2001 VOLKSWAGEN PASSAT Electrical System Problems

SO I GOT REAR ENDED AT THE OTHER PARTY'S FAULT AT HIGH SPEED WHILE I WAS AT A STOP SIGN AND THEY NEGLECTED TO STOP PUSHING ME INTO AN INTERSECTION FULL OF TRAFFIC...NO AIRBAGS DEPLOYED..AND SINCE MY HEATER DOESN'T WORK BUT PASSENGER SEAT HEAT BURNED MY 12 YEAR OLD DAUGHTERS BUTT...ANYONE HELP? I JUST WANT HEAT FOR MY BABIES..BELOW ZERO HERE :( THANK YOU!! [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

I WAS DRIVING ON I-95 AT APPROX. 78 MPH WHEN THE CAR SUDDENLY SAYS STOP! BRAKE FAILURE! SEE VOLKSWAGEN SERVICE. IN MY RESEARCH ON THE ISSUE, I'VE FOUND THIS HAPPENS ON ALMOST ALL 1998-2001 VW PASSATS AND AUDI A-4S. THIS NEEDS TO BE ADDRESSED. *TR

ABS MODULE IS OUT, CAN'T GET EMISSIONS PASSED UNLESS I PAY OVER 600 DOLLARS. ALSO I DON'T HAVE ABS, CAN'T SEE IF MY CHECK ENGINE LIGHT MEANS ANYTHING BECAUSE I'M TOLD IT ALL GETS RE ROUTED THOROUGH THE ABS MODULE AND CAN'T GET PAST THAT PROBLEM. *TR

THE FIRST THINGS THAT IS HAPPEN IS THAT MY DIGITAL INSTRUMENT PANEL BLINK IN AND OUT AND THE SECOND IS THAT WATER BE RUNNING IN THE CAR COMPARTMENT ON THE PASSENGER SIDE. *TR

2001 PASSAT GLX MY ABS LIGHT/BRAKE LIGHT/ASL LIGHT FLASH ON MY DASH PANEL RANDOMLY DURING THE DAY WHICH POINTS TO ANOTHER FAILED ABS MODULE. I GET THE THREE BEEPS THAT ACCOMPANY THE FLASHING LIGHTS. THIS HAPPENS ABOUT 10 TIMES A DAY OR MORE. I CAN FEEL A KICK FROM MY BRAKE PEDAL WHEN THIS HAPPENS DURING BRAKING. *TR

HEADLAMP WIRING HARNESS MELTS. *TR

CLASS ACTION LAW SUIT SETTLED WITH VW FOR OIL SLUDGE. THIS MAKES NO SENSE BY THE TIME THE SETTLEMENT WAS REACHED MY 2001 VW PASSAT, 1.8 TURBO WAS NOT COVERED. 7 OR 8 WEEKS AGO I TOOK MY VEHICLE INTO THE VW DEALER (HALMARK VW OF MADISON) THEY TOLD ME I HAD A SLUDGE PROBLEM AND DID NOT EVEN MENTION THAT IT WAS A KNOWN PROBLEM OR THAT THE LAW SUIT WAS UNDERWAY- VERY SNEAKY. THEY TOLD ME TO REPLACE MY ENGINE OR TO CHANGE THE OIL EVERY 1000 MILES FOR AWHILE. MY ABS AND COMPUTER MODULE FAILED AT THE SAME TIME WITH NO ONE TAKING RESPONSIBILITY FOR IT. NOW I HAVE THE PROBLEM BUT HAVE NO WAY TO GET IT RESOLVED. *TR

IGNITION COIL FAILURE AFTER 13 MONTHS AFTER VW REPLACED ALL 4 COILS UNDER PRIOR RECALL. *TR

MY FOSTER SON WAS DRIVING OUR 2001 VW PASSAT WHEN HE NOTICED A LARGE AMOUNT OF SMOKE COMING OUT FROM UNDER THE HOOD. HE PULLED OVER INTO A PARKING LOT AND THERE WERE FLAMES ENGULFING THE PASSENGER COMPARTMENT. FIRE AND POLICE WERE ON THE SCENE. IT WAS DETERMINED BY THE FIRE DEPARTMENT AND A MECHANIC THAT LOOKED AT THE CAR LATER THAT THE FIRE STARTED IN THE COMPUTER LOCATED IN THE DASH AREA OF THE CAR. THE CAR IS A TOTAL LOSS WITH THE PASSENGER COMPARTMENT MELTED BEYOND REPAIR. WE HAVE A FIRE REPORT AND PICTURES. *TR

FAULTY WIRING FOR TAIL LIGHTS, BRAKE LIGHT, TURN LIGHTS. REPLACED FUSE, REPLACED BRAKE AND TAIL LIGHT BULBS EIGHT TIMES, THIS CORRECT THE PROBLEM FOR ONE DAY. BOUGHT NEW KIT TO REPLACE OLD BRAKE ,TAIL LIGHT , TURNING LIGHT. THIS WORKED FOR APPROX. TWO MONTHS NOW NOTHING WORKS. *TR

FRONT BALL JOINT FAILURE AT APPROX. 35,000 MILES. THEN A LOWER CONTROL ARM FAILURE AT 95,000 MILES. OLD CONTROL ARM IS AVAILABLE. *TR

DEC 12TH 2008 THE INTERIOR OF MY PASST WAS FLOODED WITH WATER, VW SERVICE REMOVED 10 + GALLONS OF WATER WHICH ENTERED FROM AIR PLENUM /POLLEN FILTER HOSING(CABIN AREA). SERVICE INFORMED ME OF THE P9 RECALL FOR THE PASSATS MANUFACTURED NOV '00 TO DEC '05. BUT, VW OF AMERICA WILL NOT HELP ME THEY SAID MY VIN # IS NOT IN THE RECALL. THE COMPUTERS ARE ON THE FLOOR OF CAR. AIR BAG IS IN DEFAULT DAMAGE FROM ELECTRICAL DAMAGE FROM WATER DAMAGE.. MY TRANS MOD IS WRECKED FROM THE WATER DAMAGE, JUST THE PART ALONE WILL COST $1,300. I HAVE LOST WORK AND CAN NOT DRIVE. THE MAKE OF CAR & YEAR IS IN RECALL SO WHY IS MY VIN NOT INCLUDED?! SOMEONE PLEASE, PLEASE HELP ME. *TR

MY 2001 VW PASSAT ABS MODULE BECAME DEFECTIVE AFTER 1 YEAR OF OWNING CAR FROM THE ORIGINAL OWNER. NOT SURE IF ORIGINAL OWNER HAD DONE REPAIRS/REPLACEMENTS OF THE UNIT. NOW THERE IS NO COMMUNICATION BETWEEN THE CAR COMPUTER AND THE MODULE, THEREFORE NO ABS BRAKE IS ACTIVE. ABS LIGHT STAYS ON AND BRAKE LIGHT FLASHES INTERMITTENTLY. THERE ARE ALSO 3 BEEPS WHEN CAR HAS BEEN STARTED. I AM A VERY UNHAPPY CONSUMER OF VW DUE TO THEIR FAULTY VEHICLE EQUIPMENT AND HAS DETER ME FROM PURCHASING ANY VW IN THE FUTURE. I HAVE RECENTLY JUST HAD A REPAIR TO REPLACE MY MAF SENSOR, 2 IGNITION COILS, 4 SPARK PLUGS AGAIN AFTER PURCHASING BRAND NEW ONES JUST A MONTH PRIOR. IT WAS VERY COSTLY!! *TR

WARNING LIGHT AND BEEPING SOUND ON DASHBOARD COMES ON FREQUENTLY (ABOUT HALF THE TIME) SAYING STOP ABS BRAKE. ACCORDING TO MECHANIC, MANY MANY VWS HAVE THE SAME PROBLEM (SOMETHING TO DO WITH ABS CONTROL MODULE) WHICH CAN COST $2,000 TO FIX AT A DEALER), AND HE'S SURPRISED THERE ISN'T A RECALL FOR IT. *TR

TL*THE CONTACT OWNS A 2001 VOLKSWAGEN PASSAT. WHILE DRIVING APPROXIMATELY 55 MPH, THE "STOP VEHICLE DO NOT DRIVE", AND OIL PRESSURE WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE INDICATORS REMAINED ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER AND THEY REPAIRED THE ENGINE. THE PREVIOUS REPAIR REQUIRED THE VEHICLE TO REMAIN AT THE DEALER FOR ONE MONTH. ON THREE SEPARATE OCCASIONS, THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR IDENTICAL FAILURES, BUT THERE WERE NO RESOLUTIONS. IN ADDITION, DURING RAINY WEATHER CONDITIONS, FIVE INCHES OF WATER LEAKED ONTO THE FRONT PASSENGER SIDE FLOOR PANEL. THERE WAS ELECTRICAL FAILURE DUE TO THE WATER LEAKAGE THAT CAUSED GEAR COMPONENT DAMAGE. RECENTLY, THE CONTACT RECEIVED A RECALL NOTICE THAT CONSISTS OF INSTALLATION OF A DRAINAGE FILTER AND FUEL SYSTEM COMPONENT REPAIR. THE VEHICLE HAS NOT BEEN REPAIRED FOR THESE MALFUNCTIONS. THE NHTSA CAMPAIGN ID...

I HAVE HAD MY 2001 VW PASSAT FOR 7 YEARS NOW AND HAVE HAD IT IN THE SHOP MULTIPLE ISSUES INCLUDING WARPED ROTORS (FRONT AND BACK), CRACKED CHASSE, ELECTRICAL ISSUES AND VARIOUS OTHER PROBLEMS. BEFORE HAVING THIS CAR, I HAD A TOYOTA FOR 8 YEARS AND IN THE 8 YEARS I HAD THE TOYOTA, I ONLY HAD IT IN THE SHOP FOR ROUTINE MAINTENANCE. THIS CAR IS DISAPPOINTING AND EVERYONE I TALK TO WHO HAS A SIMILAR MODEL/YEAR SAYS THE SAME THING. I THINK THE 2001 VW PASSAT IS A LEMON. *TR

TL*THE CONTACT OWNS A 2001 VOLKSWAGEN PASSAT. WHILE PARKED IN THE DRIVEWAY, THE VEHICLE BURST INTO FLAMES UNDERNEATH THE HOOD. THE FIRE DEPARTMENT STATED THAT THE FIRE WAS DUE TO AN ELECTRICAL MALFUNCTION. THE VEHICLE ONLY HAD LIABILITY COVERAGE; THEREFORE, THE INSURANCE COMPANY WOULD NOT INVESTIGATE. THE VEHICLE WAS DESTROYED. THE CONTACT WILL GIVE THE MANUFACTURER A REPORT. THE CURRENT AND FAILURE MILEAGES WERE 87,000.

MY CAR IS A 2001 V6, WE HAD HEAVY RAIN DURING THE PAST WEEK AND ONE MORNING MY CAR HAD A PUDDLE IN THE PASSENGER SIDE AND FAILED TO START OR EVEN PUT IN GEAR THE MECHANIC EXPLAINED THE TRANSMISSION COMPUTER WAS FLOODED AND IT TOOK 4 DAYS FOR THEM TO TAKE ALL WATER OUT OF THE CAR AND TEST ALL SENSORS . *TR

MECHANIC REFUSES TO REPAIR 2001 PASSAT ELECTRONIC CONTROL SYSTEM. *TS THE CONSUMER STATED THE PROBLEM HAD BEEN MIS-DIAGNOSED ON MORE THAN ONE OCCASION. THE VEHICLE HAD AN OIL HOSE LEAK. *JB

CONSUMER HAS HAD THREE INSTRUMENT CLUSTERS REPLACED IN HIS 2001 VOLKSWAGEN PASSAT. *TS ACCORDING TO THE DEALER AND MANUFACTURER THIS PROBLEM IS RARE AND IS LIKELY A WIRING PROBLEM. THE MANUFACTURER HASN'T TAKEN ANY STEPS TO PERMANENTLY FIX THE PROBLEM, INSTEAD THEY JUST KEEP REPLACING THE INSTRUMENT CLUSTER. *NM

COWL DRAIN BECAME CLOGGED FOR NO APPARENT REASON. DURING HEAVY RAIN THE PASSENGER COMPARTMENT BECAME FLOODED AND THE DASHBOARD ELECTRONICS BECAME FLOODED RESULTING IN OVER $2,000 WORTH OF DAMAGE. PLEASE NOTE THAT I AM FILING THIS COMPLAINT ON BEHALF OF MY PARENTS WHO ARE ELDERLY AND FRAIL. *JB

THE ABS LIGHT COMES ON, BUT THE CAR IS NOT DOING ANYTHING DIFFERENT, I ALSO GET THE EPO LIGHT ON, TOOK IT TO VW SERVICE CTR THEY SAID IT WILL COST $1500 + 2.5 HRS LABOR. I CALLED UP VOLKSWAGEN OF AMERICA CUSTOMER SERVICE THEY SAID THEY CANNOT HELP, EVEN THOUGH 1000S OF OTHER VOLKSWAGENS HAVE THE SAME PROBLEM.*AK

ON THREE SEPARATE OCCASIONS, THE 2001 VW PASSAT V6 GLS ENGINE AND ALL ELECTRICAL QUIT FOR NO APPARENT REASON. ONE INCIDENT OCCURRED ON THE FREEWAY AT APPROXIMATELY 65 MPH. THE VEHICLE WAS IN THE FAST LANE AND THE MOMENTUM ALLOWED THE VEHICLE TO CONTINUE FORWARD ENOUGH TO GET THE VEHICLE RESTARTED WITHOUT COMING TO A COMPLETE STOP. LUCKILY, THERE WAS NOT A LOT OF TRAFFIC BECAUSE THIS COULD HAVE RESULTED IN A DISASTROUS SITUATION. DURING THE INCIDENT THAT OCCURRED TODAY THE VEHICLE HAD TO BE BROUGHT TO A COMPLETE STOP BEFORE BEING RESTARTED. *NM

CAR DIED WHILE DRIVING ON 55 MPH ROAD. STARTER WORKED AND ENGINE WOULD TURN, BUT WOULD NOT RUN. DEALER FOUND NO CODES IN COMPUTER. ENGINE AND HORN FUSES BLOWN AND DEALER REPLACED HORN RELAY. I ASKED THE DEALER WHY THERE WERE NO CODES IN THE COMPUTER AND THEY DIDN'T KNOW THE ANSWER. THEY WOULD NOT REPLACE THE COMPUTER. CAR WAS IN THE SHOP FOR 7 DAYS. INCIDENT HAPPENED OVER 100 MILES FROM HOME AND DEALER FINALLY AUTHORIZED LOANER AFTER 2 DAYS. DEALER WAS VERY RUDE DURING THE WHOLE INCIDENT AND CONSTRUCTION MADE IT DIFFICULT TO COMMUNICATE. PHONE LINES WERE DISCONNECTED PART OF THE TIME.

THE CAR SHUT OFF TRAVELING ABOUT 45 MPH. I WAS TOLD BY A VOKSWAGEN WARRANTY SPOKESPERSON THAT IT DOES NOT FALL UNDER A SAFTEY ISSUE. I DIAGREE. I LOST ALL BRAKING AND TURNING POWER AND WAS GLAD THAT I WAS NOT ON THE HIGHWAY WITH MY KIDS IN THE CAR. I AM CURRENTLY WAITING FOR IT TO BE FIXED. I HAVE BEEN FOUR DAYS NOW WITHOUT A VEHICLE. THEY WILL NOT PAY FOR A LOANER CAR.*AK

POLLEN FILTER SEAL FAILURE. THIS PROBLEM IS DOCUMENTED IN MANY INTERNATIONAL PASSAT OWNER GROUPS. THE SEAL AROUND THE POLLEN FILTER FAILS. THE CAR'S INTERIOR BECOMES FLOODED IN RAIN. ELECTRICAL COMPONENTS THAT GET WET FAIL OVER TIME AT ACCELERATED AND UNPREDICTABLE RATE. SAFETY CONCERN: IT IS DIFFICULT TO OPERATE AUXILLIARY COMPONENTS (DEFROSTER, RADIO, ETC WHEN INTERIOR LIGHTS FAIL) EMERGENCY FLASHER AND ASR BREAKERS ARE ALSO SUBJECT TO MOISTURE-RELATED ACCELERATED DECLINE AS A RESULT OF POLLEN FILTER LEAKAGE. OUR VW DEALER AND VWOA STATED THAT POLLEN FILTER SEAL FAILURE AND ASSOCIATED FLOODING DAMAGE AND ELECTRICAL FAILURE WERE PART OF "NORMAL WEAR AND TEAR". VW SERVICE ADVISORS IN THE WASHINGTON DC AREA HAVE SAID THEY SEE "SEVERAL OF THESE EACH WEEK" IN RAINY SEASONS. THE FILTER DESIGNED TO REDUCE ALLERGENS IN THE AIR HAS THE PERVERSE CONSEQUENCE OF ACCELERATING THE GROWTH OF MOLD INSIDE THE CAR BECAUSE IT SEAL FAILS, CREATES (IN OUR...

THIS IS THE LETTER I SENT TO VW. THEY ARE MAINTAINING "THE VEHICLE NOW OPERATES ACCORIND TO MAUFACTURER'S SPECIFICATIONS" AND ARE REFUSING TO DO ANYTHING. HELP!!WHAT DO I DO NOW???*AK VW CUSTOMER CARE 3499 W. HAMLIN ROAD ROCHESTER HILLS, MICHIGAN 48309 TO WHOM IT MAY CONCERN: I AM WRITING IN REGARDS TO OUR 2001 VW PASSAT, . IF YOU REVIEW THE FILE, YOU WILL FIND THAT THIS CAR HAS NOW FAILED THREE TIMES. THE FAILURES ARE SUCH THAT ALL POWER CUTS OUT AND CREATES A POTENTIALLY HAZARDOUS DRIVING SITUATION. WE HAVE BEEN VERY FORTUNATE IN THAT SO FAR IT HAS NOT HAPPENED WHEN TRAVELING AT FREEWAY SPEEDS. WE FEEL THAT THERE IS AN INHERENT DEFECT WITH THE VEHICLE. IDEALLY, WE WOULD EXPECT REPLACEMENT OF THE VEHICLE OR REPLACEMENT OF THE ENTIRE ELECTRONIC SYSTEM AND WIRE HARNESS. IF YOUR COMPANY IS UNWILLING TO COMPLY, WE WOULD LIKE A LETTER ACKNOWLEDGING THE...

VEHICLE'S DRAINAGE HOLE WAS INSTALLED INCORRECTLY, CAUSING A BLOCKAGE. ALSO, THE ELECTRICAL SYSTEM MALFUNCTIONED. *AK

HEADLIGHT BUILD CONNECTOR SHORTED AGAINST ADJACENT METAL DUE TO EXPOSED WIRE. CHARRING AND MELTED HARNESS CONNECTOR RESULTED. POTENTIAL EXISTS FOR THIS TO CAUSE A VEHICLE FIRE WITH POSSIBLE LOSS OF LIFE. HEADLIGHT IS INOPERABLE UNTIL WIRING HARNESS CONNECTOR CAN BE REPLACED. *TT

CONSUMER STATES THAT WATER GOT INTO THE ELECTRICAL SYSTEM, AS A RESULT OF THE MANUFACTURER FAILING TO SEAL THE FRESH AIR FILTER AT TIME OFF VEHICLE BEING MANFACTURE. WHICH CAUSE SMOKE TO COME FROM THE INTERIOR VENT INSIDE THE VEHICLE. ALMOST CAUSING A FIRE. TS