2003 CHEVROLET IMPALA Engine And Engine Coolingengine Problems

2003 CHEVY IMPALA SECURITY LIGHT RANDOMLY COMES ON WHILE DRIVING VEHICLE. LIGHT WILL TURN OFF SOMETIMES AFTER DRIVING OR SOMETIMES AFTER CAR IS TURNED OFF. CAN GO AT THE LONGEST A WEEK BETWEEN LIGHT COMING BACK ON AGAIN. CAR WITHOUT WARNING DID NOT START. TURNED KEY LIGHTS WORKED RADIO WORKED AND AC BUT WOULDN'T TURN OVER. *KB

INTAKE GASKET BLOWN. *TR

2003 CHEVROLET IMPALA. CONSUMER STATES VEHICLE IS UNRELIABLE, PERIODICALLY NOT RUNNING *TGW THE CONSUMER STATED WHEN HE TURNED ON THE IGNITION, IT WOULD NOT TURN OVER. IT DIDN'T MAKE ANY TYPE OF NOISE, BUT THE HEADLIGHTS AND SECURITY LIGHT WOULD TURN ON. AFTER LETTING THE VEHICLE SIT FOR AWHILE, IT WOULD THEN START. *JB

PROBLEM STARTED WITH THE TRANS - WASN'T SHIFTING RIGHT, HARD SHIFT. TOOK IT TO ROTOLO CHEVY IN FONTANA, CA. DX: CATALYTIC CONVERTER, NEARLY $800 TO GET NEW ONE ONLY TO HAVE THE CAR COMPLETELY DIE ON THE SIDE OF THE ROAD WHEN THE TRANNY DISINTEGRATED. REPLACED UNDER WARRANTY. EVER SINCE I HAVE HAD SHIFTING DIFFICULTIES - TOOK IT BACK A WEEK LATER TO BE TOLD IT HAS A "SMART ADAPT" IN TRANS AND NEEDED APPROX 1000 MILES TO SYNC ITSELF, NOW THE CAR SPUTTERS, HAS A MISFIRE CODE IN CYLINDER 2, TRANS CODE. HARD STARTS, RANDOMLY STALLS WHEN MAKING RIGHT TURNS, INTERIOR AND EXTERIOR LIGHTS SURGE WHEN AT AN IDLE, CAR CONSTANTLY FEELS LIKE IT WANTS TO STALL - IT CAN ACTUALLY MAKE YOU NAUSEAS WHEN SITTING AT A STOP LIGHT BECAUSE OF THE SURGING OF THE CAR. THIS MORNING THE CAR JUST STALLED WHEN I WAS AT A STOP...

WHILE DRIVING AT VARIOUS SPEEDS, THE ENGINE WOULD STALL AND SHUT OFF. THE PROBLEM STARTED AT 90,000 MILES. HAVE BROUGHT THE CAR TO THE CHEVY DEALER AND THEY HAVE NOT BEEN ABLE TO DIAGNOSE THE PROBLEM. THE CAR IS NOT GENERATING ANY ERROR CODES. I ALMOST GOT INTO AN ACCIDENT TWICE DUE TO SHUTTING OFF DURING ACCELERATION. I HAVE NOTICED THAT THE STALLING OR SHUTTING OFF STARTS AFTER THE TEMPERATURE REACHES APPROXIMATELY 125 DEGREES F AND HAPPENS RANDOMLY. WHEN I AM OPERATING THE AIR CONDITIONER, THE STALLING IS MORE NOTICEABLE DUE TO THE ENGINE LOAD. SO FAR, THE DEALER HAS REPLACED THE CRANK SENSOR AND IGNITION MODULE WHICH HAS NOT CORRECTED THE STALLING AND SHUTTING DOWN. *TR

MANIFOLD GASKET WAS LEAKING ON MY 2003 CHEVROLET IMPALA. *TR

LOWER INTAKE MANIFOLD GASKETS NEED REPLACED. I ONLY HAVE 40,000 MILES ON THE CAR THAT IS A 2003 IMPALA LS WITH 3.8 LITER ENGINE. ALSO, COOLANT HOSE SEAL IS LEAKING COOLANT. *TR

MY CHEVY, IMPALA CAUGHT ON FIRE. *TR

TL*THE CONTACT OWNS A 2003 CHEVROLET IMPALA. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD STALL. THE DEALER MADE REPAIRS TO THE CATALYTIC CONVERTER, HOWEVER FOLLOWING REPAIRS THE VEHICLE EXPERIENCED THE SAME FAILURE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE MASS AIR FLOW SENSOR WAS REPLACED. THE REPAIR DID NOT CORRECT THE FAILURE. THE VEHICLE WAS TAKEN TO ANOTHER DEALER AND THE CATALYTIC CONVERTOR WAS REPAIRED A SECOND TIME. THE DEALER ALSO ADVISED REPLACING THE SENSOR BUT THE CONTACT HAD RECENTLY HAD THE SENSOR REPLACED. THE VEHICLE CONTINUED TO STALL. THE VEHICLE WAS TAKEN TO A SECOND INDEPENDENT MECHANIC WHERE THE FUEL PUMP WAS REPLACED BUT STILL, DID NOT CORRECT THE FAILURE. THE VEHICLE WAS LEFT IN THE POSSESSION OF THE DEALER WHERE REPAIRS WERE MADE TO THE ELECTRICAL SYSTEM. THE FAILURE MILEAGE WAS 61,500.

I WAS DRIVING MY 2003 CHEVY IMPALA AND TRIED TO SIGNAL A LANE CHANGE AND THE FLASHERS WOULD NOT WORK FOR EITHER DIRECTION. THERE WAS NOT ANY ACCIDENT, BUT THE SITUATION WAS VERY AGGRAVATING. THE CAR ALSO HAS A HISTORY OF OIL SEEPAGE AND IT HAS ONLY 70,000 MILES ON IT. WE BOUGHT THE CAR 4 YEARS AGO AT A USED CAR DEALER, AND I CHANGE THE OIL MYSELF EVERY 3000 MILES. THE CAR IS HARD STARING AT TIMES, AND I HAD PUT A NEW BATTERY IN IT 2 YEARS AGO DUE TO THE TROUBLE STARTING. *TR

TOOK MY CAR TO THE DEALER IN COLLIERVILLE,TN. FOR ANOTHER WIDESPREAD PROBLEM, THAT SHOULD HAVE BEEN A RECALL COSTING 1,000.00, & WAS TOLD OF ANOTHER PROBLEM WITH THE INTAKE GASKET,THAT WILL BE ANOTHER $1,000.00, I SEE MANY OTHERS HAVE THIS SAME PROBLEM, BUT OF COURSE GM NOT CALLING IT A RECALL. I HAVE A 2003 CHEVROLET IMPALA WITH APPROXIMATELY 149,000 MILES ON IT. SUNRISE CHEVROLET IN COLLIERVILLE,TN. HAS BEEN THE PROPLE DEALING WITH ME , AND STATES, THEIR COMPUTER PROGRAMMED BCM IS NOT A RECALL, NOR THE IGNITION CHIP THAT ENGAGES THE KEY , IS ALSO NOT A GM PROBLEM BUT MANY OF THEIR CUSTOMERS. I SUFFERED WITH MY CAR NOT STARTING NUMEROUS TIMES , AND FINALLY BIT THE BULLET AND PAID HIGH DOLLAR TO THE DEALERSHIP FOR GM'S SHOULD BE RECALL. I WANT SOMEONE TO LISTEN ABOUT EVERYONE'S COMPLAINT OF THE INTAKE GASKET LEAKING, AND MAKE GM DO THE...

ABOUT 1 YEAR AGO MY 2003 IMPALAS HEAT GAUGE STARTED ACTING FUNNY LIKE THE CAR WAS OVERHEATING BUT THEN IT WOULD GO BACK TO NORMAL. IT WAS COOL OUT ABOUT THAT TIME OF YEAR AND I ALSO NOTICED THE CAR HAD NO HEAT. I REPLACED THE THERMOSTAT THINKING THAT WAS THE PROBLEM BUT IT DID NOT HELP AND THE PROBLEM PERSISTED. MY HUSBAND THEN NOTICED THAT THE COOLANT LEVEL WAS LOW AND ADDED MORE. THAT ALSO DID NOT FIX THE PROBLEM, AND ABOUT A WEEK LATER WE NOTICED THE COOLANT WAS LOW AGAIN. WE LOOKED FOR THE LEAK AND COULD NOT FIND ONE. I FINALLY TOOK THE CAR TO THE DEALERSHIP AND THEY AUTOMATICALLY KNEW WHAT THE PROBLEM WAS AND STATED IT WAS A PROBLEM WITH THE 3400 SERIES ENGINE. WE PAID NEARLY $700 TO HAVE THE CAR FIXED. I HAVE RECENTLY NOTICED THAT MY COOLANT LEVEL AGAIN IS LOW...

MY 2003 IMPALA STARTED WITH A SLOW LOOSE OF COOLANT. EVERY WEEK OR SO WOULD HAVE TO ADD TO THE OVERFLOW, BUT NEVER SAW A LEAK. WAS OVER-HEATING TOO. EVENTUALLY IT WOULD HAVE A TICKING FROM THE ENGINE AREA WHEN STARTING CAR. IT WASN'T ALL THE TIME THOUGH. I NOTICED THAT THERE WAS OIL ON MY DRIVEWAY AND THE OIL WAS ABOUT A 1/2 QUART LOW. CHECKED AGAIN IN COUPLE DAYS AND NEEDED TO ADD A QUART BECAUSE LIGHT CAME ON. TWO DAYS LATER LIGHT CAME ON AGAIN. TOOK IT TO A CHEVY DEALERSHIP WHO INFORMED ME THAT THE GASKET NEEDED REPLACING IN THE INTAKE MANIFOLD BECAUSE COOLANT MIXED WITH OIL. ALSO NEEDED COOLANT FLUSH, AND OIL CHANGE AND ANOTHER GASKET. THEY TOLD ME THERE WAS LOTS OF SLUDGE IN ENGINE AND COULD CAUSE MORE PROBLEMS IN THE FUTURE. THE CAR HAS 68,000 MILES ON IT AND IT COST ME...

DT*: THE CONTACT STATED THE FIRST WEEK AFTER PURCHASING THE VEHICLE, THE TIRES STARTING MAKING NOISES WHILE DRIVING AT 35 MPH AND THE ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO LOCAL DEALER WHO DETERMINED THE VEHICLE WAS DRIVEN OUT OF ALIGNMENT CAUSING TIRES TO WEAR DOWN. NO REPAIRS WERE MADE. THE VEHICLE WAS TAKEN TO ANOTHER DEALER WHO DETERMINE ALL FOUR TIRE SHOULD BE REPLACED AT A COST. THE TIRES WERE NOT REPLACED BECAUSE THE CONTACT DID NOT WANT TO PAY FOR THE REPLACEMENT. THE TIRES WERE ROTATED BY THE CONTACT TO REMEDY THE PROBLEM. UPDATED 8/1/2006 - *NM

HEATER QUIT WORKING, THEN CAR STARTED OVERHEATING. TURNING OFF HEATER/DEFROSTER CAUSES IT TO STOP OVERHEATING SO MUCH, BUT TEMPERATURE STILL RISES WHEN WAITING AT LIGHTS. CAR IS ALSO NEEDING OIL REPLACEMENT, AFTER HAVING AN OIL CHANGE 2 MONTHS AND 1500 MI AGO. MILEAGE IS AROUND 60,000. THERE IS OIL LEAKING OUT IN VARIOUS PLACES AROUND THE ENGINE. *JB

DT: THE CONSUMER STATED THAT THE TRUNK LATCH ON 2003 CHEVROLET IMPALA WAS DESIGNED INCORRECTLY. WHEN HE PUT A SUIT CASE IN THE TRUNK OR ANYTHING HEAVY, THE LATCH STUCK VERY HIGH, BENT, AND EVENTUALLY THE TRUNK WOULD NOT SHUT. THE DEALER CHANGED THE LATCH ONCE. THE FOREMAN AND THE MECHANIC AT THE DEALERSHIP TOLD HIM THAT THERE WAS A PROBLEM WITH THIS MODEL. THE WARRANTY WAS SOON TO RUN OUT. *AK (11/18/05) PER INVOICE, THE DRIVEABILITY SEEMED TO IDLE HIGH. *SC

WHILE DRIVING WITH THREE PASSENGERS IN MY 2003 CHEVROLET IMPALA LS AT 35 MPH THE ENGINE SHUT-OFF WITHOUT WARNING WITH COMPLETE LOSS OF POWER STEERING AND BRAKES, REQUIRING EMERGENCY MANEUVER TO BRING CAR TO A STOP BEFORE HITTING ONCOMING TRAFFIC. A REPLACEMENT VEHICLE WAS NOT MADE AVAILABLE. WHILE DRIVING TO A MEDICAL EMERGENCY, LATER THAT EVENING, THIS RECURRED AT 50 MPH (ENGINE SHUT-OFF WITHOUT WARNING, LOSS OF STEERING AND BRAKING POWER REQUIRING EMERGENCY STOP IN CENTER MEDIAN 4 LANE HIGHWAY MERGE SITE). THIS HAPPENED PREVIOUSLY WITH THIS VEHICLE ON 7/4/03 AT 50 MPH WITH MY WIFE DRIVING ON THE VAN WYCK EXPRESSWAY. AT THAT TIME, AFTER 3 DAYS GM REGIONAL SERVICE MANAGER STATED THAT THERE WAS A DEFECTIVE CRANK-SHAFT SENSOR WHICH WAS REPLACED. I ADVISED GM THAT THERE WERE OTHER REPORTS TO NHTSA ABOUT THIS PROBLEM WITH CHEVROLET IMPALAS. I REQUESTED THAT AN INVESTIGATION AND POSSIBLE RECALL SHOULD BE INITIATED...

WHEN DRIVING 35 MPH VEHICLE STALLED. CONSUMER LOST POWER STEERING, BUT MANGED TO PULL OVER. HAD NOTIFIED THE DEALERSHIP, AND MECHANIC HAD NOT RESOLVED THE PROBLEM.*AK