2003 VOLVO S60 Exterior Lighting Problems

The problem is when the weather turns cold my car a Volvo 2003 S 60 turn signals do not operate, or if they do turn on sometimes the turn signals won't stop flashing until you turn the ignition off. The head lights also will not turn on at any setting during this time. When the weather turns warm again everything works until the weather turns cold again. It appears to be related to the CENTRAL ELECTRONIC MODULE. It happens every time the weather is cold. It happen very unexpectedly my wife was driving down the road and was almost in an accident. The turn signals switch has already been replaced with a new Volvo turn signal switch.The turn signal still does not work. According to XEMODEX.INC this is a common problem for Volvo's S 60 2001-2010.

I HAVE A 2003 S60 VOLVO. THE INSTRUMENT PANEL WAS FINE YESTERDAY, BUT WHEN I GOT IN THE CAR TODAY THE PANEL INSTRUMENT PANEL IS COMPLETELY BLACK. THIS INCLUDES ALL GAUGES, SPEEDOMETER, RPM, FUEL, TEMP AND BLINKERS, ALL GAUGES ARE OFF.. (SEE ATTACHED PIC). THE VEHICLE WAS STATIONARY IN MY DRIVEWAY. THE CAR STILL RUN GREAT.

I AM SURPRISED THERE HAS NOT BEEN A RECALL ISSUED FOR CERTAIN MODEL YEAR VOLVOS RELATIVE TO THE CENTER DASH MODULE LOSING ALL COMMUNICATION APPARENTLY DUE TO FAILED SOLDER CONNECTIONS (BASED ON CHAT-ROOMS, VOLVO SPECIFIC). I UNDERSTAND COMPONENTS CAN FAIL, BUT THE SHEER NUMBER OF FAILURES AND THE FAILURE MODE IS BEYOND TYPICAL OR EXPECTED FAILURES. THE FAILURE MODE CAUSES MOST OR ALL DASH GAUGES, INDICATORS AND LIGHTS TO FAIL, INCLUDING THE SPEEDOMETER. THESE FAILURES APPARENTLY OCCUR RANDOMLY, AND AT ANY AGE/MILEAGE.

WHILE DRIVING HOME AFTER HAVING STEERING RACK REPLACED THE DASH LIGHTS (SPEEDOMETER, TURN SIGNALS, MESSAGE CENTER, ETC.) WENT COMPLETELY OUT. AFTER MULTIPLE DRIVES THE DASH LIGHTS GO ON AND OFF INTERMITTENTLY WHILE DRIVING.

DRIVING CAR LIGHTS ON DASH BOARD WENT COMPLETELY OFF. TOOK IT TO SHOP THEY TAP IT AND DASH CAME ON AGAIN, CHANGE FUSE . LIGHTS WENT OFF AGAIN AND STAYED OFF. *TR

MY 2003 S60 VOLVO HAS FAILED IT ALL STARTED WITH THE RADIO FLICKERING TO DIFFERENT STATIONS.I NOTICED FROM THAN MY LIGHTS STARTED BLINKING ON AND OFF I HAS NO IDEA WHAT WAS GOING ON WITH THIS CAR I SERIOUSLY ALMOST GOT INTO IN ACCIDENT I PULLED OVER AND TURNED THE CAR OFF 5MINS AFTER I STARTED IT UP NOW ALL THE GUAGES WHERE DOWN EVE FUEL WAS PASS EMPTY I WAS TERRIFIED THAT MY CAR WOULD SHUT OFF I HAD MY 7 YEAR OLD IN THE CAR AS I WAS CAREFULLY WAS DRIVING HOME THE GUAGES STARTING MOVING ALL OVER THE PLACE RADIO SWITCHING FROM LEFT TO RIGHT THE MSG WINDOW SAID SEA BAG SERVICE SOON IAM VERY SCARE OF MY SAFETY JUS BOUGHT THIS CAR ON FEB 12/2013. *TR

WHILE DRIVING OUT OF A PARKING LOT AND ACCELERATING TO 35 MPH, ENTIRE DASHBOARD BLACKED OUT. NO SPEEDOMETER, NO ODOMETER, NO GAS GAUGE,NO MESSAGE. RADIO, WINDOWS, AND AIR CONDITIONING CONTINUED TO WORK NORMALLY, AS DID HEADLIGHTS, INTERIOR LIGHTS, AND TURN SIGNALS. I TURNED OFF ENGINE AND THEN RESTARTED CAR. SAME SYMPTOMS. THE THIRD TIME I RESTARTED CAR I RECEIVED MESSAGE ON PANEL, SRS/AIRBAG SERVICE URGENT LIGHT COMES ON AND STAYS ON. I COULD NOT RETRIEVE ANY OTHER INFORMATION REGARDING AVERAGE SPEED, HOW FULL GAS TANK IS, ETC. I JUST WENT OUT TO MY CAR, WHICH HAS BEEN PARKED FOR ABOUT 21/2 HOURS SINCE THE INCIDENT, TO GET THE MILEAGE FOR THIS REPORT AND PANEL LIGHTS HAVE DISAPPEARED AGAIN! I WILL GET CAR TO MECHANIC TOMORROW, BUT I FEEL THIS IS A VERY DANGEROUS SITUATION TO BE IN,AND ESPECIALLY WITH NIGHT TIME OR HIGH SPEED HIGHWAY DRIVING! MY MILEAGE IS APPROXIMATELY...

I AM THE OWNER OF A 2003 VOLVO S60, THIS VEHICLE HAS BEEN A HEADACHE FOR SOME TIME NOW. THE FIRST ISSUE STARTED WITH THE HEADLIGHTS BLOWING OUT. I HAVE HAD THE CAR SINCE 2008 AND THE LIGHTS HAVE BLOWN OUT ATLEAST 10X'S. THE 2ND MAJOR ISSUE I'M HAVING WITH THE VEHICLE IS THE CAR COMPLETELY SHUTS DOWN WITHOUT WARNING WHEN MAKING A TURN OR SOMETIMES SITTING IDLE AT A RED LIGHT. OF COURSE WHEN THE CAR IS HOOKED UP TO A DIAGNOSTIC MACHINE THERE ARE NO ERROR CODES AND SINCE THIS ISSUE HAPPENS WITHOUT WARNING IT NEVER HAPPENS WHEN A SERVICE TECH IS WITH ME. LASTLY, TWO DAYS AGO I STARTED MY VEHICLE AND THE ENTIRE DASH COMPLETELY BLACKED OUT. NONE OF THE GAUGES ARE OPERABLE. I CANNOT SEE WHETHER I HAVE FUEL OR NOT IN IT. I FEEL THAT THE MANUFACTURER OF THIS VEHICLE SHOULD BE HELP RESPONSIBLE...