2001 VOLVO S80 Vehicle Speed Control Problems

TAKATA RECALL- THE VEHICLE BECOME NON RESPONSIVE WHEN PUSHING THE ACCELERATOR, THE ENGINE STARTED RUNNING ROUGH, THE CRUISE CONTROL STOPPED WORKING, THE DSTC (DYNAMIC STABILITY TRACTION CONTROL) FAILED AND THE ENGINE COOLANT TEMPERATURE STOPPED READING. THE VEHICLE STARTED STALLING EVERYTIME I COME TO A STOP. ALL THIS STARTED AT THE SAME TIME WHILE I WAS DRIVING THE VEHICLE. *TR

PLACED MY VEHICLE IN REVERSE TO PULL BACK OUT OF MY GARAGE & MY CAR ACCELERATED OUT OF CONTROL. I WAS FORCED INTO A PARKING SIGN THAT SCRATCHED AND DENTED MY LEFT REAR BUMPER. IN THE LAST 2 1/2 MONTHS RELATED PROBLEMS CONTINUE WHERE MY CAR SURGES & ALSO EXPERIENCES SUDDEN & UNEXPECTED REDUCED PERFORMANCE. WHEN I ACCELERATE MY CAR FEELS LIKE IT IS STUCK IN GEAR & WON'T RESPOND. IT IS A SAFETY HAZARD!! AGAIN!!! THIS DUPLICATES THE SAME ELECTRONIC THROTTLE MODULE PROBLEM I HAD IN AUGUST OF 2005. AFTER TAKING MY CAR IN 4 TIMES (NOT KNOWING WHAT THE PROBLEM WAS), IT WAS FINALLY DETERMINED IT IS THE ETM AGAIN. VOLVO PERFORMED A COMPUTERIZED UPGRADE ON THE ETM & THEN IT WAS FINALLY RECALLED IN JANUARY OF 2006. IT IS ANOTHER SAFETY HAZARD READY TO HAPPEN. VOLVO SHOULD HAVE IN THE BEGINNING & SHOULD AT THIS TIME BE...

I PURCHASED VEHICLE 8 MONTHS AGO I NOW HAVE PROBLEMS WITH THE FRONT AND BACK SUSPENSION. THE AIR TURNS ON ITS OWN, THE AXLE HAS BROKEN, THE SUNROOF OPENS WHEN IT WANTS TO OPEN, CHECK ENGINE LIGHT HAS TURNED ON ALONG WITH MAINTENANCE LIGHT, MY DOORS WILL UNLOCK THEMSELVES WHEN I LOCK THEM AND THE ALARM WILL ENGAGE, THE LEFT WINDOW DOES NOT WORK , SOMETIMES I CANT UNLOCK THE DOORS HAVE TO UNLOCK WITH MY HAND. MY CRUISE CONTROL DOES NOT WORK, THE BATTERY STOPS WORKING OFTEN, THE INSIDE LIGHTS WORK SOMETIMES. IT IS RUNNING TERRIBLE , IDLE UP AND DOWN I KNOW ALL HAS SOMETHING TO DO WITH RECALL PLEASE HELP! *TR

TL* THE CONTACT OWNS A 2001 VOLVO S80. THE CONTACT STATED THAT THE RPMS BEGAN TO FLUCTUATE ABNORMALLY AS THE VEHICLE EXHIBITED SIGNS OF POSSIBLE STALLING. THE VEHICLE THEN ACTIVATED IN LIMP MODE AND STOPPED RUNNING. THE CONTACT REFERENCED NHTSA RECALL CAMPAIGN ID NUMBER: 06V441000 (VEHICLE SPEED CONTROL) THAT DEALT WITH THE DIRTY THROTTLE HOUSING. THE RECALL REPAIR CONSISTED OF A SOFTWARE UPGRADE TO CORRECT THE FAILURE. THE MANUFACTURER STATED THAT THE VEHICLE WAS INCLUDED IN THE RECALL, BUT THE VEHICLE EXCEEDED THE WARRANTY STIPULATIONS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE 87,000.

TL* THE CONTACT OWNS A 2001 VOLVO S80. THE CONTACT STATED WHILE DRIVING 40 MPH THE VEHICLE SHIFTED INTO LIMP MODE AND DECELERATED AFTER THE CHECK ENGINE LAMP ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE ELECTRONIC THROTTLE MODULE WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER RECALL NHTSA CAMPAIGN ID NUMBER: 06V441000 (VEHICLE SPEED CONTROL). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 170,000 AND THE CURRENT MILEAGE WAS 170,200.

TL* THE CONTACT OWNS A 2001 VOLVO S80. THE CONTACT STATED THAT THE VEHICLE WOULD HESITATE BEFORE RESPONDING TO ACCELERATION ATTEMPTS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY ADVISED THAT THE THROTTLE MODULE HAD FAILED AND NEEDED TO BE CLEANED AND REPLACED. THE THROTTLE WAS CLEANED BUT THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE AFTER THE CLEANING SO THE THROTTLE WAS NOT REPLACED. THE FAILURE RECURRED WITHIN A FEW WEEKS. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. UPDATED 09/27/11 *BF UPDATED 09/30/11

MY CHECK ENGINE LIGHT WENT ON. I TOOK MY CAR TO MY MECHANIC WHO INFORMED ME THE CODE WAS FOR THROTTLE BODY POSITION SENSOR AND THAT THERE WAS A RECALL. I CALLED THE VOLVO DEALER AND ASKED THEM ABOUT IT. THEY SAID, YES THERE WAS A RECALL FOR SOFTWARE AND THAT MY VEHICLE HAD GOTTEN THE UPGRADE. I ASKED IF THERE WAS ANYTHING ELSE THEY COULD DO ABOUT IT, THE EMPLOYEE IN VOLVO SERVICE SAID NO. I RECEIVED THE SAME ANSWER WHEN I ASKED THEM IN PERSON. ON MARCH 1, 2011, NEARLY A YEAR LATER, I ASKED ANOTHER MECHANIC, WHO INFORMED ME THAT IF THE SOFTWARE UPGRADE DIDN'T WORK, THE DEALER WAS SUPPOSED TO REPLACE THE ENTIRE THROTTLE BODY. I CALLED THE ANOTHER VOLVO DEALER WHO INFORMED ME THAT YES, THIS WAS THE CASE. MY CAR WAS ONE DAY OUT OF COVERAGE FOR THE RECALL NOW. AND SOMETIME WITHIN THE...

WHILE TRAVELING AT 25 MPH, I APPLIED BRAKES TO STOP ABOUT 30-35 FEET BEHIND ANOTHER VEHICLE, WHEN MY VEHICLE SUDDENLY ACCELERATED (WITH MY FOOT ON THE BRAKES AND) AND LAUNCHED FORWARD AND STRUCK THE VEHICLE AHEAD OF ME, CAUSING INJURY TO THE DRIVER AND THE PASSENGER AND RESULTED IN A LAWSUIT AGAINST ME. THE LAWSUIT IS SET FOR TRIAL ON NOVEMBER 30, 2009. *TR

TL*THE CONTACT OWNS A 2001 VOLVO S80. WHILE DRIVING 35 MPH, THE CHECK ENGINE LIGHT ILLUMINATED AND THE VEHICLE SHUT OFF. THE VEHICLE WAS TOWED TO THE DEALER AND THEY REFUSED TO DIAGNOSE OR REPAIR THE VEHICLE. THE VEHICLE WAS TOWED TO ANOTHER FORD DEALER THAT WILL PERFORM THE REPAIR. THE CONTACT STATED THAT THE FAILURE HAS OCCURRED BEFORE AND SHE BELIEVES THAT THE CAUSE IS THE VEHICLE SPEED CONTROL, WHICH IS CURRENTLY UNDER NHTSA RECALL NUMBER 06V441000. SHE ALSO STATED THAT THE RADIATOR WAS REPLACED AT 28,000 AND 56,000 MILES AND CURRENTLY NEEDS TO BE REPLACED AGAIN. THE CONTACT STATED THAT THE RADIATOR FAILS EVERY 28,000 MILES AND THE ENGINE COOLANT LIGHT ILLUMINATES. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 87,000.

I'M A NEW OWNER OF A 2001 S80 T6 WITH 66K MILES. SECOND DAY OF OWNERSHIP I'M ON MY WAY HOME IN THE PASSING LANE OF A FREEWAY IN MA, TRAFFIC SLOWS TO A STOP. AS I ACCELERATE THE CAR STALLS. I PULL TO THE LEFT OF THE TRAVELING LANE, PUT THE CAR IN PARK, RESTART THE VEHICLE. THE NEXT DAY, I PULL UP TO A RED LIGHT, ACCELERATE AND THE CAR STALLS. I PUT IT IN PARK, RESTART THE CAR, AND AWAY I GO. NO MESSAGES, NO CHECK ENGINE, NO CODES THAT I KNOW OF. I TRAVEL 100 MILES A DAY, AND THE PROBLEM OCCURS AT LEAST EVERY OTHER DAY. THIS PROBLEM IN INTERMITTANT AND EXTREMELY DANGEROUS. THE HIGHWAY I TRAVEL ON ALLOWS TRAVEL IN BREAKDOWN LANES DURING RUSH HOUR. I NEED TO TRAVEL IN THE RIGHT TRAVEL LANE ALWAYS IN THE EVENT OF ANOTHER STALL. DEALERSHIP CLEANED THE...

WE BEGAN REPORTING PROBLEMS WITH HESITATION AND SURGING IN OUR 2001 S80 T6 SEVERAL YEARS AGO TO THE SERVICE DEPARTMENT AT OUR NEAREST DEALER, SILL TERHAR MOTORS IN BROOMFIELD, COLORADO. THEY TRIED REPLACING A TURBO VALVE AND A SOFTWARE UPGRADE THAT WAS AVAILABLE AT THE TIME, AND WE WERE TOLD THAT USING THE HIGHEST OCTANE FUEL WOULD BE NECESSARY IN ORDER TO PREVENT THE HESITATION. THE PROBLEM CONTINUED. GIVEN THE INCONVENIENCE OF THE DEALERS LOCATION AND THAT THEY HAD NOT SEEMED TO BE ABLE TO CORRECT THE PROBLEM, WE HAD THE VEHICLE SERVICED FOR A WHILE AT AN INDEPENDENT VOLVO MECHANIC. LAST FALL THE EMISSIONS AND CHECK ENGINE WARNING LIGHTS TURNED ON, AND THEY REPLACED AN OXYGEN SENSOR AND/OR MASS AIR SENSOR. THE WARNING LIGHTS TURNED ON AGAIN, AND THEY RECOMMENDED THAT WE GO TO THE SERVICE DEPARTMENT AT THE DEALER. WE LEARNED OF THE "EXTENDED WARRANTY" VOLVO WAS BEGINNING...

MY 2001 VOLVO S80 ETM (ELECTRONIC THROTTLE CONTROL) FAILED, THIS CAUSED A SUDDEN LOSS OF ENGINE, STEERING, BREAKING AND HEADLIGHT SYSTEMS. *NM

DT*: THE CONTACT STATED THE VEHICLE LURCHES FORWARD AND STALLS. THE VEHICLE SPEED IS 25MPH AND BELOW WHEN THE STALLING HAPPENS. IT WAS TAKEN TO THE DEALER FOR INSPECTION AND THE ETM WAS DIAGNOSED AS THE PROBLEM. THE ETM WAS REPLACED; HOWEVER THE PROBLEM STILL OCCURS. THE PERFORMANCE REDUCED LAMP ILLUMINATES EACH TIME BEFORE THE VEHICLE STALLS. THE VEHICLE IS CURRENTLY AT THE DEALER FOR ADDITIONAL TESTING.

DT*: THE CONTACT STATED WHILE IN REVERSE THE VEHICLE ACCELERATED SUDDENLY AND RAN INTO A CACTUS. AS A RESULT, THE VEHICLE SUSTAINED BODY DAMAGE. THE DEALERSHIP INSPECTED THE VEHICLE; HOWEVER THEY WERE UNABLE TO DUPLICATE THE PROBLEM. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP, WHICH REPLACED THE REAR PASSENGER DOOR AND PANEL. THE MANUFACTURER WAS NOTIFIED; HOWEVER NO ADDITIONAL REPAIRS WERE MADE. UPDATED 5/10/2006 - THE DEALER REPLACED THE ELECTRONIC CONTROL MODULE. *NM

2001 S80, MULTIPLE FAILINGS OF THE ELECTRONIC THROTTLE MODULE. THIS HAS HAPPENED REPEATEDLY OVER THE LAST 2 WEEKS. TOO MANY TIMES TO COUNT. CAR W/O NOTICE WILL NOT ACCELERATE BEYOND 20 MPH, IDLES ROUGHLY. HAS ALMOST CAUSED SEVERAL ACCIDENTS.*AK

MY 2001 VOLVO S-80 SUDDENLY LOST ALL POWER AND CAME TO A STOP AND WOULD NOT RESTART. THIS OCCURRED IN SEPT. 2003. THE DEALERSHIP, BEACH VOLVO IN MYRTLE BEACH, SC, WANTED OVER $600 TO REPAIR THE AUTO SINCE IT WAS BEYOND THE 50,000 MILE WARRANTY. IT HAD 60,000 MILES AT THE TIME. AFTER A LENGTHY DISCUSSION WITH VOLVO AMERICA, THEY AGREED TO SPLIT THE COST BETWEEN MYSELF, THE DEALERSHIP AND VOLVO AMERICA. THE ELECTRONIC THROTTLE BODY WAS REPLACED. ON 12/05/05 THE SAME THING HAPPENED. THE CAR NOW HAS 82,700 MILES. IT IS BEING LOOKED AT BY BEACH VOLVO AT THIS MOMENT. *NM

I OWN A 2001 VOLVO S80, 4 DR. SEDAN WHICH I AM IN THE PROCESS OF TRADING IN BECAUSE ON 3 DIFFERENT OCCASIONS THIS YEAR (2005) THE CAR STALLED, THE LAST TIME I NEEDED TO HAVE IT TOWED. AFTER DOING SOME RESEARCH I NOTED THAT VOLVO HAD REACHED AN AGREEMENT REGARDING COMPLAINTS FILED IN CALIFORNIA ABOUT THE ETM MODULE. I BELIEVE THAT WAS THE CAUSE OF MY STALLING. I DID HAVE THE PART REPLACED, AT MY EXPENSE AND THE MECHANIC SHOWED ME THE PART THAT WOULD NOT STAY CLOSED CONSEQUENTLY CAUSING THE CAR TO STALL. AT NO TIME WAS THERE AN INDICATION THAT THERE WAS A PROBLEM - NO WARNING LIGHT. WHILE I LOVE THE CAR, I DON'T FEEL I CAN TRUST IT EVEN THOUGH A NEW PART WAS PUT IN. ACCORDING TO THE VOLVO DEALER, PART WOULD NOT BE REPLACED UNLESS WARNING INDICATOR CAME ON. THE LAST TIME THE...

DT: THE CONTACT STATED THE VEHICLE STALLED WHILE DRIVING. THERE WERE NO WARNING LIGHTS ON WHEN THIS HAPPENED. THE VEHICLE WAS TAKEN TO THE DEALERSHIP ,AND THEY REPLACED THE THROTTLE CONTROL MODULE AT THE CONTACT'S EXPENSE. SHE RECEIVED AN EXTENDED WARRANTY FROM VOLVO, AND IT STATED SHE NEEDED TO CONTACT THE MANUFACTURER FOR REIMBURSEMENT. *AK

DT: THE CONTACT STATES WAS DRIVING ON THE HIGHWAY WHEN THE CAR COMPLETELY STALLED, RESULTING IN LOSS OF POWER. THE WARNING LIGHTS CAME ON PRIOR TO THE CAR STOPPING. SHE REPORTED HAVING NO PROBLEMS PRIOR TO THIS INCIDENT. THE VEHICLE WAS TOWED TO THE DEALERSHIP, AND THEY STATED TO CONTACT THE NHTSA HOT LINE SERVICES AND FILE A COMPLAINT. THE CAUSE HAS NOT BEEN DETERMINED.*AK

2001 VOLVO S80 T6 1. FAILURE VEHICLE SPEED CONTROL/ELECTRONIC THROTTLE CONTROL MODULE 2. TRANSMISSION FAILURE - GM TRANSMISSION. *JB

VEHICLE REPEATEDLY STALLS AT LOW RPMS, DECELERATING, OR COMING TO STOP AT TRAFFIC LIGHTS, OFF-RAMPS, TOLL BOOTHS ETC. PROBLEM IS INTERMITTANT, AND DOESN NOT YIELD DIAGNOTICS ON CONSISTANT BASIS. DEALERS REFUSE TO FOLLOW-UP ON PROBLEM AS DIAGNOSTICS ARE INCONSISTANT. ONE INJURY AVOIDING ONCOMING VEHICLE UPON EXITING STALLED VEHICLE. INJURY MINOR, AND TREATED LOCALLY. *NM

DT: 2001 VOLVO S80. VEHICLE STALLED/DIED AND LOST POWER DUE TO THROTTLE BODY FAILURE. *AK. THE THROTTLE BODY AND GASKET HAVE BEEN REPLACED THREE TIMES TO ALLEVIATE THE STALLING PROBLEM. *NM X-REF 10132057, SECOND ETM, SMCH. *AK

THE CONTACT OWNS 2000 VOLVO S80. PURCHASED IT UNDER AN EXTENDED WARRANTY CERTIFIED USED CAR PROGRAM FROM CLAYTON VOLVO IN KNOXVILLE TENNESSEE IN APRIL 2001. SEVERAL MONTHS LATER, WHILE THE CAR WAS STILL UNDER WARRANTY, THE CAR DIED IN THE MIDDLE OF AN INTERSECTION. AFTER TOWING IT TO THE DEALER IT WAS DISCOVERED THE ELECTRONIC THROTTLE MODULE WASFILLED WITH CARBON. THAT UNIT WAS REPLACED UNDER WARRANTY. A COUPLE YEARS LATER, THE CAR AGAIN DIED. THIS TIME IT HAPPENED IN A PARKING LOT. THANKFULLY, IN BOTH CASES IT HAPPENED IN A SAFE SITUATION. AGAIN, THE ETM WAS DETERMINED TO BE THE PROBLEM. BUT, THE WARRANTY HAD EXPIRED. THE DEALER AND THE MANUFACTURER REFUSED TO RECOGNIZE THAT THE PROBLEM WAS AN ONGOING ISSUE. THIS TIME THE CONTACT WAS FORCED TO PAY NEARLY $1000 FOR REPAIRS. IT WAS THE CONTACT'S UNDERSTANDING THAT INFORMATION WAS BEING COLLECTED ON THIS PROBLEM, SO HE FELT COMPELLED...

X REF 10131066, 2 ETMS, SMCH. 8-26-5 E-MAIL THAT IS THE UNIT THAT HAS CAUSED THE CAR TO TO BE TOWED TWICE. ONCE WHILE DRIVING, AND ONCE WHILE STARTING IN A PARKING LOT. THE ELECTRICAL THROTTLE MODULE (ETM) FAILED. *AK

WELL, WELL - LET'S SEE, I BOUGHT A 2001 VOLVO S-80, T-6 IN FEBRUARY 2005 TO REPLACE MY 1996 740 IL BMW - I THOUGHT I WOULD GET A MORE ECONOMICAL AND SAFE CAR. BOY WAS I WRONG! TO MY DISGUST I PAID ALMOST $20,000 FOR THIS USED CAR AND WITHIN WEEKS IT STARTED ACTING UP. IT TURNED OUT TO BE THE MASS AIRFLOW SENSOR AND THE THROTTLE BODY. I FINALLY - 9 MONTHS AFTER PURCHASING THE CAR - HAVE HAD TO GET IT FIXED - OVER $1200.00. I, LIKE ANOTHER PERSON WHO FILED A COMPLAINT, WAS MAKING A LEFT HAND TURN ON A VERY BUSY ROAD, AND THE CAR DIED WHILE IN THE MIDDLE OF MY TURN. LUCKILY I WAS ABLE TO PUT IT IN NEUTRAL QUICK ENOUGH AND RESTART IT BEFORE I GOT HIT. THE CAR ALSO SURGES DANGEROUSLY AT STOPS. IF YOU DON'T HAVE YOUR FOOT ON...

WHILE DRIVING ON AN INTERSTATE HIGHWAY AT 65-70 MPH, 2001 VOLVO S80 T6 DISPLAYED A MESSAGE INDICATING REDUCED POWER. WAS ABLE TO STEER THE CAR, BUT PUSHING THE ACCELERATOR PEDAL IT HAD NO EFFECT. THE CONTACT WAS FORCED TO MANEUVER TO THE SHOULDER, AND HAD THE CAR TOWED TO LOCAL DEALER. THE CAR WOULD START AND CONTINUED TO RUN, BUT THE CAR WOULD NOT GO. IT WAS AS IF THE ACCELERATOR PEDAL HAD BEEN DISCONNECTED. THIS HAPPENED AT ALL SPEEDS. THE MECHANIC DETERMINED THAT THE ELECTRICAL THROTTLE MODULE (ETM) MALFUNCTIONED. *AK

ETM BAD/ ELECTRONIC THROTTLE MODULE THIS HAS BEEN A NIGHTMARE AND IT'S NOT RESOLVED YET! I BOUGHT MY USED VOLVO S-80 T6 OCTOBER 20 TH WITH 76,000 MILES. WITHIN THE DAY OF OWNERSHIP THE SERVICE ENGINE REQUIRED LIGHT CAME ON, AND I FAILED MASS INSPECTION. I TRIED TO GET MY MONEY BACK, BUT I BOUGHT OUT OF STATE, AND THEY REFUSE TO RETURN CALLS. I RESEARCHED THE PROBLEM AND FOUND IT WAS THE ETM. ON WEDNESDAY NOV 10TH 2005, I CALLED MY LOCAL DEALER PIONEER VOLVO IN SOUTH DEERFIELD MASS 1 800 680 2140, AND WAS INFORMED THAT THE ETM WARRANTY EXPIRED AT 70,000 MILES, AT 76,000 MILE, THERE WAS NO WARRANTY. I ASKED HIM ABOUT KNOWN PROBLEMS WITH THE ETM, AND DENIED THAT HE WAS AWARE OF ANY! I ASKED HIM FOR AN APPOINTMENT, EXPLAINED THAT HE IS THE CLOSEST DEALER AT 47 MINUTES AWAY, AND THAT I NEEDED...

ELECTRONIC THROTTLE MODULE (ETM )REPLACED SECOND TIME, 50 MPH, STALLED X REF 10131141, SMCH. *AK UPDATED 1/4/2006 - *NM

I WAS DRIVING DOWN A US HIGHWAY WHEN I NOTICED MY CAR WAS 'LURCHING' FORWARD THEN WOULD LOOSE SPEED ALL TOGETHER KIND OF LIKE IT WANTED TO STALL. I WOULD PUSH ON THE ACCELERATOR AND NOTHING WOULD HAPPEN, THEN ALL OF A SUDDEN THE CAR WOULD DRIVE NORMALLY. I WAS ABOUT A MILE FROM MY WORK, SO I DIDN'T PULL OVER IMMEDIATELY. THE NEXT TWO STOP LIGHTS I ALMOST STALLED, BUT DIDN'T. AT THE THIRD TRAFFIC LIGHT ON ANOTHER US HIGHWAY, I WASN'T SO LUCKY - MY CAR STALLED AND WOULD NOT RE-START. I HAD TO CALL FOR A TOW TRUCK. MY SERVICE REPORT STATES THAT THE CODE ECM-130A WAS DETECTED. I FIGURED FOR SURE THIS WOULD BE COVERED UNDER MY EXTENDED WARRANTY. VOLVO SAID NO AS IT WAS 'JUST A DIRTY THROTTLE UNIT'. THEY SUPPOSEDLY TOOK IT APART, CLEANED IT, REPLACED A GASKET, UPGRADED THE ECM PET, AND PUT...

FOR THE PAST YEAR (10/04-10/05), MY 2001 VOLVO S80 SEDAN HAS HAD REPEATED PROBLEMS WITH STALLING AND LOSS OF POWER STEERING. IT HAS OCCURRED AT SLOW SPEEDS AND UP TO 40 MPH IN TRAFFIC. I HAVE TAKEN THE CAR TO THE DEALER TWICE. THEY CAN NOT FIND ANY FAULT CODES DURING THE COMPUTER TROUBLESHOOTING, SO MY WARRANTY WILL NOT COVER ANY REPAIR. THEY SUGGESTED IT MIGHT BE "BAD GAS" AND HAVE SENT ME HOME TWICE HAVING DONE NOTHING. THE STALLING PROBLEM HAS OCCURRED FIVE TIMES IN THE LAST MONTH. THE CAR HAS 66,500 MILES ON IT. *JB

NO ACCELERATION AT TIMES. FROM TIME TO TIME WHEN MERGING ON FREEWAYS OR TRAFFIC CAR WOULD NOT ACCELERATE. SOMETIMES IT WOULD SERGE. HAD A FEW CLOSE CALLS. FIRST HAD THROTTLE BODY (ETM) CLEANED WHICH DIDN'T WORK THEN HAD THROTTLE BODY REPLACED TWO DAYS LATER AT COST OF $1,177.16. *JB

SURGING IDLE SPEED. CAR LURCHES FORWARD AT TIMES WHEN ACCELERATING FROM A STOP. CAR ALMOST STALLS WHEN IDLING IN BUMPER TO BUMPER TRAFFIC, REQUIRING YOU TO PRESS ON THE GAS TO KEEP IT FROM STALLING, BUT THIS MAKES THE CAR LURCH FORWARD EVEN MORE. SEVERAL TIMES I HAVE ALMOST HIT THE CAR IN FRONT OF ME. THIS PROBLEM IS DUE TO A FAULTY ETM (ELECTRONIC THROTTLE MODULE) THAT IS DESCRIBED IN THE NHTSA DEFECT INVESTIGATION SHOWN BELOW. THE ETM IN MY CAR WAS REPLACED TWO YEARS AGO AT 46K MILES BUT THE SAME SYMPTOMS ARE RECURRING. NHTSA ACTION NUMBER : PE05041 NHTSA RECALL CAMPAIGN NUMBER : N/A MAKE : VOLVO MODEL: S80 MANUFACTURER : VOLVO CARS OF N.A. LLC. YEAR : 2001 COMPONENT : VEHICLE SPEED CONTROL DATE INVESTIGATION OPENED : JULY 26, 2005 DATE INVESTIGATION CLOSED : OPEN SUMMARY: THE OFFICE OF DEFECTS INVESTIGATION (ODI) HAS RECEIVED ONE HUNDRED...

PURCHASED 2001 VOLVO S80 ABOUT A MONTH AND A HALF AGO. IN THE PAST TWO WEEKS THE VEHICLE HAS DEVELOPED AN ENGINE SURGE AND ON TWO OCCASIONS HAS SIMPLY LOST POWER WHILE TRAVELING AT 55 MILES PER HOUR. BOTH TIMES A MESSAGE WAS DISPLAYED STATING REDUCED PERFORMANCE BUT THE VEHICLE HAD NO POWER AT ALL. AFTER PULLING ON TO THE SHOULDER I WAS ABLE TO GET IT STARTED AGAIN. THE PROBLEM HAS SUBSEQUENTLY BEEN DIAGNOSED AS THE ETM. THE CAR IS NOW PARKED WHILE I TRY TO RAISE THE MONEY TO HAVE IT FIXED. AS A RETIRED STATE TROOPER I CAN ONLY SAY THAT THIS IS A VERY DANGEROUS SITUATION AND I HOPE THE NHTSA AND VOLVO WILL NOT WAIT UNTIL THERE ARE INJURIES OR FATALITIES TO CORRECT THE PROBLEM. *NM

WHILE DRIVING LOST STEERING POWER AND ENGINE COMPLETELY SHUT DOWN, UNSAFE ON THE TURNPIKE, I SCARED. TOOK CAR TO DEALERSHIP WHILE UNDER WARRANTY REPLACED THROTTLE UNIT. CAR SHUT DOWN AND LUNGES FORWARD AT A LIGHT/TOOK TO DEALER AND FIXED RESET VALVE STICKING AND GASKET HAPPENED AGAIN REPLACED BOX AND PIPE REMOVED TRAP BOX IN PIPE, SHUT DOWN AGAIN REPLACED DID TOTAL CAN UP GRADE FAILED AGAIN. UNTIL TODAY CAR STILL SHUTS DOWN VERY DANGEROUS THIS CAR IS A DEATH TRAP AND MY WARRANTY IS OVER AND THEY WANT TO PAY 3,000.00 DOLLARS TO FIX, I FEEL THEY ARE RESPONSIBLE THEY SOLD ME A LEMON AND A VERY DANGEROUS CAR. AND THE CUSTOMER SERVICE OF VOLVO CLAIM THEY CARE ABOUT CUSTOMER SERVICE VERY UNTRUE THEY GOT YOUR MONEY AND THE DON'T CARE MY PROBLEMS STILL EXIST AND I GET SCARED JUST GETTING INTO THIS CAR. *NM

I WAS DRIVING A 2001 VOLVO S80 T6 ON THE HIGHWAY PREPARING TO PASS A VEHICLE IN ORDER TO MAKE MY EXIT. AT THIS TIME THE CAR LOST POWER AND I RECEIVED A MESSAGE "PERFORMANCE REDUCTION". AFTER DODGING A COUPLE OF CARS I WAS ABLE TO MAKE IT TO THE SIDE OF THE ROAD. AT THAT TIME THE CAR WOULD NOT START BACK UP, I DECIDED TO LET THE CAR SIT AND COOL DOWN FOR ABOUT 15 MINUTES. THE CAR WOULD STILL NOT START. I HAD THE VEHICLE TOWED TO THE DEALERSHIP AND THEY INFORMED ME THAT THE ETM HAD FAILED AND THE OXYGEN SENSOR WHICH COST ME ABOUT $1300.00 TO REPAIR. *NM

VOLVO S80 ELECTRONIC THROTTLE MODULE (ETM) PRODUCTION DEFECT NOT COVERED UNDER WARRANTY AS THE DEFECT OCCURRED JUST OUTSIDE OF WARRANTY. DEALER COST TO CORRECT IS OUTRAGEOUS GIVEN THIS IS CLEARLY A MANUFACTURER ENGINEERING DEFECT WITHIN THE THROTTLE BODY MECHANISM ITSELF. *JB

I HAVE EXPERIENCED REPEATED PROBLEMS WITH THE ELECTRONIC THROTTLE MODULE ON MY 2000 S80 VOLVO. FOR THE LAST COUPLE YEARS I HAVE TAKEN MY VEHICLE TO THE VOLVO SERVICE DEALER FOR REPEATED PROBLEMS WITH THE CAR ENGINE SURGING WHEN COMING TO A STOP. THE VOLVO DEALER SERVICE WORKED ON THE ISSUE MULTIPLE THROUGHOUT THE WARRANTY PERIOD, STATING THEY KNEW OF A PROBLEM WITH THE ETM AND TO WATCH IT. NOW MY VEHICLE IS OUT OF WARRANTY AND THE PROBLEM WAS DEFINITELY DIAGNOSED AND I HAD TO PAY OVER $900.00 TO GET IT FIXED. *JB

DT: THE CALLER SAID THAT WHILE DRIVING VEHICLE SPUTTERED AND STALLED. THE CALLER SAID THAT WHEN THE PROBLEM STARTED IT WOULD HAPPEN ABOUT ONCE A WEEK, AND IT GOT PROGRESSIVELY WORSE. IT WOULD STALL APPLYING THE BRAKES. HE SAID THIS PROBLEM MADE IT VERY HARD TO DRIVE IN DAILY TRAFFIC. THE CALLER WAS ABLE TO GET VEHICLE OFF THE ROAD. THEN, IT STARTED BACK UP. HE HAD THE ELECTRONIC THROTTLE MODULE REPLACED. DEALER SAID THE PROBLEM WAS COMMON IN THIS VEHICLE, AND THEY FIXED IT. MANUFACTURER SAID TO CALL DEALER. THE CALLER HAD THE PROBLEM FIXED ABOUT SIX MONTHS AGO. HE JUST WANTED TO LET NHTSA KNOW ABOUT THIS PROBLEM.*AK

CAR STALLED IN TRAFFIC AND THEN FAILED TO ACCELERATE AT AN INTERSECTION. PAID $900 FOR A NEW ELECTRONIC THROTTLE MODULE AND THE LEARNED VOLVO IS WELL AWARE OF PROBLEM WITH THE PART AND THAT MANY, MANY VEHICLES HAVE THE PROBLEM. *NM

THE THROTTLE SURGES AT TIMES WITHOUT ME CHANGING THE THROTTLE PEDAL...ELECTRONIC THROTTLE BODY MAY BE BAD.... *NM

VEHICLE STALLS WITHOUT WARNING. IT HAS OCCURRED WHILE DRIVING AT DIFFERENT SPEEDS, ON STRAIGHT AWAYS, ON CORNERS AND WHEN COMING TO A STOP. THE CAR , ON OCCASION, WILL ATTEMPT TO LURCH FORWARD WHILE COMING TO A STOP WITH THE FOOT ON THE BRAKE. *NM

1) DRIVING IN A 35 MPH ZONE. SLOWING DOWN TO TURN TO SIDE STREET, APPROXIMATELY 5 MPH. 2) WITHOUT WARNING, THE CAR STALLED. LOST POWER STEERING AND BRAKES. I COASTED TO THE INTERSECTION AND STOPPED. PLACED CAR IN PARK AND RESTARTED ON SECOND ATTEMPT. 3)TOOK THE CAR INTO DEALER JIM FISHER VOLVO, PORTLAND OREGON. THEY CHECKED THE THROTTLE CONTROL MODULE FOR CLEANING. IT WAS CLEAN SO NO WORK WAS PERFORMED. THEY COULD NOT REPLICATE PROBLEM, SO THE RETURNED CAR WITH NO CORRECTIVE ACTION. NO CHARGE. *NM

DT: THE CONTACT OWNS A 2001 VOLVO S80. THE VEHICLE WILL BEGIN TO BUCK AT HIGHWAY SPEEDS. THE CRUISE CONTROL WILL DROP OFF AT RANDOM AND STOP WORKING BEFORE THE BUCKING STARTS. SOMETIMES AT START UP IT WILL IDLE REALLY ROUGH. THE CONTACT PURCHASED THE VEHICLE ON JULY 16, 2005 AND THIS PROBLEM HAS BEEN OCCURRING EVER SINCE HE PURCHASED THE VEHICLE. THE VEHICLE WILL COMPLETELY STALL AS WELL AS RUN AT LOW SPEEDS. THE VEHICLE FAILED AT LEAST 50 TIMES SINCE HE PURCHASED THE VEHICLE. THE CONSUMER WAS NOT THE ORIGINAL OWNER. THE PROBLEM HAS BEEN DIAGNOSED AS THE ELECTRONIC THROTTLE MODULE, BUT HAS NOT BEEN FIXED AT THIS POINT. *AK *JB

ETM FAILURE ON MY 2001 VOLVO S80 HAS LEFT IT INOPERABLE AND A SERVICE BILL OF $1004.00 THIS IS A COMMON PROBLEM THAT HAS ALREADY BEEN STATED BY SEVERAL OTHER CUSTOMERS. I WOULD LIKE TO SEE SOMETHING DONE ABOUT THIS. VOLVO HAS A BETTER REPUTATION THAN THIS!PLEASE HELP. *NM

DT: ON SEPTEMBER 12, 2005 THE CONSUMER'S HUSBAND HAD HIS FOOT ON THE BRAKE AND THE VEHICLE SURGED FORWARD. THE ELECTRONIC THROTTLE MODULE FAILED AND WAS REPLACED. *AK *JB

THE VEHICLE BEGAN IDLING ROUGHLY ABOUT 2 WEEKS AGO. IT HAS GOTTEN PROGRESSIVELY WORSE TO THE POINT WHERE IT STALLS IN TRAFFIC AND AT STOP LIGHTS. IT ALSO FREQUENTLY REVS ITSELF UP. THE SERVICE DEPARTMENT AT MY DEALER HAS TOLD ME THAT THE THROTTLE CONTROLLER HAS FAILED AND THAT IT WILL COST $880 TO REPAIR. I READ THAT THERE IS AN INVESTIGATION IN TO THE FAILURE OF THIS PART. IT SEEMS VERY DANGEROUS TO ME AND I AM CONCERNED ENOUGH TO REPORT IT AS IT POTENTIALLY MAY CAUSE THE DRIVE TO LOSE CONTROL OR THE FAILURE COULD CAUSE AN ACCIDENT. *NM

CAR SURGED AND RAN UNEVENLY. IT WAS DIFFICULT TO ACCELERATE WITHOUT SURGING AHEAD. TOOK IT IN FOR SERVICE AND THEY "PERFORMED SOFTWARE UPGRADES TO ECM AND ETM." THEN, A MONTH LATER, THE CAR STALLED IN THE MIDDLE IF AN INTERSECTION AND WOULD NOT RESTART. THE CAR WAS TOWED TO THE DEALER AND THE ETM WAS REPLACED AS WELL AS THE MASS AIR FLOWMETER. SOFTWARE WAS THEN RELOADED. IT HAS WORKED WELL SINCE THEN. *NM

I OWN A 2001 VOLVO S80. I HAVE HAD TROUBLE WITH THE ELECTRONIC THROTTLE MODULE NOT RESPONDING TO THE THROTTLE INPUTS AND SURGING AT IDLE. IT WOULD SOMETIMES KILL THE CAR WITHOUT WARNING WHEN COMING TO A STOP (LOSING POWER-STEERING WHILE IN TURNS) OR MAKE THE CAR LUNGE FORWARD UNEXPECTEDLY. THE LUNGING FORWARD HAS ALMOST CAUSED ACCIDENTS AT INTERSECTIONS. I'VE BEEN LUCKY FOR NOW, BUT I WILL NOT LET MY WIFE DRIVE THE CAR WHILE IT IS DOING THIS BECAUSE SHE MAY NOT BE ABLE TO CONTROL THE CAR WITHOUT POWER STEERING AND BRAKES. I TOOK IT IN FOR REPAIR AND THEY TOLD ME THAT IT WAS THE ELECTRONIC THROTTLE MODULE, AND THEY NEED REPLACING AFTER A WHILE, SO I REPLACED IT. 4 MONTHS LATER, I'M EXPERIENCING THE SAME IDLE PROBLEMS AS WELL AS THE LUNGING PROBLEMS. I AM BEING TOLD THAT IT IS THE SAME PROBLEM WITH THE THROTTLE...

I WAS ON THE RAMP GETTING ON TO THE HIGHWAY, AND ALL OF A SUDDEN THE CAR STALLED. I COULD NOT ACCELERATE, AND A SEMI WAS GOING TO HIT THE BACK OF MY CAR BECAUSE I GOT OUT THERE IN FRONT OF HIM AND THEN I CAN'T MOVE. SO TO AVOID THE ACCIDENT, I DARTED OF THE HIGHWAY UNTO THE SHOULDER WITH THE DISMAY OF THE TRUCK DRIVER. THE INFORMATION IN THE LEFT CORNER GAVE "PERFORMANCE REDUCED". I DIDN'T KNOW WHAT HAPPENED. SO I HAD IT TOWED, AND WITHOUT FINDING ANYTHING THE FIRST DAY, THEY FOUND THAT IT WAS THE ELECTRONIC THROTTLE MODULE. SO I HAD TO PAY OVER $1000 TO GET THIS FIXED. THIS WAS BACK IN MARCH, AND NOW I AM HAVING THE SAME PROBLEM. I AM NOT GOING TO PAY ANOTHER $1000 FOR THE SAME THING. I ALMOST GOT INTO AN ACCIDENT AND I ALREADY PAID OVER...

I WAS DRIVING ON I-75 INTERSTATE AND WHEN I WENT TO PASS A VEHICLE IN THE LEFT LANE I FELT A SUDDEN LOSS OF POWER IN MY ENGINE. I THEN HAD TO CUT ACROSS 4 LANES OF EXPRESSWAY TRAFFIC TO GET MY CAR ONTO THE SHOULDER. THEN MY CAR STALLED OUT. WHENEVER I RESTARTED IT, IT WOULD STALL BACK OUT AGAIN. THE AUTO SHOP TOLD ME THAT I NEEDED TO REPLACE MY ELECTRONIC THROTTLE MODULE, MASS AIR FLOW SENSOR, AND GAS PEDAL SENSOR COSTING ME WELL OVER $2000. (THE OLD PARTS ARE AT MY HOUSE, I'VE KEPT THEM). *NM