NHTSA Complaint #11164973 — 2011 CADILLAC CTS

I PURCHASED A NEW 2011 CADILLAC CTS4 IN AUGUST 2012 FROM HERB CHAMBERS CADILLAC IN LYNNFIELD MA. SINCE THAT TIME, I HAVE DRIVEN THE CAR APPROXIMATELY 60,000 MILES. THIS PROBLEM AFFECTS VIRTUALLY ALL (TENS OF THOUSANDS!) CADILLAC CTS AND SRX VEHICLES BUILT SINCE 2008. AFTER DRIVING THE CAR FOR A FEW MONTHS, I NOTICED THAT CONDENSATION APPEARED IN THE HEADLIGHT ASSEMBLIES AFTER DRIVING IN OR PARKING IN THE RAIN. THE CONDENSATION WOULD NATURALLY EVAPORATE DURING EVAPORATE AFTER THE RAIN STOPPED. OVER TIME, THE LOW BEAMS BECAME DIMMER AND DIMMER. THEY HAVE BECOME SO DIM THAT DRIVING IN OTHER THAN WELL-LIT AREAS IS DANGEROUS. I CONTACTED THE MIKE ANAGNOS, SERVICE MANAGER AT HERB CHAMBERS CADILLAC. I PRESENTED THE PROBLEM TO HIM. WITHOUT INSPECTING THE CAR, HE STATED THAT THIS WAS A COMMON PROBLEM AND THAT THE HEADLIGHTS AND HEADLIGHT WIRING HARNESS NEEDED TO BE REPLACED. HE STATED THE REPLACEMENT OF TWO HEADLIGHTS COST WOULD BE $1400.00. HE EXPLAINED THAT THE PROBLEM WAS CAUSED BY WATER INGRESS TO THE HEADLIGHT ASSEMBLY CAUSING THE HEADLIGHT CONNECTORS TO CORRODE AND 'MELT'. HE OFFERED NO FURTHER EXPLANATION AS TO WHY TWO HEADLIGHTS WOULD COST APPROXIMATELY 10% OF THE CAR'S BLUEBOOK VALUE. I ASKED HIM IF THE CORRODED WIRING THAT MELTED PRESENTED A FIRE HAZARD. HE DID NOT REPLY. I BELIEVE THAT THIS PRESENTS A RISK OF UNDER-HOOD FIRE. IF YOU DO AN INTERNET SEARCH ON CTS OR SRX DIM HEADLIGHTS, YOU WILL FIND HUNDREDS OF COMPLAINTS ABOUT THIS PROBLEM AND THE OUTRAGEOUS COST TO REPAIR. SEE ALSO CADILLACFORUM.COM AND JUSTANSWERS.COM MY RESEARCH INDICATED THAT WHEN CADILLAC REPAIRS THESE VEHICLES, THEY USE THE SAME PARTS THAT WERE USED WHEN THE CAR WAS BUILT...VIRTUALLY GUARANTEEING THAT THE PROBLEM WILL PRESENT ITSELF AGAIN. THIS CAR IS A DANGER TO DRIVE AT NIGHT AND A FIRE RISK FROM THE 'MELTED' WIRING HARNESS.