NHTSA Complaint #11574430 — 2020 FORD EXPLORER

Our 2020 Ford Explorer has experienced two recent Powertrain issues Event 1: 1/28/24 ~5:20pm EST Location: Highway Situation: - Following a ~200+ mile road trip our vehicle was on the last mile of highway driving - As we started to move from the middle to right lane to exit the highway, the vehicle lurched, the dashboard lit up (with a wrench icon), the vehicle speed dropped to 40-45mph in an instant, and the RPMs revved from 1-2K to ~4K - We pulled onto the shoulder and stopped - After stopping the car, we nursed the car (at low speed and high RPM) home (a total of ~3-4 miles) - The next morning the car was started, the light was off, and we took it to a Ford dealer - The dealer had the car until 2/15, at which point they replaced an Automatic Transmission Internal Wiring Harness and Solenoid Event 2: 2/24/24 ~5:00pm EST Location: Highway Situation: - Following a ~1K mile road trip our vehicle was ~30 miles from our destination - We were traveling in the left-hand lane at highway speeds when again the vehicle suddenly lurched, the dashboard lit up (with a wrench icon), the vehicle speed dropped to 40-45mph in an instant, and the RPMs revved from 1-2K to ~4K - Despite road traffic we pulled across three lanes of traffic to the shoulder, where we stopped the vehicle - After bringing the car to a complete stop, we turned the vehicle off and restarted the engine - The wrench light was off, so we started to reenter traffic in the right lane; after travelling ~50 yards at climbing speed, the dashboard lights lit up (with a wrench icon and engine light icon), the vehicle speed held ~40-45mph, and the RPMs revved around 4K - Being within ~1/2 mile from the highway exit, we managed to the nurse the car (at low speed and high RPM) to a gas station where it was flat bedded to the same dealer - As of this writing, there has been no diagnostic activity nor timetable for the vehicle’s repair