2005 FORD ESCAPE Structurebody Problems

TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT HE WAS DRIVING 40 MPH OVER A ROAD BUMP WHEN THE REAR PASSENGER'S SIDE OF THE VEHICLE COLLAPSED AND THE TIRE PENETRATED THROUGH THE FRAME AND INTO THE INTERIOR CABIN OF THE VEHICLE. THE CONTACT EXITED THE VEHICLE AND NOTICED THAT THE FRAME WAS RUSTED. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION BUT WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 169,447.

TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING 20 MPH, THE REAR PASSENGER'S SIDE DOOR OPENED INDEPENDENTLY. THE VEHICLE WAS TAKEN TO A DEALER TO DETERMINE IF THERE WERE ANY RECALLS FOR THE VEHICLE. THE CONTACT WAS INFORMED THAT THERE WAS NO RECALL FOR THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 165,319.

MY DAUGHTERS 2005 ESCAPE STARTED MAKING A POUNDING NOISE WHEN GOING OVER BUMPS. NOT BEING A MECHANIC I THOUGHT IT WAS A SHOCK ABSORBER. AFTER A CLOSER INSPECTION I SAW THE TOP SHOCK MOUNT WAS RUSTING AWAY FROM THE FRAME. I COULD ACTUALLY MOVE IT SLIGHTLY BY HAND. THE STRUCTURAL DAMAGE IS A HOLE ON THE INSIDE OF THE STORAGE AREA INSIDE THE VEHICLE. AFTER CHECKING THE DRIVER SIDE UPPER SHOCK MOUNT THERE IS ALSO A HOLE IN THE BODY IN THE REAR STORAGE COMPARTMENT RIGHT NEXT TO THE GASOLINE FILLER NECK TUBE. THIS IS A POTENTIAL TRAGEDY WAITING TO HAPPEN.PLEASE DO SOMETHING TO REMEDY THIS UNHEARD OF PROBLEM BEFORE SOMEONE GETS HURT.THIS TYPE OF DAMAGE SURELY TOOK A FEW YEARS TO PROGRESS THIS BAD.SAW A LOT OF OWNERS OF SAME VEHICLE WITH SIMILAR COMPLAINTS. *TR

MY 2005 FORD ESCAPE HAS HAD A LOUD BANGING IN REAR PASSENGER SIDE FOR SEVERAL MONTHS. I HAS ASSUMED THAT THE STRUT NEEDED REPLACED. UPON FURTHER INVESTIGATION MY MECHANIC AND I NOTICED A TERRIBLE AMOUNT OF RUST AND CORROSION TO REAR PASSENGER WHEEL WELL THAT HAS BOLTS ATTACHED TO STRUT. YOU CAN SEE INTO INTERIOR OF VEHICLE FROM OUTSIDE. I RESEARCHED RECALLS OF THESE PROBLEM AND FOUND NONE, ALTHOUGH THERE WERE SEVERAL OTHER COMPLAINTS FOR THE SAME ISSUE. THIS SEEMS TO HAPPEN ONLY ON THE REAR PASSENGER SIDE ALTHOUGH HAS ME WORRIED ABOUT OTHER COMPLICATIONS THAT COULD ARISE. THIS IS A VERY SERIOUS ISSUE THAT THE FORD MOTOR CO. SHOULD ADDRESS POST HASTE. I FEAR THAT MY FAMILIES AND OTHERS LIVES ARE AT STAKE IF THIS PROBLEM IS NOT TAKEN CARE OF SOON. *TR

WAS DRIVING AND HEARD INCREASING NOISE AND CLUNKING FROM BACK OF VEHICLE. WHEN HOME, PULLED THE RIGHT REAR INSIDE PANEL IN THE HATCH AREA. FOUND RUST PERFORMATION SURROUNDING THE RIGHT REAR SHOCK MOUNT. THIS RUST WAS EXTENSIVE ON THIS ONE ENTIRE PANEL BUT PERFORATED SURROUNDING THE SHOCK MOUNT AREA. I COULD SEE TO THE OUTSIDE OF THE VEHICLE. THE SURROUNDING PANELS APPEARED UNAFFECTED. THE CAR WAS TAKEN TO AL PIEMONTE FORD IN ARLINGTON HEIGHTS, IL. THE RIGHT REAR WHEELHOUSE PANEL HAD TO BE REPLACED AT A TOTAL COST OF $927.97. THIS IS A SIGNIFICANT STRUCTURAL FAILURE FOR A VEHICLE OF THIS AGE. I WAS GLAD I WAS NOT ON HIGHWAY WHEN IT FAILED. *TR

THE PASSENGER-SIDE REAR WHEEL WELL HAS COMPLETELY RUSTED THROUGH TO THE POINT WHERE YOU CAN SEE INTO THE CABIN, AND THE SHOCK/STRUT IS MOUNTED TO NOTHING AND IS POKING INTO MY TRUNK. THE METAL ALL AROUND THE MOUNT (OR WHERE IT SHOULD BE MOUNTED) IS COMPLETELY CORRODED AND RUSTED TO THE POINT OF BEING COMPLETELY DETACHED, AND THE SURROUNDING METAL IS STAMPED SO THIN TO BEGIN WITH THAT IT IS PLIABLE. THE SHOCK IS COMPLETELY INEFFECTIVE, AND MY CAR IS A TICKING TIME BOMB OF SAFETY ISSUES. I HAVE CONTACTEDFORD SEVERAL TIMES, AND FORD CANADA IS DENYING THAT THIS IS A SAFETY OR QUALITY ISSUE AND HAVE TAKEN NO RESPONSIBILITY; THEY REFUSE TO FIX MY CAR. I CANNOT FIND A RECALL AT PRESENT, HOWEVER THERE ARE NUMEROUS PEOPLE REPORTING THE SAME PROBLEM WITH THEIR ESCAPES, 6 ALONE ON [XXX] AND 5 ON [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF...

TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THE VEHICLE MADE A LOUD NOISE WHILE DRIVING. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE THE FAILURE WAS LOCATED AT THE PASSENGER REAR WELL AREA, WHICH WAS SEVERELY CORRODED AND CAUSED THE BOLTS AND STRUTS TO CORRODED AND SEPARATE FROM THE WELL. THE CONTACT STATED THAT THE FRONT AND REAR WHEEL BEARINGS WERE REPLACED BUT WAS UNAWARE IF THE REPLACEMENT WAS DUE TO CORROSION. THE VEHICLE WELL WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND THE CURRENT MILEAGE WAS 161,000. UPDATED 07/27/12 *BF UPDATED 08/02/12

2005 ESCAPE WITH A RUSTED OUT RIGHT REAR FENDER WELL AND SHOCK MOUNT. I CHECKED WITH ATCHINSON FORD ABOUT ANY RECALLS, NONE. I CALLED A COUPLE BODYSHOPS IN THE AREA. THEY KNOW OF THIS PROBLEM AND COULD QUOTE ME THE TWO PARTS NEEDED, ALONG WITH THE 15 HOURS TO REPLACE/REPAIR IT. THEY SAID THAT THEY FIXED 2004, 2005, & 2006 MODELS WITH THIS PROBLEM. TODAY I WENT OUT INTO OUR WORK PARKING LOT AND LOOKED AT OUR Q.C. MANAGER'S 2005 ESCAPE. AND WE FOUND THE SAME THING HAPPENING TO HIS. IF I COULD ATTACH PICTURES I WOULD. MY ESCAPE IS 7 YEARS OLD AND HAS 115,000 MILES, HOWEVER I DON'T THINK THAT THE BODY STRUCTURE SHOULD CORRODE AWAY, LEAVING THE TOP SHOCK MOUNT READY TO BREAK FREE MAKING THE VEHICLE UNSAFE TO DRIVE. THIS IS A SAFETY ISSUE THAT SHOULD BE ADDRESS. I EMAIL FORD AND THIS WAS THERE RESPONSE:...

SUNROOF SHATTERED IN OUR 2005 FORD ESCAPE FOR NO REASON. LUCKILY WE WERE NOT DRIVING AT THE TIME. FORD WOULD NOT COVER THE DEFECT. WHEN CHECKING ON LINE THERE SEEMS TO BE ALOT OF COMPLAINTS ABOUT THIS INCLUDING TIMES WHEN THE GLASS BROKE WHILE DRIVING. ORDERED NEW GLASS FOR SUNROOF AT MY OWN EXPENSE. *TR

I BOUGHT MY 2005 ESCAPE NEW AND JUST RECENTLY (OCT 2008) I NOTICED ON TOP OF THE REAR LIFT GATE WHERE BOTH OF THE HINGES ARE THE PAINT IS PEALING OFF AND GETTING WORSE ALL THE TIME. IT STARTED OUT VERY SMALL RIGHT WHERE THE EDGE OF THE GATE IS ON TOP. BUT WITH TIME HAS STARTED TO PEAL OFF ON TOP OF THE LIFT GATE AS WELL. I HAVE SINCE STARTED LOOKING AT ALL THE 2004-2006 ESCAPES THAT I SEE PARKED AND EVERY SINGLE ONE, REGARDLESS OF COLOR, WITHOUT FAIL HAS THE PAINT PEALING AWAY IN THE SAME SPOT. I HAVE SPOKEN TO FORD MOTOR CO. AND THEY REFUSE TO HANDLE IT. *TR