NHTSA Complaint #11682517 — 2016 KIA OPTIMA

Engine began jumping during driving and loss power. No dashboard illumination warning lights and the temperature gage showed normal operating temperature. Car was not accelerating properly. Had to maneuver carefully to prevent being ran over. Engine light illuminated showing misfire. Replaced ignition coil pack and spark plugs. Driving again, car stalled. No dashboard warning lights. No high temperature on gauge. Narrowly missed being hit by a semi as there was absolutely no warning and we were on an Interstate bypass ramp with nowhere to pull over!! Towed car to dealership for diagnosis. Results: engine blown, turbos gone, and the catalytic converter is holding oil. Dealer is stating this is not covered under the extended warranty from Kia as its not connector rod bearing issues and that the piston rings failed. However, they stated the turbos got "too hot" and they failed. The gauges have never shown that the car was running hot. I have a sworn statement from my mechanic stating this is absurd and a valiant attempt to not pay for what would be the second warranty replacement of my engine. The piston rings failed as a result of the connector rod bearing failure. The "too hot" temperature that damaged the turbos was likely caused by the same bearing issue. The heat from the bearings unseated the piston rings and allowed the engine to dump its oil causing the engine to fail. I highly recommend that you open an investigation into these issues. The car not accelerating and losing power at interstate speeds is a very serious and dangerous issue.