2016 FORD EXPEDITION Unknown Or Other Problems

UNKNOWN

Blower motor which was under recall was repaired by dealership 4/18/25 continued to work intermittently following repair. As of inspection today, 10/2/2025 at same dealership, blower motor speed controller wiring harness/assembly has since gotten hot enough to melt wiring. Wiring assembly and speed controller must now be replaced by dealership at a cost of $352.56 which is not covered under the blower motor recall but should be.

Rear camera fails intermittently. Phone stopped connecting through BlueTooth. Tried different phone. Still won’t connect. Tried resetting to factory settings. Nothing. Blower fan only works on 1 speed. Changed blower motor and wiring harness. Still not working. Changed the ccm73. Still won’t work. I accidentally found what I thought was a recall on APIM but dealer says there is no recalls.

Rear view camera went out. Mechanic traced it to a broken camera. 90,000 miles on vehicle when it went out.

The dash air vent and rear vent motors are clicking when they are turned on. I have read numerous reports that this is an existing issue with 2016 Expeditions. Why are these vent motors not under recall?

In June 2023 there was a strong burning smell in our 2016 Expedition's cabin. We took the vehicle to a mechanic and they found that a small fire had started around the blower motor that burned up the wires in/around the blower motor. The mechanic replaced the control board and harness. They replaced parts AAABL3Z-19E624-B and AAAFLlZ-188518-G. Then in August 2023 I received a recall notice from Ford for the blower motor. This was the first correspondence I had received from Ford that the blower motor had been recalled. I contacted a Ford dealer, Apple Ford Lincoln in Apple Valley, MN, on August 9th and requested reimbursement for the above parts along with a replacement of the blower motor under the recall. I have been calling and emailing the dealer weekly since August 9th and continue to be told the blower motor under the recall has been on backorder for...

Sudden feel of a misfire putting truck into reverse, definitely caught my attention as vehicle has under 140k miles! Just had new Ford spark plugs and lifetime warrantied coil packs in the last 20 to 25k! it's had at least two if not three oil changes in the last 20k to 30k miles! Put vehicle into drive same felling of a misfire and doesn't take long it flashes the check engine light at me so I turn around to head back home and haven't really made it but around the corner and the car completely stalled out going by the neighbors house lost steering and brakes and noticed a very distinct smell of plastic/electrical burning! I pop the hood in total disgust and can't even see clearly enough to see the issue at the moment! A friend pulled in front my residence as I'm shaking my head and in tears!...

while operating vehicle on busy interstate bridge going uphill, engine seemed to lose power, check engine light came on along with another warning to read my owners' manual. Throttle response quit working. I was able to get to shoulder and shut off vehicle. Upon restart, vehicle ran normally for a few miles before same happened again. This occurred several more times while I nursed it home on surface streets. Independent repair shop ran code as 'Throttle body".

While driving around 30 miles an hour, the vehicle lost power and all accelerator input did not work.. The tool light came on but the vehicle was unresponsive to any accelerator input. The vehicle came to a stop in the middle of an intersection. Vehicle was turned off then back on. After which the accelerator worked. Took the vehicle to a maintenance shop, no codes were stored and couldn’t duplicate. Very dangerous to have no acceleration while driving.

2016 FORD EXPEDITION. CONSUMER WRITES IN REGARD TO UNREPAIRED SAFETY RECALL.

While accelerating to merge onto an interstate, the vehicle jerked aggressively with a loud "bang"(similar to sound of transmission popping out of gear). A flashing check engine light appeared and vehicle lost ability to accelerate further, but was able to maintain speed. Light smoke was noticed from rear view mirrors, followed seconds later by thick, dark smoke. Other cars began honking and waving at us. We pulled over as quickly as possible after the incident to assess. Once stopped, flames could be seen around the driverside cowl/front fender area and I yelled for my family to get out of the vehicle. The front end of the vehicle was engulfed within a couple of minutes of our safe exit.

driving at constant speed the automobile has entered Limp Mode at which time power to the drive train is loss and it losses speed rapidly. This is the third time it has happened over a 4-5 month period.

Rear camera is intermittently non-operative. Only works approximately 20% of the time. Due to the size & shape of this vehicle, this makes backing up dangerous for persons and property that are difficult to see when backing.

2/1/2019 I WAS DRIVING UP INTERSTATE I16 AT ABOUT 1PM. WHEN MY TRUCK STARTED STALLING. I IMMEDIATELY PULLED OVER TO THE EMERGENCY LANE. I THEN NOTICED SMOKE COMING OUT FROM UNDER THE ENGINE BAY. A COUPLE OF OTHER DRIVERS STOPPED TO TRY TO RENDER ASSISTANCE WITH SMALL FIRE EXTINGUISHERS; TO NO AVAIL. THE VEHICLE SOON BECAME FULLY ENGULFED IN FLAMES. BY THE TIME THE FIRE DEPARTMENT ARRIVED, IT WAS A TOTAL LOSS. THE ONLY THING THAT WAS OUT OF THE ORDINARY WAS I RAN OVER A PLASTIC BAG BLOWING ACROSS THE INTERSTATE, LIKE A WALMART BAG. I HAD ASSUMED THAT THE INSURANCE ADJUSTER HAD ALREADY FILED THIS REPORT BUT THEY HAVE NOT.

WHEN DRIVING PAST CELL TOWERS THE SATELLITE SIGNAL GOES OUT REPEATEDLY. VERY DISTRACTING WHILE DRIVING. EXAMPLE ON I-5 AT 38.475641, -121.504846, ON BUSINESS-80 AT 38.571184, -121.468347, ON I-80 AT 38.663596, -121.357112, AND ON WALERGA RD SOUTH OF ELVERTA BLVD IN SACRAMENTO COUNTY. THERE IS A FORD SSM FOR THIS, AND WHILE MY VEHICLE WAS MANUFACTURED IN THE TIME RANGE SPECIFIED, I HAVE BEEN TOLD IT DOESNT' APPLY TO MY VIN. - HTTPS://STATIC.NHTSA.GOV/ODI/TSBS/2016/SB-10092559-5448.PDF SSM 46016

THE SUNROOF EXPLODED WHILE PARKED. THE VISOR WAS CLOSED SO GLASS DID NOT ENTER THE CAR. THE CAR WAS PURCHASED NEW, AND HAS 15,000 MILES ON IT. THE SUNROOF GLASS HAD EXPANDED OUTWARDS, AS SEEN IN THE PICTURE, AND DID NOT HAVE ANY CRACKS DUE TO IMPACTS PRIOR TO THE GLASS FAILURE.