NHTSA Complaint #10778116 — 2011 HYUNDAI SONATA

11/20/10: STEERING COLUMN SHAFT. 5/18/11: BRAKE SWITCH. CAR WILL NOT START OR SHIFT OUT OF GEAR. C1513 CODE. INTERNAL SHORT IN BRAKE SWITCH. 3/26/12: BRAKE SWITCH. CAR WILL NOT START. C1513 CODE. INTERNAL SHORT IN BRAKE SWITCH. SHIFT LEVER KNOB REPL. 8/5/13: BRAKE SWITCH. RECALL. REPL LEFT FRONT AXLE ASSEMBLY. 7/7/14: INHIB SWITCH-CHECK ENGINE LIGHT ON. CAR IS SHIFTING HARD, ESPECIALLY FROM P-R & THEN TO D. JOLTING SENSATION LIKE SOMEONE HIT FROM BEHIND. CODE P0705-TRANSM RANGE SENSOR MALF. 10/1/14: BRAKE TUBE. SHIFT LEVER CABLE. 10/16/14: CODE P0106: MAP SENSOR. FLEXIBLE COUPLING-CLICKING SOUND & WOBBLING WHEN TURNING. TOLD ME I WAS OVER 70K. INDICATED I WAS UNDER 70K WHEN I MADE THIS APPT. MGR WAIVED COST. 2/26/15: STARTER-WOULD NOT START-TOWED. 5/15/15: REAR PASSENGER BRAKE LIGHT-BULB BURNED OUT & MELTED INTO SOCKET. TAIL LAMP ALSO MELTED. TECH WAS ABLE TO HEAT & RESHAPE SOCKET. 8/3/15: BRAKE LIGHT SWITCH-CAR DEAD AFTER WORK. INTERNAL MALFUNCTION & CAUSED BRAKE LIGHTS TO STAY ON. HESITATION DURING ACCELERATION. DECLINED ACCURATE AUTO TO LOOK FURTHER AS CAR IS STILL UNDER WARRANTY SO I WILL TAKE IT TO HUB. IT IMPROVED. 8/25/15: BRAKE LIGHT SWITCH. SEVERE HESITATION-ALMOST REAR-ENDED FELT LIKE IT WOULD STALL (TECH NOTICED). INFORMED ACCURATE THE CAR WAS STILL UNDER WARRANTY SO I WILL TAKE IT TO HUB. HESITATION IMPROVED. 8/27/15: DIAG TESTING-HUB WAIVED COST OF DIAG TESTING-NO CODES FOUND. UNABLE TO DUPLICATE HESITATION. HESITATION OCCURRED WHEN LEAVING. 9/21/15: BRAKE LIGHT SWITCH-BRAKE LIGHTS ON. DRIVE SIDE BRAKE LIGHT IS OUT. HESITATION WORSE-FELT AS IF IT WOULD STALL! DRIVER SIDE BRAKE LAMP BULB. DRIVER SIDE TAIL LAMP OVERHEATED & WARPED. EVENTUALLY REPLACE TAIL LAMP ASSEMBLY. DECLINED FOR ACCURATE TO DO FURTHER TESTING ON THE HESITATION AS THE CAR WAS STILL UNDER WARRANTY SO I WILL TAKE IT BACK TO HUB. HESITATION IMPROVED. TO DATE, STILL DOES NOT RUN SMOOTH.