1994 FORD EXPLORER Vehicle Speed Control Problems

MY TENANT'S VEHICLE - A 1994 FORD EXPLORER - SPONTANEOUSLY CAUGHT FIRE WHILE PARKED IN MY PROPERTY'S GARAGE IN THE MIDDLE OF THE NIGHT. THE FIRE DEPARTMENT WAS ABLE TO EXTINGUISH THE FLAMES AND DETERMINED THAT THE CAUSE OF THE FIRE WAS THE CAR ITSELF - LIKELY A FAULTY CRUISE CONTROL VALVE ACCORDING TO THEM. THE INSURANCE COMPANY WILL CONDUCT ITS OWN INVESTIGATION. *TR

I WAS SITTING AT A STOP LIGHT ALL OF A SUDDEN THE TRUCK ACCELERATED FORWARD. THE NEXT EVENT I WAS TRAVELING ABOUT 40 MILES AN HOUR AND THE TRUCK ACCELERATED OUT OF CONTROL AND I WAS UNABLE TO STOP IT, THE BRAKES WOULDN'T STOP IT, FINALLY I TURNED THE KEY OFF AND IT SHUT DOWN. IT'S BEEN HAPPENING ON AND OFF SINCE THEN. IT DOESN'T HAPPEN ALL THE TIME, BUT, I NEVER KNOW WHEN IT WILL HAPPEN AGAIN. I CONTACTED FORD SEVERAL TIMES ABOUT THIS PROBLEM AND THEY TOLD ME IT COULD BE ALOT OF DIFFERENT REASONS, THEY NAMED OFF SOME PARTS AND I REPLACED ALOT OF THEM AND AM STILL HAVING THE SAME PROBLEM. THEY DID SAY THEY HAVE HEARD OF OTHER PEOPLE HAVING THE SAME PROBLEMS, BUT THEY WERE NOT ALL FOR THE SAME REASONS. *TR

INVESTIGATION OF A MOTOR VEHICLE TRAFFIC COLLISION REVEALED THAT THE ACCELERATOR PEDAL ON 1994 FORD EXPLORER (UNKNOWN MILES) MAY BECOME STUCK IN THE "FULL OPEN THROTTLE" POSITION. CONDITION OCCURS WHEN THE ACCELERATOR PEDAL ARM WEARS A SLIT IN THE RUBBER SOUND/HEAT INSLUATION ON THE FLOOR BOARD. AFTER THAT OCCURS, WHEN THE ACCELERATOR IS FULLY DEPRESSED, THE ARM CAN BECOME STUCK IN THE RUBBER. CONDITION WAS DISCOVERED DURING INVESTIGATION OF A FATAL CRASH. AFTER THE CONDITION WAS DISCOVERED, IT COULD BE EASILY AND REPEATEDLY REPLICATED. NOTE: FATALITY OCCURRED WHEN THE DRIVER, FOR UNKNOWN REASONS, EXITED THE VEHICLE WHILE IT WAS STILL IN MOTION AT UNKNOWN SPEED. DRIVER DIED UPON IMPACT WITH ROAD. VEHICLE CONTINUED OFF ROAD AND CAME TO REST, MOSTLY UNDAMAGED, IN A FIELD WELL OFF ROAD SURFACE. *TT

WHILE DRIVING I TURNED ON AIR CONDITIONER AND IMMEDIATELY LIGHT SMOKE BEGAN OUT OF AIR CONDITIONING VENTS AND THEN THE NEXT MOMENT THE SMOKE WAS EXTREMELY HEAVY OUT OF THE VENTS AND THEN VISIBLE FIRE UNDERNEATH FRONT PASSENGER SIDE DASHBOARD. I IMMEDIATELY PULLED THE VEHICLE OFF THE SIDE OF THE ROAD AND EXITED, 10 MINUTES LATER IT WAS FULLY ENGULFED IN FLAMES. *LN

THE GAS PEDAL GOT STUCK CAUSING MY VEHICLE TO ACCELERATE AT A HIGHER THAN NORMAL SPEED IN AN APARTMENT PARKING LOT, WHICH CAUSED MY VEHICLE TO RUN INTO THE APARTMENT BUILDING AND CAUSED STRUCTURAL DAMAGE AND FRONT END DAMAGE TO THE EXPLORER. IT IS INOPERABLE AT THIS TIME DUE TO THIS INCIDENT. A POLICE REPORT WAS MADE AND INSURANCE COMPANY NOTIFIED. *TR

TL*THE CONTACT OWNS A 1994 FORD EXPLORER. AFTER MAKING A RIGHT TURN AT 5 MPH, THE VEHICLE SLOWLY GAINED SPEED AND THEN UNEXPECTEDLY ACCELERATED. THE CONTACT DEPRESSED THE BRAKE PEDAL AND THE VEHICLE SLOWED DOWN MOMENTARILY, BUT DID NOT STOP COMPLETELY. THE SPEEDOMETER DISPLAYED 80 MPH AND THE REAR WHEELS BEGAN TO SMOKE, DUE TO THE FACT THAT THE BRAKE PEDAL WAS DEPRESSED WHILE THE VEHICLE WAS STILL ACCELERATING. HE MANAGED TO TURN THE KEY AND SHUT OFF THE ENGINE. THE CONTACT ATTEMPTED TO RESTART THE ENGINE, BUT THE RPM DIAL WAS IN THE RED ZONE. HE WAS ABLE TO DRIVE THE VEHICLE BACK TO HIS RESIDENCE AND DISCOVERED THAT THE THROTTLE PLATE WAS STUCK IN THE OPEN POSITION. HE REPAIRED THE FAILURE ON HIS OWN, WITHOUT THE DEALER'S ASSISTANCE. HE BELIEVES THAT HAD HE NOT BEEN KNOWLEDGEABLE OF THE FAILURE, IT COULD HAVE BEEN A LOT MORE SEVERE. THE...

THE VEHICLE SURGED FORWARD WHEN CONSUMER MOVED GEARSHIFT FROM PARK TO DRIVE, THE VEHICLE WENT OUT OF CONTROL AND HIT A DIRT BANK. THE VEHICLE WAS TOTALED AND THE DRIVER SUFFERED MINOR BRUISES DURING THE ACCIDENT. *YH

THE LAST TIME THIS HAPPENED WE WERE IN HEAVY TRAFFIC ON I5, ON THE GRAPEVINE IN CALIFORNIA AND IT TERRIFIED US. WE JUST MANAGED TO STOP . THE DEALER INDICATED THAT THERE WERE NO TECHNICAL BULLETINS ON THIS, BUT IT HAS HAPPENED TOO MANY TIMES FOR US TO BELIEVE THIS. MY HUSBAND SHOWED THE DEALER THAT HE COULD MAKE IT HAPPEN EVEN WHEN IT WAS IN PARK BY MAKING THE ACCELORATOR INCREASE. WE HAD A PART REPLACED ONLY AFTER TAKING IT BACK TWICE AND NOW IT'S DOING IT AGAIN!! THE TOW TRUCK DRIVER SAID THAT HE TOWED ANOTHER FOR (A TRUCK) THAT HAD THAT SAME PROBLEM. WE HAD THE EXPLORER TOWED THE FIRST TIME THIS HAPPENED AND VALLEY FORD HAD IT FOR A WEEK AND SAID THEY COULD NOT FIND ANY PROBLEM.*AK

WHILE SITTING IN DRIVEWAY IN IDLE CONSUMER REVVED UP THE ENGINE, AND IN DOING SO, VEHICLE WITH A LOUD BANG ENGAGED ITSELF INTO DRIVE AND STARTED MOVING BEFORE RUNNING INTO A FOREIGN OBJECT WHICH STOPPED VEHICLE. CONTACTED DEALER, AND DEALER WAS NOT WILLING TO DO ANYTHING.*AK *TS

THE VEHICLE SURGED FORWARD WHEN CONSUMER MOVED GEARSHIFT FROM PARK TO DRIVE, THE VEHICLE WENT OUT OF CONTROL AND HIT A DIRT BANK. THE VEHICLE WAS TOTALED AND THE DRIVER SUFFERED MINOR BRUISES DURING THE ACCIDENT. *YH

THROTTLE STICKS IN UP POSITION, REQUIRING A HARD PRESS( STOMP) TO ACTIVATE. THIS LEAD TO A ACCIDENT IN WET WEATHER WHERE THE STOMP LED TO THE VEHICLE SPINNING OUT DURING A TURN. WAS TOLD BY REPAIR SHOP THAT THE BUTTERFLY WAS STICKING AND CAUSING THE PROBLEM. I ALSO HAVE HAD PROBLEMS WITH THE SPEED CONTROLL STAYING ON DESPITE PRESSING THE BRAKE PEDAL. (TIRESIZE: 235/175R15)

WHILE DRIVING 65 KM THE RPMS WILL GO UP IN RED, AND NOT GO BACK DOWN UNTIL CONSUMER SLOWS DOWN TO ABOUT 30 KM. THEN, SHE CAN FEEL TRANSMISSION KICK IN, AND RPMS GO DOWN. THIS HAS HAPPENED 3 TIMES . MECHANIC STATED TRANSMISSION NEEDED TO BE REBUILT AND UPGRADED. CONSUMER CALLED FORD, AND WAS TOLD THERE WERE A LOT OF COMPLAINTS ON EXPLORER'S TRANSMISSIONS WITH THIS PROBLEM. *AK

CRUISE CONTROL HAS NEVER WORKED. *MJS

CRUISE CONTROL HAS NEVER WORKED. *MJS

VEHICLE PARKED. SHIFTED FROM PARK TO DRIVE AND VEHICLE SUDDENLY ACCELERATED FORWARD. FOOT WAS NOT ON BRAKE OR GAS PEDAL. HIT ANOTHER VEHICLE. GAS PEDAL WAS TO FLOOR. WAS DEPRESSING BRAKES HARD TO STOP, BUT VEHICLE FAILED TO STOP UNTIL IT HIT ANOTHER VEHICLE.*AK

CONSUMER PUT THE VEHICLE IN REVERSE AND EXPERIENCED SUDDEN ACCELERATION, CAUSING THE VEHICLE TO STOP AFTER HITTING A LARGE DEVICE. *SLC

MAJOR PROBLEM REGARDING IGNITION SYSTEM: FIRST PROBLEM BEGAN ABOUT 6 MONTHS AGO. ON AN INTERMITTENT BASIS, UNABLE TO RESTART THE ENGINE AFTER LETTING IT SIT FOR APPROXIMATELY 5 OR 10 MINUTES. REPEATED ATTEMPTS IN SUCCESSION FAIL TO START THE ENGINE BUT HAVE FOUND THAT IF I GIVE IT A COUPLE OF MINUTES BEFORE TRYING TO CRANK IT UP AGAIN IT WILL USUALLY START. SEEMS TO HAPPEN ONLY AFTER SHORT TRIPS, LESS THAN 10-15 MILES. REPLACED THE FUEL CIRCUIT RELAY 2 MONTHS AGO, HAD ONLY ONE REOCCURRENCE A WEEK LATER. NOW FOR THE PAST 2 MONTHS THERE IS A MUCH WORSE AND POTENTIALLY DANGEROUS PROBLEM. THE ENGINE SHUTS OFF RANDOMLY USUALLY WHILE DRIVING BETWEEN 55-70 MPH. NO SPUTTERS, NO BACKFIRES, NO INDICATIONS THAT THE ENGINE HAS SHUT OFF OTHER THAN THE INSTRUMENT PANEL DIMS AND THE GAUGES STOP READING. THE ENGINE WON'T RESTART UNTIL AFTER A FEW MINUTES HAVE PASSED BEFORE...

IF FOR ANY REASON THE BRAKE LIGHT FUSE SHOULD BLOW, THE CRUISE CONTROL ON THIS VEHICLE WILL NOT DISENGAGE WHEN STEPPING ON THE BRAKE. THERE IS NO WARNING FOR THIS BY THE WAY. THIS COULD CAUSE A FATAL INJURY AS THE CRUISE CONTROL WILL MAKE THE CAR LUNGE FORWARD TRYING TO GET BACK TO THE CRUISE SPEED SETTING. YOU ALSO WILL LOOSE YOUR POWER BRAKES. I HAVE CONTACTED FORD AND THEIR ANSWER WAS TO GO BACK TO THE DEALER WHEN YOU HAVE A TECHNICAL ISSUE. I HAVE DONE THAT AND THE DEALER'S ANSWER WAS THAT THIS IS NORMAL FOR THIS VEHICLE. I WAS TOLD THAT IT IS THE WAY IT IS WIRED. THIS APPEARS TO BE A PROBLEM ON THE 1994 EXPLORER. I DON'T KNOW IF IT IS LIKE THAT ON ANY OTHER MODEL OR YEAR FORD. IN MY OPINION IT SHOULD NOT MATTER WHAT THE CONDITION OF THE FUSE...

CRUISE CONTROL FAILED. *MJS

CALIPERS STICK AND GRIND UP ROTORS,SPEED CONTROL WILL NOT RELEASE, BRAKE LIGHT SWITCH GOES BAD, ACCELERATOR PEDDAL STICKS. *AK

WAS DRIVING VEHICLE WITH THE CRUISE CONTROL ENGAGED. THEN THROTTLE BECAME STUCK. VEHICLE WOULD ACCELERATE ON ITS OWN WHEN CRUISE CONTROL WAS IN USE. WHENEVER ACCELERATOR PEDAL WAS TAPPED, CRUISE CONTROL FAILED TO DISENGAGE. TOOK VEHICLE TO DEALERSHIP & MECHANIC COULD NOT SOLVE PROBLEM. *AK

SPEED SENSOR IN 5 SPEED TRANSMISSION IS GENERATING JUMPY VALUES; CAUSES CRUISE CONTROL TO SURGE AND FALL TRYING TO MATCH JUMPY SPEED READINGS. SPEED SENSOR ALSO FEEDS ABS, SUGGESTING ABS COULD FAIL WHEN NEEDED. SPEED SENSOR ALSO FEEDS COMPUTER, SUGGESTING ENVIRONNMENTAL ENGINE CONTROLS ARE NOT FUCNTIONING. INTERESTED IN FINDING IF THIS HAS BEEN REPORTED BEFORE, AND IF THERE IS A SAFETY RECALL OR SERVICE BULLETIN IN PLACE FOR THIS CONDITION. *AK

CRUISE CONTROL FAILED. MJS

WHILE DRIVING AT 15 MPH AND MAKING A TURN APPLIED THE BRAKE'S AND VEHICLE KEPT ACCELERATING AT HIGH SPEED. CONSUMER RAN INTO A COUNTY HOLE. *AK

WHILE DRIVING AT 65MPH WITHOUT CRUISE CONTROL ON, VEHICLE WOULD NOT SLOW DOWN AFTER LETTING OFF THE GAS PEDAL, BUT ACCELERATED. CONSUMER PUT THE VEHICLE IN NEUTRAL IN ORDER TO SLOW DOWN AND TURNED ENGINE OFF. VEHICLE DID NOT SLOW DOWN, BUT ACCELERATED AND CRASHED. *AK

THE CONSUMER SET CRUISE CONTROL AT 60 MPH AND VEHICLE ACCELERATED BY ITSELF. CONSUMER HAD TO SLAM ON THE GAS PEDAL IN ORDER TO GET THE VEHICLE TO SLOW DOWN. *AK

CONSUMER EXPERIENCING ONGOING, INTERMITTENT PROBLEM WITH VEHICLE ACCELERATING WITHOUT CAUSE. CONSUMER HA CRUISE CONTROL DISCONNECTED WHICH STOPPED VEHICLE FROM ACCELERATING. PART IS AVAILABLE FOR INSPECTION IF NEEDED. DEALER NOTIFIED AND INFORMED CONSUMER THAT NOTHING WOULD BE DONE UNLESS COST GOES TO CONSUMER. *AK

WHILE PARKING IN DRIVEWAY, VEHICLE SUDDENLY ACCELERATED. DRIVER APPLIED THE BRAKES WHICH MALFUNCTIONED, CAUSING AN ACCIDENT. HAS NOT YET BEEN INSPECTED. CAUSE UNKNOWN. *AK *ML

ON 4 DIFFERENT OCCASIONS FEB 9,15,19,26 1999 THE FORD EXPLORER ACCELERATOR ENGAGED ITSELF, 3 TIMES WHILE COMMUTING ON ROAD APPROX. 30 MILES PER HOUR. EACH TIME THE RPM WAS OVER 4. QUICK ACTION BY DEPRESSING THE BRAKE PEDAL WHICH HALTED THE ACCELERATION, WHICH WAS A POTENTIAL FOR DISASTER. THE 4TH TIME HAPPEN WHEN FROM A PARKING STARTUP, (WITHOUT TOUCHING THE ACCELARATOR) THE GAS PEDAL ENGAGED ITSELF, LUCKLY WHILE SITTING IN FRONT OF A MAJOR SHOPPING MALL GLASS PLATE WINDOW THE THE WASN'T IN MOTION. SO WITH THE DEPRESSING OF THE BRAKE PEDAL IT DISENGAGED THE ACCELARATOR. I'VE CONTACTED THE FORD CAR DEALER WITHIN MY AREA FOR SERVICE CHECK AND ADDRESS THIS PROBLEM. A DIAGNOSTIC WAS DONE WITH NO INDICATIONS OF NOTED PROBLEMS. IT WAS SUGGESTED THAT IT COULD BE THE CRUISE CONTROL CERVIAL, WHICH COULD BE REPLACED FOR $275.00. PLEASE CONTACT ME ASAP FOR FURTHER GUIDANCE.

ACCELERATOR PEDAL STICKING DUE TO FAILURE OF THE THROTTLE BODY AND CABLE.

BRAKE SWITCH ON THE CRUISE CONTROL FAILED.

SUDDEN ACCELERATION, CAUSING ACCIDENT.

WHILE STARTING VEHICLE AND PUTTING IT INTO GEAR, VEHICLE SUDDENLY TOOK OFF, CAUSING OWNER TO HIT ANOTHER VEHICLE. DEALER SAID NOTHING WAS WRONG WITH VEHICLE. *AK

DRIVING VEHICLE AND STEPPING ON THE ACCELERATOR PEDAL VEHICLE STALLS, CHECK ENGINE SENSOR CAME OFF AND ON, VEHICLE WENT INTO OPEN THROTTLE POSITION , LOST CONTROL OF VEHICLE ON WET ROAD SURFACE, WENT INTO A DITCH AND VEHICLE ROLLED OVER. *AK

WHILE DRIVING, CRUISE CONTROL MALFUNCTIONED, WHEN RESUMED, OVERPOWERING BRAKES, UPON APPLICATION, AND WOULD NOT DISENGAGE. *AK

VEHICLE STICKS IN OPEN THROTTLE POSITION, CAUSING A HIGH IDLE, IN COLD WEATHER. TT

DURING NORMAL OPERATING CONDITIONS PEDAL WENT TO THE FLOOR OVER A QUARTER OF A MILE. TT