2006 TOYOTA TUNDRA — Problems, Recalls & Safety Data
N/A
Safety Rating
676
Owner Complaints
13
Recalls
12
Service Bulletins
0
Investigations
Overview of the 2006 TOYOTA TUNDRA
The 2006 TOYOTA TUNDRA has received a total of 676 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There have been 14 recall campaigns affecting this vehicle, covering issues with SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT, AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE, AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE. 12 technical service bulletins have been issued by Toyota Motor Corporation for this model year. The most commonly reported problems involve the Air Bags (132 complaints), Structurebody (122 complaints), and Suspension (72 complaints).
Recalls for the 2006 TOYOTA TUNDRA
NHTSA has recorded 14 recalls for the 2006 TOYOTA TUNDRA, potentially affecting up to 6,270,897 vehicles.
Recall 22E002000 — SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
| 15,200 vehicles affected
Defect: Tenneco Automotive (DRiV) is recalling certain aftermarket ball joints for 2004-2007 Toyota Sequoia and 2004-2006 Toyota Tundra vehicles, MOOG part number K80521, K80522, NAPA part number NCP2601633, NCP2601634, ACDelco part number 45D2344, and 45D2345. The ball joint housing may have inadequate hardness, causing premature failure.
Consequence: A ball joint failure may cause a loss of control, increasing the risk of a crash.
Remedy: DRiV will work with distributors to return unsold parts. Dealers will inspect and replace the ball joint as necessary, free of charge. Owner notification letters were mailed on March 17, 2022. Owners may contact DRiV customer service at 1-877-489-6659 or...
View full details →Recall 19V741000 — AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
| 928,220 vehicles affected
Defect: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger...
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact...
View full details →Recall 19V741000 — AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
| 928,220 vehicles affected
Defect: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger...
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact...
View full details →Recall 16V065000 — AIR BAGS:SIDE/WINDOW
| 320,409 vehicles affected
Defect: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2003-2006 Toyota Land Cruiser and Lexus LX470, 2005-2006 Toyota Tundra and Sequoia, 2004-2006 Toyota 4Runner and Lexus GX470 vehicles equipped with side curtain-shield-air bags. The affected vehicles have an air bag control module that may be improperly programmed, causing the side curtain-shield-air bags to deploy inadvertently.
Consequence: If the side curtain-shield-air bags deploy unexpectedly, it can increase the risk of occupant injury.
Remedy: Toyota will notify owners, and dealers will replace the air bag control module with one that has improved programming, free of charge. The recall began on December 1, 2016. Owners may contact Toyota customer service at 1-888-271-9371. Toyota's number for...
View full details →Recall 16V396000 — SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER
| 7,749 vehicles affected
Defect: Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element....
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET...
View full details →Recall 15V285000 — AIR BAGS
| 1,973,468 vehicles affected
Defect: Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015 that they are recalling certain model year 2004 Sequoia vehicles manufactured August 18, 2003, to August 19, 2004, and 2003-2004 Tundra vehicles manufactured March 18, 2003, to August 25, 2004. On June 16, 2015, Toyota expanded the recall to include an additional 1,270,468 vehicles, including model year...
Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Remedy: 2003-2004 Corolla and Corolla Matrix vehicles that are recalled under both 15V-043 and 15V-285 are under a Do Not Drive advisory. Owners of these vehicles are advised not to drive their vehicles until the recall remedy has been completed. Toyota...
View full details →Recall 15V286000 — AIR BAGS
| 1,069,055 vehicles affected
Defect: Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015, that they are recalling 2005-2007 Lexus SC, Toyota Corolla, Corolla Matrix, Sequoia, and Pontiac Vibe, and 2005-2006 Toyota Tundra vehicles that were originally sold, or ever registered, in Florida, along the Gulf Coast, Puerto Rico, Hawaii, the U.S. Virgin Islands, Guam, Saipan and American Samoa. On June...
Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Remedy: 2003-2004 Corolla and Corolla Matrix vehicles that are recalled under both 15V-043 and 15V-286 are under a Do Not Drive advisory. Owners of these vehicles are advised not to drive their vehicles until the recall remedy has been completed. Toyota...
View full details →Recall 14V743000 — SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER
| 3,233 vehicles affected
Defect: Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact...
View full details →Recall 10V036000 — EQUIPMENT:OTHER:LABELS
| 153,418 vehicles affected
Defect: SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
View full details →Recall 10V035000 — EQUIPMENT:OTHER:LABELS
| 271,417 vehicles affected
Defect: GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS...
View full details →Recall 09V223000 — EQUIPMENT:OTHER:LABELS
| 27,080 vehicles affected
Defect: TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
View full details →Recall 07E023000 — SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER
| 13,128 vehicles affected
Defect: CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
Consequence: LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
View full details →Recall 07V013000 — SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
| 533,124 vehicles affected
Defect: ON CERTAIN TRUCKS AND MINI VANS, DUE TO POSSIBLE IMPROPER FINISHING OF THE FRONT SUSPENSION LOWER BALL JOINT, SOME BALL JOINTS MAY EXPERIENCE AN INCIDENTAL DETERIORATION OF THE INTERNAL LUBRICATION. THIS MAY CAUSE THE BALL JOINT TO WEAR AND LOOSEN PREMATURELY, WHICH COULD RESULT IN INCREASED STEERING EFFORT, REDUCED VEHICLE SELF-CENTERING, AND NOISE IN THE FRONT SUSPENSION.
Consequence: IN EXTREME CASES, IF THE VEHICLE IS CONTINUOUSLY OPERATED IN THIS CONDITION, THE LOWER BALL JOINT MAY SEPARATE FROM THE KNUCKLE AND COULD CAUSE A LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION LOWER BALL JOINTS. THE RECALL BEGAN ON FEBRUARY 28, 2007. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
View full details →Recall 06E049000 — EXTERIOR LIGHTING
| 27,176 vehicles affected
Defect: CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Remedy: CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
View full details →Owner Complaints for the 2006 TOYOTA TUNDRA
676 complaints have been filed with NHTSA for the 2006 TOYOTA TUNDRA. Below is a breakdown by vehicle component.
Most Recent Complaints
My frame is rotting, with literal holes in it. I spoke with a dealership and they stated the recall had been fixed in 2015, prior to me owning it. I was told to contact the manufacturer and they said it would be an out of pocket expense. When I research the recall, the affected area of the frame is the same, with no apparent fixes.
The frame has rusted so badly that the sway bar mount disengaged from the frame. Brought it to a Toyota dealership and confirmed that frame recalls were performed on earlier models with the same issue . However my year did not qualify.
The frame has rusted so badly that the sway bar mount disengaged from the frame. Brought it to a Toyota dealership and confirmed that frame recalls were performed on earlier models with the same issue . However my year did not qualify.
The frame has rusted so badly that the sway bar mount disengaged from the frame. Brought it to a Toyota dealership and confirmed that frame recalls were performed on earlier models with the same issue . However my year did not qualify.
The contact’s father owns a 2006 Toyota Tundra equipped with Cooper Tires, Tire Line: Discoverer Rugged Trek, Tire Size: 265/70/R16, DOT Number: (N/A). While the contact’s father was driving at an undisclosed speed, the driver lost control of the vehicle. The contact’s father was able to regain control of the vehicle by releasing the accelerator pedal and allowing the vehicle to decelerate. The driver was able to pull over to the side of the road to inspect the vehicle. The driver became aware that the tread on the driver's side tire had separated, causing a portion of the tire near the seam to detach around the entire tire. The tire was a replacement tire. The driver replaced the tire with the spare. The contact sent an email to American Tire Depot where the tire was purchased. The manufacturer was informed of the failure. The vehicle failure mileage was approximately 194,040, and the tire failure mileage was approximately 17,339.
Safety Rating for the 2006 TOYOTA TUNDRA
NHTSA has not yet tested the 2006 TOYOTA TUNDRA in its New Car Assessment Program.
Technical Service Bulletins for the 2006 TOYOTA TUNDRA
Toyota Motor Corporation has issued 12 technical service bulletins (TSBs) for the 2006 TOYOTA TUNDRA. TSBs are notices sent by manufacturers to their dealers describing a known issue and the recommended repair procedure.
T-TT-0636-20 Rev — SERVICE BRAKES
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.
D0D_DSD_Limited — STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
DL: These campaigns are expired as of July 31, 2015.
D0D_Limited Serv — EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
EC: LSC D0D expires July 31,2015.
D0D_DSD_Dealer D — STRUCTURE:FRAME AND MEMBERS
DD: FRAME REPLACEMENT - Customer vehicles that qualify for frame replacement under D0D/DSD must have their vehicle inspected on or before July 31,2015. Frame and ancillary parts orders must be submitted no later than Monday, August 4th, 2015 following the expiration date.CRC APPLICATION - D0D ONLY-Last day of CRC application...
D0D_DSD_LSC_Deal — EQUIPMENT
DL: Toyota will be sending Limited Service Campaign Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for Regional and PD associates.
DSD_LSC_Dealer D — STRUCTURE:FRAME AND MEMBERS
Dealer Daily: Toyota has received reports that certain 2004 through 2006 model year Tundra vehicles operated in specific cold climate areas with high road salt usage may exhibit more-than-normal corrosion to the vehicle's frame. This condition is unrelated to and separate from normal surface rust which is commonly found on...
TC-15-002 — STRUCTURE:FRAME AND MEMBERS
TOYOTA: TSB CONTAINS AN OWNER NOTIFICATION LETTER. SELECT DOCUMENT SEARCH BUTTON BELOW. LIMITED SERVICE CAMPAIGN (LSC) ISSUED FOR CERTAIN VEHICLES, THAT ARE REGISTERED OR OPERATE, IN SPECIFIC COLD CLIMATE AREAS WITH HIGH USAGE OF ROAD SALT THAT CAUSES CORROSION TO VEHICLE'S FRAME. MODEL 2004-06 TUNDRA. *PE
DSD_LSC_Dealer L — STRUCTURE:FRAME AND MEMBERS
Dealer Letter: * Toyota has received reports that certain 2004 through 2006 model year Tundra vehicles operated in specific cold climate areas with high road salt usage may exhibit more-than-normal corrosion to the vehicle's frame. * This condition is unrelated to and separate from normal surface rust which is commonly...
LSC DOD - Dealer — STRUCTURE
Toyota has received reports that certain 2004 through 2006 model year Tundra vehicles operated in specific cold climate areas with high road salt usage may exhibit more-than-normal corrosion to the vehicle?s frame. Toyota investigated these reports and determined that the frames in some vehicles may not have corrosion resistant protection...
Info packet for — STRUCTURE
Toyota has been offering Corrosion-Resistant Compound ("CRC") campaigns for different model year ("MY") Toyota vehicles registered in certain cold climate states with high road salt use. Toyota Motor Sales. U.S.A. Inc. ("TMS") has developed this Dealer Information Pack to apply across all current and any potential future CRC campaigns
Showing 10 of 12 technical service bulletins.
NHTSA Investigations for the 2006 TOYOTA TUNDRA
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the TOYOTA TUNDRA
- 2001 TOYOTA TUNDRA — 539 complaints
- 2002 TOYOTA TUNDRA — 643 complaints
- 2003 TOYOTA TUNDRA — 514 complaints
- 2004 TOYOTA TUNDRA — 650 complaints
- 2005 TOYOTA TUNDRA — 491 complaints
- 2006 TOYOTA TUNDRA (current)
- 2007 TOYOTA TUNDRA — 535 complaints
- 2008 TOYOTA TUNDRA — 458 complaints
- 2009 TOYOTA TUNDRA — 53 complaints
- 2010 TOYOTA TUNDRA — 216 complaints
- 2011 TOYOTA TUNDRA — 183 complaints
Other TOYOTA Models
- TOYOTA CAMRY — 23,209 total complaints
- TOYOTA PRIUS — 15,411 total complaints
- TOYOTA COROLLA — 14,342 total complaints
- TOYOTA RAV4 — 11,737 total complaints
- TOYOTA SIENNA — 10,769 total complaints
- TOYOTA TACOMA — 10,512 total complaints
- TOYOTA HIGHLANDER — 6,663 total complaints
- TOYOTA 4RUNNER — 6,405 total complaints