2020 TOYOTA RAV4 Engine Problems

Engine coolant bypass valve failure @40k miles. Could cause engine to overheat possibly be stranded.

Car operating as normal in the morning, few hours later went to start up car again and had message saying “hybrid system malfunction”. Drove it around for a few minutes then other lights started flashing, lane departure, traction control, crash detection. They all went away and except the hybrid malfunction warning.

Vehicle displayed Engine Maintenance Required light at 54,000 miles. As issue was described from dealer, "Engine code was P268115 for an engine coolant bypass valve circuit short to battery or open. Found Coolant valve intermittently sticking." Was told by technician that if the part was not replaced, the issue could lead to engine overheating and that after they made the fix, they were going to check to see if a gasket was possible blown from the issue resulting from overheating that may have gone overlooked.

Engine bypass coolant valve… Engine maintenance required pops up intermittently. Per dealer there is a short circuit in valve/ bypass part. The dealer had already known this was issue prior to car being diagnosed. They stated they are aware and this is a known issue.

2020 RAV4 with 47,589 miles. The engine maintenance light came on. It turns off once I shut off the vehicle and start it up again. It only comes back on when I put the air conditioner or heater on. I was told it's the heater control valve/coolant bypass valve and would cost around $900+ to repair. I did some research and see that this problem is occurring alot.

Coolant bypass valve failed vehicle warning lights came on for this 2020 Toyota Rav4 at 31,641 miles. This is absolutely available for inspection on request. Safety as this can potentially cause overheating, coolant leaking, a cracked cylinder. The manufacturer (Local Toyota dealership - "Ed Morse Delray Toyota" inspected and suggested replacement of the coolant bypass valve for this 2020 toyota rav4 for a price around 800$. the technician say they see a load of these newer model Rav4's needing new coolant bypass valves. I opted not to immediately replace the valve due to it being a vehicle model-wide issue that should likely be a recall. These appeared the day before I brought it in to the dealer so withing 5-10 miles of the 31,641 miles for this 2020 Toyota Rav4. Warning just says "error please take in to dealership for service".

My coolant bypass valve in the engine malfunctioned and shorted at a mere 27,300 miles on the vehicle and I had to bring it into the dealership to be replaced. A coolant bypass valve failing or malfunctioning can cause the engine to overheat, catch fire, or cause complete seizure. Can also cause the vehicle to stall and possibly cause a crash or wreck. Toyota has acknowledged the problem in the RAV4’s but no recalls have been issued. Dealer knew exactly what the problem was when I mentioned that the ‘engine maintenance required’ light came up on my dashboard BEFORE mechanic diagnosed it and confirmed which tells me they are aware of the issue in these cars.

In September 12,2023 I took my 2020 Toyota Rava 4 vehicle in to Cobb Toyota for a coolant by pass valve to be replaced after my check engine light kept coming on. I only had 25 790 miles on my vehicle at the time. Anthony Sullivan was my service rep. at the time And he stated that this something has been common with this type of vehicle. But could not explain why. I just wanted to report this to Toyota. They need to know about this. And I need to be reimbursed for $99.30 for what I paid for this repair under warranty. Thank you,

engine coolant bypass valve short to battery

At 68,000 miles my Toyota Rav4 needs to have coolant bypass valve replaced. My understanding is this is getting to be a common problem and would like to see it placed on a RECALL. Thank You.

My 2020 Toyota RAV4, "Engine Maintenance Required: See Dealer" message came on my dashboard and would not go away when I cleared it. I took it into the dealership, and they stated that they had 1000s of RAV4's come in with this same message. They said it was the engine's coolant bypass valve. After diagnosing the problem, the dealership confirmed it was the coolant bypass valve. This was very expensive to fix, $926.67, to be exact. For a car that is just over 3 years old, less than 40,000 miles, Toyota knew of these defective parts and still put them in to get the car out of their factory and onto a dealer’s lot. They do not care if it kills anybody, just get the car sold. Toyota needs to have this bypass valve as a ‘recall’ and issue refunds to THEIR loyal customers, so they call us, loyal customers,...

Coolant Bypass valve has stopped working, which can cause engine issues and forces a message on LED display saying Engine Maintenance Required. Local Toyota technician admitted that they've had 100's of these issues with the Rav4 recently and it costs over $500 to fix.

Engine maintenance light came on and dealership indicates it’s the coolant bypass valve. This seems to be a common safety issue being ignored by both Toyota and the transportation safety board…

Coolant bypass valve shorts out and doesn't open or close to allow coolant through it. "Engine Maintenance Required" message pops up for this. Toyota dealer inspected it and it replacing the part. NOT covered under my warranty.

Engine coolant bypass valve needs to be replaced. Seems to be a very common issue in 2019-2023 RAV4s but Toyota has not issued a recall and is making customers pay $600-900 to fix. I ask that Toyota take responsibility and issue the recall now so this can be fixed!

Unknown engine maintenance light alert check light Recommend engine coolant bypass valve with gallon of coolant

Part # 16260-f0010 - engine coolant bypass valve failed due to open or internal short and caused a Engine maintenance required warning which blocked other safety items on the display. This is a wide spread and known issue for Toyota which can result in engine overheating due to leaking coolant and result in engine failure (severely damage the engine) leading to engine stall and/or fire risk, causing potentially unsafe situations to occur for the driver and others in the vehicle. The error code is "P268115" for "Engine Coolant Bypass Valve Circuit Short to Battery or Open". Yes. the problem has been reported with NHTSA by others and from some dealers. When I took the vehicle into the dealership, and they stated that they had many RAV4's come in with this same message. They immediately said it is some engine component failure. There is a related NHTSA Campaign Number: 20V064000 (Engine...

There was a warning message pop up all the time and I went to Toyota service. They said I need to pay for a coolant bypass valve replacement and it costs approx 600-800 dollars. Also, they did not fill up for the engine oil even it’s in very low to dry position.

Engine maintenance required light came on. Scan code came up engine coolant bypass valve stuck open. Had to replace it. Cost me $120 for the part with hoses attached.

-Inspection found coolant bypass valve seized recommendation, was to replace coolant hose with bypass valve. YES, the car is available for inspection upon any request -Safety risk unknown if not fixed -Michaels Toyota of Bellevue Washington confirmed on September 23rd 2023. I brought the car in originally on September 9th 2023 for a 10,000 mileage service and oil change. when I called to ask why the engine maintenance notice wouldn't turn off. I was scheduled to bring the car back on September 23, 2023 the needed part was not in stock nor covered by the factory or powertrain warranty with 31,2002 miles on it. The warning light came on at the same time the service and oil change was due. I was stopped a month prior by a random mechanic who noticed the car was leaking abnormal amounts of what he said could be coolant on the passengers front undercarriage....

RAV4 53,000 miles on and engine maintenance required prompt came on. No other warning lights on dash. Took it to dealership and it was a coolant bypass valve. Read up on it and it’s been happening to many more people. Was originally charged $900 but got a discount ended up being $825

Engine maintenance required “Visit dealer” Light is on and won’t turn off even when resetting the scheduled maintenance data. Needs a 3 point valve according to dealership. $650 cost for that part to make light go away. This is something that needs fixed and recalled as he says it’s a common issue with the RAV4.

I have 2020 Toyota rav4 XLE and all of sudden I got "Engine Maintenance Required" When I turn off the AC, this message goes away but comes in when I turn on the AC. I believe, it is coolant bypass valve which needs to be replaced. I read my forums in [XXX] and [XXX] and many others have complaint about the same. Toyota has to have a recall on this poorly manufactured bypass value. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Got an engine maintenance required alert, took to Toyota and they advised the coolant bypass valve needs to be replaced at just 38,000 miles. Googled this and found out many 2020 RAV4 with the same issue at just under 40,000 miles. Also a common issue is the voltage being low and we already had to get the battery replaced once and still get alerts of it being low after replacement. Have to pay today $765 for the coolant bypass to be replaced, will have the receipt later in the day.

My RAV4 doesn’t even have 40,000 miles on it. I found out that the coolant bypass system needs to be replaced. After investigating online, I realized that this is a very common problem for RAVs. I believe this should be a recall!

ENGINE COOLANT BYPASS VALVE failed internally causing an open circuit.

I have a 2020 RAV4 Toyota with 60,000 miles.. I have replaced the car battery 3 times now Toyota has no clue why. The 2nd battery only lasted 8 months and it was a name brand battery (Die Hard).. The engine problem started with a warning light that i could not turn off.. I took my car to Toyota and they told me right off (without checking) it was because of a Coolant Bypass Value, the Toyota service lady said it was her 5th Rav4 this week with the same problem. I checked on line and was surprised how many Rav4 customers were complaining about the same issue so i reported it to you.. Toyota is charging me $900 to replace.

Coolant bypass valve failure my car has less than 50k Dealerships informed me that they fix around 10 a month for that part there is a defect regarding this pump

In my 2020 Toyota RAV4, a "Engine Maintenance Required: See Dealer" message came onto my dashboard and would not go away when I cleared it. I took it into the dealership, and they stated that they had many RAV4's come in with this same message. They said it was most likely the engine's coolant bypass valve. After diagnosing the problem, the dealership confirmed it was the coolant bypass valve. This was very expensive to fix, and for a car that is just over 3 years old it seems unusual for this to occur so soon and to so many other card within the same year and time period. This part needs to be recalled and reimbursement should be provided to those who had to pay hundreds of dollars to get this fixed when it is very likely a faulty part.

This is a common issue for the 5th Generation Rav4. It doesnt read fault codes on the OBD2 scanner, but the ENGINE MAINTENANCE alert continuously comes up because of a faulty coolant bypass hose/valve. Toyota OEM Part # 16260-f0010. This should be a recall. Instead, we are paying out of pocket to get this fixed.

Coolant Bypass Valve on my 2020 RAV4. There needs to be a recall; even Toyota dealerships in the Dallas/Fort Worth metroplex say that there needs to be a recall. Service advisors say this is a big problem they see daily and with all cars and at all mileage. The cost to replace the Coolant Bypass Valve in my car = $855- RIDICULOUS!! In addition, due to the constant “Engine Maintenance Required” message on the screen triggered by the Coolant Bypass Valve needing to be replaced, that can’t be removed, all other car related information and/or service issues, is unable to be seen…which is dangerous!! Toyota used to be one of the best car manufacturers for quality and reliability, but now, their quality has tanked…

Coolant value had to be replaced apparently this happens more than we realize and if it’s a repetitive issue for many I believe it should be looked into. Thanks

I was driving and out of nowhere this warning came on engine maintenance required, and this now a normal maintenance required that means an oil change. The problem with this warning is the coolant bypass valve, and I’m not the only one with this issue, my car has only 32100 miles only, this a ridiculous for a new car. Plus it seem that this issue only comes on with tha A/C on

My car is leaking coolant and needs a new coolant bypass valve. It seems like it is happening to every rav4 and camry. They put in faulty parts.

Coolant Bypass Valve failure at 41K miles. Confirmed by dealership. "Engine Maintenance" warning light came on before taking to dealership.

Coolant Bypass valve internal short.

The Engine Maintenance Required Visit your Dealer came on and wouldn’t go away. I took it into Toyota and they charge $166 dollars to run a diagnostic. Plus what ever it cost to fix it. Turns out that 2020 Toyota RAV 4 Have an issue with the coolant by pass it’s a pipe if left unfixed it can make the car over heat and it’s part of the radiator can cost $700 to fix at the dealership. My car is only 3 years old it shouldn’t have this issues and be costing my hundreds of dollars to fix.

The engine maintenance required light came on at 56,000 miles and would not reset even after a scheduled oil change. The Toyota dealership neglected to evaluate this light when I brought my car in for servicing. After getting a diagnostic, it was found that the coolant bypass valve needed to be replaced which was at least $600. I was advised that the vehicle was to not be driven long distances as it could result in more damage to the car. This is my 4th expensive repair on this 3 year old car in 1 year. This is my very first Toyota, & I am extremely disappointed. I bought a Toyota anticipating a low maintenance, high quality vehicle and have had nothing but issues.

There is a known issue with the coolant bypass valve failing. Dealerships are charging over $600 to fix and many people are having the same issue. The engine maintenance required message is persistent, and will not allow you to bypass it.

The vehicle has a message engine maintenance required. The Toyota dealership diagnostic was that the coolant bypass valve needed to be replaced. The dealer told us they are getting at least 6 Rav4 a week coming in with the same issue. The part replacement isn't covered manufacturer under warranty. This needs to be a recalled part.

Coolant Bypass Valve failure/malfunction. Frequently reported issue for model/year.

The coolant bypass valve is defective on a 3 year old single owner, well maintained under 50,000 miles vehicle. This is a wide spread and known issue for Toyota which can result in engine overheating, causing potentially unsafe situations to occur for the driver. This can also severely damage the engine.

The Coolant flow control valve is malfunctioning. This was diagnosed by a Toyota dealer. My car is 3 years old and has 56k miles. Upon doing more research, a lot of people have complained that the same things are happening to their vehicles as well. To my understanding, this is not something typical for a car as young as mine.

Coolant Bypass Value Replacement required on my 2020 Rav 4. I have 33,000 miles & purchased in 2019, so it is not covered under warranty. The dealer is charging me over $850 to replace. I have been told by the Dealer that this is a "KNOWN" problem with this and other Toyota models. Why is there not a recall or extended warranty on this repair if so many owners are paying hundreds of dollars on relatively newer cars with the same FAULTY PRODUCT? I would like Toyota to reimburse me. I am having the car repaired tomorrow because I have been told it is dangerous to use the vehicle in this condition. Please assist me with ways to get reimbursed from Toyota and for others to receive repairs at no cost, especially on vehicles under 5 or 6 yrs old. thank you.

Coolant valve replacement

2020 Toyota Rav4, just around 25K miles, took to dealership to get regular maintenance service, (oil change, tire rotation). After a couple days, "engine maintenance required" message pops up. Plugged in code reader and brings up code "P268115" for "Engine Coolant Bypass Valve Circuit Short to Battery or Open". This issue is popping up for many recent year Toyota models (Rav4, Camry, Corolla) and is not being repaired by Toyota for free. They are charging $600 - $1000 to repair faulty part that is not the owner's fault and issue needs to be recalled.

At approximately 60K on my 2020 Toyota Rav4 XLE The Engine Maintenance Required Visit Your Dealer message came on my dash. It's been a known issue for many Rav4's not to mention other Toyota models for the engine coolant bypass switch to have gone bad. The vehicle is available for inspection upon request. My safety and whom I may be transporting can be put at risk if the engine refuses to start or operate as normal and can leave us stranded. The problem is known by Toyota and many of these valves have been replaced at the dealer for a very high cost.

Dash reported "Engine Maintenance Required / Visit Dealer" - dealer said it was a "coolant bypass hose", not covered by any warranty. $100 part but engine-out procedure costs $800. This vehicle has less than 40,000 miles.

Car has 26K miles on it (3 year 2 months old). A light appears saying Emergency Engine Maintenance is required. After research as this error is not in manual, found out it was a failed coolant bypass valve and this was a common failure/faulty equipment but we are being asked to pay full price to repair. A simple internet search shows 100's of consumers with same issue in same model and low miles.

Coolant Bypass Valve breaks easily and in many RAV4s and Corollas. When this happens an "Engine Maintenance Required" see your dealer message comes up in the heads up display and won't go away. Makes seeing the important details of speed, miles to empty, etc on the screen impossible read. It is a known issue by Toyota and they refuse to do a recall.