2000 VOLVO V70 Vehicle Speed Control Problems

TL* THE CONTACT OWNS A 2000 VOLVO V70. WHILE DRIVING 65 MPH, THE RPMS EXCESSIVELY INCREASED AND THE ETS WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS AWARE OF NHTSA CAMPAIGN NUMBER: 06V441000 (VEHICLE SPEED CONTROL); HOWEVER, THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 115,000.

MY VOLVO V70 HAS BEEN DYING IMMEDIATELY AFTER STARTING THE ENGINE AND HAS PROGRESSIVELY GOTTEN WORSE OVER THE LAST 6 MONTHS. HAVE HAD TWO TRIPS TO A MECHANIC WHO REPAIRED A FEW PARTS, BUT IT DIDN'T FIX IT. PROBLEM CONTINUES. RECENTLY, WE WERE DRIVING ON THE HIGHWAY AT ABOUT 65 MPH AND THE CAR SPEED DROPPED TO ABOUT 20 MPH AND COULDN'T GO ANY FASTER AND WE HAD TO PULL OVER. THIS IS A MAJOR SAFETY RISK. NOW THE CAR STARTS AND IMMEDIATELY DIES FOR ABOUT 4-5 TIMES BEFORE IT WILL START AND CONTINUE RUNNING. THERE IS A WHIRRING NOISE COMING FROM THE ELECTRONIC THROTTLE WHEN IT DIES IMMEDIATELY. I TOOK IT TO A VOLVO DEALER AND THEY SAID A RECALL FOR A SOFTWARE UPDATE WAS PERFORMED ON MY CAR IN 2006 TO LOWER THE WEAR INSIDE THE THROTTLE. THEN VOLVO ISSUED A SERVICE CAMPAIGN FOR THE ETM WHEN IT...

AUGUST 8, 2012 I AM SENDING THIS COMPLAINT CONCERNING THE SERVICE I RECEIVED ON A RECALL FOR A 2000 V-70 VOLVO, CAMPAIGN# R115 ( VEHICLE SPEED ), NHTSA -CAMPAIGN# O6V441000, ACTION # EAQ-5021. I SCHEDULED AN APPOINTMENT WITH A VOLVO DEALERSHIP. I WENT TO THE SCHEDULED APPOINTMENT AND LEFT MY VEHICLE TO BE SERVICED. I WAS CALLED FROM THE DEALERSHIP AND WAS TOLD MY CAR WAS READY FOR ME TO PICK UP. AFTER DRIVING MY VEHICLE FOR ABOUT 15 MIN MAX. IT BEGAN UNFORTUNATELY WITH THE SAME SYMPTOMS I PREVIOUSLY WAS EXPERIENCING. I CALLED THE SERVICE DEPARTMENT WHERE I APPARENTLY HAD MY CAR SERVICED FOR REPAIR AND WAS TOLD BY THE MANAGER THAT I WOULD BE RESPONSIBLE FOR ANOTHER DIAGNOSIS, AND THAT IT WAS PROBABLY SOMETHING ELSE, SINCE THE RECALL SERVICE WAS DONE I DECIDED TO CALL THE: VOLVOCARS.US TELEPHONE #, @ 1-800-458-1552. I THOUGHT FOR SURE, I WOULD RECEIVE...

WHY AREN'T YOU DOING ANYTHING ABOUT VOLVO BUILDING CRAP? THEY SHOULD BE IN JAIL. ETM - DESIGN WAS UNACCEPTABLE FROM A DAY ONE. THE ETM IS CAUSING SURGING, STALLING AND MANY OTHER SYMPTOMS. ONCE VOLVO STARTED TO REPLACE SOME OF THEM, THEY USED NEW ONES WITH EXACTLY THE SAME FLAWED DESIGN. ABS MODULE - IS KNOWN FOR CAUSING LOSS OF BRAKING POWER, EARLY BRAKE PADS WEAR AND DAMAGING TRANSMISSION. FRONT BRAKE CALIPERS - RUST ON CALIPERS IS SQUEEZING RUBBER BOOTS AROUND SLIDING PINS. DAMAGE TO ROTORS, PADS AND WHEEL BEARINGS. FRONT LIGHTS LOW BEAMS - UNACCEPTABLE LIGHT OUTPUT. FRONT SEAT BELTS - ARE CUTTING INTO SIDE TRIM AND SIDE TRIM IS CUTTING INTO SEAT BELTS. WIND SHIELD WIPERS - HIGHEST SPEED IS USELESS IN HEAVY RAIN. CRUISE CONTROL - RPM SURGES WHILE GOING 55MPH AND TURNING ON THE CRUISE CONTROL. DO SOMETHING! *TR

I OWN A 2000 VOLVO V70 WITH 130K MILES AND THE CAR INTERMITTENTLY CUTS OFF WITHOUT WARNING AND/OR IT HAS DIFFICULTY STARTING. THIS OCCURS SEVERAL TIMES A WEEK. THERE ARE ALSO TIMES WHEN I TRY TO START THE CAR, IT DOES NOT HAVE ENOUGH POWER TO MOVE FORWARD, SPITS SPUTTERS, AND THEN CUTS OFF. THE LOCAL DEALERSHIP, VOLVO OF CHARLOTTE, NC SAID IT WAS THE ELECTRONIC THROTTLE SYSTEM (ETS) AND THAT MY RECALL/REPLACEMENT WARRANTY RAN OUT IN FEBRUARY 2010. AFTER NOTIFICATION OF A PROBLEM EXISTING IN 2006/2007, I COMPLIED WITH THE RECALL AND THE SOFTWARE UPGRADED SHORTLY AFTER THE 2006 RECALL NOTICE WAS RECEIVED, BUT NOW VOLVO WILL NOT HONOR THE ISSUE WITH THE FAULTY SOFTWARE UPGRADE OR REPLACE THE ETS MODULE. WHEN I CONTACTED VOLVO USA, THE REPRESENTATIVE SAID THEY HAVE CUSTOMERS EVERY DAY THAT ARE BEYOND THE 200,000 MILE OR 10-YR IN SERVICE DATE, AND THEY WON'T HELP....

TL*THE CONTACT OWNS A 2000 VOLVO V70 CROSS COUNTRY. THE CONTACT IS CURRENTLY EXPERIENCING DIFFICULTY STARTING THE VEHICLE. WHILE DRIVING 60 MPH, THE THROTTLE LIGHT ILLUMINATES INTERMITTENTLY. SHE RECEIVED A SAFETY RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 06V441000 (VEHICLE SPEED CONTROL). THE RECALL REPAIR WAS PERFORMED AND THE SURGING AND STALLING CEASED FOR A SHORT PERIOD OF TIME; HOWEVER, THE FAILURES HAVE RECURRED. ON JULY 18, 2008, THE DEALER STATED THAT THEY WOULD REPAIR THE ECM SYSTEM IF NEEDED, BUT THE CONTACT WOULD HAVE TO PAY TO HAVE THE VEHICLE DIAGNOSED. THE CURRENT AND FAILURE MILEAGES WERE 140,000.

TL*THE CONTACT OWNS A 2000 VOLVO V70. THE CONTACT WAS ATTEMPTING TO BRAKE WHEN THE VEHICLE SURGED FORWARD AND STRUCK THE PRECEDING VEHICLE. AT THE TIME, SHE THOUGHT THAT THE BRAKES FAILED. THE CONTACT LEARNED OF NHTSA RECALL NUMBER 06V441000 (VEHICLE SPEED CONTROL) AFTER THE CRASH. THE VEHICLE SUSTAINED DAMAGES TO THE FRONT END (HOOD BRACKET, HOOD HINGE, MARKER LIGHT, FRONT BUMPER COVER, WIPER BLADES, SIDE LAMPS, GRILL, HEAD LAMPS, HOOD AND LATCH, AND PAINT). THE REPAIR WILL COST $4,870.81, WHICH INCLUDES THE $500 INSURANCE DEDUCTIBLE. THE COST OF THE RENTAL VEHICLE WAS $390. THE DAMAGES TO THE REAR END OF THE OTHER VEHICLE (1998 TOYOTA FORERUNNER) WERE THE QUARTER PANEL, RE-FINISH ON THE REAR BUMPER, AND A REPLACED PASSENGER SIDE REAR BUMPER OUTER EXTENSION. THE TOTAL REPAIR COST WAS $563.22. THE FAILURE MILEAGE WAS 98,590. UPDATED 01/09/09. *LJ UPDATED 01/15/09. *JB

ON 2/3/06 OUR VOLVO V70 YEAR 2000, 74000M SHOWED AN ETS LIGHT AND CHECK ENGINE LIGHT. CAR STALLED AT UPON STOPPING AND ALSO UPON STOPPING AT A STOP LIGHT THE VEHICLE WOULD NOT ACCELERATE. UPON TURNING THE CAR OFF AND BACK ON I WAS ABLE TO HAVE IT ACCELERATE. THE CAR WOULD RUN OK FOR ABOUT 20 MILES THEN LIGHTS CAME ON AGAIN. CONTACTED VOLVO BYERS IN COLS OH 614-864-0780 WHOM INFORMED ME THAT THE THROTTLE SYSTEM IS NEEDING REPLACED. HAD THE VEHICLE SERVICED ON 2/6/06. BYERS PERFORM FAULT TESTS AND NOTED THAT THERE WAS LOW VOLTAGE AND STATED CABLES FROM BATTERY WERE NEEDING REPLACED. I INFORMED THEM THAT I WAS CONFUSED WITH HOW THIS COULD CAUSE THE ETS LIGHT AND CHECK ENGINE LIGHT TO COME ON AND CAUSE MY CAR TO STALL AND AT TIMES NOT ACCELERATE WHILE THE CAR IS RUNNING. THEY INDICATED THAT PRIOR TO FIXING THE...

WITH ONLY 80,000 MILES, AFTER 5 YEARS OF DRIVING, THE ENGINE IS WARNING THAT THE ELECTRONIC THROTTLE SYSTEM' (ETS) FAILED. THE DEALER AND AN INDEPENDENT REPAIR SHOP ONLY CAN REPLACE THE ETS MODULE AT A COST OF $1,200. THE REPLACEMENT PART IS ACTUALLY THE SAME AS THE FAILED PART WITH NO IMPROVEMENT. SEARCHES ON THE INTERNET SHOWED THAT THIS PART FAILED OVER AND OVER AGAIN. WHEN IT FAILED THE CAR COULD BE DRIVEN IN A LIMP ALONG HOME MODE, WHICH I HAVE HAD TO USE, MAKING OTHER CARS PASS ME WHILE THIS CAR COULD ONLY GO ABOUT 5-10 MPH. THE INTERNET POSTINGS INDICATED THAT NHTSA WAS TRYING TO WORK WITH VOLVO TO EXTEND THE FACTORY WARRANTY OF THIS PART, BUT WITH NO SETTLEMENT YET. LETTING VOLVO TO CONTINUE TO USE KNOWN TROUBLE-PRONE PARTS WHICH SHOULD BE RESOLVED.*AK

ENTERING THE HIGHWAY, MY VOLVO V70 HAD A COMPLETE STALL. CAR COMPLETELY STOPPED AND WOULD NOT START. AFTER ABOUT 20 MINUTES, IT RE STARTED. IT WAS DRIVEN TO THE VOLVO DEALER ONCE IT STARTED AGAIN AND THE "ELECTRONIC THROTTLE MODULE" WAS REPLACED AT A COST OF $800. *JB

MY VOLVO RECENTLY BEGAN TO HAVE PROBLEMS WITH ITS ACCELERATION. IT WOULDN'T RESPOND AS WELL AND AT TIMES WOULD FEEL LIKE IT LOST POWER. ON 10/27/05 MY ETS LIGHT CAME ON AND MY MECHANIC TOLD ME IT WOULD COST AROUND 1000$ TO REPLACE MY ELECTRONIC THROTTLE SYSTEM. *JB

DT: THE CONTACT'S WIFE HAD THE ELECTRONIC THROTTLE MODULE (ETM)REPLACED. THE VEHICLE WOULD SLOW DOWN, ALMOST STALLING, AND THEN THE VEHICLE WOULD SURGE. THE REPLACEMENT OF THE ETM REMEDIED THE PROBLEM.*AK UPDATED 11/29/2005 - *NM

A MONTH AND A HALF AGO MY 2000 VOLVO V70 THROTTLE HAD TO BE COMPLETELY REPLACED. AFTER FURTHER RESEARCH I HAVE DETERMINED THIS IS AN MAJOR ON GOING ISSUE. I AM VERY UPSET I HAD TO SPEND OVER $1100 TO REPLACE THE THROTTLE. MY CAR ONLY HAD 90,500 MILES WHEN THE THROTTLE FAILED. *NM

MY 2000 V70 VOLVO'S ETS SYSTEM BROKE DOWN THIS SUMMER, HAVING BEEN ON THE ROAD FOR APPROX. 5 HRS. I WAS TRAVELING HOME ON 95 FROM NY, & I WAS ON THE DC BELTWAY (495) WHEN THE INCIDENT OCCURRED. I WAS IN THE CENTER LANE, GOING WITH THE PACE OF TRAFFIC (OR A LITTLE SLOWER - I HAD MY 23-MONTH-OLD SON IN THE CAR WITH ME), WHEN THE CAR STARTED BUCKLING A LITTLE BIT. ABOUT .10 MILE LATER, THE CRUISE CONTROL WOULDN'T WORK, & I COULD NO LONGER ACCELERATE. I WAS QUICKLY DECELERATING FROM 60+ MPH DOWN TO 20. THE SHOULDERS WERE NOT AVAILABLE TO ME AS THERE WAS CONSTRUCTION ON THE SIDES, BUT I WAS FORTUNATE ENOUGH THAT THE CAR WOULD JUST GO FAST ENOUGH & TRAFFIC WAS JUST LIGHT ENOUGH THAT I COULD MOVE TO THE CLOSEST EXIT - ABOUT A .5 MILES FROM THE BREAKDOWN. MY CAR...

DT: THE VEHICLE STALLED/DIED AND LOST POWER DUE TO ELECTRONIC THROTTLE MODULE FAILURE. *AK *JB

DT: THE CONSUMER SAID THE ELECTRONIC THROTTLE CONTROL MODULE (ETCM) ON 2000 VOLVO V70 HAD TO BE REPLACED. THE DASHBOARD LIGHT KEPT COMING ON AND OFF INTERMITTENTLY. THE VEHICLE STALLED DUE TO ETCM FAILURE. THE DEALER REPLACED THE ETCM. *AK *NM

ENGINE LIGHT AND ETS WARNING LIGHTS COME ON. WAS SUPPOSEDLY REPAIRED AT DEALER BUT LIGHTS ARE COMING ON AGAIN. HAVE READ ON A NUMBER OF FORUMS THAT THE ETS FAILURE CAN CAUSE DANGEROUS DRIVING CONDITIONS...SUDDEN LOSS OF POWER. IF THIS PROBLEM CAN CAUSE THIS PROBLEM VOLVO SHOULD OFFER A RECALL ON THE DEVICE. I HAVE ALSO RESEARCHED THAT INCORRECT DIAGNOSTIC SOFTWARE WAS INSTALLED ON SOME MODELS. *NM

DT: THE CONTACT STATED VEHICLE STALLED/DIED, AND LOST POWER. THROTTLE CONTROL MODULE WAS REPLACED. *AK *JB

DT: CONTACT STATED VEHICLE STALLED/DIED, AND LOST POWER DUE TO THROTTLE BODY FAILURE. *AK

DT: CONTACT STATES HAS A 2000 VOLVO V-70 STATION WAGON. HAD TO REPLACE THE ELECTRONIC THROTTLE MODULE BECAUSE THE VEHICLE KEPT STALLING. THE ABS LIGHT AND THE ELECTRONIC THROTTLE MODULE LIGHTS ILLUMINATED ON THE DASHBOARD. THE CONSUMER STATED AFTER THE VEHICLE WAS SERVICED THE PROBLEM WAS CORRECTED.*AK *NM

WE HAVE A 2000 VOLVO V70 STATION WAGON. WE HAVE EXPERIENCED STALLING IN TRAFFIC, ESPECIALLY FROM IDLE (MADE A LEFT TURN IN INTERSECTION AND ENGINE STALLED AND CUT OUT) AND OTHER STALLING AND IDLING PROBLEMS OVER LAST TWO - THREE YEARS. WE HAVE TAKEN IT TO OUR DEALERSHIP; THEY HAVE CLEANED OUT THE THROTTLE CONTROL MODULE TWICE AT APPROX. $200 PER TIME; A NEW UNIT COSTS $500; DEALERSHIP BLAMES PROBLEM ON TODAY'S FUEL QUALITY. LAST STALL IN ONGOING TRAFFIC WAS JULY 21, 2005. *NM

THE VEHICLE WAS TRAVELING AT 40 MILES PER HOUR WHEN ALL OF A SUDDEN THE ELECTRONIC THROTTLE SYSTEM BROKE CAUSING THE VEHICLE TO SLOW DOWN AND STOP ON ITS OWN. MANUFACTURER WAS CONTACTED BY OWNER. *NM

THROTTLE UNIT MALFUNCTIONED. AS A RESULT WHEN IDLING ENGINE STALLED. *AK