2002 TOYOTA RAV4 Engine And Engine Cooling Problems

DEFECTIVE ENGINE CONTROL MODULE (ECM). AS A RESULT OF SENDING THE WRONG SIGNAL TO THE TRANSMISSION, IT GOT RUINED AND THE TRANSMISSION HAD TO BE REBUILT. IF THERE WAS A RECALL ON THE ECM FOR THE 2002 TOYOTA RAV4, I WAS NOT AWARE OF IT, OR I STILL DID NOT OWNED THE VEHICLE. *TR

TL* THE CONTACT OWNS A 2002 TOYOTA RAV4. THE CONTACT STATED THAT THE VEHICLE JERKED ABNORMALLY WHILE DRIVING AND WOULD LOSE ACCELERATION. THE VEHICLE WAS TAKEN TO THE DEALER WHO PERFORMED A DIAGNOSTIC WHICH LOCATED THE FAILURE AT THE ELECTRONIC CONTROL MODULE (ECM). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DENIED ANY ASSISTANCE WITH THE REPAIRS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 100,600. UPDATED 10/11/12*LJ

I HAVE A 2002 TOYOTA RAV4. ABOUT A MONTH AGO IT STARTED INTERMITTENTLY SKIPPING/JERKING AND BEING STUCK IN GEAR. I TOOK IT TO TWO TOYOTA DEALERSHIPS, THE FIRST ONE INFORMED ME OF A FACTORY WARRANTY EXTENSION FOR THE ECU FOR MY VEHICLE, BUT BECAUSE THE CHECK ENGINE LIGHT IS NOT ON THEY CANNOT GET ANY CODES, THE SECOND DEALERSHIP TOLD ME THE SAME THING AS WELL AS THE TOYOTA COMPANY. THE WARRANTY IS FOR 10YRS OR 100,000 MILES WHICHEVER COMES FIRST. I HAVE 70,000 MILES AND IT WILL BE 10YRS THE 25TH OF THIS MONTH. I HAVE RESEARCHED THIS PROBLEM ONLINE AND HAVE FOUND THAT HUNDREDS OF PEOPLE HAVE THE SAME PROBLEM WITH THIS VEHICLE. DO I HAVE ANY OPTIONS TO HAVE THIS TAKEN CARE OF, ASAP BECAUSE OF THE 10YR WARRANTY THAT WILL NO LONGER COVER ME FOR THIS? *TR

HARSH SHIFTING AND JERKING, PARTICULARILY 1ST & 2ND GEAR SLOW TO ACCELERATE LAUNCHING AND BUCKING HARD ENGAGEMENT WHEN PUT IN REVERSE REVS UP FROM 2 TO 3 - 4 RPMS. *TR

TL* THE CONTACT OWNS A 2002 TOYOTA RAV4. WHILE DRIVING APPROXIMATELY 55 MPH, THE CONTACT HEARD A GRINDING SOUND COMING FROM THE FRONT END OF THE VEHICLE FOLLOWED BY THE VEHICLE STALLING. THE VEHICLE WAS TOWED TO THE CONTACTS HOME AND WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE CONTACT HAD PREVIOUSLY TAKEN THE VEHICLE TO THE DEALER FOR A SIMILAR FAILURE WHERE THE TECHNICIANS REPLACED THE FLYWHEEL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 128,000. UPDATED 04/19/12*LJ UPDATED 04/25/12

TL*THE CONTACT OWNS A 2002 TOYOTA RAV4. THE CONTACT STATED THAT WHILE DRIVING THE CHECK ENGINE LIGHT ILLUMINATED, AND SHE WAS UNABLE TO SHIFT GEARS. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THE FAILURE WAS WITHIN THE ELECTRIC CONTROL UNIT. THE VEHICLE WAS TAKEN TO A FOREIGN GARAGE SPECIALIST WHO REPLACED THE ELECTRONIC CONTROL UNIT. THE CONTACT RECEIVED A LETTER FROM THE MANUFACTURER CONCERNING A WARRANTY ENHANCEMENT FOR THE ECU FAILURE, BUT THE MANUFACTURER DENIED REIMBURSEMENT SINCE THE VEHICLE WAS OVER THE 150,000 MILE WARRANTY ENHANCEMENT PROGRAM. THE FAILURE MILEAGE WAS 172,000. THE CURRENT MILEAGE WAS 188,000. UPDATED 03/07/11*LJ UPDATED 11/28/11 *CN

TL*THE CONTACT OWNS A 2002 TOYOTA RAV4. WHILE THE CONTACT WAS DRIVING APPROXIMATELY BETWEEN 30-40 MPH, THE OIL PRESSURE WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE FAILURE WOULD OCCUR AT VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION. THE TECHNICIAN WAS UNABLE TO LOCATE A PROBLEM. THE FAILURE PROGRESSED OVER A PERIOD OF TIME. RECENTLY, THE "SERVICE ENGINE" WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN DETECTED AN ENGINE OIL SLUDGE AND LOW OIL PRESSURE. ALSO, HE RECOMMENDED THE ENGINE BE REPLACED. THE CONTACT STATED THAT THE MANUFACTURER SHOULD BE LIABLE FOR THE REPAIR; HOWEVER, THE MANUFACTURER REFUSED TO TAKE FINANCIAL RESPONSIBILITY. THE VEHICLE WAS AT THE DEALER AND HAD NOT BEEN REPAIRED. THE CONTACT PLANNED TO HAVE THE VEHICLE TOWED TO HIS RESIDENCE. THE FAILURE MILEAGE WAS APPROXIMATELY 33,000.

2002 TOYOTA RAV4 STARTED HESITATING ON INITIAL ACCELERATION AND BOLTING WHEN THE GEAR CAUGHT 2ND. WAS PULLING OUT INTO INTERSECTION AND NEARLY T-BONED BY FORD EXPEDITION. BROUGHT TO TRANSMISSION SPECIALIST. NO ENGINE LIGHT, NO CODE. READ ABOUT POTENTIAL ECM PROBLEM. BROUGHT TO TOYOTA AND SPENT $1400.00 TO REPLACE ECM. *TR

IN 2003 WE BOUGHT A BRAND NEW 2002 TOYOTA RAV4. IN 2007, THE ENGINE SEIZED UP AT 56,000 MILES. WE TOOK IT TO TOYOTA AND THEY TOLD US IT WOULD COST $7,000 BECAUSE THEY NEEDED TO REPLACE THE ENGINE. AFTER GATHERING ALL OUR MAINTENANCE HISTORY AND MUCH DELIBERATION TOYOTA AGREED TO REPLACE THE ENGINE BUT WE HAD TO PAY FOR THE LABOR ($2500); WE AGREED. AFTER THEY DID THE WORK, WE HEARD A SOFT CONSTANT BEATING SOUND COMING FROM THE ENGINE. WHEN WE TOOK IT BACK, WE WERE TOLD THAT SOUND WAS NORMAL WHEN A NEW ENGINE IS INSTALLED AND IT WILL GO AWAY -- IT DIDN'T. 18 MONTHS AND 10,000 MILES LATER, THE ENGINE DIED AGAIN. BAFFLED AT HOW TWO SEPARATE ENGINES CAN DIE WE TOOK IT TO OUR PERSONAL MECHANIC. HE EXPLAINED TO US THAT THE ENGINE WAS NEVER REPLACED, BUT REBUILT. WE TOOK IT BACK TO THE...

TL* THE CONTACT OWNS A 2002 TOYOTA RAV4. THE CONTACT WAS DRIVING APPROXIMATELY BETWEEN 35-45 MPH ON NORMAL ROAD CONDITIONS, PROCEEDING TO A TRAFFIC STOP SIGNAL. THE ENGINE REVED EXCESSIVELY HIGH. THE TRANSMISSION EXHIBITED A HARSH SHIFT AS A RESULT OF AN UNEXPECTED ACCELERATION. THE DRIVER WAS ABLE TO CONTINUE IN OPERATION WITH CAUTION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING. THE FAILURE WAS CONTRIBUTED TO THE ENGINE CONTROL MODULE (ECM). THE VEHICLE VEHICLE HAS NOT BEEN REPAIRED AT THIS TIME. THE FAILURE MILEAGE WAS 104,000. UPDATED 11/16/10. *LJ

I HAVE A 2002 TOYOTA RAV 4 WITH 82K MILES ON IT. AT THE BEGINNING OF NOVEMBER, 2009, I WAS DRIVING MY VEHICLE AND IT BEGAN TO JERK VIOLENTLY WHEN I ACCELERATED BETWEEN 1ST AND 2ND GEARS. I HAD DIFFICULTY MAINTAINING CONTROL AND AVOIDED AN ACCIDENT. SUBSEQUENTLY, I TOOK THE CAR TO THE DEALER AND LEARNED THAT I HAD A COMMON PROBLEM FOR 2002 RAV 4'S -- A FAULTY ENGINE CONTROL MODULE. I RESEARCHED THE PROBLEM AND LEARNED THAT MANY PEOPLE HAVE ALSO HAD THIS PROBLEM IN 2001 AND 2002 RAV 4'S. TOYOTA IS NOT TAKING RESPONSIBILITY FOR THIS PROBLEM. THIS SHOULD BE A RECALL ITEM. *TR

I HAVE A TOYOTA RAV4 2002. I AM NOW EXPERIENCING A NIGHTMARE. A FEW WEEKS AGO, MY CAR STARTED SHIFTING GEARS, SHAKING, AND THE ENGINE LIGHT WENT ON. I BROUGHT IT TO HYANNIS TOYOTA. THE CSR TOLD ME IT WAS A DEFECTIVE COMPUTER. THE CAR WAS UNDER WARRANTY AND THEY WOULD REPLACE IT. APPROX. 3 WEEKS LATER, MY CAR STARTED WITH THE SAME PROBLEM. SHAKING, MOVING INTO A DIFFERENT GEAR AND THE ENGINE LIGHT WENT ON. I BROUGHT IT BACK TO HYANNIS TOYOTA AND WAS TOLD, "THIS IS NOT THE SAME PROBLEM." YOU NEED A NEW COIL. IT WILL COST YOU $250.00. ALSO, I HAD TO RENT A CAR. OF COURSE AT MY OWN EXPENSE. NOW, I DO NOT KNOW HOW TO DEAL WITH THIS COMPANY. IF THE COMPUTER WAS DEFECTIVE, AND WAS REPLACED. WHY AM I STILL EXPERIENCING THE SAME PROBLEMS? *TR

TL*THE CONTACT OWNS A 2002 TOYOTA RAV 4. WHILE ACCELERATING FROM AN IDLE POSITION, THE VEHICLE BEGAN HESITATING AND STALLED. THE VEHICLE ALSO HESISTATED 30 TO 45 SECONDS WHEN SHIFTING INTO SECOND GEAR AND ENGAGING THE ACCELERATOR TO IT'S FULL CAPACITY. THE DEALER FLUSHED OUT THE TRANSMISSION FLUID AND REPLACED IT; HOWEVER, THE FAILURE RECURRED. THE MECHANIC LATER STATED THAT THE ELECTRONIC CONTROL MODULE (ECM) WAS DEFECTIVE. THE MANUFACTURER WILL NOT ASSUME THE REPAIR COSTS; HOWEVER, THE CONTACT STATED THAT SINCE THERE IS A DEFECT THE REPAIR SHOULD BE FREE. THE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE WAS 96,000.

CHECK ENGINE LIGHT KEPT COMING ON; I WOULD CARRY IT TO TOYOTA DEALERSHIP AND THEY WOULD RE-SET. THIS HAPPENED MORE THAN TWICE. FINALLY, WHAT I THOUGHT AND WAS TOLD THAT THE TRANSMISSION BLEW, BUT FOUND OUT LATER THAT IS JUST SOUNDED AND REACTED AS IF THE TRANSMISSION WAS GONE. BUT WAS THE ENGINE CONTROL MODULE WHICH HAD FAILED. OF COURSE THE WARRANTY WAS OFF AND AFTER CONTACTING TOYOTA I GET NO ASSISTANCE. THIS IS SOME OF THE INFORMATION I FOUND OUT: ) THAT TOYOTA HQ HAS BEEN AWARE FOR AT LEAST A FEW (2,3?) YEARS THAT THERE WAS A DEFECT IN THE DESIGN OF THE ECM INSTALLED IN 2001/2002 TOYOTA RAV4?S > > 2) THAT THE DEFECT CAUSES PROBLEMS WITH TRANSMISSION OR GEAR-CHANGING MECHANISM > > 3) THAT THE RESULTING TRANSMISSION OR GEAR-CHANGING PROBLEMS ARE NOT DUE TO ?NORMAL WEAR AND TEAR? OF THE VEHICLES. THEY ARE CAUSED DIRECTLY BY...

I BOUGHT A TOYOTA RAV4 2002 AT THE DEALER "TOYOTA OF ALAHAMBRA" AND I BEEN HAVING A PROBLEM TO MANY TIMES WITH THE COMPUTER ENGINE LIGHT COME ON. WHEN I TAKE THE CAR TO THE DEALER THEY TOLD ME THAT NOTHING WAS WRONG. THEY TURNED OFF THE LIGHT AND SAID AND SAID THAT EVERYTHING WAS OK, THIS HAPPENED THREE TIMES. RECENTLY I HAD PROBLEMS AGAIN WITH THE COMPUTER ENGINE AND THEY CHARGED $1,200.00 DOLLARS TO FIX IT AND THEY TOLD ME THAT WAS MY FAULT THAT I WAS TAKING OFF IN 2ND GEAR BUT I NEVER USE THE 2ND GEAR. WHAT I KNOW THIS CARS HAD PROBLEMS WITH THE ENGINE COMPUTER. THE NAME OF THE DEALER IS "TOYOTA-SCION OF GLENDALE" 1260 S. BRAND BLVD. GLENDALE, CALIFORNIA 91204. AS I KNOW WE HAVE 170 COMPLAINTS ABOUT THIS RAV4 TOYOTA CARS. FORTUNATELY I HAVE NOT ANY PROBLEM WITH DEATH, OR FIRE, OR...

OUR RAV4 BEGAN TO HAVE PROBLEMS SHIFTING, AND THE CHECK ENGINE LIGHT WAS ON. TOOK TO LOCAL DEALER. FIRST VISIT RESULTED IN TUNE-UP ITEMS. DEALERSHIP TREATED IT AS AN ENGINE-RELATED PROBLEM. CHECK ENGINE CAME BACK ON AGAIN THE SAME AFTERNOON. ON SECOND VISIT, DEALERSHIP KEPT CAR OVERNIGHT TO DRIVE IT WHILE IT WAS COLD. WE WERE TOLD THAT WE HAD A BAD CATALYTIC CONVERTER, AND THAT THIS WOULD HAVE TO BE REPLACED BEFORE ANY FURTHER DIAGNOSIS COULD OCCUR. THE CC WAS ONLY THREE YEARS OLD, ALREADY HAVING BEEN REPLACED UNDER WARRANTY. THEY HAD ALREADY REPROGRAMMED THE ECM. PER A TOYOTA SERVICE CAMPAIGN. AFTER THE CC REPLACEMENT, CAR IS STILL NOT SHIFTING PROPERLY, AND IS GETTING WORSE. DEALERSHIP ADVISED US THAT WE NEED AN ECM REPLACEMENT, AT A COST OF $1300. AFTER THE FACT, WE FOUND TOYOTA TSB TC002-06, WHICH DESCRIBES THE EXACT ISSUES OUR RAV4 IS HAVING. TOYOTA ADMITS IN...

TOYOTA RAV4 2002, 98367 MILES, TAKEN TO TOYOTA DEALER FOR RECALL ON ECM REPROGRAM, AFTER DONE THE RECALL BY TOYOTA DEALER, TRANSMISSION SHIFTING VERY ERRATICALLY. TOOK CAR BACK TO DEALER AND THEY SAID THAT TRANSMISSION NEEDS TO BE REPLACED. ALSO IT IS DANGEROUS TO DRIVE DUE TO LOSS OF TRANSMISSION. *TR

CAR TRIES TO STALLS. *TR

MY 2002 RAV4 HAS BEEN DIAGNOSED AS HAVING ENGINE OIL SLUDGE AND NEEDS TOTAL REPLACEMENT. OIL CHANGES HAVE BEEN PERFORMED BETWEEN 3,000 - 4,000 MILES. *TR

FAULTY ENGINE CONTROL MODULE. IT HAS FAILED AND CAUSED TRANSMISSION TO FAIL AS WELL. AFTER $4K REPLACEMENT TRANSMISSION IS SHOT AGAIN. TRANSMISSION MISSES GEARS AND HAS STALLED IN THE MIDDLE OF INTERSECTION. NOTHING WAS DONE TO CORRECT. DEALERSHIP IS STATING TO REPLACE TRANSMISSION FIRST THEN COME BACK TO FIX COMPUTER. FOR OTHER COMPLAINTS OF SIMILAR NATURE SEE: WWW.CARCOMPLAINTS.COM/TOYOTA/RAV4/2002/TRANSMISSION/PROBLEMS_SHIFITING.SHTML *TR

NOVEMBER 17, 2006 - AFTER BEING PARKED IN MY DRIVEWAY FOR APPROXIMATELY 30 MINUTES THE ENGINE CAUGHT ON FIRE. THE RAV4 ENGINE COMPARTMENT AND ENTIRE INTERIOR WAS DEMOLISHED, TIRES EXPLODED, GLASS EXPLODED OVER AT LEAST A 20 FOOT RADIUS. TWO ENGINE TRUCKS AND 10 RESPONDERS LATER THE FIRE WAS OUT. 63,000 MILES, NO PRIOR PROBLEMS, 50K MAINTENANCE COMPLETED BY DEALER JAN 2006. VIN HAS ZEROS AND LETTER O WHICH ARE INDISTINGUISHABLE. TRY BOTH. *JB

WAS DRIVING ON THE FREEWAY WHEN MY OIL LIGHT TURNED ON AN SECONDS LATER WHITE SMOKE STARTED COMING OUT OF THE ENGINE. HAD CAR TOWED TO DEALERSHIP. AFTER LOOKING AT THE CAR THE DEALERSHIP DETERMINE THAT THE RADIATOR HAD CRACKED DUE TO THE SLUDGE IN THE ENGINE. SAID I WOULD NEED TO REPLACE THE ENTIRE ENGINE. TOLD THEM I HAD A 100,000 MILE 5 YEAR WARRANTY. MY CAR HAD ABOUT 85,000 MILES ON IT AT THE TIME. TOYOTA DEALERSHIP SAID THAT THEY DOUBTED THAT THE WARRANTY PEOPLE WOULD COVER THAT AND THEY RARELY SAW PEOPLE GET COVERAGE FOR SLUDGE IN THE ENGINE. REPORTED TO WARRANTY PEOPLE AND THEY TOLD ME THAT MY CAR WAS "VERY POORLY MAINTAINED" AND BECAUSE I DID NOT CHANGE OIL OR MAINTAIN MY CAR THEY WOULD NOT COVER. I TOLD THEM THAT I HAD CHANGED MY OIL SEVERAL TIMES SINCE I OWNED THE CAR. THEY SAID...

I HAVE A 2002 TOYOTA RAV 4. I HAVE TAKEN MY CAR TO THE DEALER FOR THE CHANGES OF OIL AND FILTER. TWICE THEY SUGGESTED A WYNNS SYSTEM ENGINE CLEANING WHICH WE PAID FOR. THE LAST ONE WAS DONE ON APRIL 2005. LAST OCTOBER 7, 2005 I WAS DRIVING MY CAR ON THE EXPRESSWAY AND ALL OF A SUDDEN THE OIL LIGHT LIT UP AND THE CAR STOPPED. THE CAR WAS TOWED FROM THE HIGHWAY TO OUR HOUSE AND THE NEXT DAY WAS TOWED TO THE DEALER ADRIEL TOYOTA IN RIO GRANDE, PUERTO RICO. ABOUT TWO HOURS LATER THEY CALLED ME AND STATED THAT THE MOTOR STALLED AND THE WARRANTY WAS NOT GOING TO PAY SINCE I HAD NOT TAKEN THE CAR TO THEM FOR THE LAST OIL CHANGE. I REMINDED THEM THAT JUST NINE MONTHS EARLIER A WYNNS MOTOR ENGINE CLEANING HAD BE DONE BY THEM AND THAT IT...