2003 FORD ESCAPE Structure Problems

The contact owns a 2003 Ford Escape. The contact stated that the front wheel would extend outward while turning the vehicle, braking, or during acceleration, causing the vehicle to slightly veer to the right. The vehicle was taken to the dealer where it was diagnosed that the front passenger’s side control arm had slightly detached. The dealer informed the contact the failure was a result of NHTSA Campaign Number: 14V165000 (Structure) and the vehicle was included; however, the fix needed exceeded the repair stated in the recall remedy. The dealer diagnosed that the front subframe was extremely rusted and needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the failure and opened. The contact was also referred to NHTSA Hotline to file a complaint. The approximate failure mileage was 122,000.

TL* THE CONTACT'S MOTHER OWNS A 2003 FORD ESCAPE. THE CONTACT'S MOTHER RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V165000 (STRUCTURE) THE VEHICLE WAS REPAIRED AT HOPKINS FORD OF ELGIN INC. LOCATED AT (1045 E CHICAGO ST, ELGIN, IL 60120) HOWEVER, THE FAILURE WAS EXPERIENCED. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS THE VEHICLE MOVED FROM LEFT TO RIGHT INDEPENDENTLY. THE CONTACT STATED THAT IT WAS DIFFICULT TO CONTROL THE VEHICLE. THE CONTACT STATED THAT THERE WERE NO WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE DRIVER AND PASSENGER'S SIDE CONTROL ARMS AND THE FRONT SUBFRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 86,000.

2003 FORD ESCAPE. CONSUMER WRITES IN REGARDS TO VEHICLE FRONT SUBFRAME CROSSBRACE RECALL ISSUES. *SMD

TL* THE CONTACT OWNS A 2003 FORD ESCAPE. WHILE DRIVING 50 MPH, THE VEHICLE WAS UNSTABLE AND THERE WAS LOSS OF STEERING CONTROL. THE VEHICLE WAS TOWED TO A LOCAL DEALER (ARLINGTON HEIGHTS FORD LOCATED AT 801 W DUNDEE RD ARLINGTON HEIGHTS, IL 60004, 888 481-8607) WHERE IT WAS DIAGNOSED THAT THE SUBFRAME WAS CRACKED. THE VEHICLE WAS REPAIRED WITH A BRACE. TWO MONTHS LATER, THE VEHICLE WAS TOWED TO A LOCAL DEALER (FOX FORD LINCOLN LOCATED AT 2501 N ELSTON AVE CHICAGO, IL 60647 773-687-7800) WHERE IT WAS DIAGNOSED THAT THE SUBFRAME WAS FRACTURED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND OPENED CASE NUMBERS: CASDASH12577845 AND CAS12593478. THE FAILURE MILEAGE WAS 96,000.

TL* THE CONTACT OWNS A 2003 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING AT 25 MPH, THERE WAS AN ABNORMAL NOISE COMING FROM THE VEHICLE AND THAT WHEN DRIVING IT FELT ABNORMAL WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SUB FRAME HAD EXPERIENCED SEVERE CORROSION AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CONTACT STATED TWO YEARS PRIOR TO THE FAILURE VEHICLE WAS REMEDIED UNDER NHTSA CAMPAIGN NUMBER: 14V165000 (STRUCTURE). THE FAILURE MILEAGE WAS APPROXIMATELY 130,000.

TL* THE CONTACT OWNS A 2003 FORD ESCAPE. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE DROVE ABNORMALLY. THE DEALER CONFIRMED THAT THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 14V165000 (STRUCTURE) PRIOR TO BEING PURCHASED. THE ONTACT STATED THAT THE FRAME OF THE VEHICLE HAD CORRODED WHERE THE SUPPORT BRACKETS WERE INSTALLED FROM THE PREVIOUS RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 170,000. ..UPDATED 02/09/17 *BF

2003 FORD ESCAPE. CONSUMER WRITES IN REGARDS TO CORROSION OF THE SUBFRAME LOWER CONTROL ARM RECALL NOTICE REPAIRS AND SEEKS REIMBURSEMENT. *SMD THE CONSUMER STATED SIX MONTHS AFTER THE RECALL WAS PERFORMED, HIS WIFE HEARD A TERRIBLE NOISE AND THE VEHICLE BECAME IMPOSSIBLE TO STEER. THE CONSUMER ARRIVED TO WHERE HIS WIFE WAS AND DID AN INSPECTION, AND DISCOVERED THE FRAME ON THE PASSENGER SIDE WAS COMPLETELY RUSTED THROUGH AND BROKEN IN HALF. THE NEXT DAY, A MECHANIC INSPECTED THE VEHICLE AND FOUND THE FRONT CROSS MEMBER WAS RUSTED OUT AND BROKEN ON THE PASSENGER SIDE AND THE VEHICLE WAS UNSAFE TO DRIVE. THE CONSUMER WAS INFORMED HE WAS NOT ENTITLED TO REIMBURSEMENT, BECAUSE THE LOWER CONTROL ARM SEPARATED FROM THE SUBFRAME AFTER THE RECALL WAS PERFORMED. *JB

2003 FORD ESCAPE. CONSUMER WRITES IN REGARDS TO EXCESSIVE RUST ON VEHICLE SUB-FRAME RECALL NOTICE. *SMD THE CONSUMER STATED THE ARM CROSS BAR WAS REPLACED. HOWEVER, THE SUBFRAME WAS NOT COVERED. THE CONSUMER HAS BEEN UNSUCCESSFUL AT GETTING THE SUB FRAME REPLACED, BECAUSE NO WAS WILLING TO SELL THE PART. THE PART WAS BEING USED FOR CERTAIN VIN'S. THE CONSUMER REFERENCED RECALL # 14V165000. *JB

TL* THE CONTACT OWNS A 2003 FORD ESCAPE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V165000 (STRUCTURE); HOWEVER, THE RECALL REPAIR WAS NOT EFFECTIVE. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THE REAR FRAME WAS COMPLETELY RUSTED DUE TO CORROSION. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 114,000. MA 08/10/15 THE DEALER INFORMED THE CONSUMER, THE REAR FRAME WAS IN THE PROCESS OF RUSTING. HOWEVER, THE FRONT FRAME WAS ALREADY RUSTED. UPDATED 08/18/15*JB

TL*THE CONTACT OWNS A 2003 FORD ESCAPE. THE CONTACT STATED THAT WHILE HAVING A ROUTINE INSPECTION PERFORMED, THE VEHICLE FAILED TO PASS INSPECTION DUE TO RUST ON THE RIGHT WHEEL WELL, THE RIGHT FENDER, THE CROSS MEMBER AND THE FRAME. THE INSPECTOR DETERMINED THAT THE COMPONENTS DETERIORATED AND NEEDED TO BE REPLACED. THE CONTACT WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 14V165000 (STRUCTURE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 57,600. UPDATED 5/4/15*CN UPDATED 05/26/15*JB

THIS VEHICLE IS PART OF THE FORD RECALL 14S02 (NHTSB #14V165000 ). I HAD THE RECALL DIRECTED CROSS-BRACE INSTALLED IN JUNE 2014 (3 MONTHS AGO). I WAS TURNING A CORNER AT ABOUT 5-10 MPH, HEARD A POP IN THE RIGHT FRONT OF THE CAR AND THEN HEARD A SCRAPING SOUND AND HAD DIFFICULTY STEERING. I HAD THE VEHICLE TOWED TO THE DEALERSHIP WHO FOUND THAT THE CROSS-BRACE HAD FAILED BECAUSE THE SUBFRAME GAVE WAY. I WAS TOLD THAT THE BRACE WAS ONLY TO PROVIDE AN ENVELOPE OF SAFETY IF THE SUBFRAME FAILED BUT IT WAS NOT MEANT TO PREVENT FRAME FAILURE OR CORRECT FRAME WEAKNESS. I WAS ALSO TOLD THAT THE SUBFRAME REPAIR WAS NOT COVERED AS PART OF THE RECALL AND THAT THE REPAIR WOULD COST ABOUT $2000. I DON'T THINK THAT A QUALITY VEHICLE WOULD HAVE A FRAME FAILURE AFTER ONLY 10 YEARS. I THINK THIS IS A...

TL* THE CONTACT OWNS A 2003 FORD ESCAPE. THE CONTACT STATED THAT THE REAR DRIVER SIDE INTERIOR DOOR WAS CORRODED AND AS A RESULT, EXHAUST FUMES WERE EMITTING INTO THE VEHICLE. THE VEHICLE HAD NOT BEEN REPAIRED OR DIAGNOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 82,000.

TL* THE CONTACT OWNS A 2003 FORD ESCAPE. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 45 MPH, THE FRONT END OF THE VEHICLE BEGAN TO SHAKE VIOLENTLY WHICH CAUSED A LOSS OF STEERING. THE CONTACT WAS ABLE TO REGAIN CONTROL AND MANEUVERED TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED FIRST TO AN INDEPENDENT MECHANIC AND THEN AUTHORIZED DEALER. THE TECHNICIAN INFORMED THAT THE PASSENGER'S SIDE ENGINE CRADLE WAS COMPLETELY RUSTED. THERE WAS A VOLUNTARY RECALL ISSUED BY THE MANUFACTURER RELATED TO A NEWLY DESIGNED ENGINE CRADLE CROSS MEMBER BRACKET. THE VEHICLE WAS REPAIRED UNDER THE RECALL AND THE PROBLEM PERSISTED. THE REMEDY FAILED TO CORRECT THE PROBLEM. THE VEHICLE HAD NOT BEEN REPAIRED FOR THE MOST RECENT FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

WE HAVE A 2003 FORD ESCAPE LIMITED. THE PAINT HAS STARTED PEELING OFF AROUND THE HATCH AT THE BACK. IT'S JUST BUBBLING UP FOR NO APPARENT REASON. WE HAVE NEVER ABUSED THE CAR AND IT STILL HAS LESS THAN 70,000 MILES ON IT. *TR

PAINT DEFECTIVE ON 2003 FORD ESCAPE WITH GOLD ASH PAINT. *TR

PAINT PEELING PREMATURELY ON 2003 FORD ESCAPE. *TR

2003 FORD ESCAPE ... PAINT PEELING ON ROOF AROUND SUN ROOF OPENING. *TR

PAINT IS PEELING OFF ON THE DRIVERS SIDE BACK UNDER THE HATCH WINDOW AND ON TOP OF THE VEHICLE JUST BEHIND THE SUN ROOF. THIS VEHICLE HAS 74K MILES AND IS GARAGED. FROM NOV. 2002 - FEB. 2005 IT WAS EVEN IN PARKING GARAGE WHILE I WORKED. I TAKE GREAT CARE OF MY VEHICLE AND IT HAS NEVER BEEN IN AN ACCIDENT. I HAVE READ A LOT OF OTHER PEOPLE ARE HAVING THE EXACT SAME PROBLEM IN THE EXACT SAME PLACE ON THE SAME MAKE, MODEL AND YEAR. I CALLED FORD AND THEY DON'T CARE!!! IT IS OUT OF WARRANTY AND THERE IS NO RECALL.. WHAT CAN I DO? *TR

THE PAINT ON MY ASH GOLD 2003 FORD ESCAPE HAS STARTED TO BUBBLE AND PEEL AWAY FROM THE METAL BODY PARTS. DOORS, HOOD, REAR HATCH AND A LARGE SPOT ON THE ROOF JUST BEHIND THE MOON ROOF WINDOW. THIS IS NOT SOMETHING YOU CAN TOUCH UP. THE PAINT IS LITERALLY PEELING OFF OF THE PRIMER WHICH THEN QUICKLY ERODES TO EXPOSE THE METAL WHICH STARTS TO RUST. THERE ARE HUNDREDS OF COMPLAINTS ON THIS SPANNING SEVERAL YEARS AND SEVERAL FORD MODELS. IN THIS AGE WHERE WE HAVE TO KEEP CARS LONGER, THIS IS A TERRIBLE THING TO DISCOVER - THE COMPANY SIMPLY CAN'T FIGURE OUT HOW TO PAINT A CAR!!! I AM THE SECOND OWNER AND BOUGHT FROM THE ORIGINAL OWNER. HE POINTED OUT THE PEELING BUT WE BOTH THOUGHT IT COULD BE TOUCHED UP AS HE HAD BEEN DOING FOR A COUPLE YEARS. THE ROOF WAS NOT LOOKED AT...

MY PROBLEM IS NOT MECHANICAL BUT RATHER "PHYSICAL". THE PAINT HAS BEEN PEELING OFF THE ROOF AND HATCH OF MY 2003 ASH-COLORED FORD ESCAPE LIMITED SINCE 2007. AFTER READING OTHERS' BLOGS I AM AWARE THAT I AM NOT ALONE BY ANY MEANS. I PURCHASED THE SUV FOR IT'S NICE APPEARANCE AND COLOR. I WISH I'D KNOWN BEFOREHAND THAT THIS WAS GOING TO HAPPEN, OTHERWISE I WOULD NEVER HAVE PURCHASED A FORD. APPARENTLY FORD IS DOING ABSOLUTELY NOTHING ABOUT THE PROBLEM. IS THERE ANYTHING YOU CAN DO TO HELP US? CAN'T FORD BE FORCED INTO A RECALL FOR THIS? THESE VEHICLES AREN'T CHEAP!! PLEASE HELP. *TR

PAINT PEELING IN SEVERAL SPOT ON 2003 FORD ESCAPE. *TR

I HAVE A 2003 FORD ESCAPE XLT,WHITE IN COLOR AND CURRENTLY HAVE A PROBLEM WITH THE PAINT BLISTERING AND PEELING ON THE REAR HATCH BELOW THE WINDOW BOTH SIDES. ADDITIONALLY, THE PAINT PEELING HAS STARTED UNDER PASSENGER SIDE REAR CARGO WINDOW. I VISITED A LOCAL FORD DEALERSHIP AND THEY DENIED IT AS A DEFECT. OUT OF WARRANTY. I HAVE HAD FOUR AUTOBODY SHOPS TELL ME $600.00 TO A $1000.00 TO REPAINT. "THE PROBLEM IS FACTORY PRIMER PROBLEM" AND SHOULD EXPECT TO SEE MORE PEELING IF NOT REPAINTED SOON. *TR

PAINT BLISTERING AND PEELING ABOVE THE WINDSHIELD ON ROOF. *TR

WE OWN A 2003 FORD ESCAPE SUV. THE PAINT IS PEELING OF THE BACK TAILGATE. THIS CAR HAS BEEN GARAGE AND ONLY HAS 80,000 MILES. THIS PAINT SHOULD NOT PEEL OFF LIKE THIS. THE DEALER SAID I COULD PAY $300 TO HAVE IT REPAINTED. *TR

PAINT PEELING OFF THE ROOF AND REAR TAILGATE OF VEHICLE. BROUGHT THE VEHICLE INTO THE DEALER. BODY SHOP INSPECTED AND REPORTED THAT IT NEEDED TO BE REPAINTED. INTERNET SEARCH SHOWS THAT THIS IS NOT AN UNCOMMON EVENT AND THAT IT HAS TO DO WITH IMPROPER PREP OR PARTS USED. *TR

PAINT PEELING DOWN TO BARE METAL ON ROOF OF VEHICLE WITH PAINT BLISTERING ELSEWHERE. EXPOSED BARE METAL RUSTING DUE TO EXPOSURE TO ELEMENTS. ATTEMPTING RESOLUTION VIA DEALER BUT NO HELP AT THIS TIME. *TR

TL*THE CONTACT OWNS A 2003 FORD ESCAPE. THREE MONTHS AFTER THE VEHICLE WAS PURCHASED, THE CONTACT NOTICED A BLOCK OF PAINT CHIPPING OFF OF THE HOOD. WEEKS LATER, THE CONDITION BECAME PROGRESSIVELY WORSE. THE PAINT BEGAN BUBBLING AND CHIPPING EXCESSIVELY. WHEN THE CONTACT ATTEMPTS TO WASH THE VEHICLE THE PAINT WILL COME OFF. SHE IS IN THE PROCESS OF NOTIFYING THE MANUFACTURER. THE FAILURE MILEAGE WAS 74,000 AND CURRENT MILEAGE IS 100,000. UPDATE 06/10/08 *BF UPDATED 06/10/08

TL*THE CONTACT OWNS A 2003 FORD ESCAPE. THE CONTACT NOTICED THAT THE PAINT ON THE PASSENGER SIDE DOOR, LIFT GATE, AND LEDGE SHOWED SIGNS OF BUBBLING PAINT. THE DEALER STATED THAT THE FAILURE WAS NOT COVERED UNDER WARRANTY AND DOES NOT HAVE A RECALL. THE MANUFACTURER STATED THAT THEY WILL SPEAK WITH THE DEALER. THE CURRENT MILEAGE WAS 19,400 AND FAILURE MILEAGE WAS 19,350. THE CONSUMER PROVIDED A REPAIR INVOICE. UPDATED 08/31/07 *TR

WHEN THE VEHICLE WAS DRIVEN IN THE RAIN WATER CAMES THROUGH THE DRIVERS SIDE WINDOW FRAME. THE WATER WENT DOWN INTO THE ELECTRICAL BUTTONS ON DOOR PANEL. FORD REPLACED ALL THE RUBBER SEALS BUT IT STILL LEAKS. *AK