2003 VOLKSWAGEN PASSAT Electrical System Problems

I PURCHASED A USED 2003 VW PASSAT FROM A PRIVATE DEALER DROVE THE CAR FIVE MONTHS AND THE TIMING BELT CAME OFF WHILE I WAS DRIVING. I ALMOST GOT INTO AN ACCIDENT BUT AVOIDED IT. THIS PARTICULAR VEHICLE AND ONES LIKE IT WAS RECALLED IN 3/7/2014 FOR ENGINE AND ENGINE COOLING ENGINE PROBLEMS THAT CAUSES THE TIMING BELT TO COME OFF WHILE DRIVING. RECALL: 14E007000 BECAUSE OF THE TIMING BELT FAILURE. I CONTACTED A VW DEALERSHIP AND THEY SAID THE RECALL DIDN'T APPLY TO MY CAR. I FIND THAT INSULTING CONSIDER ING WHAT I JUST EXPERIENCED.

TL* THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT IT TOOK MULTIPLE ATTEMPTS FOR THE VEHICLE TO BECOME OPERABLE EVEN WHEN THE STARTER WAS ENGAGED. THE VEHICLE ALSO EXPERIENCED AN INTERIOR WATER LEAK AND THE DRIVER SIDE DOOR LATCH WOULD NOT PROPERLY LATCH. IN ADDITION, THE VEHICLE EXPERIENCED A COMPLETE LOSS OF ENGINE POWER AND THE CHECK ENGINE, BRAKE, AND VARIOUS OTHER WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED AS A SOFTWARE FAILURE, AND THE IGNITION COIL SPRINGS WERE DEFECTIVE AND NEEDED TO BE REPLACED. THE IGNITION COIL SPRINGS WERE REPLACE HOWEVER THE FAILURE RECURRED. THE MANUFACTURER AND DEALER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 190,000.

TL* THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. WHILE DRIVING 45 MPH, THE VEHICLE JERKED AND STALLED. THE VEHICLE INADVERTENTLY SHIFTED IN REVERSE AND THE BRAKES STOPPED WORKING. THE CONTACT HAD TO APPLY THE PARKING BRAKE. THE CONTACT MENTIONED THAT THE GEAR SHIFTER WAS STUCK IN PARK. ALSO, THE CHECK ENGINE, TIRE PRESSURE, AND EPC INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO HERITAGE VOLKSWAGEN OF SOUTH ATLANTA AT (678) 263-3711 (4305 JONESBORO RD, UNION CITY, GA 30291) WHERE IT WAS DIAGNOSED THAT THE IGNITION CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND CONFIRMED THAT THERE WERE NO RECALLS ASSOCIATED WITH THE VIN. THE CONTACT WAS ADVISED TO CALL NHTSA. THE APPROXIMATE FAILURE MILEAGE WAS 172,000.

TL* THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING WHILE DRIVING AT VARIOUS SPEEDS. THE FAILURE WAS EXPERIENCED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO PERFORMED DIAGNOSTIC TESTING. THE ENGINE OXYGEN SENSOR, COIL SPRING, SPARKS PLUGS, AND WIRES WERE REPLACED; HOWEVER, THE FAILURE WAS NOT CORRECTED. THE CONTACT STATED THAT THE TAIL LIGHTS ALSO FAILED. THE TAIL LIGHTS WERE NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 130,000.

DRIVING AT NIGHT, 65MPH, INTERSTATE HWY. LOW BEAM HEADLIGHTS WENT OUT. HIGH BEAMS DID WORK. REPLACED BOTH HEADLIGHT BULBS. DID NOT FIX. COST $95. REPLACE HEADLIGHT RELAY. DID NOT FIX. COST IN EXCESS OF $200. RECALL FOR LATER YEAR PASSAT FOR SAME PROBLEM CAUSED BY "HOOD SLAM?"

CYLINDERS MISFIRE CAUSING ACCELERATION HESITATION. SPARK PLUGS AND COIL WERE REPLACED FEB.2009, DEC. 2013, AUG. 2014, JUNE 2015. THE CONDITIONS ARE REPETITIVE AND IDENTICAL.

CAR WAS CONSTANTLY GETTING THE PASSENGER SIDE (FRONT AND BACK) FLOODED W WATER DURING A RAIN STORM. HAD TO GET NEW BATTERY CLEANED OUT SUNROOF DRAINAGE. IT DIDN'T MATTER. WHENEVER IT RAINED THE BATTERY WOULD BE DEAD BECAUSE THE CONTROL MODULE WHICH IS THERE IS ALL MESSED UP SENDING MIXED MESSAGES. FINELY JUST DIED IN THE MIDDLE OF THE ROAD. NOT WORTH PUTTING MONEY INTO THE CAR. I PURCHASED THIS CAR LESS THEN A YEAR AGO AND HAD THIS PROBLEM AFTER THE FIRST RAIN AND WENT DOWN FROM THEIR. IM SO DISAPPOINTED HOPING BUYING A USED VW I WAS GOING TO BE SATISFIED BUT HAD NOTHING TROUBLE FROM DAY ONE. *TR

ABS MODULE FAILURE, ABS LIGHT ON BRAKE LIGHT BLINKING AND THEN ASR LIGHT ON, HAPPENS RANDOMLY, NO SPECIFIC REASON, DRY WEATHER, HUMID, DAY OR NIGHT. STILL COMES ON RANDOMLY, NO SPEEDING, PROBLEM GOES AWAY WHEN CAR IS TURNED OFF. *TR

THE TURN SIGNAL WOULD CONTINUE TO MAKE A CLICKING NOISE EVEN AFTER THE SIGNAL HAD BEEN SHUT OFF. THIS CONTINUED TO HAPPEN FOR SEVERAL MINUTES AND THEN SMOKE BEGAN TO RISE FROM BEHIND MY STEERING WHEEL WHERE THE TURN SIGNAL ENTERS THE WHEEL CONSOLE. I BEGAN TO PULL OVER AT THE NEXT SAFE AREA AND BEFORE I COULD I NOTICED SMALL FLAMES COMING FROM THE SAME AREA WHERE THE TURN SIGNAL ENTERS THE WHEEL CONSOLE. WHEN I TURNED OFF THE CAR THE SMOKE/FIRE SLOWLY SUBSIDED. I ENDED UP REMOVING THE TURN SIGNAL FUSE IN ORDER TO DRIVE TO A REPAIR SHOP. AFTER SOME RESEARCH THIS SEEMS TO BE A COMMON ISSUE WITH NO RECALLS ISSUED YET. *TR

TL* THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. WHILE DRIVING APPROXIMATELY 20 MPH, THE CONTACT NOTICED SMOKE COMING FROM UNDER THE HOOD AND POURING INSIDE THE VEHICLE. THE CONTACT FOUND WATER AND COOLANT LEAKING FROM THE DASHBOARD AND ONTO THE DRIVER'S SIDE OF THE VEHICLE. THE VEHICLE WAS ALSO OVERHEATING. AFTER EXITING THE VEHICLE, THE CONTACT NOTICED FLAMES COMING FROM UNDER THE HOOD. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE HOWEVER, THE CONTACT SUSTAINED BURNS TO HER LEGS DUE TO THE HOT LEAKING COOLANT. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THAT THE ENGINE BLEW AND THE INSTRUMENT PANEL CLUSTER WAS DAMAGED. THE CONTACT WAS UNAWARE OF WHAT CAUSED THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 174,256.

COILS FAILING RANDOMLY AND CAUSING THE CAR TO SHAKE VIOLENTLY AND LOSE POWER ON HIGHWAY. POTENTIAL DAMAGE TO BE CAUSED TO OTHER AREAS OF THE CAR BECAUSE OF THIS. IE OXYGEN SENSOR ETC. *TR

HEATED SEAT COILS OVERHEATED AND BURNT SEAT ON DRIVER SIDE. 1 YEAR AFTER RECALL WAS DONE BY [XXX] VW BROCKTON MA, THEY TOLD ME THE HEATERS IN THE SEAT ARE NO LONGER UNDER WARRANTY AND TOLD ME TO CALL VW USA WITH MY PROBLEM, INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

MY 2003 VOLKSWAGAN PASSAT WAGON HAS ROOF/CHASSIS DRAINS THAT ARE BACKING UP INSIDE THE VEHICLE CAUSING THE VEHICLE ELECTRONICS TO SHORT OUT AND FAIL. MY REAR DOOR WILL NOT OPEN. THIS IS A SAFETY ISSUE. *TR

TL* THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE MALFUNCTION INDICATOR WARNING LIGHT ILLUMINATED INTERMITTENTLY, CAUSING THE VEHICLE TO SHAKE EXCESSIVELY. THE DEALER MADE SIX ATTEMPTS TO DIAGNOSE THE FAILURE BUT TO NO AVAIL. THE MANUFACTURER WAS NOTIFIED WHO CONTACTED THE LOCAL DEALER BUT OFFERED NO ADDITIONAL ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE CURRENT MILEAGE WAS 91,252 AND THE FAILURE MILEAGE WAS APPROXIMATELY 89,000.

I WAS DRIVING MY VW PASSAT 1.8L TURBO STATIONWAGON AT A SPEED OF 40 MILES PER HOUR AND THE CAR SUDDENLY STALLED WITHOUT ANY WARNING. MY FOUR MONTH OLD BABY WAS IN THE BACK IN HIS CARSEAT AND HAD I BEEN IN A DIFFERENT SETTING WE BOTH COULD HAVE BEEN INJURED OR KILLED. THIS WAS THE FIRST TIME IT HAD OCCURRED AND ONCE I TOOK IT TO THE MECHANIC THE CAR STARTED AND DROVE FINE AND THEY COULD NOT DUPLICATE THE PROBLEM. THEY INFORMED ME THAT IT WAS LIKELY A PARTS RECALL ISSUE: RECALL: 07V375000: FUEL PUMP REPLACEMENT. I CONTACTED VW AMERICA, INC. AND WAS INFORMED THAT WHILE IN FACT THERE WAS SUCH A RECALL FOR 2003 PASSATS, MY VIN NUMBER WAS NOT COVERED IN THE RECALL AND THUS THERE WAS NOTHING THEY COULD/WOULD DO TO HELP ME DESPITE THE FACT THAT THE PROBLEM APPEARS TO BE THE VERY ONE...

VW 2003 PASSAT AWD 2.8 L V6 GASOLINE ENGINE...WIFE CALLED ME SAID CAR WAS MISS FIRING BADLY AND THEN SMOKE WAS REPORTED COMING FROM UNDERNEATH CAR. SHE PULLED OVER AND SAW FLAMES COMING FROM UNDERNEATH THE CAR. TURNED CAR OFF AND FIRE LUCKILY WENT OUT...I CHANGED COIL AND PROBLEM WAS FIXED FOR ABOUT THREE MONTHS. NOW CAR IS MISS FIRING AGAIN AND RUNNING ROUGH....I HATE THAT I'VE FIXED THIS SAME COIL THREE TIMES NOW AND IT IS ACTING UP AGAIN... *TR

I PURCHASED A 2003 PASSAT 6 MONTHS AGO. I HAVE HAD NOTHING BUT TROUBLE FROM IT. IT IS JUST ONE THING AFTER ANOTHER. I HAVE HAD TO TAKE IT IN TO BE FIXED ABOUT SIX TIMES. I CAN'T EVEN REMEMBER EVERYTHING I HAVE HAD TO HAVE FIXED. I DO REMEMBER THE LAST THING THOUGH. IT WAS THE TAIL LIGHTS, THE TAIL LIGHT WOULD NOT GO OUT EVEN WHEN I HAD NO LIGHTS ON AND EVEN WHEN THE CAR WAS TURNED OFF. MY CAR IS IN THE SHOP AGAIN RIGHT NOW. IT HAS BEEN THERE SINCE MONDAY DECEMBER 27TH. IT IS A FOUR CYLINDER AND HAS BEEN RUNNING ON THREE. I FOUND OUT FOR THE FIRST TIME MONDAY THAT MY CAR HAS 5 RECALLS ON IT. I WAS NEVER NOTIFIED OF NONE OF THEM. AFTER LEAVING IT FOR ALL THE RECALLS TO BE FIXED, I HAD TO RENT A CAR FOR...

I JUST READ THAT THE NHTSA WAS INVESTIGATING THE FAILURE OF COILS ON 2002/2003 VW PASSATS. I HAD A 2003 PASSAT THAT HAD THE NUMBER 2 CYLINDER COIL FAIL AT ABOUT 28,000 MILES IN 2007. THE DEALER REPLACED IT, BUT I HAD TO PAY APPROXIMATELY $150. AT ABOUT 29,000 THE NUMBER 4 CYLINDER COIL FAILED. I STILL HAD TO PAY ABOUT $100 WITH THE DEALER ABSORBING THE COST OF THE PART ITSELF. THE VW DEALER TOLD ME THAT VW DID NOT HAVE A PROBLEM WITH THEIR COILS OTHER THAN ON A RANDOM BASIS, AND THAT THERE WERE NO MANUFACTURING DEFECTS WITH THE COILS. THEY SAID THAT IT WAS JUST COINCIDENCE THAT I HAD TWO COILS FAIL. BECAUSE OF THE FAILURE OF TWO COILS AT RELATIVELY LOW MILEAGE I DECIDED THAT THE CAR WAS NOT RELIABLE, AND TRADED IT IN FOR A HONDA ACCORD. NOW IT APPEARS THAT VW DID HAVE...

I PURCHASED AN 03 VW PASSAT FROM A VW DEALER AS A CERTIFIED PRE-OWNED VEHICLE BACK IN 2/07. WITHIN THE FIRST WEEK OF PURCHASE I HAD BRAKE PROBLEMS. THE NEXT COUPLE YEARS WERE FOLLOWED BY VALVE COVER LEAKS, ENGINE LEAKS, AUTO WINDOW PROBLEMS, BATTERY PROBLEMS, RECALL ISSUES, WATER INTRUSION ISSUES, IGNITION COIL RECALL AND THE LIST GOES ON. AFTER A WATER INTRUSION JUST DAYS AFTER THE REPLACEMENT OF FAULTY IGNITION COILS I CONTACTED THE MANUFACTURE NOTIFYING THEM OF THE PROBLEMS. THE MANUFACTURE HAD HELD THEIR FOOT TO THE GROUND THAT MY CAR IS OUT OF WARRANTY (THAT I WAS TOLD AT TIME OF SALE I DID NOT HAVE) AND SO THEY ARE ABLE TO DO NOTHING ABOUT ANY OF THE PROBLEMS WITH THIS VEHICLE. HOWEVER AS IT STANDS I HAVE NEARLY $3000 IN REPAIRS NEEDED TO THIS VEHICLE. NOT TO MENTION THE WATER LEAK/DAMAGE FROM WHAT I UNDERSTAND MAY ACTUALLY...

ON APRIL 20, 2010 MY 2003 VOLKSWAGEN PASSATS CHECK ENGINE LIGHT CAME ON AT AROUND 4:45 PM. I IMMEDIATELY CALLED THE PLACE WHO DOES ALL MY REPAIR WORK, AND WAS TOLD I COULD DROP OFF THE CAR THAT NIGHT, AND THEY WOULD CHECK IT OUT THE FOLLOWING MORNING. I ARRIVED AT THE LOCATION AROUND 5:10, PARKED THE CAR AND WENT TO PLACE MY KEY IN THE NIGHT DROP BOX. WHEN I WALKED BACK TO THE CAR I SAW SMOKE COMING OUT FROM UNDER THE HOOD. I RAISED THE HOOD AND SAW FLAMES COMING FROM WHAT LOOKED LIKE UNDER THE BACK OF THE ENGINE COMPARTMENT. THEN I NOTICED THAT THERE WERE FLAMES COMING OUT FROM UNDER THE DASHBOARD INSIDE THE CAR. I CALLED 911 AND RAN TO A NEARBY GAS STATION TO GET A FIRE EXTINGUISHER. WHEN I GOT BACK TO THE CAR THERE WERE FLAMES VISIBLE INSIDE THE CAR. I...

RECALLED VW COIL FAILURE. *TR

WENT TO START MY CAR AND THE MALFUNCTION INDICATOR LAMP LIGHT WAS ON AND MY CAR WAS SHAKING UNCONTROLLABLY. I CALLED THE DEALERSHIP THEY HAD TOLD ME TO HAVE MY CAR TOWED IN. AS I DID, THE PROBLEM WAS THE IGNITION COILS, THEY DID MENTION THAT THERE WAS A RECALL ON THE 4 CYLINDERS AND THEY HAVE HAD SEVERAL PEOPLE COME IN WITH THIS PROBLEM AFTER THE ARTIC BLAST CAME THROUGH LAST WEEK. THE REASON WHY I'M WRITING IS BECAUSE I THINK ITS KIND OF WEIRD AFTER THIS RECALL CAME OUT SO MANY PEOPLE HAVE HAD THIS PROBLEM RECENTLY AND JUST WONDERING WHY THIS PARTICULAR PART IS NOT COVERED UNDER A RECALL FOR A V6. TO ME IT DOESN'T MAKE ANY SENSE WHY NOT, MY PROBLEM IS OCCURRING EXACTLY WHEN ALL THESE OTHER CARS ARE BEING RECALLED FOR THE SAME THING. *TR

TL*THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. WHILE DRIVING 40 MPH THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER, AND A TECHNICIAN REPLACED THE IGNITION COIL AT AN EXPENSE OF $403.00. THE FAILURE RESURFACED ONE YEAR AFTER THE VEHICLE WAS REPAIRED. AN AUTHORIZED TECHNICIAN CONCLUDED THAT THE IGNITION COIL FAILED AND CAUSED THE WIRING HARNESS, AND THE ENGINES COMPUTER TO BURN. THE VEHICLE WAS REPAIRED AT AN EXPENSE OF $887.97. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 83,000 AND THE CURRENT MILEAGE WAS 92,000. UPDATED 10/21/09. *LJ UPDATED 12/07/09. *LJ THE CONSUMER STATED IN ADDITION TO THE OTHER PROBLEM, THE FAILED STALLED ON THE HIGHWAY AND THE THE LIGHTS ON THE DASHBOARD ILLUMINATED. UPDATED 12/08/09

POLLEN FILTER AND/ OR SUNROOF DRAINS BECOME BLOCKED AND WATER LEAKS BEHIND BATTERY AND INTO CABIN OF CAR. THE WATER THEN POOLS UNDER AND BEHIND THE DRIVERS SEAT WHERE THE CONVENIENCE MODULE IS STORED. I AM CONCERNED BECAUSE IT CAUSED MY CAR TO BE UNABLE TO START BECAUSE IT IS AFFECTING THE ELECTRICAL COMPONENTS OF THE CAR. IN ADDITION, THE POOLING UNDER THE DRIVERS SEAT IS TROUBLING SINCE IT IS A HUB FOR INTERIOR ELECTRICAL EQUIPMENT. THE CONVENIENCE MODULE IN MY CAR NOW HAS TO BE REPLACED. *TR

I HAVE HAD MY 2003 VW PASSAT FOR 7 MONTHS NOW AND HAVE ALREADY HAD IT IN THE SHOP 3 TIMES. RIGHT AFTER I BOUGHT IT USED FROM A VW DEALERSHIP THE TURBO WENT OUT. I HAD TO PAY FOR THAT. I THEN DROVE THE CAR ABOUT 150 MILES FOR A TOURNAMENT AND WHEN ALMOST THERE A LIGHT CAME ON SAYING TO STOP AND TURN OFF THE ENGINE. TOOK IT TO VW DEALERSHIP AND IT WAS COVERED BY VW. IT HAD SOMETHING TO DO WITH SLUDGE FROM OIL. GOT IT BACK AND 3 DAYS LATER A LIGHT CAME ON. IT WAS THE MIL LIGHT. I TOOK IT IN TO THE VW DEALERSHIP. STILL WAITING TO HEAR WHAT THE PROBLEM IS THIS TIME. I HAVE NOW HAD MY OIL CHANGED 3 TIMES IN 5 THOUSAND MILES DUE TO REPAIRS. IT HAS BEEN ONE THING AFTER ANOTHER WITH THIS CAR SO FAR....

BRAKE FAILURE LIGHT APPEARS EVEN AFTER MULTIPLE BRAKE REPAIRS. DRIVER?S SIDE REAR UPPER BRAKE LIGHT REPLACED FOR 29TH TIME IN LESS THAN 2 YRS. MULTIPLE COOLANT LEAKS STILL PRESENT EVEN AFTER REPAIR AND WATER PUMP REPLACEMENT. RADIO/AMPLIFIER NOT FUNCTIONING EVEN AFTER REPLACEMENT (RADIO WAS ONLY USED TWICE IN VEHICLE?S LIFETIME). DIAGNOSTICS SHOW AIRBAG MALFUNCTION. REGULATOR PIN ON REAR PASSENGER SIDE WINDOW KEEPS BREAKING (3RD REPLACEMENT SINCE 2003). ENGINE COVER BELOW CAR KEEPS FALLING OFF DUE TO RUSTED BOLTS. HOMELINK SYSTEM KEEPS MALFUNCTIONING. FUSES KEEP BLOWING OUT. DASHBOARD PANEL LIGHTS OUT (ODOMETER, FUEL GAUGE, ETC.). CCM MODULE KEEPS BREAKING DOWN. CAR NEEDS TO BE JUMPSTARTED WHEN NOT IN USE FOR OVER 48 HRS. CLIMATE CONTROL (A/C AND HEATER) WORKS ONLY SPORADICALLY. ALL REPAIRS PERFORMED BY VW DEALERSHIP, YET SAME ISSUES KEEP REAPPEARING JUST A FEW WEEKS AFTER REPAIRS. REPAIRS PERFORMED IN PAST 2 YEARS: ECU UNIT REPLACED, BRAKE LIGHT SWITCH REPLACED...

TL*THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. WHILE DRIVING 65 MPH, THE VEHICLE SUDDENLY LOST POWER. THE VEHICLE WAS DRIVEN TO THE CONTACT'S HOME AND THEN TOWED TO THE DEALER. THE DEALER DISCOVERED THAT THE IGNITION COIL FAILED AND WILL MAKE THE REPAIR AT THE COST OF $250. THE CONTACT PREVIOUSLY TRADED IN HIS VOLKSWAGEN JETTA DUE TO THE IDENTICAL COIL FAILURE. THE VIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 55,000.

IN 4/08 AND 5/08 HAD MALFUNCTION LIGHT INDICATOR COME ON, THEN HAD SEPARATE REPAIRS AT BAYSIDE VOLKSWAGEN. SAME LIGHT CAME ON 7/6/08. ITS SEEMS EVERY MONTH OR SO, ITS AN ISSUE WITH THE CAR AND HAVING DIFFERENT REPAIRS. *TR

MY 2003 VOLKSWAGEN PASSAT IS HOLDING 6INCHES OR MORE OF WATER ON THE PASSENGER SIDE IN THE FLOOR BOARD AND HAS SHORTED OUT THE COMPUTER UNDERNEATH, IN SERVICING THE CAR THE TECHNICIAN ADVISED HE FOUND 3 OTHER VOLKSWAGEN PASSATS OF THE SAME YEAR TO HAVE THE SAME DEFECT. I HAVE ALSO BEEN ADVISED THAT A SERIOUS CRASH COULD HAVE RESULTED BECAUSE THE COMPUTER UNDERNEATH REGULATES THE TRANSMISSION. *TR

I DROVE ABOUT TEN MILES UP THE CANYON PARKED THE CAR. THEN GOT A CALL ABOUT 15 MIN LATER TELLING ME MY CAR WAS ON FIRE AND THE FIRE DEPARTMENT HAD PUT IT OUT. I AM STILL WAITING TO FIND OUT WHAT IS GOING TO HAPPEN WITH THE CAR FROM THE DEALER AND INSURANCE. IT LOOKED LIKE THE FIRE STARTED IN THE DASH. *TR

RADIO NOT FUNCTIONING, AIR CONDITIONING UNIT WORKS INTERMITTENTLY, AIRBAG MALFUNCTION RECOGNIZED, OPERATION UNIT IN STEERING WHEEL MALFUNCTIONS, NO COMMUNICATIONS WITH BRAKE CONTROL UNIT, BRAKE LIGHT SWITCH CAUSES DRIVERS SIDE BRAKE LIGHT TO MALFUNCTION. HORN NOT FUNCTIONING NEARLY CAUSED 2 ACCIDENTS WITHIN A MONTH. I DROVE OVER AN ISLAND TO AVOID ONE COLLISION FROM THE OTHER NON-ATTENTIVE DRIVER AND ENDED UP SCRAPING THE TRANSMISSION PAN. COST OF REPLACEMENT: $550. AFTER THOUSANDS OF DOLLARS IN REPAIRS AND DIAGNOSTICS, VW DEALERSHIPS STILL UNABLE TO FIX ANY OF THE ABOVE! *TR

EVERY 5,000-7,000 MILES AN IGNITION COIL FAILS ON MY CAR. THIS RESULTS IN MY CAR INSTANTLY STARTING TO SHUTTER AND I HAVE TO PULL OVER IMMEDIATELY. LAST TIME THIS HAPPENED, DRIVING ONLY A MILE RESULTED IN A SEVERE VEHICLE FIRE PUTTING MYSELF AND OTHER IN DANGER. *TR THIS TIME, I WAS ABLE TO PULL OVER BEFORE SERIOUS INCIDENT OCCURRED. *TR

I HAVE A 2003 PASSAT V6 IN WHICH THERE IS A LEAK THROUGH THE POLLEN FILTER BECAUSE OF FAULTY DESIGN. EVERY TIME IT RAINS OR SNOWS IN THE NORTHEAST WATER GETS THROUGH THE FAULTY SEAL AND IS ACCUMULATING IN THE PASSENGER REAR AND FRONT SEAT. THE WATER ACCUMULATION HAS CAUSED THE TCM TO WORK IMPROPERLY AND MAY MALFUNCTION. WITH OUT THE USE OF A TCM THAT WORKS PROPERLY THE CAR MAY SHUTDOWN OR MALFUNCTION AND CAUSE AN ACCIDENT. THIS A PROBLEM VW KNOWS ABOUT AND HAS IN FACT ISSUED A RECALL ON THE 2002 MODEL. THIS IS AN ISSUE ON ALL B5 PASSAT MODELS. PLEASE HELP ISSUE A RECALL TO CORRECT THIS MATTER. THANKS STEVE *TR

A THIRD IGNITION COIL FAILURE IN 18 MONTHS, THE LAST ONE ALLOWING RAW GASOLINE INTO THE CATALYTIC CONVERTER, WHERE IT CAUGHT FIRE, DESTROYING THE TURBO AND CAUSING A LARGE AMOUNT OF BLACK SMOKE. I LOST POWER WHILE DRIVE, WAS UNABLE TO ACCELERATE IN A SAFE MANNER AND EVENTUALLY SUFFERED SMOKE INHALATION. ALL COILS NEED TO BE REPLACED. *TR

BATTERY GOING DEAD WITHOUT TIME OR REASON; DOORS WOULD LOCK AUTOMATICALLY WITH NO ONE AROUND; TRUNK WOULD UNLOCK AND WOULD NOT SHUT WITHOUT KEY INTERVENTION; LIGHT ON DRIVER'S DOOR LOCK WOULD FLASH INCESSANTLY WITH NO ONE NEAR. CAR WENT OVER FOUR YEARS WITH NO INCIDENT AND SUDDENLY STARTED ACTING "STRANGE." NO CHANGES OR WORK DONE ON ELECTRICAL SYSTEM SINCE NEW WHEN THE BATTERY HAD TO BE REPLACED TWICE. DEALER HAS BEEN VERY COOPERATIVE BUT UNSUCCESSFUL IN FINDING SOURCE, KEEPING CAR AS LONG AS THREE WEEKS (WITH A "LOANER") AND NOT CHARGING EXCEPT FOR A SMALL FIRST TIME INSPECTION. SIX RETURNS TO DEALERSHIP WITH SOME RELIEF; ONLY THE BATTERY GOES DEAD WITH IRREGULARITY. WE HAVE A 2000 PASSAT THAT SITS NEARBY AND HAS NEVER EXPERIENCED THE PROBLEM. NUMBER OF FAILURES IS ONE, BUT ALL RELATED . . SIX TRIPS TO DEALERSHIP AND RELIEF ON ALL BUT THE BATTERY GOING DEAD. WE...

TL*THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. THE CONTACT HAS HAD THE VEHICLE REPAIRED, HOWEVER, SEVERAL FAILURES CONTINUE TO RECUR. THE FAILURES INCLUDE THE INSTRUMENT PANEL LIGHTS, CRUISE CONTROL, HEATED SEATS, THE REGULATOR PIN IN THE PASSENGER SIDE REAR WINDOW, THE GLOVE COMPARTMENT, AND THE HEAD LIGHTS. THE FAILURES WERE NOTICED WHILE DRIVING 40 MPH. THE CURRENT MILEAGE IS 109,000 AND FAILURE MILEAGE WAS 80,000.

VEHICLE BATTERY GOES DEAD IF CAR SITS FOR MORE THAN 3 DAYS WITHOUT BEING STARTED. ALTERNATOR WIRING HARNESS HAS BEEN REPLACED ONCE. BATTERY HAS BEEN REPLACE 5 TIMES IN 6 MONTHS. DEALER CAN NOT FIND ANYTHING THAT IS DRAINING THE BATTERY AND INSISTS THAT "NOTHING IS WRONG WITH THE CAR AND THAT IT IS PERFECTLY NORMAL (EXCEPT FOR A DEAD BATTERY) FOR THIS TO HAPPEN. "JUST START THE CAR EVERY 1-2 DAYS" IS THEIR REMEDY. I HAVE NEVER HEARD OF ANYTHING SO LAME IN MY LIFE!! *JB

HEADLIGHTS FAILS PROPER FUNCTION. THEY HAVE BEEN REPLACED. SEAT BELTS AND SUN ROOF DO NOT WORK PROPERLY. ENGINE REPLACED; STEERING WHEELS - CAR PULLS TO THE RIGHT EVERYTIME AN ALIGNMENT WAS DONE AND THEY CALIBRATED THE WHEELS. - PROBLEM CONTINUED - THIS PROBLEM CAUSED THE TIRES TO BE DESTROYED IN A FEW KMS - LESS 20 000; WATER INFILTRATION - FOR NOW IT IS FIXED; TRUNK WAS HARD TO OPEN AND CLOSE - PROBLEM FIXED. FRONT DOORS VIBRATED - THE RUBBER OF THE DOORS ARE BEING EXHIBITING SIGNS OF DAMAGE; THE FRONT GLASS ( WINDSCREEN ) ISN'T FROM THE SAME YEAR OF ALL THE OTHERS. *JB

FRONT HEADLIGHTS MALFUNCTIONED - REPLACED THEM BUT THEY COULDN'T MAKE THE ALIGNMENT OF THE BEAM. THE CAR RUNS TO THE RIGHT BUT THE WHEELS ARE CALIBRATED AND THE DIRECTION ALIGNMENT IS DONE. THE CAR INFILTRATED WATER INSIDE THE CAR AND TRUNK. SUNROOF MALFUNCTION - OPENS IN ALL POSITIONS BUT DON'T CLOSE. THE CAR AS THE FRONT GLASS IS FROM 2005 AND ALL THE OTHERS ARE FROM 2002, CONSTRUCTION OF THE CAR 2003. DIESEL ESCAPED FROM THE PUMP. CD CHANGER - 6 CDS AS MALFUNCTION THE RADIO DOESN'T EJECT THE CD'S. THE MOTOR GAG VARIOUS TIMES A CONSTANT ROTATION. THE TRUNK WAS HARD TO OPEN AND CLOSE. THERE ARE OTHER COMPLAINTS.... THE COMPLAINTS BEGIN 15 DAYS FROM THE PURCHASE. *JB

I AM INVESTIGATING AND GATHERING INCIDENT INFORMATION ABOUT THE FLOODING PROBLEMS THAT VOLKSWAGENS, ESPECIALLY THE PASSAT, EXHIBIT FROM MODEL YEARS 1998 TO THE PRESENT. THERE IS A CHANCE OF A CLASS ACTION SUIT FOR WHICH THIS INFORMATION IS BEING GATHERED. IF INTERESTED, PLEASE RESPOND TO [email protected] FOR MORE INFORMATION. *NM

DT*: THE CONTACT STATED RAIN WATER LEAKED INTO THE VEHICLE. THERE WERE CONCERNS EXPRESSED OF CABLES UNDER THE DASH BECOMING WET, THEREFORE CREATING AN ELECTRICAL HAZARD. THE RAIN WATER USUALLY ACCUMULATED IN THE DOORS, AND WHEN THE DOORS WAS OPENED THE WATER TRAVELED TO THE DASH BOARD.

STARTED CAR AND ASRS LIGHT CAME ON AND REMAINED ON. SOON THE MIL LIT UP, FOLLOWED BY THE AIR BAG SYSTEM LIGHT FLICKERING AND A CLICKING SOUND COMING FROM THE CAR. DEALERSHIP COULD NOT CHECK CAR THE NEXT MORNING B/C FULLY BOOKED SO HAD ALTERNATE MECHANIC CHECK IT OUT. MECHANIC REALIZED IT WAS NOT THE BATTERY RUNNING LOW (BATTERY CHARGE CHECKED). THE NEXT MORNING ALTERNATOR CHECKED (ALTERNATOR REPLACE AND TESTED AND SAME PROBLEM CONTINUED). THE MECHANIC FINDS A PUDDLE OF WATER ON THE FLOOR OF THE PASSENGER SIDE THAT SAME MORNING WHICH WAS NOT THERE DAY BEFORE. HE STATES CAR HAD BEEN PARKED AT SLIGHT INCLINE OVERNIGHT WITH FRONT OF CAR HIGHER THAN TRUNK. MECHANIC RECOMMENDED TOWING CAR TO DEALERSHIP. CURRENTLY AT DEALERSHIP TO TRY AND FIGURE OUT PROBLEM. *NM

I RECENTLY HAD MY 40K MILE SERVICE DONE AND WAS PREPARING TO GO ON VACATION. THE CAR MADE IT THERE WITHOUT INCIDENT HOWEVER THE SECOND DAY INTO OUT VACATION THE ASR LIGHT CAME ON AND THEN THE PRND432 ALL STAYED LIT. IT HAD BEEN BEAUTIFUL WEATHER FOR SEVERAL DAYS HOWEVER THERE WAS EASILY TWO INCHES OF WATER ON THE PASSENGER SIDE. THE VEHICLES CHECK ENGINE LIGHT CAME ON AND IT STOPPED AUTOMATICALLY SHIFTING. THE VEHICLE IS AT THE SHOP WAITING REPAIR. *NM

CAR HAD TROUBLE STARTING, ELECTRICAL PROBLEMS, LURCHING WHILE DRIVING AND ULTIMATELY TRANSMISSION AND AIR BAG FAILURE. *NM

DESIGN DEFECT RESULTS IN FAILURE OF COMPUTER DUE TO WATER FLOODING. COMPUTER FAILURE RESULTS IN DISABLING OF VEHICLE AND EXPENSIVE REPAIRS. THIS CONDITION CAUSED BY PARKING THE CAR WHERE LEAVES OCCASIONALLY FALL ONTO IT. REASON: WINDSHIELD DRAINS INTO COMPARTMENT CONTAINING THE BATTERY, WHICH HAS A DRAIN HOLE LOCATED UNDER THE BATTERY, REQUIRING REMOVAL OF BATTERY TO PROPERLY CLEAN. DRAIN GETS CLOGGED DUE TO LEAVES, RESULTING IN BATTERY COMPARTMENT FILLING WITH WATER. WHEN THIS HAPPENS, WATER ENTERS PASSENGER COMPARTMENT FOOT WELL. I TOOK MY CAR TO VW DEALER WITH THIS CONDITION AND THEY TOLD ME THE COMPUTER COULD GET FLOODED/RUINED AND THIS WOULD NOT BE COVERED UNDER WARRANTY DUE TO "EXTERNAL INFLUENCE". THEY AGREED TO CLEAN THE DRAIN FREE OF CHARGE, BUT WERE UNABLE AND UNWILLING TO PROVIDE ME WITH A SERVICE ADVISORY THAT THE DRAIN MUST BE CLEARED TO PREVENT COMPUTER DAMAGE. I CONTACTED VW OF AMERICA AND THEY ACKNOWLEDGE...

2003 VOLKSWAGEN PASSAT CONSUMER REQUEST FOR EARLY TERMINATION OF THE LEASE.***NO ANSWER REQUIRED***. *MR THE CONSUMER MADE THE REQUEST DUE TO THE NUMEROUS MECHANICAL PROBLEMS SUCH AS A DEFECTIVE PURGE VALVE, RIGHT FRONT HEAD LIGHT, THE VEHICLE OVERHEATED AND STARTED T O SMOKE DUE TO A FAULTY WATER PUMP. THE BRAKE LIGHT WOULD NOT SHUT OFF AND THE RIGHT HEAD LIGHT WENT OUT FOR THE SECOND TIME. THE BRAKE LIGHT SWITCH WAS REPLACED. THE CRUISE CONTROL WOULD NOT DISENGAGE. THE VEHICLE WOULD NOT START AT TIMES. *JB

I PURCHASE A NEW 2003 VOLKSWAGEN PASSAT FROM BURLINGTON VOLKSWAGEN 2 YEARS AGO AND HAVE TAKEN IT BACK TO THE DEALERSHIP AT LEAST 7 TIMES SINCE THEN FOR A MYRIAD OF PROBLEMS, FROM AIRBAG LIGHTS COMING ON TO CHECK ENGINGE LIGHT TO THE LATEST OF THE CAR SHUTTING OFF IN THE MIDDLE OF THE ROAD.

AFTER RAINY DAYS MY 2003 PASSAT WAGON (4 MOTION) HAS 1 -2 INCHES OF WATER ON FLOOR OF THE FRONT PASSENGER SIDE. THIS HAS NOW BEEN TO THE DEALER TWICE (I JUST TOOK IT BACK TODAY) - THE FIRST TIME THEY TOLD US THAT IT WAS A DRAIN PROBLEM FROM THE SUN ROOF THAT WAS CLOGGED. THE CARPET SMELLS AND I AM AFRAID THAT THE ELECTRIC SEATS WILL SOON SHORT OUT.*AK

ON THREE SEPARATE OCCASIONS, 2/29/04, 3/5/04, AND 4/15/04 MY 2003 VW PASSAT (6 CYL.) HAD TO BE TOWED TO THE DEALER BECAUSE THE CHECK ENGINE LIGHT (MIL) AND ELECTRONIC POWER CONTROL (EPC) LIGHT CAME ON AND I HAD SIGNIFICANTLY REDUCED POWER SUCH THAT I WAS UNABLE TO DRIVE MY CAR HOME WITHOUT ENDANGERING MYSELF ON THE HIGHWAY. THE DEALER'S SERVICE GROUP HAS BEEN UNABLE TO RESOLVE THE PROBLEM THUS FAR.*AK

MY 2003 PASSAT, WITH 10K MILES, HAS BEEN IN THE SHOP FOR 22 DAYS NOW AND THEY DON'T KNOW WHAT'S WRONG WITH IT. THIS IS THE FOURTH TRIP IN FOR THE SAME THING. THE BATTERY GOES DEAD EVERY NIGHT. ACCORDING TO UTAH LEMON LAW I SHOULD BE ENTITLED TO ARBITRATE, BUT VW WILL NOT DISCUSS THIS OPTION. *NLM