2001 TOYOTA SIENNA Structurebodydoor Problems

I PURCHASED A BRAND NEW 2001 TOYOTA SIENNA XLE IN 2001. THE PASSENGER SIDE POWER SLIDING DOOR HAS GIVEN US PROBLEM SINCE WE PURCHASED THE CAR. WE HAD IT BACK TO THE DEALER FOR THE SAME POWER DOOR ISSUE AT LEAST 11 TIMES. THEY NOW WANT TO CHARGE ME. THE NTSB SHOULD FORCE A RECALL TO FIX THIS ISSUE. THE DOOR WILL NOT OPEN OR CLOSE AND NOW IT WILL NOT MOVE AT ALL EITHER BY REMOTE OR MANUALLY. *KB

I PURCHASED A BRAND NEW 2001 TOYOTA SIENNA XLE IN 2001. THE PASSENGER SIDE POWER SLIDING DOOR AND THE DRIVERS SIDE POWER SLIDING DOOR HAS GIVEN US PROBLEMS SINCE WE PURCHASED THE CAR. WE HAD IT BACK TO THE DEALER FOR THE SAME POWER DOOR ISSUE AT LEAST 11 TIMES. THEY NOW WANT TO CHARGE ME. THE NTSB SHOULD FORCE A RECALL TO FIX THIS ISSUE. THE DOOR WILL NOT OPEN OR CLOSE AND NOW IT WILL NOT MOVE AT ALL EITHER BY REMOTE OR MANUALLY. WE PURCHASED THE DUAL POWER SLIDERS AS A CONVENIENCE AND NOW WE HAVE INCONVENIENCE. WE HAVE NOT BEEN ABLE TO USE THE DOOR PROPERLY FOR YEARS, WE HAVE NEVER HAD THE BENEFIT OF THE POWER SLIDING DOORS THAT WE PAID FOR. I WOULD REQUEST THAT THE GOVERNMENT INVESTIGATE THE NUMEROUS COMPLAINTS ON THE VARIOUS BLOGS FOR THE SAME ISSUE DESCRIBED HERE. WE HAVE HAD...

BOTH DRIVER AND PASSENGER SLIDING DOORS WILL NOT OPEN FROM THE INSIDE. THE CHILD LOCKS ARE NOT ON, AND OCCASIONALLY THE DOORS WILL NOT LATCH CLOSED. AFTER FIDGETING WITH THE LOCK AND LATCH, IT WILL EVENTUALLY LATCH. *TR

I OWN A 2001 TOYOTA SIENNA VAN CE. IN THE PAST 1.5 YEARS ALL DOOR HANDLES HAVE SEPARATED FROM THE CAR. THIS INCLUDES THE DRIVER, PASSENGER, REAR DRIVER, REAR PASSENGER AND TAILGATE DOORS HANDLES. THESE HANDLES ARE MADE FROM PLASTIC AND CRACK AND BREAK OFF AT THE HINGE POINT. I DON'T BELIEVE THE NUMBER OF BREAKAGES OF THESE HANDLES CAN BE CAUSED BY NORMAL WEAR AND TEAR AND CERTAINLY WITH TWO SMALL CHILDREN AND TWO ADULTS MAKING USE OF THE VEHICLE WOULD CONSTITUTE NORMAL WEAR AND TEAR. THIS PROBLEM IS A DEFECT OF DESIGN OR WORKMANSHIP OF THE HANDLE AND THE COST TO REPAIR IS APPROXIMATELY $350 PER HANDLE. IT IS A SERIOUS THREAT SHOULD THEY BREAK AT THE IMPROPER TIME OR FOR EMERGENCY ACCESS TO THE AUTOMOBILE. I HAVE ADDRESSED MY CONCERNS WITH TOYOTA AND THEY DON'T BELIEVE THERE IS A NEED TO CORRECT. PLEASE INVESTIGATE AND RESPOND. [XXX]...

WHEN CHILD LOCK IS ON THE POWER DOOR ON PASSEGER SIDE CAN BE OPENED BY A 4 YEAR OLD. *TR

PASSENGER SLIDING DOOR WOULD NOT CLOSE/OPEN ELECTRONICALLY OR MANUALLY. THE BUTTON TO TURN OFF THE ELECTRONIC OPEN/CLOSE DID NOT WORK. TOYOTA SERVICE COULD NOT FIX. HAD THEM CUT CABLE SO CAN CLOSE AND OPEN DOOR MANUALLY. UNTIL THE CABLE WAS CUT, DOOR COULD NOT BE USED TO EXIT VAN. *TR

I HAVE A 2001 TOYOTA SIENNA AND THE BOTH THE REAR SLIDING DOORS HAVE HAD INTERMITTENT ISSUES WITH EITHER OPENING OR CLOSING SINCE AROUND 2003 (ALTHOUGH MORE OFTEN SEEN WITH DRIVER SIDE). WHEN THE ISSUES IS PRESENT THE DOORS WORK FINE WHEN THE AUTOMATIC OPEN/CLOSE IS TURNED OFF. THE ISSUE MAY OCCUR MORE OFTEN WHEN RAINING THEN WHEN DRY. ONE OBSERVANCE OF ISSUE IS THAT WHEN AUTO OPEN IS ENGAGED THE DOOR MAKES A CLICKING SOUND BUT DOESN'T OPEN. THE OTHER OBSERVANCE OF ISSUE IS WHEN THE DOOR IS OPEN AND THE AUTO CLOSE IS ENGAGED THE DOOR STARTS TO CLOSE (MAYBE AN INCH) AND THEN RE-OPENS...THE ONLY WAY TO GET THE DOOR CLOSED IS TO TURN OFF THE AUTO OPEN/CLOSE. WHILE UNDER WARRANTY I TOOK THE VAN TO BE SERVICED TWICE, BUT WAS NOT ABLE TO RE-PRODUCE THE ISSUE AT THE DEALERSHIP...AS SUCH THEY WOULD NOT EVEN LOOK AT...

THE POWER SLIDING DOOR ON OUR 2001 TOYOTA SIENNA MINIVAN QUIT WORKING. AFTER A MORNING OF RESEARCH ON THE INTERNET I FEEL COMPELLED TO COMPLAIN AS THIS IS EVIDENTLY A RECURRING PROBLEM. IT CAN BE OPENED MANUALLY WITH MODERATE EFFORT. *TR

TL*THE CONTACT OWNS A 2001 TOYOTA SIENNA. THE CONTACT STATED THAT THE PASSENGER SIDE SLIDING DOOR STOPPED WORKING. THE DOOR DOES NOT OPEN ALL THE WAY WITH THE REMOTE CONTROL OR MANUALLY. THE CONTACT HAS TO FIND A WAY TO OPEN THE DOOR WHEN THIS OCCURS, WHICH IS USUALLY IN RAINY OR SNOWY CONDITIONS. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT IT WOULD COST $2,200 TO REPLACE THE MOTOR AND THE COMPUTER. THE FAILURE MILEAGE WAS 110,000.

COMPLAINT REGARDING THE 2001 TOYOTA SIENNA DRIVER'S SIDE DOOR CONTINUOUSLY OPENS AND CLOSES.*MR THE ONLY WAY TO STOP THE DOOR WAS TO DISENGAGE THE POWER AND CLOSE IT MANUALLY. THE DEALER DETERMINED THAT THE MOTOR THAT OPERATES THE POWER DOOR AND THE ECU NEEDED TO BE REPLACED AT A COST OF $1939. THE MANUFACTURER HAS AGREED TO ASSIST WITH THE COST OF THE REPAIR, HOWEVER THE CONSUMER'S PORTION IS STILL QUIT COSTLY. *NM

HILD SAFETY LOCKS ON REAR SLIDING DOORS ARE BYPASSED AND RENDERED USELESS BY REAR POWER DOOR BUTTONS. WITH THE CHILD SAFETY LOCKS ENGAGED THE SLIDING DOORS CAN NOT BE OPENED MANUALLY FROM THE INSIDE. HOWEVER THE REAR POWER DOOR BUTTONS LOCATED ON THE REAR DOORS, ON THE FRONT CONSOLE, AND ON THE REMOTE ALL FUNCTION NORMALLY. THERE IS A SEPARATE BUTTON ON THE FRONT CONSOLE THAT DEACTIVATES THE POWER DOOR FUNCTION, BUT IT DEACTIVATES IT FROM ALL 3 POINTS (BUTTONS ON THE REAR DOORS, ON THE FRONT CONSOLE, AND ON THE REMOTE) RENDERING THE EXPENSIVE POWER DOOR FEATURE USELESS. TO COMPLY WITH THE CHILD SAFETY LOCK REQUIREMENT, WHEN THE CHILD SAFETY LOCK IS ENGAGED IT SHOULD DISABLE MANUAL OPENING OF THE DOOR BY BACKSEAT OCCUPANTS AND SHOULD DISABLE THE POWER DOOR BUTTONS LOCATED ON THE BACK DOORS WITHIN EASY REACH OF BACKSEAT OCCUPANTS. MANUFACTURER WAS CONTACTED, BUT HAS FAILED TO...

DEAR SIRS, I WANT TOYOTA TO BUY BACK MY SIENNA VAN. I HAVE HAD MY VAN REPAIRED 4 TIME FOR A INOPERATIVE POWER SLIDING DOOR,ERRATIC OPERATING POWER SLIDING DOOR, UNINTENTIONAL ACTIVATION POWER SLIDING DOOR. THE DOOR IS NOW BROKE AGAIN. AFTER THEY FIX THE DOOR THIS WILL BE THE 5TH REPAIR TO THE DOOR. THE DOOR NOW OPENED ONE TIME WHILE DRIVING THE CAR AT SLOW SPEED. THIS IS NOT SAFE!

VEHICLE SHUT OFF WITHOUT PRIOR WARNING. BATTERY/ ALARM SYSTEM/ KEY, AND STARTER WERE CHECKED. *AK

AUTOMATIC SLIDING DOORS W/O REVERSING SENORS ARE A SERIOUS INJURY RISK. *AK

AFTER PURCHASING A NEW SIENNA IN MARCH MY DRIVER SIDE POWER SLIDING DOOR FAILED IN MAY. THE DRIVER SIDE POWER DOOR ECU WAS REPLACED. 10 DAYS LATER THE DOOR FAILED AGAIN, THIS TIME THE DOOR WAS ADJUSTED AND REINITIALIZED. AS I TESTED THE DOOR AT TIME OF PICKUP THE DOOR FAILED AGAIN. THE REAR LATCH PIN SWITCH WAS REPLACED AND THE DOOR WAS REINITIALIZED. THE DOOR WORKED FINE UNTIL FAILURE JULY 31ST. SOME ADJUSTMENTS WERE MADE AND THE DOOR WAS REINITIALIZED, AT TIME OF PICKUP AUGUST 5TH THE DOOR FAILED AGAIN. A FIELD TECH FROM TOYOTA FOUND LOOSE PINS IN THE DOOR AND THE MAIN BATTERY POWER LEVEL WAS LOW. THE PINS WERE FIXED AND THE ALTERNATOR BELT WAS REPLACED WITH A HEAVIER ONE TO INCREASE THE MAIN BATTERY POWER. HOPEFULLY THIS WILL SOLVE THE PROBLEM AS I FEAR DOOR MALFUNCTION WITH MY CHILDREN'S SAFETY MY MAIN CONCERN!*AK

THE POWER SLIDING DOOR SYSTEM IS DANGEROUS WITH SMALL CHILDREN. THE DOOR TAKES INCREDIBLE RESISTENCE BEFORE THE REVERSING SYSTEM WILL KICK IN AND STOP THE DOOR FROM CLOSING. THE SYSTEM APPEARS TO BE DESIGNED MAINLY TO PROTECT THE DOOR MOTORS FROM DAMAGE, NOT TO PROTECT PEOPLE FROM INJURY. INFACT, THE OWNER'S MANUAL SPECIFICALLY SAYS TO TURN THE POWER DOOR SYSTEM OFF WHEN SMALL CHILDREN ARE PRESENT, YET THIS VEHICLE AND THESE FEATURES ARE MARKETED TO FAMILIES WITH SMALL CHILDREN. ALSO THE CHILD LOCK-PROTECTION SYSTEM DOES NOT WORK WHEN THE POWER DOOR SYSTEM IS TURNED ON. THE RESISTANCE REQUIRED TO STOP THE POWER DOOR IS VERY SUBSTANTIAL. ANY BODY PART, EVEN AN ARM OR LEG OF AN ADULT THAT GOT CAUGHT IN THE DOOR COULD SUFFER SERIOUS INJURY. THE DOORS ARE VERY DIFFICULT TO OPEN AND CLOSE WHEN THE POWER SYSTEM IS TURNED OFF. THE DEALER AND SALES PERSON KNEW I...

IT TAKES CONSIDERABLE AMOUNT OF WEIGHT TO HAVE REBOUND FEATURE FOR POWER SLIDING DOOR TO OPERATE. CONSUMER FEELS THIS FEATURE IS USELESS AS A SAFETY FEATURE.*AK *SLC