1998 DODGE DURANGO Power Traindrivelinedifferential Unit Problems

HAD REAR REBUILT IN 2003 BY DEALER.BACK IN 12/15/05 REAR WENT AGAIN.TALKED TO MECHANIC HE SAID DODGE KNOWS ABOUT REARS BEING BAD.DUE TO TIGHT TOLERANCES IN GEARS.

DODGE DEALER REPORTED THAT BALL JOINTS ON 1998 DODGE DURANGO HAVE EXCESSIVE WEAR AND REQUIRE REPLACEMENT. THE QUOTE TO REPLACE EXCEEDED $2000 AND I WAS TOLD AT THE TIME THAT THE RECALL WAS PENDING. I AM THE ORIGINAL OWNER, VEHICLE MILEAGE IS 76,898. VIN IS [XXX]. I SEE THAT THE RECALL IS FOR 2000 THROUGH 2003 AND THAT WARRANTY ON 2000 THRU 2003 MODELS WAS EXTENDED TO 100,000 MILES FOR BALL JOINTS. IS THERE ANY RECOURSE? ISN'T THIS THE SAME SUSPENSION DESIGN AS THE 2000 MODEL? I ALSO REPLACED THE REAR AXLE IN 2003 FOLLOWING A TOTAL FAILURE RESULTING IN REAR LOCKING UP AND SHEARING THE U-JOINT AND DROPPING THE DRIVE SHAFT WHILE DRIVING. REPLACEMENT COST EXCEEDED $3000 AND I WAS TOLD AT THE TIME THAT THIS IS A KNOWN PROBLEM WITH DURANGO'S AS WELL. *JB UPDATED 07/24/2012* JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5...

1. SEATBELTS, HOUSING REPEATEDLY FELL DOWN. NEVER REPLACED, SERVICE ONLY PULLED IT BACK UP AND THE PROBLEM CONTINUES 2. ALL FOUR WINDOW REGULATORS REPLACED PRIOR TO RECALL. NOW I HAVE ONE WINDOW THAT WILL GO DOWN. THE REST ARE STUCK IN THE UP POSIITON. OF COURSE, MY WARRANTY IS UP. 3. REAR DIFFERENTIAL WENT OUT AT 63,000. 3,000 PAST WARRANTY. 4. ALL FOUR BALL JOINTS ARE BAD. SERVICEMAN SAYS UNSAFE TO DRIVE UNTIL REPLACED. STILL WAITING ON A RECALL. 5. PASSENGER FRONT SEAT COVER CAME APART AT SEAMS. SERVICE SAID NOT COVERED BY WARRANTY. 6. HOOD LATCH DOES NOT RELEASE HOOD. MY VEHICLE IS NOW PARKED AND NOT BEING DRIVEN AT 80,000. I DO NOT HAVE AND WILL NEVER HAVE ANOTHER CHRYSLER PRODUCT IN MY DRIVE. I BOUGHT THIS VEHICLE NEW AND TOOK VERY GOOD CARE OF IT. IT SEEMS TO BE FALLING APART AROUND ME. SEEMS I HAVE HEARD...

DEFECTIVE REAR-END OF THE VEHICLE INCLUDING THE RING AND PINION OF THE DIFFERENTIAL. DODGE DURANGO 1998. *AK

VEHICLE WAS MAKING HIGH PITCH SOUND WHEN GAS PEDAL WAS PRESSED. TRUCK ONLY HAD 70,000 MILES ON IT WHEN I BOUGHT IT (APRIL 2003) USED. I WAS ASSURED BY WELL KNOWN AND RESPECTED CAR DEALER (KOEPPEL OF NEW YORK) THAT VEHICLE WAS IN GREAT SHAPE. 6 MONTHS LATER THE VEHICLE NEED TO HAVE THE FRONT DIFFERENTIAL AND REAR DIFFERENTIAL TO BE REPLACED. FRONT DIFFERENTIAL WAS LEAKING FLUID AND REAR WAS CAUSING HIGH PITCH NOISE. *LA

WHINING NOISE COMING FROM REAR. TOOK TO DODGE DEALERSHIP. NEEDS COMPLETE REAR END REBUILD. $1300-$1500 ESTIMATE. ONLY 63K MILES. APPARENTLY IT'S A DESIGN DEFECT BY DODGE.

WHILE DRIVING, THE VEHICLE HAD A HIGH PITCH SQUEAKING NOISE. THIS WAS CAUSED BY A FAILURE IN THE REAR END. *AK THE FRONT ROTOR DISK, RING GEAR AND PINION WAS REPLACED. *SCC *JB

WE HAD NOTICED THAT THE TRANMISSION WAS ACTING VERY SLUGGISH. DESPITE HAVING THE VEHICLE CHECKED, OUR LOCAL SHOP COULD NOT FIND A PROBLEM. WHILE ON OUR WAY TO FLORIDA, JUST OUTSIDE OF BIRMINGHAM ALABAMA WITH TWO CHILDREN IN THE CAR, DRIVING 70 MPH ON THE INTERSTATE, WE HAD A CATASTROPHIC FAILURE IN THE VEHICLE. THE TRANSFER CASE BLEW UP AND BOTH DRIVESHAFTS BROKE. WE WERE ABLE TO BE ABLE TO STOP THE VEHICLE WITHOUT CAUSING AN ACCIDENT, OR HAVING ANOTHER VEHICLE HIT US, DESPITE THE BLACK COUD OF TRANSFER CASE FLUID TRAILING BEHIND US. THE VEHICLE REQUIRED EXTENSIVE SERVICE - TO THE TUNE OF $ 2,600.00. WE HAD 95,000 MILES ON THE VEHICLE AND WERE OFFERED NO ASSISTANCE BY CHRYSLER. IN FACT, NOT EVEN AN OFFER TO ASSIST US WITH THE RENTAL CARS WE WERE FORCED TO TAKE.

I HAVE A 1998 DODGE DURANGO WITH 52,000 MILES ON IT. THIS PAST WEEK I NOTICED A HIGH PITCHED WHINE FROM THE REAR DIFFERENTIAL. I HAVE TAKEN THE VEHICLE TO THE ORIGINAL DEALER IN CORYDON, INDIANA. THAT I HAVE PURCHASED 2 OTHER VEHICLES FROM. THEY ARE TELLING ME THAT I AM RESPONSIBLE FOR EITHER ALL THE COST OF REPAIRS, OR THAT THEY MIGHT BE ABLE TO GET CHRYSLER TO PAY HALF. I THINK THIS EXTREMELY UNFAIR. I HAVE HAD REAR DIFFERENTIAL VEHICLES WITH WELL OVER 100,000 MILES THAT ARE STILL MOVING WITH NO DIFFERENTIAL FAILURES. WHEN IS SOMEONE GOING TO MAKE THESE CAR COMPANIES STAND BEHIND THERE PRODUCT. THANKS, FOR YOUR TIME. RLC. *JB

WHEN CO. REP SAID THE CO. WOULD NOT COMPENSATE DUE TO AGE AND MILAGE EVEN THOUGH PARTS FAILED FAR SHORT OF NORMAL SERVICE LIFE. ANY HELP YOU CAN PROVIDE WILL BE GREATLY APPRECIATED. DT

PINION SHAFT BROKE WHILE DRIVING, CAUSING REAR END TO LOCK UP. GEAR BUSTED, AND THERE WAS A HOLE IN REAR END.*AK THE GEARS BROKE AND PUT A HOLE IN THE BOTTOM OF REAR END. *YH

THE 1998 DODGE DURANGO REAR DIFFERENTIAL UNIT SEIZED AND FAILED ON A MAJOR HIGHWAY . I WAS UNABLE TO MOVE THE VEHICLE AND CAUSED US TO IMMEDIATELY EXIT THE VEHICLE TO AVOID ON COMING TRAFFIC. THE VEHICLE WAS TOWED TO THE DEALERSHIP WHERE I WAS TOLD THAT THE REAR DIFFERENTIAL WAS IN PIECES. THE DEALER DENIED TO ABSORB THE REPAIR COST FOR THEY SAID IT WAS OUT OF WARRANTY. I APPEALED TO THE CUSTOMER SERVICE REPRESENTATIVE WHO DENIED THE CLAIM. I CALLED AN INDEPENDENT INSURANCE TECH REP AND HE CONCLUDED IT WAS A SERIOUS DESIGN FLAW. IN MY PERSONAL OPINION I FEEL DODGE SHOULD INSPECT AND REPAIR THESE VEHICLES. *AK

WHILE ON THE HIGHWAY, VEHICLE'S DIFFERENTIAL FREEZES AND IS UNABLE TO MOVE FORWARD OR BACKWARDS.*AK THIS IS NOT UNCOMMON FOR THIS MODEL. THERE HAVE BEEN FAILURES REPORTED PREVIOUSLY BY OTHER CONSUMERS. CONSUMER FEELS DODGE SHOULD RECALL AND REPAIR THE PROBLEM. *JG

WHILE DRIVING THE VEHICLE, A LOUD WHINING SOUND WAS HEARD COMING FROM THE REAR OF THE DURANGO. AFTER VERIFYING THE TIRE PRESSURE WAS CORRECT AND ATTEMPTING TO MAKE SURE THAT THE 4WD WAS NOT ENGAGED, THE WHINING SOUND BECAME LOUDER. I TOOK THE VEHICLE IN FOR SERVICE TO A DEALER IN NORTH RICHLAND HILLS, TX (A SUBURB OF FORT WORTH). THE SERVICE ADVISOR WAS SURE THAT THE REAR DIFFERENTIAL NEEDED TO BE CHANGED AND ALL WOULD BE FINE. AFTER SERVICING THE DIFFERENTIAL THE SERVICE ADVISOR CONTACTED ME TO LET ME KNOW THAT THE PROBLEM STILL EXISTED. AFTER FURTHER INVESTIGATION THE DEALER FOUND THAT THE "RING AND PINON SET, AND CUP AND CONES" NEEDED TO BE REPLACED ( THIS IS THE RING AND PINON GEAR, THE PINON SEAL, AND THE SIDE BEARING THAT SUPPORT THE DIFFERENTIAL CASE). THE ESTIMATED COST FOR THIS REPAIR WAS $1323.08. I REMINDED THE SERVICE ADVISOR THAT...

A LOUD HOWLING NOISE WAS HEARD COMING FROM THE REAR OF THE VEHICLE. TOOK THE VEHICLE TO THE REPAIR SHOP WHERE I WAS TOLD THAT THE REAR AXLE BEARINGS AND POSSIBLY DIFFERENTIAL RING AND PINION WERE BAD. I WAS ADVISED BY MY MECHANIC TO GO BACK TO THE DEALER SINCE THIS WAS AN ORIGINAL EQUIPMENT MATERIAL AND WORKMANSHIP DEFECT OBVIOUS BY THE LOW (22,000) MILEAGE ON THE VEHICLE THAT LOOKS LIKE THE DAY IT CAME OUT OF THE SHOWROOM. THIS VEHICLE HAS NEVER BEEN USED OFF-ROAD. I RECEIVED NO SATISFACTION FROM THE DEALER AND WAS TOLD SINCE THE VEHICLE IS 9 MONTHS OUT OF WARRANTY THAT I WAS RESPONSIBLE FOR REPAIR COSTS. I STRONGLY DISAGREE. THERE ARE SEVERAL OTHER COMPLAINTS LISTED IN THIS SECTION WITH THE SAME PROBLEM I EXPERIENCED AND I'VE BEEN TOLD BY AN EXPERT THAT THE REAR DIFFERENTIAL IN THIS VEHICLE HAS A SERIOUS DESIGN DEFECT INVOLVING...

THIS VEHICLE HAS HAD MAJOR COMPONENT BREAKDOWNS SINCE PURCHASE. INITIALLY, IMMEDIATELY AFTER PURCHASE THERE WAS A CLICKING SOUND IN THE STEERING COLUMN. THE DEALER INDICATED THAT THERE WAS A TSB AND REPLACED STEERING COLUMN. THE SECOND PROBLEM OCCURRED IN FEBRUARY 2000, SOME THREE MONTHS AFTER PURCHASE. WE BEGAN TO NOTICE A SIGNIFICANT PULSING IN THE BRAKE PEDAL. THE DEALER ATTRIBUTED THIS TO ABS BRAKES. SEVERAL MONTHS LATER WHEN THE PULSING WAS SIGNIFICANTLY GREATER AND THE BRAKING WAS BEING AFFECTED, AN INDEPENDENT SHOP REVIEWED THE BRAKES AND INDICATED THAT THE ROTORS WERE SEVERELY WARPED AND CAUSING THE PULSING SENSATION. THIS WAS REPAIRED OUT OF POCKET. IN FEBRUARY, 2001 THE TEMPERATURE BEGAN FLUCTUATING, SPIKING HIGHER TEMPERATURES CAUSING THE CHECK GAUGE LIGHT TO ILLUMINATE. IT WOULD THEN RESET. HANOVER DODGE, A DIFFERENT DEALER INDICATED THAT THE THERMOSTAT HOUSING SEAL WAS LEAKING AND REPLACED THE THERMOSTAT AND GASKET. THIS WAS PAID OUT OF POCKET....

WHILE BACKING OUT OF DRIVEWAY CAR MADE A LOUD NOISE, CAR WAS INOPERABLE, CAR WAS TOWED TO DEALER. WAS NOTIFIED BY THE DEALER THAT THE RING AND PINION GAR HAD CRACKED, AND REAR NEEDS TO BE REPLACED.*AK

VEHICLE WAS EXPERIENCING LOUD NOISE FROM THE REAR DIFFERENTIAL UNIT. TOOK TO REPAIR SHOP AND THEY REPLACED LEFT AND RIGHT SIDE OF REAR DIFFERENTIAL. WANTED TO ALSO REPAIR DIFFERENTIAL RING AND PINION BECAUSE THERE WAS STILL A LOUD NOISE.

REAR DIFFERENTIAL LOCKS UP. UNDER NORMAL DRIVING CONDITIONS IT MAKES THE VEHICLE FEEL AS THOUGH THE REAR END IS LOOSE ON THE ROAD AS A LOW TIRE PRESSURE PROBLEM. WHEN ATTEMPTING TO MAKE A TIGHT TURN AT AN INTERSECTION THE VEHICLE REQUIRES CONSIDERABLE POWER TO FORCE IT THROUGH THE TURN. THE UNIT WILL RELEASE WITH A SUDDEN BANG THAT WOULD MAKE YOU THINK THE DRIVETRAIN GAVE WAY. THE VEHICLE WILL NOT ACHIEVE ITS TURNING RADIUS UNDER THESE CONDITIONS, TAKING THE DRIVER BY SURPRISE WHEN TRYING TO PULL INTO TRAFFIC.

1)INITIALLY HEARD A "CLUNK" FROM RIGHT REAR EVERY TIME WE'D HIT A BUMP. TURNED OUT TO BE NOT A BROKEN SHOCK ABSORBER, NOR THE BOLT WHICH ATTACHES THE SHOCK ABSORBER TO THE FRAME, BUT THE ACTUAL FRAME PIECE TO WHICH THE BOLT/ABSORBER ASSEMBLY ATTACHES. 2)WHILE OBSERVING PROBLEM 1, NOTICED OIL/DIRT "LEAK" ON DRIVER'S SIDE OF REAR DIFFERENTIAL/AXLE.

VEHICLE WAS EXPERIENCING LOUD NOISE FROM THE REAR DIFFERENTIAL UNIT. TAKEN TO DEALER FOR REPAIRS, AND DEALER REPLACED DIFFERENTIAL RING AND PINON AND REAR AXLE BEARING AT CONSUMER'S COST. ALSO, DEALER NOTICED THAT SOME OF THE BEARINGS WERE MISSING WHEN REMOVED. *AK *ML

REAR END NOISE DUE TO FAILURE OF THE DIFFERENTIAL UNIT/ BEARINGS/ PINION. MJS