NHTSA Complaint #11486860 — 2020 TOYOTA SIENNA

For a month prior, there were intermittent incidents of the van shuddering and the RPM needle jumping upon ignition. Sometimes the van would have a hard time accelerating before jerking and driving normally. No issues before this started in late July and no indication when/where would occur. •September 15: drove the van all day running errands. It drove normally. Filled up the gas tank (Gulf gas station), then continued errands. About a half hour later, while at a stop sign, a notification appeared that the “Traction Control System has been turned off” and the check engine light came on. Tried to move through the stop sign, but the van would barely go. Applied the gas, but no results. Able to turn onto a side street and had to have it towed to Toyota of Irving. The Service Advisor stated the issue was due due to bad gas and indicated the van needed to be flushed and the fuel injection system cleaned. Paid $725 for these repairs. •September 17: Started van in driveway. Shuddering and RPM needle jumping again. Drove normally. •September 21: Same as above. •September 25: Drove the van all day with no issues. Filled up with Valero Plus gas. As we pulled out of the gas station and sitting at the light, the Traction Control message and check engine light again appeared. The van would barely go to get us through the traffic light and into a nearby parking lot. Once we parked, the screen displayed the following message:"A malfunction in the electronic control of the engine, throttle, or automatic transmission has been detected." Had the vehicle towed to Toyota of Irving. The service advisor called 2 days later to say they cannot detect any issues.