NHTSA Complaint #11568553 — 2011 FORD EXPLORER

FUEL/PROPULSION SYSTEM issue reported to NHTSA

Check any vehicle history by VIN - Free vehicle history report

Complaint Details

ODI Number	11568553
Vehicle	2011 FORD EXPLORER
Component	FUEL/PROPULSION SYSTEM
Date of Incident	January 17, 2024
Date Filed	January 29, 2024
Mileage	N/A miles
Crash	No
Fire	No
Injuries	0
Deaths	0
Vehicle Towed	No
State	WV

Consumer Description

The fuel sending unit goes bad due to the split tank and differential and drive train have to be taken apart and dropped in order to change. Costing over $1,000.00. You can not go under half a tank of gas and if you do you just run out of gas immediately causing you to stop on highways side roads etc.Its very dangerous to have a vehicle that will just all of a sudden run out of gas and no one is paying to get them fixed because of the pricepoint charged to repair. This is Fords faulty work 1000%

Related Complaints for the 2011 FORD EXPLORER

Other FUEL/PROPULSION SYSTEM Complaints

#11580448 — April 1, 2024 — Hidráulic problem

#11487008 — September 28, 2022 — 9/25/22 My 2011 Ford Explorer xlt would start jerking when pushing on the gas paddle and then would start losing spee...

#11456797 — March 15, 2022 — The vehicle has been in for service at Downs Ford Dealership twice in the past two years for the same issue and has y...

#11445337 — December 28, 2021 — No warning when the fuel relay gasket attached to the pump assembly fails and allows fuel vapor to fill the cabin of ...

#11363135 — October 7, 2020 — AS A REPAIR SHOP OWNER, THE VEHICLE OWNER STATED THAT THERE WAS A STRONG FUEL ODOR AFTER FILLING THE FUEL TANK. I NOT...

Recent Complaints for the 2011 FORD EXPLORER

#11717906 — FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL — February 13, 2026 — During a red-light, as I was coming to a stop, the vehicle gave the warning saying “service power-steering now” and “...

#11717906 — POWER TRAIN — February 13, 2026 — During a red-light, as I was coming to a stop, the vehicle gave the warning saying “service power-steering now” and “...

#11715978 — STEERING — February 5, 2026 — The contact owns a 2011 Ford Explorer. The contact stated that while driving at various speeds, the steering wheel wa...

#11710555 — POWER TRAIN — January 12, 2026 — The wheel locks in low speeds. It does not happen often, maybe about 3 times per year. I have brought this up to For...

#11708272 — STEERING — January 2, 2026 — The contact owns a 2011 Ford Explorer. The contact stated that while driving approximately 15 MPH, the power steering...