2003 CHEVROLET IMPALA Structure Problems

UPON GOING FOR STATE INSPECTION I WAS INFORMED THAT THE FRONT AND REAR ROTORS WERE RUSTING AND FLAKING AND IF THIS WAS NOT CORRECTED, CAR WOULD NOT PASS INSPECTION NEXT YEAR. WAS TOLD THIS WAS DUE TO NOT DRIVING THE CAR ENOUGH (UNDERUSAGE). MY CAR IS A 2003 CHEVROLET IMPALA 4 DOOR SEDAN. THE COST WAS $344.50 TO REPAIR. ON TODAY'S NEWS I NOTICED THAT GENERAL MOTORS PICKUP TRUCKS AND SUV'S ARE UNDER INVESTIGATION FOR THE SAME PROBLEM. I AM NOW CONCERNED THAT THIS PROBLEM MIGHT ALSO INVOLVE THE IMPALA. *TR

WHENEVER IT RAINS, THE FLOORBOARDS, IN MY 2003 IMPALA, ON THE PASSENGER SIDE OF MY CAR FLOOD. FOUND A SOLUTION FOR GM'S POOR DESIGN. THE COWLING GASKET ABOVE THE CABIN FILTER SHOULD BE REPLACED AND GLUED IN POSITION WITH RTV. THIS SHOULD SOLVE PROBLEM. ALSO MAKE SURE DRAINHOLES AROUND CABIN FILTER ARE CLEAR OF ALL DEBRIS. *TR

WHENEVER IT RAINS, THE FLOORBOARDS, IN MY 2003 IMPALA, ON THE PASSENGER SIDE OF MY CAR FLOOD. IT DOESN'T MATTER HOW LITTLE OR HOW MUCH IT RAINS, THE FLOORBOARDS ALWAYS FLOOD. THERE WAS ONE INSTANCE WHERE THE WATER WAS PAST MY ANKLES. THE WATER IS DRIPPING FROM UNDER THE GLOVE COMPARTMENT BOX AREA AND IT RUNS ALONG THE DOOR SEAL TO THE BACK PASSENGER SEAT. I HAVE BEEN TOLD FROM MY LOCAL CHEVY DEALERSHIP THAT IT IS POSSIBLE A BAD CABIN SEAL. AFTER FINALLY GETTING FED UP WITH THE SITUATION I LOOKED FOR A POSSIBLE SOLUTION ONLINE AND WHILE I DIDN'T FIND A SOLUTION I FOUND MANY OTHERS THAT HAVE THE SAME PROBLEM AS ME. THIS HAS BEEN AN ONGOING PROBLEM THAT HAS LASTED SINCE I BOUGHT THE CAR 2 YEARS AGO. *TR

FAILING PAINT ON FRONT AND REAR BUMPERS OF WHITE IMPALAS. ON ALL WHITE IMPALAS FROM MY AREA THE PAINT IS FLAKING OFF OF THE BUMPERS, BOTH FRONT AND REAR, VERTICALLY IN CHUNKS ALONG THE CURVES TOWARD EITHER SIDE OF THE CAR. THIS ONLY APPEARS TO BE A CONDITION WITH THE WHITE MODELS, AND LOOKS LIKE THERE WAS NOT ENOUGH FLEX ADDED TO THE PAINT BEFORE APPLICATION. *TR

I DISCOVERED ACCIDENTALLY THAT MY 2003 CHEVROLET IMPALA HAS A DESIGN DEFECT THAT MAY CAUSE SOME HEALTH PROBLEMS AND POSSIBLE LEAD TO DEATH. IN THE RIGHT REAR QUARTER PANEL OF THE CAR IS A DEVICE THAT IS CALLED A BODY PRESSURE VALVE THAT VENTS CABIN PRESSURE. THE PROBLEM IS IT LETS SNOW AND RAIN IN THE STAGNANT WATER SITS IN YOUR FENDER AND IS A BREEDING GROWN FOR GERMS. THE DEALER WAS SHOCKED WHEN I BROUGHT IT IN AND ASKED ME WHAT MADE ME THINK TO REMOVE THE CARPET AND LOOK IN THE FENDER. ALL THEY COULD DO WAS TAKE THE WATER OUT. STANDING WATER IN A FENDER WILL CAUSE A RUST PROBLEM. I ASKED THEM WHAT COULD BE DONE AND THEY TOLD ME TO PUT A NEW VALVE IN. THAT WILL NOT CORRECT THE PROBLEM BECAUSE THE FLAP IS NOT AIR TIGHT AND IS VENTED WATER AND FUMES SUCH...

MY BLACK IMPALA HAS CHIP IN THE PAINT. MY BLACK IMPALA HAS PLACES WHERE THE PAINT IS COMING OFF. HAVE NOT SEEN THIS PROBLEM ON OTHER PAINT COLORS. *TR

DT: THE DASH WAS CAVING IN, THE WINDSHIELD WAS OFF LEVEL AND THERE WAS KNOCKING IN THE STEERING, THE UNDERNEATH FRAME WAS HANGING DOWN ON THE DRIVER'S SIDE; THERE WAS A GAP IN THE CONNECTION OF THE REAR PASSENGER'S SIDE DOOR, AND OTHER PROBLEMS. THE CONSUMER HAD THE ROTORS REPLACED, AND THE WHEELS ALIGNED. THEN, THE CONSUMER TOOK VEHICLE TO A DEALERSHIP AND THEY TOLD HER THAT THERE WAS NOTHING WRONG WITH THE VEHICLE. SHE CONTACTED THE MANUFACTURER, WHO TOLD HER THAT THERE WAS NOTHING THEY COULD DO BECAUSE IT WAS OUT OF WARRANTY. THE CONSUMER STATED THAT AT FIRST THERE WAS A PROBLEM WITH THE STEERING AND THEY REPLACED GEAR SHAFT.*AK

RADIO HAS VERY BAD RECEPTION. HAVE TAKEN CARE TO DEALERSHIP AND THEY HAVE REPLACED NEW RADIO WITH RECONDITIONED RADIOS TWICE. FIRST REPLACEMENT RADIO, DISPLAY DID NOT WORK PROPERLY. SECOND REPLACEMENT RADIO WAS NOT CALIBRATED PROPERLY WHEN INSTALLED AND WHEN TAKEN BACK TO THE DEALERSHIP AND RE-CALIBRATED, HAD THE SAME PROBLEM WITH THE DISPLAY AS REPLACEMENT RADIO NUMBER ONE. I NOW SUPPOSEDLY NEED A NEW DIMMER SWITCH. (AM TAKING TO ANOTHER DEALERSHIP IN THE HOPES THAT THEY CAN REPAIR THE PROBLEM) THE FOG LIGHTS CONSTANTLY HAVE EXCESSIVE CONDENSATION. AM TOLD BY THE DEALERSHIP AND GM THAT THIS IS NORMAL HOWEVER I HAVE HAD SEVERAL PEOPLE TELL ME THIS IS NOT NORMAL. HAVE NOT OBSERVED THIS TYPE OF CONDENSATION ON ANY OTHER VEHICLE'S FOG LIGHTS. GM WILL NOT REPAIR OR REPLACE UNLESS THERE IS STANDING WATER. GM REFUSED CLAIM. THERE IS AN EXTREMELY LOUD POPPING AND CRACKING NOISE FROM THE DASH. TEMP...

WHILE DRIVING, THE CONSUMER'S FOOT SLIPPED OFF THE GAS PEDAL BECAUSE THE GAS PEDAL WAS TOO SHORT. THE DEALER WAS NOTIFIED. *AK THERE WASN'T GOOD ARM ROOM FOR STEERING. THE DEALER STATED THEY WERE UNABLE TO DO ANYTHING ABOUT THE SIZE OF THE PEDAL. *SCC *JB

CONSUMER EXPERIENCED EXTREME STATIC ELECTRICITY WHEN ENTERING THE VEHICLE. THE DEALER STATED THAT THIS IS COMMON DURING COOL DRY CONDITIONS. *NLM