NHTSA Complaint #10548025 — 2011 FORD EXPLORER

WE PURCHASED OUR 2011 EXPLORER IN JULY 20, 2013 WITH APPROX 43,000 MILES. THE FIRST INSTANCE (8/30/13) WE WERE LEAVING A FRIEND'S HOUSE, TURNED ON THE CAR AND HAD NO POWER STEERING FOR THE ENTIRE RIDE HOME. THIS WAS A FRIDAY NIGHT SO WE WERE UNABLE TO TAKE THE CAR TO THE DEALERSHIP. POWER STEERING CAME BACK THE NEXT MORNING WHEN WE RESTARTED THE VEHICLE. SUNDAY (9/1/13) WE WERE DRIVING AT APPROXIMATELY 40 MPH WHEN WE LOST POWER STEERING AGAIN. WE PULLED OVER AND SHUT THE CAR OFF. ONCE RESTARTED, THE POWER STEERING WORKED AGAIN. OUR LOCAL DEALERSHIP WAS CONTACTED AND COULD NOT FIT US IN FOR SERVICE UNTIL 9/9/13. THE FORD DEALERSHIP KEPT OUR CAR FOR EXACTLY 2 WEEKS TRYING TO FIGURE OUT THE EXACT PROBLEM. INEVITABLY, WE WERE TOLD THAT THE STEERING GEAR ASSEMBLY WAS REPLACED. ALL WAS FINE UNTIL 10/14/13 WHEN WE ONCE AGAIN LOST POWER STEERING AND "SERVICE POWER STEERING" AND "TERRAIN MANAGEMENT SYSTEM" WARNINGS WERE DISPLAYED ON THE DASH WHILE DRIVING AT APPROXIMATELY 35 MPH. THE VEHICLE WAS TAKEN IMMEDIATELY TO THE FORD DEALERSHIP YET AGAIN. WE WERE CONTACTED BY THE SERVICE DEPARTMENT REP, WHO SPOKE WITH FORD, TO DETERMINE THAT THE GEAR THAT WAS PREVIOUSLY REPLACED WAS "DEFECTIVE." WE ARE NOW AWAITING YET AGAIN TO HAVE OUR CAR RETURNED TO US. EACH TIME THIS HAPPENS THERE IS NO WARNING AND THE CAR IS EXTREMELY HARD TO STEER. THIS IS NOT ONLY INCONVENIENT BUT ALSO A HUGE SAFETY ISSUE. WE DRIVE AROUND TWO SMALL CHILDREN AND MY WIFE FEELS UNSAFE DRIVING THE VEHICLE BECAUSE THIS CAN HAPPEN AT ANYTIME WITHOUT WARNING. AS TIME GOES ON, IT HAS BEEN BROUGHT TO OUR ATTENTION THAT THIS IS A FAIRLY COMMON PROBLEM AMONG 2011 FORD EXPLORERS THROUGH PRESENT MODELS. UNFORTUNATELY, IT SEEMS THAT MANY PEOPLE HAVE BEEN GOING THROUGH THIS EXACT VICIOUS CYCLE FOR YEARS NOW. IT SEEMS THAT FORD CANNOT SEEM TO PIN POINT THE EXACT PROBLEM. *TR