/FORD_SPARK.HTML IF YOU WOULD LIKE TO CHECK IT OUT. *TR

DRIVING 35 TO 40 MILES AN HOUR. HEARD A LOUD POP UNDER THE HOOD PULLED OVER AND FOUND A SPARK PLUG HAD BLOWN OUT OF THE ENGINE. NOT FIXED YET. *TR

I OWN A 2001 FORD F 150 W/ THE 5.4 TRITON ENGINE, WHILE I WAS BACKING THE TRUCK OUT OF A RESTAURANT, THE ENGINE MADE A LOUD POP. I TOOK THE TRUCK TO A FORD DEALERSHIP...THEY TOLD ME THAT THE ENGINE BLEW THE # 3 SPARK PLUG OUT. THE SERVICE DEPARTMENT TOLD ME THAT THIS IS A COMMON PROBLEM WITH THE MOTOR BECAUSE OF BAD DESIGNED HEADS. THEY ADVISED ME THAT I WOULD BE BETTER OFF WITH A NEW ENGINE AT THE COST OF $4800.00. I PULLED UP A SITE ON THE INTERNET THAT STATES THAT THERE HAVE BEEN THOUSANDS OF COMPLAINTS WITH THE SAME PROBLEMS. I FEEL LIKE FORD SHOULD HAVE A RECALL ON THIS ENGINE. *TR

TL*THE CONTACT OWNS A 2001 FORD F150 LD. THE CONTACT'S VEHICLE CAUGHT FIRE WHILE IT WAS PARKED. SHE STATED THAT THE FIRE ORIGINATED NEAR THE MOTOR AND BRAKE FLUID. THE FIRE DEPARTMENT WAS NOT CALLED TO THE SCENE. THE CONTACT EXTINGUISHED THE FIRE BY DISCONNECTING THE BATTERY. THE MANUFACTURER HAS NOT YET BEEN NOTIFIED AND THE VEHICLE HAS NOT BEEN REPAIRED. THE VEHICLE IS STILL AT THE CONTACT'S RESIDENCE. THE VIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 157,889.

ON 10/5/08, DRIVING NEAR HOME, SLOW SPEED, HEARD A LOUD NOISE FROM UNDER THE HOOD, LOST POWER. DETERMINED THAT THE 4TH SPARK PLUG ON DRIVERS SIDE HAD UNTHREADED FROM ENGINE, DAMAGING COIL. ON ATTEMPT TO REPLACE WITH NEW SPARK PLUG, LEARNED THAT THE CYLINDER HEAD THREADS WERE DAMAGED (STRIPPED). 76,000 MILES, SPARK PLUG HAD NEVER BEEN REMOVED, WAS ORIGINAL FROM FORD FACTORY. *TR

MY 2001 FORD F-150 BLEW A SPARK PLUG OUT OF THE 7 HEAD ON 09/30/2008. THE TRUCK HAS 150K ON IT. I BOUGHT IT NEW IN 2001 AND HAVE ALWAYS MAINTAINED IT. I WENT OUT TO GO TO WORK IN THE AM AND THE TRUCK JUST ROARED WHEN I STARTED IT, I FOUND THE SPARK PLUG ON THE DRIVEWAY THE THREADS ON THE PLUG WERE COMPLETELY IN TACT. TOOK IT FORD SERVICE AND IT WILL COST ME $2500.00 TO FIX WITH NO GUARANTEE. I HAVE FOUND THAT THIS IS A REALLY COMMON COMPLAINT FROM OWNERS OF V8 TRITON ENGINES. FORD NEEDS TO DO A RECALL ON THESE VEHICLES. MY BROTHER-IN-LAW IS AN ASI FRONT END MECHANIC FOR FORD AND HE SAYS HE HAS SEEN A LOT OF THIS PROBLEM. IF HE DIDN'T LIVE IN DENVER I WOULD HAVE HIM FIX IT. MY FAMILY HAS ALWAYS DRIVEN FORD PRODUCTS. MY FATHER...