2003 VOLKSWAGEN PASSAT Structure Problems

CAR WAS CONSTANTLY GETTING THE PASSENGER SIDE (FRONT AND BACK) FLOODED W WATER DURING A RAIN STORM. HAD TO GET NEW BATTERY CLEANED OUT SUNROOF DRAINAGE. IT DIDN'T MATTER. WHENEVER IT RAINED THE BATTERY WOULD BE DEAD BECAUSE THE CONTROL MODULE WHICH IS THERE IS ALL MESSED UP SENDING MIXED MESSAGES. FINELY JUST DIED IN THE MIDDLE OF THE ROAD. NOT WORTH PUTTING MONEY INTO THE CAR. I PURCHASED THIS CAR LESS THEN A YEAR AGO AND HAD THIS PROBLEM AFTER THE FIRST RAIN AND WENT DOWN FROM THEIR. IM SO DISAPPOINTED HOPING BUYING A USED VW I WAS GOING TO BE SATISFIED BUT HAD NOTHING TROUBLE FROM DAY ONE. *TR

I PURCHASED AN 03 VW PASSAT FROM A VW DEALER AS A CERTIFIED PRE-OWNED VEHICLE BACK IN 2/07. WITHIN THE FIRST WEEK OF PURCHASE I HAD BRAKE PROBLEMS. THE NEXT COUPLE YEARS WERE FOLLOWED BY VALVE COVER LEAKS, ENGINE LEAKS, AUTO WINDOW PROBLEMS, BATTERY PROBLEMS, RECALL ISSUES, WATER INTRUSION ISSUES, IGNITION COIL RECALL AND THE LIST GOES ON. AFTER A WATER INTRUSION JUST DAYS AFTER THE REPLACEMENT OF FAULTY IGNITION COILS I CONTACTED THE MANUFACTURE NOTIFYING THEM OF THE PROBLEMS. THE MANUFACTURE HAD HELD THEIR FOOT TO THE GROUND THAT MY CAR IS OUT OF WARRANTY (THAT I WAS TOLD AT TIME OF SALE I DID NOT HAVE) AND SO THEY ARE ABLE TO DO NOTHING ABOUT ANY OF THE PROBLEMS WITH THIS VEHICLE. HOWEVER AS IT STANDS I HAVE NEARLY $3000 IN REPAIRS NEEDED TO THIS VEHICLE. NOT TO MENTION THE WATER LEAK/DAMAGE FROM WHAT I UNDERSTAND MAY ACTUALLY...

WATER LEAKED IN TO THE PASSENGER COMPARTMENT OF THE VW PASSAT. THE TRANSMISSION ELECTRONIC CONTROLS ARE LOCATED UNDER THE FLOOR MAT OF THE PASSENGER SIDE OF THE AUTO. THE WATER SHORTED OUT THE ELECTRONICS FOR THE TRANSMISSION DISABLING THE VEHICLE. A VW DEALER REPAIRED THE PASSAT BY REPLACING THE ELECTRONICS AT A COST OF $2250.00 TO US. THEY ALSO MODIFIED THE AIR INTAKE TO PREVENT FUTURE DAMAGE. THIS WAS THE SECOND TIME WE HAD THE AUTO IN FOR CABIN WATER. THE SERVICE REP. TOLD ME THERE IS A PROBLEM WITH THE CABIN AIR INTAKE AND THIS WAS REPLACED UNDER A RECALL ON THE 2000, 2001 AND 2002 YEARS OF THE PASSAT. HE TRIED VW FOR WARRANTY BUT THEY DECLINED. *TR

MY 2003 VOLKSWAGEN PASSAT IS HOLDING 6INCHES OR MORE OF WATER ON THE PASSENGER SIDE IN THE FLOOR BOARD AND HAS SHORTED OUT THE COMPUTER UNDERNEATH, IN SERVICING THE CAR THE TECHNICIAN ADVISED HE FOUND 3 OTHER VOLKSWAGEN PASSATS OF THE SAME YEAR TO HAVE THE SAME DEFECT. I HAVE ALSO BEEN ADVISED THAT A SERIOUS CRASH COULD HAVE RESULTED BECAUSE THE COMPUTER UNDERNEATH REGULATES THE TRANSMISSION. *TR

I HAVE A 2003 VW PASSAT. I'VE HAD TWO LEAKS INTO THE FRONT RIGHT FLOORBOARD IN THE PAST SIX MONTHS FROM EITHER A SUNROOF DRAIN LINE OR A AIR CONDITIONER. THE LEAKS HAVE PRODUCED SO MUCH WATER THAT IT HAS GONE TO RIGHT BACK FLOORBOARD. THE PLASTIC ON THE INTERIOR IS WORN OFF. THE ASHTRAY FELL APART. THEY CAN'T SEEM TO GET THE ALIGNMENT RIGHT SO I KEEP GOING THROUGH TIRES AND THE TIRES I DO HAVE SOUND UNEVEN WHEN I ROTATE THEM, MAKING ME THINK THERE'S A PROBLEM. HOVE REPLACED THE HEADLIGHTS THREE TIMES IN 1 AND 1/2 YEARS. THERE'S A DEFECT INVESTIGATION INTO FIRES IN THE ENGINE AND A RECALL ON OIL SLUDGE. THIS CAR IS AN ACCIDENT WAITING TO HAPPEN AND IT'S VERY POORLY ENGINEERED. ONE THING AFTER ANOTHER. VW HAS ON A BUNCH OF RECALLS ALREADY ON THIS MODEL, TO MANY FOR ME TO FEEL SAFE...

MY 2003 VW PASSAT WAGON FLOODED DURING A RAINSTORM BECAUSE THE POLLEN FILTER SEAL FAILED. FURTHERMORE, BECAUSE THE COMFORT CONTROL MODULE COMPUTER IS MOUNTED ON THE FLOOR, THAT WAS DAMAGED AND THE BILL IS SIGNIFICANT. *TR MY DEALER'S SERVICE DEPARTMENT REP (BOSTON VW) TOLD ME THAT HE RECOMMENDS CLEANING LEAVES OFF THE CAR 2 TO 3 TIMES PER DAY IN ORDER TO PREVENT THIS PROBLEM. THAT SEEMS LIKE AN UNREASONABLE MAINTENANCE REQUIREMENT TO PREVENT AN ISSUE THAT I'VE NEVER SEEN PREVIOUSLY WITH OTHER CARS.

I HAVE A 2003 VW PASSAT AND AM ORIGINAL OWNER. I'VE HAD THREE LEAKS INTO THE FRONT RIGHT FLOORBOARD IN THE PAST SIX MONTHS FROM EITHER A SUNROOF DRAIN LINE OR A AIR CONDITIONER, DEPENDING ON THE REPAIR PERSON YOU TALK TO. THE LEAKS HAVE OCCASIONALLY PRODUCED SO MUCH WATER THAT IT HAS GONE TO RIGHT BACK FLOORBOARD. MY TRUNK HINGES ARE BROKEN. MY HOOD LIDS ARE BROKEN. THE PLASTIC ON THE INTERIOR IS WORN OFF. THE ASHTRAY IN BACK FELL APART. THEY CAN'T SEEM TO GET THE ALIGNMENT RIGHT SO I KEEP GOING THROUGH TIRES AND THE TIRES I DO HAVE SOUND UNEVEN WHEN I ROTATE THEM, MAKING ME THINK THERE'S A PROBLEM. NOW MY BRAKE LIGHTS ARE OUT. IT'S NOT A FUSE BUT APPARENTLY A SWITCH. BUT MY CAR ISN'T COVERED BY A RECALL THAT VW HAS ON A BUNCH OF OTHER MODELS. THERE'S A DEFECT INVESTIGATION INTO...

FRONT HEADLIGHTS MALFUNCTIONED - REPLACED THEM BUT THEY COULDN'T MAKE THE ALIGNMENT OF THE BEAM. THE CAR RUNS TO THE RIGHT BUT THE WHEELS ARE CALIBRATED AND THE DIRECTION ALIGNMENT IS DONE. THE CAR INFILTRATED WATER INSIDE THE CAR AND TRUNK. SUNROOF MALFUNCTION - OPENS IN ALL POSITIONS BUT DON'T CLOSE. THE CAR AS THE FRONT GLASS IS FROM 2005 AND ALL THE OTHERS ARE FROM 2002, CONSTRUCTION OF THE CAR 2003. DIESEL ESCAPED FROM THE PUMP. CD CHANGER - 6 CDS AS MALFUNCTION THE RADIO DOESN'T EJECT THE CD'S. THE MOTOR GAG VARIOUS TIMES A CONSTANT ROTATION. THE TRUNK WAS HARD TO OPEN AND CLOSE. THERE ARE OTHER COMPLAINTS.... THE COMPLAINTS BEGIN 15 DAYS FROM THE PURCHASE. *JB

1) OUR 2003 VOLKSWAGEN PASSAT 1.8T IS LEAKING WATER INTO THE PASSENGER SIDE OF THE CAB. 2) THIS APPEARS TO BE A COMMON PROBLEM IN THE PASSAT AS WELL AS OTHER VOLKSWAGENS AND HAS THE POTENTIAL TO CAUSE ELECTRICAL MALFUNCTIONS. 3) REPAIR WILL REQUIRE MODIFICATION OF DRAIN SYSTEMS AROUND THE VEHICLE TO PREVENT INTRUSION OF WATER INTO SENSITIVE SPACES. *NM

MY PASSAT HAD TWO PREVIOUS INSTANCES OF WATER LEAKAGE IN THE FLOOR OF THE BACK SEAT, WHERE THE COMPUTER IS HOUSED. THIS RESULTED IN A SHORT-CIRCUIT IN THE CARS COMPUTER IN THE FALL OF 2005, CAUSING THE CAR TO SLOW IN TRAFFIC AND ULTIMATELY STOP WHEN I REACHED DEALERSHIP. MAROONE VOLKSWAGEN OF DELRAY BEACH ADDRESSED THESE TWO INSTANCES UNDER WARRANTY BY FOCUSING ON THE POLLEN FILTER AND POLLEN FILTER CAGING. ON THE THIRD OCCASION, I AGAIN TOOK IT TO MAROONE VOLKSWAGEN ON SEPTEMBER 6, 2006 SINCE THIS SEEMED TO BE ANOTHER RECURRENCE OF THE SAME PROBLEM. DEALER WOULD NOT FIX UNDER WARRANTY. SERVICE ADVISOR SAID COWL HAD A HAIRLINE FRACTURE, WHICH WAS ALLOWING WATER UNDER MY HOOD AND INTO THE CAR. HOWEVER, COWL WAS INTACT ON PREVIOUS VISITS FOR SAME PROBLEM. CONTACTED VW OF AMERICA WHO ACCEPTED DEALERS DIAGNOSIS. THIS IS ESPECIALLY TROUBLING GIVEN THERE IS A WEALTH OF INFORMATION...

WATER LEAK - PASSAT 2003. *NM

I RECENTLY HAD MY 40K MILE SERVICE DONE AND WAS PREPARING TO GO ON VACATION. THE CAR MADE IT THERE WITHOUT INCIDENT HOWEVER THE SECOND DAY INTO OUT VACATION THE ASR LIGHT CAME ON AND THEN THE PRND432 ALL STAYED LIT. IT HAD BEEN BEAUTIFUL WEATHER FOR SEVERAL DAYS HOWEVER THERE WAS EASILY TWO INCHES OF WATER ON THE PASSENGER SIDE. THE VEHICLES CHECK ENGINE LIGHT CAME ON AND IT STOPPED AUTOMATICALLY SHIFTING. THE VEHICLE IS AT THE SHOP WAITING REPAIR. *NM

DUE TO A SUNROOF DRAIN CLOG, OUR 2003 PASSAT WAGON PASSENGER FLOORBOARD QUICKLY FILLED WITH WATER IN WHAT I WOULD DESCRIBE AS MAJOR FLOODING. AS AN IMMEDIATE AND DIRECT RESULT WITH NO OPPORTUNITY TO REACT AND RESPOND OUR CAR BEGAN TO HAVE TROUBLE STARTING. AFTER GETTING IT STARTED AND BEING UNAWARE OF THE SITUATION WE WERE DEALING WITH, AN ATTEMPT WAS MADE TO DRIVE IT TO THE DEALER TO SEE WHAT WAS WRONG. DURING THAT RIDE THE ELECTRICAL SYSTEM WENT HAYWIRE, THE CAR BEGAN TO LURCH AND ULTIMATELY SHUT DOWN ON THE SIDE OF THE HIGHWAY. I WAS FORCED TO CALL VW FOR A TOW AND WAS RESPONDED TO PROMPTLY. THE DEALER'S SERVICE DEPT EXAMINED THE CAR AND FOUND THAT THE TRANSMISSION CONTROL MODULE AND THE AIR BAG CONTROL MODULE WERE BOTH SUBMERGED AS THEY BOTH REST UNDERNEATH THE CARPET IN THE FLOORBOARD. BOTH ITEMS WERE DEEMED TO BE NONFUNCTIONING...

FAILURE OF ELECTRICAL SYSTEM DUE TO INTERIOR WATER LEAKS INTO THE FOOTWELL AREA FROM BLOCKED PLENUM DRAIN. AS STATED IN THE JUNE 18,2004 VW TECHNICAL SERVICE BULLETIN VEHICLE HAS 28,000MILES . IT IS A LEASE. FIRST ELECTRICAL PROBLEMS BEGAN AT APPROX 20,000 MILES WHEN AIR BAG LIGHT AND CHECK ENGINE LIGHT CAME ON AND REMAINED ON. SERVICE DEPARTMENT KEPT CAR FOR 3 WEEKS AND REPAIRED. SECOND PROBLEM KEY LOCK SYSTEM FAILED. UNABLE TO START THE VEHICLE NEEDED TO RE-DO CODES AND REPLACE KEYS, ALSO CHANGED STEERING WHEEL. THIRD PROBLEM, DAMPNESS ON FLOOR OF DRIVERS SIDE, FRONT AND BACK., TRUNK OPENED WHILE DRIVING, INTERIOR LIGHTS REMAINED ON UNLESS TURNED OFF MANUALLY, DOOR LOCKS OPENED AND CLOSED RANDOMLY WHILE DRIVING, ALARM SYSTEM WENT OFF RANDOMLY, SOUND SYSTEM WENT ON AND STAYED ON AFTER CAR WAS VACANT. CAR NEEDED TO BE JUMP STARTED IN ORDER TO USE. CAR TOWED TO DEALERSHIP AND WAS...

LEAK INTO THE PASSENGER COMPARTMENT WITH HEAVY RAIN RESOLUTION PENDING PASSENGER AIR BAG CAN BE AFFECTED. *JB