2006 FORD EXPLORER Engine And Engine Cooling Problems

MY CAR SLOWED DOWN TO A CRAW IN THE HIGHWAY AND HAD TO LIMP HOME AT VERY LOW SPEED ALMOST CAUSED A CRASH.

I BOUGHT MY FORD EXPLORER IN 2006 BUT THREE YEARS LATER HAD TO REPLACE THE RADIATOR. AFTER THAT I NOTICE THAT THE TRANSMISSION WOULD SLIP EVERY NOW AND THEN. THE PROBLEM SEEMS TO HAVE ESCALATED SINCE JUNE 2013 WITH THE VEHICLE JACKING OR DRAGGING BEFORE SHIFTING GEARS. MY WIFE IS ACTUALLY AFRAID OF DRIVING THIS VEHICLE AND INSTEAD PREFERS TO DRIVE MY 2000 HONDA ACCORD WHICH HAS BEEN RUNNING WITH NO PROBLEMS. I TOOK THE VEHICLE TO MY MECHANIC WHO TOLD ME THIS HAS BEEN A PROBLEM WITH THE MODEL AND YEAR OF MY FORD EXPLORER AND THAT THE TRANSMISSION WILL NEED TO BE REPLACED AND SO HE TOLD ME I SHOULD FILE THIS COMPLAIN SINCE THIS WAS NOT OUR FAULT BUT A FACTORY DEFECT WHICH BY THE LOOK OF WHAT I HAVE SEEN ON THIS SITE, FORD IS AWARE OF. MY QUESTION IS WHY HAS FORD NOT RECALLED THIS...

I HAVE HAD THE DOOR BLENDER PLASTIC PIECE CHANGED ON MY CAR THREE TIMES! EACH TIME THE SEASON CHANGES. I NOW HAVE TO REPLACE IT AGAIN. I CURRENTLY HAVE A RADIATOR LEAK AND WILL HAVE TO REPLACE THE RADIATOR AND PLASTIC HOLDER AS WELL. I ALSO CURRENTLY HAVE A TRANSMISSION SLIPPAGE PROBLEM AND I WILL HAVE TO GET THAT FIXED AS WELL. THIS IS HORRIBLE. I PURCHASED THE FORD EXPLORER BECAUSE I THOUGHT IT WAS DEPENDABLE. THIS IS DEPRESSING AND I CAN NOT AFFORD IT! *TR

THE RADIATOR IN THE 2006 FORD EXPLORER LEAKS, AND A RECALL IS MANDATORY. I BOUGHT THIS VEHICLE IN 2007, USED, AND I AM NOW FACED WITH REPLACING THE RADIATOR FOR THE 4TH TIME IN 7 YEARS. IT IS A KNOWN ISSUE THAT THIS RADIATOR IS FAULTY AND STILL THERE IS NO RESOLVE. PLEASE OPEN AN INVESTIGATION AND READ ALL THE COMPLAINTS REGARDING THE RADIATOR FOR THIS VEHICLE. *TR

VEHICLE WAS JUST AT THE FORD DEALERSHIP FOR OVER A WEEK IN MARCH FOR TRANSMISSION RELATED ISSUES, NEW RADIATOR, ETC. JUST FOUR MONTHS LATER, I AM HAVING THE SAME ISSUES THAT MANY OTHERS ARE WRITING ABOUT; HARD SHIFT INTO REVERSE, VEHICLE IS JUMPING/JOLTING FORWARD FROM A STOP, RPM FLUCTUATION WHILE IDLING. *TR

THE RADIATOR LEAKS ON ALMOST ALL 2006 MODELS FROM THE FACTORY. FORD ACKNOWLEDGES THE ISSUE WAS FROM OVERTIGHTENING, YET DOES NOT ISSUE A RECALL. *TR

I DISCOVERED A LEAK IN THE RADIATOR AFTER NOTICING THAT THE TEMPERATURE GAUGE NEEDLE WAS BOUNCING AROUND AT AN IDLE. AFTER ABOUT A MINUTE, THE VEHICLE OVERHEATED AND STARTED STEAMING. WE ENDED UP HAVING TO HAVE THE RADIATOR REPLACED AT A COST OF $600. (IT WAS ALSO OVER 90 DEGREES THAT DAY AND I WAS STRANDED WITH TWO SMALL CHILDREN, THE YOUNGEST WAS 4 MONTHS OLD.) THEN ABOUT A MONTH AGO, IN MAY 2012, I WAS AT A GROCERY STORE AND WHEN I WENT TO ENTER THE VEHICLE I NOTED A LARGE PUDDLE OF ANTIFREEZE ON THE GROUND AND IT WAS DRIPPING FROM THE RADIATOR. WE HAD TO HAVE THE RADIATOR REPLACED, AGAIN AT A COST OF $600. THE SAME MECHANIC REPAIRED IT BOTH TIMES AND SAID IT WAS THE SAME ISSUE AS THE FIRST ONE. NOW WE ARE HAVING TRANSMISSION FLUID LEAKING FROM THE COOLING LINE THAT LEADS FROM...

I HAVE A 2006 FORD EXPLORER XLT AND THIS WILL BE THIRD TRANSMISSION TO GO INTO THE VEHICLE. IN ADDITION, I HAVE REPLACED THE RADIATOR THREE TIMES AND AN ENGINE BLOCK SEAL. THESE ARE VERY COSTLY FIXES FOR A CAR THAT IS ONLY A COUPLE OF YEARS OLD. I HAVE REACHED OUT TO FORD CUSTOMER SERVICE AND THEY ARE NOT HELPFUL OR SYMPATHETIC AT ALL AND CLAIM THAT THEY ARE NOT AWARE OF ANY TRANSMISSION PROBLEMS. MEANWHILE, WHEN YOU SEARCH THE WEB IT IS AN ISSUE ACROSS THE BOARD. I FEEL THEIR CUSTOMER SERVICE IS HORRIBLE AND SO ARE THEIR CARS. I WOULD NEVER RECOMMEND A FORD TO ANYONE, NOT EVEN MY WORST ENEMY. I COULD HAVE BOUGHT TWO CARS FOR THE MONEY I AM PUTTING INTO THIS VEHICLE. *TR

I HAVE BEEN HAVING SOME MISFIRING SPARK PLUGS ON MY TRUCK. WE ARE PRICING THEM OUT AND ARE FINDING OUT THAT THEY ARE VERY HARD TO REPLACE AND THEY BREAK OFF INSIDE THE ENGINE! DEALERS DO NOT RECOMMEND REPLACING THEM YOURSELF AND IT COSTS $300 TO HAVE THEM DO IT, THEN $100 FOR EVERY SPARK PLUG THAT BREAKS DURING THAT PROCESS, PLUS THE $19 FOR EACH MOTORCRAFT BRAND PLUG! THIS COULD COST US UP TO $1500 JUST TO REPLACE SPARK PLUGS?! THIS IS INSANITY!!! NOT ONLY DOES IT BUILD UP CARBON BUT IT IS ALSO A 2 PIECE PLUG AND IT BREAKS APART! THIS NEEDS TO BE RECALLED! PEOPLE ARE SPENDING A FORTUNE JUST TO REPLACE SPARK PLUGS! ITS SICK! *TR

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT THE PLASTIC IN THE RADIATOR CRACKED AND WAS LEAKING. THE FAILURE CAUSED THE VEHICLE TO OVERHEAT. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DETERMINED THAT THE RADIATOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND THE CURRENT MILEAGES WERE 68,000.

HAVING PROBLEMS WITH FLUID OVERFLOWING TO THE OVERFLOW TANK, OVERHEATING AND CYLINDER MISFIRE READINGS. *TR

I HAVE HAD TO CHANGE THE RADIATOR THREE TIMES AND GETTING READY TO DO IT AGAIN THE SECOND TIME THE TRUCK RAN HOT AND RUINED THE MOTOR. I THEN PUT ANOTHER MOTOR AND NEW RADIATOR AND IT HAS NOT BEEN 40000 MILES AND WITH NO WARNING AT ALL IT DONE IT AGAIN WITH ALL OF THE COMPLAINTS THAT HAS BEEN POSTED ONLINE THIS SHOULD HAVE BEEN ADDRESSED TO EVERY ONE THAT HAS THIS PROBLEM. *TR

THE VEHICLE HAS HARSH UPSHIFTS WHEN ACCELERATING FROM 1ST TO 4TH GEAR, CREATING MOMENTARY LOSS OF CONTROL. THE VEHICLE WILL STALL, THEN JERK FORWARD A FEW INCHES UNANNOUNCED, WHICH HAS THE POTENTIAL OF CAUSING A WRECK OR HITTING A PEDESTRIAN. THE SAME WILL OCCUR WHEN SHIFTING FROM DRIVE TO REVERSE, AND VICE-VERSA. ALSO, SOMETIMES THE RPM WILL INCREASE DRASTICALLY ON ITS OWN WITHOUT AN INCREASE IN SPEED. I'M AFRAID THIS WILL CAUSE AN ACCIDENT IF THE SPEED DECIDES TO INCREASE. *TR

2006 FORD EXPLORER XLT W/4.0 L HAD A COOLANT LEAK AND NEEDED A NEW RADIATOR. MILEAGE WAS 40,005. RADIATOR WAS REPLACED ON 11/16/2009. TWO YEARS LATER (1/1/12) THE RADIATOR IS AGAIN LEAKING AND NEEDS TO BE REPLACED. CURRENT MILEAGE IS 54,435. *TR

RADIATOR FAILURE. THE RADIATOR FAILED CAUSING THE ENTIRE ENGINE TO OVERHEAT. SEE ODI NUMBER 10439878. REPLACED ENTIRE ENGINE AND RADIATOR IN THIS VEHICLE WHICH ONLY HAS 68,000 MILES ON IT. (COSTING OVER $6000). PLEASE ISSUE A RECALL. *TR

THIS 2006 EXPLORER EDDIE BAUER CAR STARTED MAKING ROARING SOUND WHEN TRYING TO ACCELERATE. TRIED BACKING OFF THE ACCELERATOR AS MUCH AS POSSIBLE. THERMOSTAT GAUGE TEMPERATURE WENT TO HOT AND DISPLAYED RED AND A/C STARTED BLOWING COLD AIR. THERMOSTAT THEN WENT FROM HOT TO COLD MULTIPLE TIMES. CHECKED COOLANT LEVELS AND THEY WERE FINE. THE ENGINE AND CAR FINALLY SHUT DOWN COMPLETELY AND THE CAR THEN OVERHEATED. COOLANT BLEW OUT AT THE HOSE AT THE THERMOSTAT. TOWED THE CAR TO A NATIONWIDE REPAIR SHOP WHERE THEY REPLACED THERMOSTAT AND PRESSURE TESTED COOLING SYSTEM BUT CAR WILL NO LONGER IDLE AND ENGINE NOW HAS MAJOR PROBLEMS. TOWED THE CAR TO THE FORD DEALERSHIP AND THEY ARE NOW SAYING IT MAY HAVE A BLOWN HEAD GASKET ($2200 OR MORE) AND OR ENGINE NEEDS TO BE REPLACED ($5600). THEY ARE GOING TO CHECK WITH FORD TO SEE IF THEY CAN PROVIDE ASSISTANCE. THIS...

TL* THE CONTACT OWNS A 2006 FORD EXPLORER EDDIE BAUER EDITION. THE CONTACT WAS DRIVING APPROXIMATELY 45 MPH WHEN THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT THEN REALIZED THAT THE VEHICLE HAD OVERHEATED AS IT PROCEEDED TO STALL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY ADVISED HER THAT THE RADIATOR AND THERMOSTAT FAILED. THE VEHICLE WAS REPAIRED BUT THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED AGAIN AFTER TWO WEEKS. THE VEHICLES WAS TAKEN BACK TO THE INDEPENDENT MECHANIC WHERE THEY INFORMED THE CONTACT THAT THE HEAD GASKET WAS BLOWN AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED BUT OFFERED NO ASSISTANCE TO THE CONTACT. THE FAILURE MILEAGE WAS APPROXIMATELY 84,000.

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT THE TEMPERATURE GAUGE STARTED TO INCREASE AND THE TEMPERATURE WARNING LAMP ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE RADIATOR WAS LEAKING AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 36,000.

RADIATOR FAIL CAUSED CAT DEATH. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING TRANSMISSION FLUID AND RADIATOR COOLANT. AND AS A RESULT, THE RADIATOR FAILED. A PRIVATE MECHANIC MADE THREE ATTEMPTS TO REPAIR THE FAILURE BY REPLACING THE RADIATOR BUT TO NO AVAIL. THE DEALER DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE HOWEVER, DID NOT OFFER ANY ASSISTANCE. THE CURRENT MILEAGE WAS 78,000 AND THE APPROXIMATE FAILURE MILEAGE WAS 43,000.

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT THE RADIATOR CONTINUED TO LEAK. THE LEAKING WAS CAUSED BY THE PLASTIC MATERIAL SEPARATING FROM THE ALUMINUM, WHICH WAS CAUSING THE VEHICLE TO OVERHEAT. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHERE THE DEALER ADVISED THAT THE RADIATOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE DEALER ALSO ADVISED THAT THE THERMOSTAT NEEDED TO BE REPLACED AS WELL DUE TO THE RADIATOR FAILURE. THE FAILURE MILEAGE WAS 67,000. THE CONSUMER COULD NOT AFFORD TO FIX THE PROBLEM. SHE ALSO STATED THE WERE PLENTY OF WEBSITES DEVOTED TO THE EXACT RADIATOR AND THERMOSTAT PROBLEM. UPDATED 11/21/11...UPDATED 11/25/11 *BF UPDATED 11/30/11

WHILE DRIVING THE VEHICLE, THE SMELL OF ANTIFREEZE STARTED COMING INTO THE CAR. MY FIANCE' CHECKED THE RADIATOR AND OVERFLOW BOTTLE AND FOUND OUT IT WAS GAS MIXED WITH THE ANTIFREEZE. MY CAR'S MILEAGE IS 80100. I DO NOT BELIEVE THE CAR SHOULD HAVE THIS ISSUE AT ONLY 5 YEARS. THIS PROBLEM/COMPLAINT SHOULD BE INVESTIGATED AND DAMAGES SHOULD BE COVERED BY THE DEALERSHIP OR MANUFACTURER. *TR

WE PURCHASED OUR 2006 EXPLORER USED WITH 61,000 IN SUMMER 2009. THE DEALERSHIP DID A COMPLETE INSPECTION AND REPLACED EVERYTHING WE FOUND AS DEFECTIVE OR AS A RECALLED ITEM. THE COOLANT SYSTEM WASN'T ONE OF THESE ISSUES. DROVE VEHICLE ALL SUMMER AND INTO THE FALL WITHOUT ISSUE. BY LATE FALL OF 2009 VEHICLE HAD ANTI-FREEZE LEAK, JUST AFTER THE FIRST FROST IN NE. LOCAL AUTO SERVICE PROVIDOR REPLACED RADIATOR TWICE IN ONE MONTH WITH NAPA PARTS WITHOUT REMEDY AND THEN EVENTUALLY THEY HAD TO REPLACE WITH AN AUTHORIZED FORD RADIATOR TO GET IT NOT TO FAIL. ALSO REPLACED THE WATER PUMP, ALL HOSES, PULLIES, AND FLUID TO MAKE SURE THERE WERE NO OTHER ISSUES. STILL LEAKED BUT MINOR AND FINALLY WAS CORRECTED IN SPRING OF 2010. BY LATE FALL 2010, AGAIN AFTER THE FIRST FROST THE VEHICLE WAS LEAKING ANTI-FREEZE AGAIN. TOOK IT TO FORD DEALERSHIP THIS TIME WHERE THEY...

ENGINE STALLS. WHENEVER IT FEELS LIKE IT, HOT OR COLD, SLOWING DOWN TO STOP, TURNING LEFT OR RIGHT, ON THE STREET ROADS AND FREEWAYS. STARTS AND GO AGAIN AFTER 5/10 MINUTES BUT THIS IS RIDICULOUS. I PAID SO MUCH MONEY AND TIME FOR DIAGNOSTIC AND PARTS ALREADY AND YESTERDAY WAS THE WORST. MY 2006 FORD EXPLORER STALLED IN THE MIDDLE OF THE FREEWAY. DATE: NOV 1, 2011, TIME:1550, AND MY WIFE WAS DRIVING, WHEN SHE'S NOT HAPPY, NOBODY'S HAPPY....SHE ALMOST GOT RAN OVER AS SHE OPEN HER DOOR, SHE COULD NOT GO ANYWHERE BUT WAIT FOR TIME TO EITHER COOL OFF OR RESET ON THE ENGINE. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT THE RADIATOR FAILED. THE RADIATOR WAS REPLACED TWO YEARS PRIOR TO THE MOST RECENT FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THEY COULD REPLACE THE RADIATOR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 39,000 AND THE CURRENT MILEAGE WAS 63,000.

MY 2006 FORD EXPLORER HAS 44,000 MILES ON IT AND NEEDS A NEW RADIATOR,AFTER CHECKING COMPLAINTS ONLINE FOR THE SAME PROBLEM, I HAVE FOUND MANY COMPLAINTS ABOUT THIS ISSUE.I BELIEVE FORD NEEDS TO RECALL THIS VEHICLE FOR THE RADIATOR ISSUE. THE LEAK FROM THE RADIATOR CAN SEEP INTO THE GROUND AND INTO THE UNDERGROUND WATER SYSTEM,NOT TO MENTION ANY ANIMALS THAT WOULD DRINK FROM THE PUDDLES LEFT BEHIND FROM THIS VERY TOXIC ANTI-FREEZE. THE REPLACEMENT OF THIS ITEM COST ALMOST $1200 AT A FORD DEALER,THESE TRUCKS ARE ONLY 5 YEARS OLD AND I KNOW PEOPLE WHO HAVE REPLACED 3 OR MORE RADIATORS SINCE THEY PURCHASED THEIR EXPLORERS. IT SEEMS TO BE A BIGGER PROBLEM FOR THE 2006 MODEL WHEN FORD CHANGED THE RADIATOR TO PLASTIC. I WONDER HOW MANY ACCIDENTS WHERE CAUSED WHEN THE RADIATOR FAILED AND SEIZED THE ENGINES WHILE PEOPLE WHERE DRIVING? *TR

TL* THE CONTACT OWNS A 2006 FORD EXPLORER XLT. THE CONTACT WAS DRIVING 60 MPH WHEN THE ENGINE STALLED. THE CONTACT NOTICED A LEAK COMING FROM THE RADIATOR. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY CONFIRMED THAT THERE WAS A HOLE IN THE RADIATOR .THE MANUFACTURER WAS NOT CONTACTED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 71,000 AND THE CURRENT MILEAGE WAS 82,000.

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED WHILE DRIVING 45 MPH, THE TEMPERATURE GAUGE DISPLAYED A READING INFORMING HER THAT THE ENGINE WAS OVER HEATING. THE CONTACT ALSO STATED THAT WATER WAS LEAKING FROM THE ENGINE. AN INDEPENDENT MECHANIC EXAMINED THE VEHICLE AND STATED THAT THE RADIATOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE RECURRED APPROXIMATELY EIGHT MONTHS LATER. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 80,000.

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS, THE TEMPERATURE GAUGE WOULD INDICATE THAT THE ENGINE WAS OVERHEATING. THE CONTACT ALSO NOTICED THERE WAS FLUID LEAKING FROM THE RADIATOR. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO INFORMED THE CONTACT THAT THE RADIATOR WAS CRACKED AND THE THERMOSTAT HOUSING FAILED. THE CONTACT WAS ALSO INFORMED THAT THIS WAS A COMMON FAILURE THAT REQUIRED THE RADIATOR BE REPLACED WITH A NEWLY DESIGNED VERSION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 85,000. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THE RADIATOR WAS REPLACED FOUR TIMES. THE RADIATOR BEGAN TO LEAK AND CAUSED THE VEHICLE TO RUN HOT. THE CONTACT STATED THAT THE RADIATOR WAS REPLACED EVERY 25,000 MILES. ALL OF THE RADIATORS WERE BEEN REPLACED BY AN AUTHORIZED DEALER, BUT THE DEALER STATED THERE WAS NO CAUSE FOR THE FAILURE. THE VIN WAS NOT AVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE 105,000.

THIS VEHICLE CONSTANTLY OVERHEATS. I HAVE TO ADD COOLANT EVERY FEW DAYS. IT FIRST STARTED DURING A DAY TRIP. PRIOR TO LEAVING I HAD MY OIL CHANGED AND ALL MY FLUIDS WERE FILLED. AFTER LEAVING THE HIGHWAY THE CAR COMPLETELY SHUT OFF. I HAD TO GO TO A GAS STATION AND ADD MORE COOLANT IT WAS ONLY A THREE HOUR TRIP AND IT WAS COMPLETELY DRY. SHORTLY AFTER THE TRANSMISSION BECAME SHIFTING HARD. IT JERKS AND SEEMS TO MISS GEARS. AT THE TIME IT ONLY HAD 40,000 MILES. NOW I HAVE TO BE EXTREMELY CAREFUL WITH THE TRANSMISSION AND MUST KEEP COOLANT IN MY VEHICLE. I HAVE 4 SMALL CHILDREN AND I AM AFRAID THIS VEHICLE IS A FIRE DANGER BECAUSE OF THE RADIATOR. I AM FINANCING THIS VEHICLE AND DON'T HAVE THE MONEY TO GET A NEW ONE. THIS VEHICLE TODAY HAS 54,000 MILES AND IF BUILT CORRECTLY I...

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH, ALL OF THE WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL AND THE TEMPERATURE GAUGE BEGAN TO FLUCTUATE TO VERY HOT. THE CONTACT DROVE TO THE SIDE OF THE ROAD WITH CAUTION. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE RADIATOR WAS REPLACED. THE MOST RECENT IDENTICAL FAILURE RECURRED AND THE RADIATOR WAS REPLACED FOR THE SECOND TIME. THE MANUFACTURER WAS NOT MADE AWARE OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 90,000. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2006 FORD EXPLORER EDDIE BAUER. WHILE DRIVING APPROXIMATELY 10-60 MPH, THE VEHICLE BEGAN TO JERK ABNORMALLY. THE VEHICLE WOULD ALSO OVERHEAT SPORADICALLY AND THE REAR WINDSHIELD WIPERS WOULD NOT OPERATE. THE VEHICLE WAS TAKEN TO A LOCAL TRANSMISSION SPECIALIST WHERE THEY REBUILT THE TRANSMISSION AND ATTEMPTED TO REPAIR THE REAR WINDSHIELD WIPERS BUT TO NO AVAIL. THE FAILURE PERSISTED AND THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR THE FAILURES. THE DEALER MADE REPAIRS TO THE COOLING SYSTEM BUT WAS UNABLE TO DISABLE THE REAR WINDSHIELD WIPERS TO MAKE REPAIRS. THE FAILURE MILEAGE WAS 100,000. UPDATED 04/25/11 *BF UPDATED 1/13/2012 *LN *TR

VEHICLE JUST CUT OFF ONE DAY WHILE DRIVING, LOST POWER, WRENCH LIGHT CAME ON. CUT THE VEHICLE OFF AND START IT UP AND OFF YOU GO. THIS PROBLEM OCCURS OVER THE NEXT YEAR, ABOUT 2 TO 3 TIMES A MONTH. HAVE TAKEN THE VEHICLE TO THE DEALER, THEY SAID THERE WAS NOTHING THEY COULD DO BECAUSE THE ENGINE LIGHT WAS NOT ON. FINALLY AFTER SEVERAL MORE MONTHS OF THE SAME PROBLEM HAPPENING THE ENGINE LIGHT COMES ON AND STAYS ON. TAKE IT BACK TO THE DEALER AND GIVE SOME MORE MONEY TO THEM, JUST FOR THEM TO COME TO THE CONCLUSION THAT THE THROTTLE BODY NEEDS TO BE REPLACED, AND THAT I HAVE A SMALL LEAK IN THE RADIATOR. I DO NOT HAVE THE MONEY TO GET THE REPAIRS DONE. I'M ALREADY MAKING PAYMENTS EVERY MONTH FOR A VEHICLE THAT WON'T WORK RIGHT. I TAKE CARE OF MY VEHICLE AND...

WE PURCHASED A 2006 FORD EXPLORER A FEW YEARS AGO AND EVER SINCE WE GO IT, WE HAVE BEEN HAVING ISSUES WITH THE WRENCH LIGHT COMING ON. WHEN THIS LIGHT TURNS ON THE CAR STARTS JERKING AND WE CANT STEP ON THE GAS ANY MORE BECAUSE THE CAR HESITATES TO GO. WE HAVE TO PULL OVER TURN THE CAR OFF, WAIT A WHILE THEN TURN IT BACK ON AND THE CAR IS OK AGAIN, BUT THE ENGINE LIGHT STAYS ON SOMETIMES FOR A FEW HOURS AND SOMETIMES FOR A FEW DAYS. WHEN WE 1ST HAD THE PROBLEM WE TOOK IT BACK TO THE DEALER AND THEY SAID NOTHING WAS WRONG. WE TOOK IT BACK A FEW MORE TIMES AND THEY KEPT TELLING US THE SAME THING. WELL THAT DEALER CLOSED, WE TOOK IT TO OTHER FORD DEALERS AND THEY WOULD TELL US THE SAME THING, THERE IS NOTHING WRONG WITH...

TL*THE CONTACT OWNS A 2006 FORD EXPLORER. WHILE DRIVING AT 55 MPH, A RED SERVICE LIGHT ILLUMINATED AND THE VEHICLE SUDDENLY STALLED. THE CONTACT PULLED OVER AND WOULD NOT RESTART. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALERSHIP WHERE THE CONTACT WAS INFORMED THAT THE RADIATOR FAILED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 44,000. UPDATED 07/22/10 *BF THE CONSUMER STATED THE ENGINE AND THE RADIATOR NEEDED TO BE REPLACED. UPDATED 07/26/10

RADIATOR LEAK IN 2006 FORD EXPLORER. V6 ENGINE. HAPPENED AT 42,000 MILES. HAPPENED A SECOND TIME ON 4/11/10. *TR

2006 FORD EXPLORER - RADIATOR FAILURE - VEHICLE HAS 70,000 MILES ON IT. THIS IS THE FOURTH TIME THE RADIATOR HAS HAD TO BE REPLACED. FORD MOTOR COMPANY HAS REFUSED TO OFFER ANY ASSISTANCE REGARDING THE REPAIR OF THIS PROBLEM. HOWEVER, IN APRIL 2009 THEY ISSUED A TSB REGARDING RADIATOR LEAKS OCCURRING IN CERTAIN 2006 EXPLORERS MADE BEFORE 8/8/2006. IT SHOULD BE NOTED THAT IT IS NOT A "LEAK" IN THE RADIATOR BUT A COMPLETE FAILURE OF THE PART. THEY ARE CURRENTLY ON THEIR FOURTH DESIGN OF RADIATORS FOR THIS SPECIFIC VEHICLE. MY QUESTION IS THIS, WITH ALL OF THE COMPLAINTS REGISTERED REGARDING THIS PROBLEM, WHY HASN'T NHTSA LAUNCHED AN INVESITGATION REGARDING THIS PROBLEM AND WHY HASN'T THE FORD MOTOR COMPANY STEPPED UP AND ACKNOWLEGED THERE IS A PROBLEM AND DONE SOMETHING TO ASSIST THE OWNERS OF ALL VEHICLES THAT ARE SUBJECT TO THE PROBLEM. THIS VEHICLE NEEDS TO BE...

2006 FORD EXPLORER WITH 62,000 MILES I NOTICED THAT THE RADIATOR IS LEAKING CALLED FORD DEALER FOR PARTS AND THE PRICE OF THE RADIATOR IS $500.00 ALL SO FOUND OUT THAT A NUMBER OF OTHER PEOPLE ARE EXPERIENCING THE SAME CONCERN AND THAT THERE IS A SHORTAGE OF RADIATORS AVAILABLE. *TR

NOTICED A 6 INCH PUDDLE UNDER MY 2006 EDDIE BAUER. HAD IT TESTED AND THE TUBES AT THE BOTTOM WERE LEAKING. BOUGHT A REPLACEMENT RADIATOR FOR 220.00. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. WHEN ATTEMPTING TO MAKE A TURN, OR DECELERATE, THE ENGINE WOULD STALL. THE VEHICLE WAS TAKEN TO THE DEALER OVER FIVE TO SIX TIMES FOR IDENTICAL FAILURES. THE DEALER REPLACED THE FUEL FILTER AND THE POWER TRAIN MODULE . NONE OF THE REPAIRS HAVE REMEDIED THE FAILURE. THE FORD MANUFACTURER WAS CONTACTED, BUT NO ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 25,800. UPDATED 1/25/10 *CN UPDATED01/26/10.*JB

TRAC CONTROL, ABS, CHECK ENGINES LIGHTS ON. RATTLE ON LEFT REAR AXLE, ABS RING LOOSE FORM AXLE, NEED TO REPLACE RING AND AXLE. *TR

2006 FORD EXPLORER, PURCHASE NEW. RADIATOR REPLACED AS DEFECTIVE JAN 2008. RADIATOR REPLACE AS DEFECTIVE NOVEMBER 2008, JAN 2009 RADIATOR DEFECTIVE AGAIN. FORD REFUSE TO FIX DUE TO OUT OF WARRANTY. GENE EVENS FORD IN UNION CITY GEORGIA SERVICE MANAGER WAYNE SAID HE HAS A LOT OF FORD EXPLORERS WITH SAME PROBLEM HE SAID "IT SEEMS THAT A CHEMICAL IN THE ENGINE IS WHAT IS CAUSING THE RADIATOR TO MALFUNCTION". THIS SHOULD BE A RECALL BUT FORD IS NOT DOING ANYTHING ABOUT IT. *TR

I AM CURRENTLY HAVING TO PUT MY SECOND ALL NEW RADIATOR IN MY 06 EDDIE BAUER EXPLORER. THIS IS THE SECOND IN 13 MONTHS. I FEEL THAT THESE RADIATORS ARE DEFECTIVE AS I KNOW OTHERS HAVE HAD THE EXACT SAME PROBLEM AND FORD REFUSES TO ACKNOWLEDGE THIS PROBLEM. *TR

ENGINE WAS RACING, TOOK IT TO DEALER, THEY SAID IT WAS PROGRAMMABLE TRANSMISSION,COST $100 TO DIAGNOSE AND RESET PROGRAM. OK FOR A WHILE, STARTED RACING AGAIN. TOOK BACK TO DEALER, SAID IT IS LEAKY RADIATOR, IT WAS BONE DRY AND IT WAS THE ENGINE FAN RACING NOT THE MOTOR. JUST PAST WARRANTY, NEVER RECEIVED EXTENDED WARRANT INFORMATION UNTIL JUST LAST WEEK,AFTER THE FACT. TAKING IT TO A DIFFERENT REPAIR GUY, ENGINE COULD HAVE OVERHEATED AND LOCKED UP! *TR

ROARING SOUND, RUSHING WATER, LEAKING UNDER DRIVERS SIDE. DEALER SAID RADIATOR DEFECTIVE, SEAM SPLIT, CANNOT REPAIR. 2006 EXPLORER, 48,000 MILES. SERVICE REP SCOLDED ME FOR NOT GETTING EXTENDED WARRANTY; RADIATOR WARRANTY IS 3 YR/36K MI. ALSO SAID TRANSMISSION NEEDS FLUSHING. TOLD HIM TRANSMISSION HAD BEEN FLUSHED 3 MONTHS AGO. HE TOLD ME I COULD TALK WITH FORD, BUT "GIVEN THEIR CURRENT SITUATION," THEY WERE NOT GOING TO BE COOPERATIVE. I PLAN TO CALL FORD. A 2.5 YEAR OLD VEHICLE SHOULD NOT HAVE A FAILED RADIATOR/TRANSMISSION. *TR

I HAVE MY THIRD RADIATOR IN MY 2006 FORD EXPLORER WITH THE V6 ENGINE. *TR

2006 FORD EXPLORER EB RADIATOR LEAK @ 35,600 MILES. I FIRST NOTICED THE PROBLEM DUE TO PUDDLE ON THE GROUND AND DURING INSPECTION I FOUND THE RADIATOR OVERFLOW TANK EMPTY. THE I TOOK IT TO FORD AND THEY TOLD ME THE RADIATOR CORE WAS CRACKED. VEHICLE NO LONGER COVERED UNDER WARRANTY AND DEALER WOULD NOT PROVIDE ANY AFTER WARRANTY ASSISTANCE WITH REPAIR. AFTER CHECKING WITH A COUPLE AUTO PARTS STORES, I WAS TOLD THE 06 EXPLORER HAS A DEFECT WITH THE RADIATOR THAT CAUSES IT TO CRACK. NAPA FOR ONE, WOULD ONLY OFFER ME A THREE MONTH WARRANTY ON A NEW RADIATOR DUE TO THE DEFECT IN THE RADIATOR DESIGN FOR THAT VEHICLE. I CALLED FORD AND THEY WOULD NOT PROVIDE ANY ASSISTANCE EITHER AND WOULD NOT ACKNOWLEDGE THEIR WAS A PROBLEM WITH THE RADIATOR DESIGN ON THE 2006 FORD EXPLORER. QUOTE FROM FORD DEALER TO REPLACE RADIATOR WAS $690.00....

TL*THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT THE RADIATOR WAS DEFECTIVE AND LEAKING FLUID. THE DEALER STATED THAT THE RADIATOR NEEDED TO BE REPLACED; HOWEVER, THEY REFUSE TO ACKNOWLEDGE IT AS A MAJOR ISSUE THAT IS AFFECTING ALL THE FORD EXPLORER VEHICLES. THE FAILURE AND CURRENT MILEAGES WERE 47,000.

MY 2006 FORD EXPLORER JERKS AND JOLTS EXTREMELY HARD WHILE COMING TO A STOP. THE FIRST TIME I TOOK IT IN FOR THE WARRANTY REPAIR THEY REPROGRAMMED THE COMPUTER WHICH SEEMED TO HELP FOR A FEW MONTHS. TODAY I RETURNED FOR THE SAME PROBLEM ONLY IT IS THREE TIMES AS BAD AS BEFORE. THEY TOLD ME AT FIRST IT WAS THE DRIVERS FAULT. THEN THEY CAME BACK AND SAID IT WAS NORMAL OPERATION. MY NECK IS VERY SORE FROM ALL THE JERKING AND JOLTING IT HAS RECEIVED FROM THIS CAR. IN FACT MY NECK IS BURNING RIGHT NOW FROM PAIN. *TR