2003 VOLVO S60 Electrical System Problems

The problem is when the weather turns cold my car a Volvo 2003 S 60 turn signals do not operate, or if they do turn on sometimes the turn signals won't stop flashing until you turn the ignition off. The head lights also will not turn on at any setting during this time. When the weather turns warm again everything works until the weather turns cold again. It appears to be related to the CENTRAL ELECTRONIC MODULE. It happens every time the weather is cold. It happen very unexpectedly my wife was driving down the road and was almost in an accident. The turn signals switch has already been replaced with a new Volvo turn signal switch.The turn signal still does not work. According to XEMODEX.INC this is a common problem for Volvo's S 60 2001-2010.

INSTRUMENT PANEL/CLUSTER GOES OUT WHILE DRIVING WHICH MEANS YOU CAN'T READ ANY OF THE GUAGES OR WARNINGS LIGHTS OTHER THAN IF CHECK ENGINE LIGHT IS ON. THIS IMPOSES A SAFETY RISKS TO ME AND OTHER TRAFFIC ON THE ROAD. IT DOES THIS ERRATICALLY, GOING OUT COMPLETELY AND COMING BACK ON IN TIME. NO FUSE PROBLEMS, THEY ARE CHECKED WHEN THIS ISSUE HAPPENS. I HAVE A PICTURE OF EXACTLY WHAT HAPPENS RIGHT BEFORE THE WHOLE PANEL GOES OUT.

THE DASHBOARD INSTRUMENT PANEL AND LIGHTS GO OFF AND COME BACK ON WHENEVER. I HAVE HAD THE CAR FOR OVER A YEAR. IT WAS A GIFT. I JUST FOUND OUT TONITE FROM AN OFFICER THAT WHEN THE INSTRUMENT PANEL AND LIGHTS ARE OFF I HAVE NO TAIL LIGHTS. I WAS WONDERING IF THERE HAS EVER BEEN A RECALL. THIS IS VERY DANGEROUS THE DATE BELOW IS IT AN APPROXIMATE. I REALLY DO NOT REMEMBER THE EXACT DATE.

INSTRUMENT CLUSTER NOT ILLUMINATING. I UNDERSTAND THIS IS A COMMON ISSUE WITH 2003 S60 VOLVOS. MANUFACTURER NEEDS TO RECALL/REPAIR AS THIS IS A SIGNIFICANT SAFETY ISSUE WHEN ALL THE INSTRUMENTS GO DARK AND YOU CANNOT GAUGE YOUR SPEED AND GAS LEFT IN TANK

TL* THE CONTACT OWNS A 2003 VOLVO S60. WHILE DRIVING AT VARIOUS SPEEDS, THE INSTRUMENT PANEL INDICATOR INTERMITTENTLY ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT A CABLE BEHIND THE MILEAGE GAUGE FAILED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 179,000.

DASH CLUSTER LIGHTS AND GAUGES AND TURN SIGNAL INDICATOR SHUT DOWN AND BACK ON INTERMITTENTLY, MOTOR SEEMS TO LOSE POWER WHEN DRIVING, AND ROUGH IDLE. THE DASH CLUSTER PROBLEM HAPPENS WHILE DRIVING AND IN THE PARK POSITION. *TR

ENTIRE DASHBORAD HAS WENT BLACK GAS GAUGE,SPEEDODMETOR,TURNING SIGNALS AND HAZARD LIGHTS.

THE INSTRUMENT PANEL WENT DEAD LAST WINTER; NO LIGHTS, NO INDICATORS, NO INSTRUMENTS, NOTHING. I RECENTLY BECAME AWARE THAT THIS IS NOT AN UNCOMMON PROBLEM. JUST AN EXTREMELY EXPENSIVE ONE. A VOLVO TECHNICIAN INFORMED ME THAT THE JAPANESE FIRM THAT VOLVO HIRED DID A POOR JOB AND MANY OF THE INSTRUMENT PANELS HAVE DEFECTIVE SOLDERING AND REQUIRE REPLACEMENT OR HAVE THE PANEL "RE-POINTED". APPARENTLY, IT IS LESS OF AN ISSUE IN MOIST CLIMATES. VOLVO WILL NOT REPAIR THE PANEL. THEY WILL ONLY REPLACE IT. I WAS QUOTED $1,605.00 PLUS $157.00 TO PROGRAM IT TO THE CAR'S COMPUTER. THE TECHNICIAN KNEW EXACTLY WHAT I WAS TALKING ABOUT. SO, AS I SAID BEFORE, THIS IS NOT A UNCOMMON PROBLEM. WITH A DEAD INSTRUMENT PANEL, YOU CANNOT DETERMINE HOW FAST YOU ARE GOING, HOW MUCH GAS YOU HAVE IN YOUR CAR, NO OIL INDICATOR, NO TURN SIGNALS, NO HIGH BEAM, OR ANY OF...

INSTRUMENT CLUSTER FAILURE

AIR BAGS SAY URGENT SERVICE NEEDED ,CLOCK GOING BACKWARDS , ON BOARD COMPUTER GOING CRAZY , WORRIED ABOUT IT CATCHING FIRE ,TAIL LIGHTS HAVE BEEN REPLACED 2 TIMES AND STILL THEY GO OUT RIGHT AFTER BEING REPLACED

WHILE DRIVING MY 2003 VOLVO S60, THE DASH INSTRUMENT PANEL SUDDENLY LOST ALL POWER W/THE GAUGES/DISPLAY ALL STOPPING. THEN IT WOULD RETURN AND KEEP WORKING. THEN IT WOULD DO IT A DIFFERENT TIME, CONTINUING IN THIS CYCLE - RANDOMLY SHUTTING OFF COMPLETELY SO I HAD NO GAUGES, WARNING LIGHTS, TURN SIGNAL LIGHTS, ETC. JUST A LARGE BLACK AREA WHERE THE INSTRUMENT PANEL IS. THIS WAS ESPECIALLY CONCERNING AT NIGHT WHEN I WOULD JUST RANDOMLY LOOSE THE DISPLAY WHILE DRIVING ON THE HIGHWAY. I CONTACTED VOLVO AND THEY SAID THIS IS A KNOWN PROBLEM W/THEIR VEHICLES (AND IS ALSO CONFIRMED WHEN LOOKING ONLINE FOR OTHERS WHO HAVE HAD THE SAME PROBLEM). THE REPAIR IS NOT COVERED UNDER ANY SORT OF SAFETY RECALL, AND IS VERY EXPENSIVE. FOR A MFG WHOSE CARS ARE TOUTED AS BEING VERY SAFE, HAVING THE INSTRUMENT PANEL SUDDENLY STOP WORKING SO NO IDEA OF SPEED NOR ANY...

TRANSMISSION SHIFTING PROBLEMS OIL LEAKS.

I AM SURPRISED THERE HAS NOT BEEN A RECALL ISSUED FOR CERTAIN MODEL YEAR VOLVOS RELATIVE TO THE CENTER DASH MODULE LOSING ALL COMMUNICATION APPARENTLY DUE TO FAILED SOLDER CONNECTIONS (BASED ON CHAT-ROOMS, VOLVO SPECIFIC). I UNDERSTAND COMPONENTS CAN FAIL, BUT THE SHEER NUMBER OF FAILURES AND THE FAILURE MODE IS BEYOND TYPICAL OR EXPECTED FAILURES. THE FAILURE MODE CAUSES MOST OR ALL DASH GAUGES, INDICATORS AND LIGHTS TO FAIL, INCLUDING THE SPEEDOMETER. THESE FAILURES APPARENTLY OCCUR RANDOMLY, AND AT ANY AGE/MILEAGE.

WHILE DRIVING HOME AFTER HAVING STEERING RACK REPLACED THE DASH LIGHTS (SPEEDOMETER, TURN SIGNALS, MESSAGE CENTER, ETC.) WENT COMPLETELY OUT. AFTER MULTIPLE DRIVES THE DASH LIGHTS GO ON AND OFF INTERMITTENTLY WHILE DRIVING.

TL* THE CONTACT OWNS A 2003 VOLVO S60. THE CONTACT STATED THAT THE ENTIRE INSTRUMENT PANEL GRADUALLY BECAME INOPERABLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE INSTRUMENT PANEL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 90,000. UPDATED 4/20/15*CN

DRIVING CAR LIGHTS ON DASH BOARD WENT COMPLETELY OFF. TOOK IT TO SHOP THEY TAP IT AND DASH CAME ON AGAIN, CHANGE FUSE . LIGHTS WENT OFF AGAIN AND STAYED OFF. *TR

THE ENTIRE GAUGE CLUSTER TURNS OFF AND ON WHEN THE VEHICLE IS TRAVELING DOWN THE ROAD. THIS IS A WIDE SPREAD PROBLEM THATS WELL DOCUMENTED BY THE VOLVO COMMUNITY. THE ISSUE IS A POORLY SOLDERED CIRCUIT BOARD ON THE DIM. *TR

VEHICLE DRIVER INFORMATION MODULE (DIM) STOPPED WORKING WHILE VEHICLE WAS TRAVELING ON THE ROAD AT APPROXIMATELY 45 MILES PER HOUR. *TR

I STARTED MY CAR AND WHERE IT TELLS YOU IF SOMETHING NEEDS TO BE DONE TO CAR IT SAID AIRBAG WARNING URGENT SERVICE NEEDED. THEN LATER WHILE DRIVING ALL THE GAUGES STOPPED WORKING. NOW THE GAUGES DON'T WORK AT ALL. PLUS WHEN DRIVING AND TURNING A CORNER THE CAR STALLS NOW THIS HAS BEEN HAPPENING FOR A COUPLE YEARS NOW. PLUS A COUPLE YEARS AGO ALL MY HEAD LIGHTS BURNT OUT AT ONCE THEN THEY ONLY LASTED A COUPLE DAYS HAD TO BUY MORE THAT HAPPENED 5 TIMES IN ONE YEAR STILL HAVE NO BRIGHTS. *TR

DASHBOARD WENT DEAD WHILE DRIVING. GAS METER, RPM, EVERYTHING WENT DEAD. THE DASH LIGHTS LATER CAME ON FOR A WHILE, BUT THE SPEEDOMETER WENT BACK TO 40 MPH. NOTHING WORKS PROPERLY. *TR

CLOCK STARTED ROTATING NUMBERS.. AND NOT STOP. THEN INSTRUMENT DASH INFORMATION STOPPED. NO DASH LIGHTS, SPEED, GAS, WARNINGS. ALL OFF. WHEN I CAN SEE DASH. ONCE A MONTH, MAYBE....IT SAYS AIR BAGS NEED CHECKING, CHECK ENGINE. I AM CONCERNED THAT THE AIR BAGS WILL NOT WORK IF AN ACCIDENT OCCURS. AND IF I WERE TO BE ABLE TO AFFORD THE REPAIR, THEN WILL I HAVE TO PAY TO CHECK AIR BAGS? ENGINE? WHAT IF A FIRE DID OCCUR... HOW WOULD I KNOW? DEALER STATES $ 1700 TO REPAIR. IT IS SAFETY ISSUE FOR SPEED LIMIT, AIR BAG DEPLOYMENT IF AN ACCIDENT OCCURS, FUEL CONSUMPTION. CAN'T SEE MILEAGE FOR THIS COMPLAINT! DASH NOT WORKING... ENGINE MOUNTS SHOT. SEAT WARMER BROKE FIRST YEAR. NEEDED REPLACEMENT. THE ELECTRICAL HARNESS IN THIS CAR IS SHOT, BROKE, NOT CORRECT. TOO MANY COMPLAINTS ENTERED FOR THIS TO NOT BE A RECALL. PLEASE, PLEASE HELP! *TR

THE DASHBOARD HAS A FAULT IN IT, POSSIBLY A SHORT OR SOME OTHER ELECTRICAL FAULT THE PROBLEM HAS BEEN INTERMITTENT. BUT, ONLY RECENTLY HAS BECOME RATHER ACUTE. LIGHTS AND GAUGES GO ON AND OFF. PROBLEM HAS ADVERSELY AFFECTED THE SRS AIRBAG SYSTEM TO THE POINT THAT IT IS NO LONGER FUNCTIONS AND REQUIRES RESETTING; APPARENTLY. I AM FILING THIS COMPLAINT BECAUSE SINCE DOING MY RESEARCH, THERE HAVE BEEN NUMEROUS INCIDENTS BEING REPORTED ON THE INTERNET. CONSIDERING THE LARGE NUMBER OF ISSUES/COMPLAINTS I HAVE SEEN ABOUT THIS ISSUE, THE PROBLEM WITH MY CAR IS APPARENTLY NOT AN ISOLATED INCIDENT. REPAIR FOR SUCH APPEARS TO BE IN THE $1,500.00 TO $2,000.00 RANGE. *TR

LOST INSTRUMENT PANEL WHILE DRIVING. ALL GAUGES NOT WORKING. IT HAPPENED WHILE DRIVING. *TR

MY 2003 S60 VOLVO HAS FAILED IT ALL STARTED WITH THE RADIO FLICKERING TO DIFFERENT STATIONS.I NOTICED FROM THAN MY LIGHTS STARTED BLINKING ON AND OFF I HAS NO IDEA WHAT WAS GOING ON WITH THIS CAR I SERIOUSLY ALMOST GOT INTO IN ACCIDENT I PULLED OVER AND TURNED THE CAR OFF 5MINS AFTER I STARTED IT UP NOW ALL THE GUAGES WHERE DOWN EVE FUEL WAS PASS EMPTY I WAS TERRIFIED THAT MY CAR WOULD SHUT OFF I HAD MY 7 YEAR OLD IN THE CAR AS I WAS CAREFULLY WAS DRIVING HOME THE GUAGES STARTING MOVING ALL OVER THE PLACE RADIO SWITCHING FROM LEFT TO RIGHT THE MSG WINDOW SAID SEA BAG SERVICE SOON IAM VERY SCARE OF MY SAFETY JUS BOUGHT THIS CAR ON FEB 12/2013. *TR

THE DASH INFORMATION SYSTEM WILL RANDOMLY GO BLANK AND DISPLAY SRS FAILURE. ALONG WITH ALL INFORMATION LIGHTS START BLINKING ON AND OFF. THE ANALOG GAUGE LIKE THE SPEEDOMETER AND FUEL GAUGE WILL GO TO "0" OR JUST MOVE ERATICALLY TO ANY NUMBER OR POSITION WHILE DRIVING. AT NIGHT THE ENTIRE INFORMATION CENTER GO BLANK THE CLOCK AND THE MILEAGE(NO LIGHTS AT ALL). *TR

TL* THE CONTACT OWNS A 2003 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, SHE WAS INFORMED THAT THE TURN SIGNALS HAD FAILED. THE CONTACT ALSO MENTIONED THAT THE CLOCK FAILED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE INSTRUMENT PANEL MODULE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED FOR THE INSTRUMENT PANEL MODULE. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 125,000.

WHILE DRIVING THE DASH (NOT THE RADIO, OR OTHER ELECTRICAL COMPONENTS) WENT OUT-COMPLETELY BLANK. I LOST, THE TAC, THE SPEEDOMETER/ODOMETER, ENGINE GAUGE AND GAS GAUGE. THIS PROBLEM HAS CONTINUED INTERMITTENTLY AND I CAN NOT RELATE IT TO A GIVEN SPEED OR WEATHER. NOT KNOWING YOUR SPEED IS A SAFETY ISSUE AND AT NIGHT IT'S ODD TO BE DRIVING A CAR W/OUT AN ILLUMINATED DASH/CONTROLS. I DO HAVE AN SRS CODE-SERVICE IMMEDIATELY. WHEN I WAS LAST AT THE DEALER THEY HAD "NEVER HEARD OF THIS ISSUE" AND WOULD HAVE TO CHARGE ME DIAGNOSTIC FEES. ONLINE RESEARCH SHOWS THIS TO BE A COMMON PROBLEM AND A NEW DIM ($1200) CAN FIX THE PROBLEM. THIS IS A SAFETY ISSUE AND THERE ARE TOO MANY COMPLAINTS POSTED ONLINE FOR THIS TO BE A LITTLE PROBLEM. WHAT IS THE R/1000 (REPAIR PER THOUSAND VEHICLES)? *TR

TL* THE CONTACT OWNS A 2003 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE INSTRUMENT PANEL FAILED AND THE GAUGES STOPPED FUNCTIONING. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 82,000 AND THE CURRENT MILEAGE WAS 82,300.

TL* THE CONTACT OWNS A 2003 VOLVO S60. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE BEGAN TO DECELERATE INDEPENDENTLY TO APPROXIMATELY 5 MPH. THE CONTACT STOPPED THE VEHICLE ON THE SHOULDER AND SHUT THE ENGINE OFF. AFTER RESTARTING, THE CONTACT WAS ABLE TO DRIVE NORMALLY. THE VEHICLE WAS TAKEN TO THE DEALER THREE TIMES FOR DIAGNOSTIC TESTING. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE THIRD TIME THE VEHICLE WAS TAKEN TO THE DEALER, THE TECHNICIAN REPLACED THE ECM. THE FAILURE CONTINUED AFTER THE REPAIR. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE THE TURBO WAS REPLACED BUT TO NO AVAIL. THE VEHICLE WAS NOT FURTHER REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 38,000.

THE DASH INFORMATION SYTEM WILL RANDOMLY GO BLANK AND DISPLAY SRS AND BRAKE FAILURE, ALONG WITH ALL INFORMATION LIGHTS BLINKING ON AND OFF. ALSO THE ANALOG GAUGES LIKE THE SPEEDOMETER AND FUEL GAUGE WILL GO TO "0" AND EMPTY OR JUST MOVE ERATICALLY TO ANY NUMBER OR POSITION WHILE DRIVING. AT NIGHT SOMETIMES THE ENTIRE DASH OR INFORMATION CENTER WILL GO BLACK (NO LIGHTS AT ALL) AND ON ODD OCCASIONS ONE HEADLIGHT MAY GO OUT AND COME BACK ON. *TR

WHILE DRIVING OUT OF A PARKING LOT AND ACCELERATING TO 35 MPH, ENTIRE DASHBOARD BLACKED OUT. NO SPEEDOMETER, NO ODOMETER, NO GAS GAUGE,NO MESSAGE. RADIO, WINDOWS, AND AIR CONDITIONING CONTINUED TO WORK NORMALLY, AS DID HEADLIGHTS, INTERIOR LIGHTS, AND TURN SIGNALS. I TURNED OFF ENGINE AND THEN RESTARTED CAR. SAME SYMPTOMS. THE THIRD TIME I RESTARTED CAR I RECEIVED MESSAGE ON PANEL, SRS/AIRBAG SERVICE URGENT LIGHT COMES ON AND STAYS ON. I COULD NOT RETRIEVE ANY OTHER INFORMATION REGARDING AVERAGE SPEED, HOW FULL GAS TANK IS, ETC. I JUST WENT OUT TO MY CAR, WHICH HAS BEEN PARKED FOR ABOUT 21/2 HOURS SINCE THE INCIDENT, TO GET THE MILEAGE FOR THIS REPORT AND PANEL LIGHTS HAVE DISAPPEARED AGAIN! I WILL GET CAR TO MECHANIC TOMORROW, BUT I FEEL THIS IS A VERY DANGEROUS SITUATION TO BE IN,AND ESPECIALLY WITH NIGHT TIME OR HIGH SPEED HIGHWAY DRIVING! MY MILEAGE IS APPROXIMATELY...

THE ENTIRE INSTRUMENT PANEL WENT DEAD, AND WILL NOT COME BACK TO LIFE. THE TACHOMETER, ODOMETER, SPEEDOMETER AND FUEL GAUGE ARE OFF AS THOUGH THE CAR IS OFF. SEVERAL MECHANICS HAVE QUOTED ME $1200+ TO REPLACE THE ENTIRE INSTRUMENT PANEL. THE INSTRUMENTS WENT DEAD WHILE I WAS ON THE INTERSTATE AND LEAVE ME WITHOUT THE INFORMATION I NEED TO SAFELY DRIVE. VOLVO SHOULD RECALL THESE VEHICLES AND REPLACE THE FAULTY PARTS, THERE A QUITE A FEW FORUMS ON THE INTERNET WHERE OTHER VOLVO DRIVERS HAVE THE SAME INSTRUMENT FAILURE. *TR

VEHICLE BEGAN DISPLAYING CONFLICTING SPEED INFORMATION, ALONG WITH INTERMITTENT WARNING LAMPS. SPEEDOMETER FROZE AT CURRENT SPEED DURING DECELERATION, THEN GAUGES BEGAN TO FLUTTER SIDE TO SIDE. *TR

SINCE ABOUT THREE MONTHS AFTER I GOT MY CAR IN 2010 THE ENTIRE DASHBOARD SYSTEM DOES NOT WORK. THE GAUGES DO NOT MOVE OR TURN ON WHATSOEVER AND THE LIGHTS DO NOT COME ON. I HAVE LOOKED ON VOLVO FORUMS AND IT SAYS THAT THE MOTOROLLA CHIP IN THE DASHBOARD IS DEFECTIVE IN ALL OF THE 2001-2003 MODELS. IT IS RATHER SCARY IN MY OPINION NEVER KNOWING HOW MUCH GAS I HAVE OR HOW FAST I AM GOING. *TR

1) ELECTRIC READING OF DASHBOARD GOES COMPLETELY DARK. UNABLE TO DETERMINE SPEED, FUEL, ENGINE TEMPERATURE, ECT. URGENT AIR BAG WARNING LIGHT WENT ON PRIOR TO IT GOING DARK. CAR SKIPS GEARS AND REVS WHEN GAS PEDAL IS PRESSED. 2) RADIATOR COOLING FAN KEEPS RUNNING WHEN CONNECTED EVEN WHEN VEHICLE IS TURNED OFF. IT NEVER TURNS OFF UNTIL BATTERY IS DRAINED. REPLACED ENTIRE UNIT AS WELL AS BATTERY AND STILL HAS THE SAME PROBLEM. VOLVO REPAIR STATED THEY NEVER HAD AN ISSUE LIKE THIS AND ISSUE MAYBE CONNECTED TO FAILED ELECTRICAL SYSTEM. *TR

CAR EXPERIENCES LOSS OF POWER, STALLING, SPUTTERING AND HESITATION WHEN GAS PEDAL IS PRESSED DOWN. SAN LUIS OBISPO SMITH VOLVO AUTHORIZED DEALER COULD NOT FIND ANY CODES TO EXPLAIN THIS. CHECKED TIMING SENSORS, FUEL PRESSURE, RPM CAM SIGNALS, ETH SYSTEM, AIR FLOW METER, MAP SENSOR. ALL CHECKED OUT OK, DEALER SAID ALL SIGNS POINT TO ETA FAILING. CAR STALLS AND LOSES POWER ABRUPTLY, I DO NOT FEEL SAFE DRIVING IT ANYMORE. THERE IS A RECALL FOR MODELS UP TO 2002, THIS 2003 S60 NON TURBO MANUAL SEEMS TO EXHIBIT THE FLAWS OF ELECTRONIC THROTTLE FAILURE. *TR

I AM THE OWNER OF A 2003 VOLVO S60, THIS VEHICLE HAS BEEN A HEADACHE FOR SOME TIME NOW. THE FIRST ISSUE STARTED WITH THE HEADLIGHTS BLOWING OUT. I HAVE HAD THE CAR SINCE 2008 AND THE LIGHTS HAVE BLOWN OUT ATLEAST 10X'S. THE 2ND MAJOR ISSUE I'M HAVING WITH THE VEHICLE IS THE CAR COMPLETELY SHUTS DOWN WITHOUT WARNING WHEN MAKING A TURN OR SOMETIMES SITTING IDLE AT A RED LIGHT. OF COURSE WHEN THE CAR IS HOOKED UP TO A DIAGNOSTIC MACHINE THERE ARE NO ERROR CODES AND SINCE THIS ISSUE HAPPENS WITHOUT WARNING IT NEVER HAPPENS WHEN A SERVICE TECH IS WITH ME. LASTLY, TWO DAYS AGO I STARTED MY VEHICLE AND THE ENTIRE DASH COMPLETELY BLACKED OUT. NONE OF THE GAUGES ARE OPERABLE. I CANNOT SEE WHETHER I HAVE FUEL OR NOT IN IT. I FEEL THAT THE MANUFACTURER OF THIS VEHICLE SHOULD BE HELP RESPONSIBLE...

MY INSTRUMENT CLUSTER HAS BEEN MALFUNCTIONING UNTIL IT WENT COMPLETELY BLANK, OCCASIONALLY IT WILL LIGHT UP, THIS IS A SAFETY CONCERN SINCE UNABLE TO SEE SPEEDOMETER OR VEHICLE FAULT LIGHTS. *KB

2003 VOLVO S60 AW DASHBOARD FAILURE. I UNDERSTAND FROM TALKING WITH AUTO MECHANICS THIS IS A COMMON PROBLEM AND IS ALSO RECOGNIZED BY AUTO ELECTRICAL REPAIR SITES. THIS EXTREMELY DANGEROUS WITH THIS LOSS OF EQUIPMENT. *TR

COMPLIANT 1: I HAVE A 2003 S60 VOLVO. THE INSTRUMENT PANEL GOES DARK AND ALL INSTRUMENTS STOP WORKING. THIS INCLUDES ALL GAUGES, SPEEDOMETER, RPM, FUEL, TEMP AND BLINKERS. THEY ALL GO TO ZERO AND PANEL TURNS BLACK AND COMPLETELY OFF. THE EXTERIOR BLINKERS DO STILL WORK. WHEN THE PANEL IS WORKING I RECEIVE VARIOUS MESSAGES SUCH AS SRS AIRBAG SERVICE URGENT, BRAKE FAILURE, AND STOP IMMEDIATELY NO OIL PRESSURE. I TOOK THE CAR TO MY MECHANIC AND HE SAID IT'S THE DRIVER INFORMATION MODULE WHICH COSTS $1300 TO REPLACE. MY MECHANIC ALSO STATED THAT THIS IS A REOCCURING PROBLEM IN THIS CAR. I HAVE DONE RESEARCH ON THE INTERNET AND HAVE FOUND THAT THERE ARE MANY VOLVO'S OF THE SAME MAKE AND MODEL IN WHICH THE SAME EXACT PROBLEMS ARE OCCURING. I FEEL THAT THE MANUFACTURER SHOULD BE RESPONSIBLE FOR FIXING THIS PROBLEM. IT'S OBVIOUS THAT IT'S A RECURRING PROBLEM....

FOR SEVERAL WEEKS I HAVE INTERMITTENT ISSUES WITH ODD CODES SHOWING UP ON THE DASH BOARD AND THEN THE CAR NOT STARTING. I TOOK IT IN AND NO ONE COULD FIND ANYTHING WRONG. THIS WEEK DRIVING HOME FROM WORK ON THE HIGHWAY THE CAR WENT INTO FULL SHUT DOWN. (EXTREMELY DANGEROUS !!!!) I MANAGED TO GET THE CAR TO THE SIDE OF THE ROAD AND WAS ABLE TO RESTART A FEW MINUTES LATER AND DROVE THE CAR HOME WITH THE FLASHERS ON AND REMAINING IN THE RIGHT LANE IN CASE OF A REPEAT. I WAS IN THE FAR LEFT LANE KEEPING UP WITH RUSH HOUR TRAFFIC WHEN THE CAR DIED INITIALLY. IT APPEARS THAT THIS IS A COMMON PROBLEM WITH VOLVOS AND I AM HOPING THAT SOMETHING WILL BE DONE AS THIS IS VERY DANGEROUS. *TR

TL* THE CONTACT OWNS A 2003 VOLVO S60. THE CONTACT STATED THAT THE ENTIRE INSTRUMENT PANEL FAILED, INCLUDING ALL GAUGES AND WARNING LIGHTS. IN ADDITION, THE CONTACT STATED THAT THE BRAKES WERE AFFECTED BY THE FAILURE. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FACILITY WHERE THE FAILURE WAS DIAGNOSED AS THE INSTRUMENT PANEL CONTROL MODULE. THE MANUFACTURER WAS CONTACT AND ADVISED THAT THE VEHICLE WAS OUT OF WARRANTY THEREFORE, THEY WERE NOT ABLE TO ASSIST WITH THE REPAIR. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 89,000.

I HAVE A 2003 S600 AND THE INSTRUMENT PANEL GOES DARK AND ALL THE INSTRUMENTS STOP WORKING (SPEEDOMETER, RPM, FUEL, TEMP -- ALL GO TO ZERO) . THIS OCCURS INTERMITTENTLY, WHILE DRIVING, THE ENGINE WAS RUNNING FINE AND NO WARNING LIGHTS CAME ON. I AM ALSO EXPERIENCING PROBLEMS WITH INDICATOR LIGHTS ON THE DASHBOARD. AS AN EXAMPLE, THE BLINKER LIGHTS ON THE DASHBOARD ONLY WORK ABOUT 20% OF THE TIME. THE ACTUAL DIRECTIONALS ON THE EXTERIOR OF THE CAR ARE STILL WORKING ALL OF THE TIME. THE CONDITION SEEMS TO BE GETTING PROGRESSIVELY WORSE. IN ADDITION VARIOUS MESSAGES HAVE APPEARED -- SUCH AS SRS AIRBAG SERVICE URGENT, BRAKE FAILURE - STOP SAFELY. BROUGHT IT TO MY MECHANIC AND HE HAD TO REPLACE THE DRIVER INFORMATION MODULE (DIM) $1,300. HE STATED THAT HE HAS REPLACED 4 DIM'S WITHIN THE PAST MONTH. APPEARS TO BE A COMMON FAILURE WITH 2003 S60 MODEL....

MY 2003 VOLVO S60 HAS A SEATBELT WARNING MESSAGE. THE DEALER DIAGNOSED THE PROBLEM AS A FAULTY DRIVER INFORMATION MODULE WHICH WOULD COST 1400 PLUS TAX TO REPAIR. THE CAR IS VALUED AT APPROXIMATELY 4000 AS A TRADE. THERE ARE MANY COMPLAINTS OF FAILURE OF THIS PART EVEN IN MUCH NEWER VOLVOS. *TR

2003 VOLVO S60 EXPERIENCED "DEATH" OF DRIVER INFORMATION MODULE (DIM), WHICH MONITORS ALL GAUGES ON THE VEHICLE. DEALERSHIP IS ABLE TO REPLACE THE PART FOR $1500! IT NOT AVAILABLE "AFTER MARKET" BY ANOTHER MANUFACTURER. RESEARCH ONLINE SHOWS THIS IS A VERY COMMON PROBLEM AMONG 2001-2003 MODELS. THIS MAJOR SAFETY CONCERN SHOULD BE INVESTIGATED, AS NUMEROUS PEOPLE ARE DRIVING WITHOUT DASH PANEL INFORMATION DUE TO THE EXORBITANT COST. THE PROBLEM BEGAN APPROXIMATELY TWO WEEKS AGO AND CANNOT BE REMEDIED WITHOUT BUYING THE DIM. *TR

ON 12 DEC, 2008, MY 2003 VOLVO S60 STALLED WITH NO WARNING WHILE TRAVELING ON A BUSY HIGHWAY AT 60 MPH. I PULLED TO SAFETY (VEHICLE WAS IN "LIMP HOME" MODE) AND HAD THE VEHICLE TOWED TO THE DEALERSHIP (PARK PLACE VOLVO). SINCE THE VEHICLE STARTED RIGHT BACK UP AND PRESENTED NO CODES, I WAS TOLD THERE WAS NOTHING WRONG AND GIVEN A BILL FOR $418 (FOR TOW AND DIAGNOSTIC CHECK). APPROX. 1 MONTH LATER, VEHICLE PRESENTED SAME PROBLEM; IT STALLED, WITHOUT WARNING, WHILE DRIVING... CREATING A GREAT SAFETY RISK FOR THE SECOND TIME. I HAD VEHICLE TOWED AGAIN TO SAME DEALERSHIP, AND SINCE VEHICLE STARTED RIGHT BACK UP WITH NO CODES, I WAS TOLD THERE WAS NOTHING WRONG. DEALERSHIP COULD NOT GET VEHICLE TO DUPLICATE PROBLEM ON EITHER OCCASION. HOWEVER, TO APPEASE ME, DEALERSHIP DID REPLACE ACCELERATOR PEDAL...VEHICLE STILL PRESENTS SAME STALLING ISSUE, AND INTERMITTENTLY GOES INTO "LIMP HOME"...

THE CAR STALLED REPEATEDLY WHILE THE ENGINE WAS IDLING. ALL POWER WAS LOST MAKING THE CAR VERY DIFFICULT TO STEER AND BRAKE. I NEARLY GOT INTO SEVERAL ACCIDENTS THE ENGINE STALLED WHILE: 1) STOPPED AT A RED LIGHT 2) WHILE SHIFTING GEARS ON THE HIGHWAY 3) WHILE SHIFTING GEARS IN HEAVY TRAFFIC I TOOK THE CAR TO THE DEALERSHIP 4 TIMES BEFORE THE PROBLEM CORRECTLY FIXED. THE FOLLOWING ITEMS WERE REPLACED BUT DID NOT FIX THE PROBLEM: 1) FUEL PUMP 2) MAP SENSOR (REPLACED 2 TIMES) NEITHER OF THESE FIXES WORKED. THE PROBLEM WAS CORRECTED AFTER MODIFYING THE SOFTWARE ON THE COMPUTER BOARD. *JB

DT: IN APRIL THE VEHICLE STALLED WHEN MAKING A RIGHT HAND TURNS. DID THE SAME THING A FEW DAYS LATER. TOOK VEHICLE TO THE DEALER, THEY CHECKED THE VEHICLE AND THEY HADN'T HEARD OF THIS BEFORE. SOME KIND OF PLATE HAD TO BE CLEANED . THE VEHICLE JUST TURNED 30,000 MILES. THEN A MONTH LATER WHILE MERGING AT 55 MPH THE VEHICLE DIED. IT DID START AGAIN. BROUGHT THE VEHICLE BACK TO DEALER, THEY KEPT THE CAR A WEEK AND DID TESTING, AND CLAIMED ONE OTHER PERSON HAD THE SAME COMPLAINT. THEY DID THE SAME THING TO CONSUMER'S VEHICLE THAT THEY DID TO OTHER PERSON' VEHICLES. THEN, DEALER SAID THERE WAS A RECALL. *AK

DURING NORMAL CITY AND HIGHWAY DRIVING, MY 2003 VOLVO S-60 SEDANS ENGINE AND ELECTRICAL SYSTEM SUDDENLY FAILS WITHOUT WARNING, RESULTING IN A DANGEROUS COMPLETE LOSS OF POWER AND CONTROL OF THE VEHICLE. THE DANGEROUS INCIDENT HAS OCCURRED NUMEROUS TIMES. THE ORIGINAL DEALER, WARREN HENRY VOLVO, AND VOLVO NORTH AMERICA, WERE BOTH NOTIFIED OF THE VOLVOS HAZARDOUS PROBLEM, AND THE VEHICLE HAS BEEN IN SERVICE AND REPAIR ON THREE SEPARATE OCCASIONS FOR THE SAME PROBLEM WITHOUT SATISFACTORY RESOLUTION. TO DATE, THE 2003 VOLVO S-60 EXHIBITS THE SAME DANGEROUS PROBLEMS.*JB

DT: VEHICLE STALLED FOR NO APPARENT REASON. THE VEHICLE WAS TAKEN TO THE DEALERSHIP THREE TIMES BUT THEY COULD NOT FIND ANY CAUSE. THERE WAS NO WARNING AND THE VEHICLE COULD BE STARTED BACK UP. CONSUMER STATED THAT THIS OCCURRED AT LEAST 6 TIMES, AND THEY DID NOT DRIVE THE VEHICLE ANYMORE. THIS STARTED IN MARCH 2005.*AK