2022 VOLVO XC60 Electrical System Problems

Manufacturer Recall NumberR10320 NHTSA Recall Number25V282 the recall for "Camera is Temporarily Not Available" was preformed at dealer on Monday 7/14/2025 today the same message appear on the display screen when I went to backup in a parking lot. Software version shows it as unto date in settings 3.7.##

Case number 240821-000271 was opened on 8/21/24 with Volvo Car USA Support. I have three main concerns: 1) The infotainment system losing the favorites that I have saved in the Sirius application. This had been an intermittent problem that I had been having since I purchased the car. I finally took it into the service department at Volvo Cars of Gilbert on 1/7/23 for this problem (Invoice Number VOCS110975). The service department was unable to recreate the problem so they did nothing. 2)A complete car system reboot while I was driving on 6/10/24. As I was driving down the road the HVAC system shut off and the dash and infotainment system screens went blank. All car systems completely shut down except the engine. This was an extremely frightening experience as all of this happened with no warning whatsoever WHILE I WAS DRIVING. This is a huge safety issue! Within about...

This Volvo XC60 B8 has a serious deficiency with the 12v system and main Battery where it discharges below 10v when the vehicle sits idol for more than a week. Every 7-10 day interval the vehicle must be jump-started and driven for 30 min to recharge the 12v system. The vehicle reports itself in limp-mode until the 12v system charges above 11v then switches to normal drive mode for the remainder of the 30 min drive. I installed a battery tender to the POS and NEG posts under the hood but it charges the mild hybrid battery to full then disables continued charging of the 12v system, leaving the 12v main battery under voltage and draining while the car sits idol. We have to drive the vehicle for 30 minutes every 4-5 days to keep the battery charged. Not even Audi or Lamborghini require this much attention to their 12v...

What component or system failed or malfunctioned, and is it available for inspection upon request? -The backup camera system fails to respond intermittently. Often times the screen will remain black for several seconds while backing up before the screen shows any picture. Other times it will come on, and then flash to black while you are backing up. This is a major hazard should a child run/walk behind a car, when this occurs. I'm hoping others have expressed this problem so action can be taking. How was your safety or the safety of others put at risk? -Since Backup cameras are a federal requirement since 5/2018. The Failure to function on these new cars I find to be unacceptable. Even more so given that Volvo is supposed to be a brand dedicated to safety. Has the problem been reproduced or confirmed by a dealer or independent service center? -Indirectly yes,...

The contact owns a 2022 Volvo XC60. The contact stated that on several occasions while the vehicle was turned on, the radio cluster and instrument panel failed to illuminate. Additionally, the contact stated that he and his wife observed a clicking sound coming from the engine compartment when the vehicle was turned off. The vehicle was taken to a dealer however, the failure could not be duplicated. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 1,500.

I have had 5 visits with problems with engine , braking sensors, and automatic braking incidents when no obstruction is noted. Propulsion System failure has occurred 3+ times and turtle mode has come on and limited my speed to 30 MPG. It has also started bouncing and shaking while in reverse. I am extremely concerned about the safety threats and lack of consistency when taking it to be repaired.

The vehicle performed an over the air update which failed. The vehicle became inoperable. The vehicle was force started with dash lights indicating multiple system failures. The infotainment system has crashed multiple times rendering climate control non usable. A loaner 2023 XC60 was provided which also resulted in the infotainment center crashing twice. Dealership acknowledged the issue but has no solution for the issue. My concern is there is no guarantee the other safety features are functioning correctly if the most simple electrical component of the vehicle is failing.

I purchased the car in April 2022. Did not have any issues until February 2023. Initially, the engine light came on with a turtle icon in the dash screen. I was driving and the car would not go over 45 mph. on a busy street . The car was hesitating badly and also said something about the propulsion? Volvo Ontario towed it from my business and supposedly fixed it. Fast forward the following week, engine light came. Back to dealer, who said the software at that time was not available and it was a recall. A few days later they said they were disconnecting the engine light until new update was available. Back to dealer with update now installed, supposedly this would fix all the engine issues. A few days later, 3/7 I got into car and started it . This mesage came on, "Slow down, the vehicle will reduce...

The Google/Android (IHU) electrical system controls the entire car: brakes, engine, safety features, AC/Heat, etc. It is unreliable after 4 repair attempts. Problems started date of delivery (9/6/22) & have been ongoing. The ones that directly affect safety are the auto braking activating without cause, blind spot warning missing motorcycles, lane keeping will pull car towards a hazard in middle of road when you swerve to avoid it and the Google/Android system in general malfunctioning. I live in south Florida and I can assure you that air conditioning is a safety concern, especially in people like me who have medical conditions in which excessive heat exposure can result in an ER visit. My AC has failed upon starting the car as well as following the rebooting of the Google/Android system. The rebooting of the system must be done whenever the system malfunctions & it is wise to pull off the...

Picked the vehicle up from dealership, rapidly received errors in May 2022. Errors as follows; Blind Spot Sensor service required, rear auto brake reduced functionality, park assist system reduced functionality, vehicle had less that 15 miles. A different incident in May, the AC wouldn’t work and had to shut down and reset screen. July 2022, car would not start with either key, confirmed both keys working. Would not recognize key or respond to app, eventually radio would come on but car wouldn’t crank. Dealership updated software. August 2022, GPS kept dropping and continued issues with electrical, TCAM module replaced.

I have had several software/computer issues since purchase. Now the whole control system has failed and all safety functions are dead, in addition to radio, heating/cooling and voice command systems.

infotainment system quits working or will not boot up

The screen does not come on, so no heat, no safety stuff, no reverse camera and no sensors. All the above ADAS features do not work either. This is definitely a safety hazard, which I think traces back to the vehicle operating system. Details reported to Volvo in this tweet--> https://twitter.com/ameyaroskar/status/1608642311923339266?t=CUl77cpdg6qWIP8AJqetyQ&s=19

A/C failed to turn on. This is the second time this has occurred. It was on a 100 degree Texas day. I was already in the vehicle and it was so hot in the vehicle I was worried about a heat stroke. It caused a distraction while driving because the electrical components weren’t functioning as intended potentially causing an accident. The 2022 models have known electrical issues and the dealership was not surprised. The vehicle is currently in the shop.

The car is only a few months old with less than 10k miles. After parking the car for about 2 hrs, came back and the battery was completely dead. This left me and my family stranded unexpectedly. After jumping the car, a warning displayed "Stop Safely, 12 V Battery Critical Charging Fault". I decided to try to make the short drive home as I was stranded with my family otherwise, the vehicle was in a limp home "turtle mode" which was not safe. The acceleration was surging unexpectedly and without warning. I realize that there was a warning not to drive, however I didn't have a lot of good options given the electrical failure. Also, in thinking back, there was a warning sometime in the last month regarding collision detection that needed to be fixed, but warning went away. In researching this issue online, seems that there are other complaints...

The google android automotive operating system is unstable. It will reboot while driving. During this time all Settings and functions of the car including safety systems are rebooted as well. For about 30-60 seconds the cars systems are unavailable even the HVAC. I’ve had it serviced twice and they have been unable to fix the issue. The cars data/cell connection also does not work and is required for the SOS and Volvo On Call systems. It is currently at the dealership with no estimated time of when they can fix as they have exhausted all possible ways to fix. A case is active with Volvo to work to find the issue to the problem. They replaced the cars modem but data is still not working and updated the software but the glitches and issues with the android automotive remain.

Car will not start because of eCALL and SOS system malfunctioning. Car will only start with key in cupholder (where secondary reader is located). Possible TCAM issue or 12v battery issue.

4 day old car with 45 miles on it wouldn’t unlock-manually unlocked the car to find it wouldn’t start/no power. Car was towed to dealer after being jump started. Software error caused application downloads or refreshes to continually run draining the battery which needed to be replaced entirely.

Started car after driving an hour, and having it sit 2.5 hours. Center panel was very dim and no air out of vents despite leaving air on when turned off. Error Message that cooling infotainment system. Audio sound for turn signal also not working Had to drive/leave. Left and found somewhere safe to pull over turn car off and sit. After 10+min no change. Drove home 60miles with no AC, cruise control or other safety features, or sounds w blinkers. At home, the beeeping for 360 camera and red/orange lights to help backup/part not functioning. The backup Light was. Car felt a little jerky during trip. After 4+ hours it appeared to be functioning. When restarted Car is 5-6 weeks old with 346 miles on it Including the 100+ from Saturday. Did not make a planned drive Sunday as did not feel it was safe. Verified all software/apps up to...

Brand new vehicle that I brought home 18 days ago. Went to start car this morning and it had zero power. The FOB didn't work so I couldn't get into my car. Tow Truck Driver jump started car successfully. Fortunately, I instructed the driver to take it to the dealership anyway because there was no reason for the new vehicle to have a dead battery. I had left the car running and returned to it after chatting with driver. At some point a warning message appeared on the display reading "Stop Safely. 12V Battery Critical Charging Fault." If I had driven off after the car was jump started -- as I have always done before -- the vehicle could have gone into a serious fail mode that would have endangered me and those around me. Prior to this event, I had a few minor electrical glitches that I ignored because...

Continuous problems associated with the computer of the car that are affecting its ability to drive safely. While in reverse and in motion, the car's camera will often, an unpredictably, shut off. Additionally, the car's forward collision warning system will initiate when there are no cars in front of; rather, it sometimes engages when oncoming traffic going the opposite direction. Lastly, the car lost all power while on the highway due to a "battery error". It required a redownload of software; however, these other safety problems persist.

4 months old 2022 Volvo XC60 software bug that drained all batteries on board caused the vehicle to not to start, stuck in park, it was impossible disengage parking brake or put the car in neutral. Without any warning or battery low or battery empty indicator, the vehicle failed to start. We were put at risk by a car that can fail without warning and not start at all as we were stranded at a remote location. When the car failed to start, it could only be moved by a flat-bed tow truck, as it was impossible to put the car into neutral and it would not roll. The Volvo dealer confirmed that the vehicle failed to start because of a software bug. Dealer indicated that they were not able to start or move the car, they had to connect to it wirelessly and applied updates then reset battery and...

Multiple occurrences: The screen goes blank in front of the driver including the main center on the dash. The car simply stops working and slows down to a crawl showing a turtle symbol on the dash. To reset, the vehicle has to be completely shut down and restarted. The ventilation system stops working and required a reset. The Google operating system which controls everything in the vehicle is a failure. This vehicle should have never been released for sale and Volvo should have told their many customers that the 2022 XC60 had serious issues before the sale.

I had only had my car for approximately 2 weeks and had to have it towed to the dealership due to an electrical problem that caused my car to act like it was running out of gas. The dealership had my car for about 3 days and it was an computer problem with the batteries not communicating between systems so they had to order a new module and reset the computer. Another 3 weeks later my parking alert sensors started going off and wouldn’t go off they just stayed on once again took to dealership and it was a computer problem. Both issues was fixed but was told don’t be surprised if happens again might happen until Volvo gets the whole company program updates and if it does happen just bring it back to the dealership and have computer reset. It’s just an inconvenience to think I might have to...

Volvo rushed the 2022 model year XC60 with the new Google infotainment to market before all the bugs were worked out. While driving after 4 weeks of ownership, the HVAC was not working so unable to defog the windshield, the turn signal lights were not working, maps and speed limit alerts not working. Had to manually reboot the infotainment to regain these necessary safety features. There are numerous internet forums describing issues with the new Google based infotainment that Volvo is using and the slow response to address them. Even the dealer is aware of these reported issues.