2005 TOYOTA PRIUS Engine And Engine Cooling Problems

FAILURE OF ENGINE THROTTLE CONTROLS: SUDDEN RAPID ACCELERATION, UN-COMMANDED, WHICH TERMINATED QUICKLY AFTER APPLYING THE BRAKES.

ENGINE SHUT OFF AT APPROXIMATELY 8500 FEET ABOVE SEA LEVEL (CARSON PASS, HIGHWAY 88). DRIVING APPROXIMATELY 35-40MPH. CLEAR DAY 70 DEGREES. NO WARNING LIGHT FOR OVERHEATING, BUT AUX FAN TURNED ON IN REAR SEAT.. TOWED CAR APPROXIMATELY 50 MILES TO CARSON CITY. INSPECTED BY TOYOTA DEALER IN CONSULTATION WITH TOYOTA SERVICE CONSULTANTS. REPLACED HYBRID CONTROL ECU. NO CHARGE TO ME AND TOYOTA REIMBURSED FOR 2 DAYS EXPENSES. TRIP HOME , AUX FAN TURNED ON AT 8500 FEET REMAINED ON UNTIL APPROX. 7000 FEET ELEVATION. CONSULTED TOYOTA, REFERRED ME TO TOYOTA DEALER NEAR HOME. THEY CONSULTED WITH TOYOTA HQ. HQ RECOMMEND ANOTHER TEST COSTING $500. DEALER COULD FIND NO FAULT. I ASKED TOYOTA FOR REIMBURSEMENT OF $500 AND TO INVESTIGATE ENGINE SHUT OFF AS A POTENTIALLY VERY DANGEROUS SITUATION.TOYOTA REFERRED ME BACK TO LOCAL DEALER. MAINTENANCE MANAGER THERE TOLD ME THEY HAD ALREADY PERFORMED TESTS:NOTHING MORE TO BE DONE. HAVE NOT...

WE WERE DRIVING ON THE HIGHWAY AT NIGHT AND SUDDENLY, WITHOUT WARNING, THE ENGINE STALLED COMPLETELY, THE CAR DIED, AND ALL OF THE WARNING LIGHTS CAME ON, INCLUDING A RED TRIANGLE, CHECK ENGINE, BRAKE, AND SOME OTHERS. THE PRIUS LOST POWER AND I HAD TO TURN ON THE HAZARD LIGHTS AND COAST TO THE SHOULDER. WE CALLED THE AAA TOWING SERVICE AND 911 (AS THE SHOULDER WAS VERY NARROW AND WE COULD NOT GET OUT OF THE CAR). THE OFFICER AND THE TOW TRUCK DRIVER CHECKED FOR ALL POSSIBLE DRIVER ERRORS, INCLUDING GAS, BUT DID NOT FIND ANYTHING OUT OF THE ORDINARY (THE GAS GAUGE SHOWED 5/8 FULL). THE CAR WAS TOWED TO THE TOYOTA DEALERSHIP IN SUNNYVALE WHO ARE WORKING TO DETERMINE THE CAUSE. THIS WAS A VERY DANGEROUS SITUATION AS WE WERE DRIVING ON A HIGHWAY, WITH A CHILD IN THE CAR, AT HIGHWAY SPEEDS AT NIGHT AND...

I WAS DRIVING ON THE HIGHWAY WHEN MY VEHICLE'S CHECK ENGINE LIGHT CAME ON. SHORTLY AFTER I SAW A LARGE AMOUNT OF SMOKE COMING FROM THE ENGINE. I PULLED OVER AND SHUT OFF THE CAR. CAR SMELLED LIKE BURNED PLASTIC AND SMOKE. I WAS WORRIED THAT THE CAR COULD CATCH ON FIRE OR BLOW UP! I HAD THE CAR TOWED TO MY NEAREST TOYOTA DEALERSHIP.TOYOTA CLAIMED THAT THE THREE WAY COOLANT CONTROL VALVE HAD FAILED AND THE STEAM CAME FROM A RUPTURED LINE IN THE COOLANT SYSTEM. THE JOB COST ME $422.32. I DIDN'T MIND PAYING THE SERVICE BUT AFTER CAREFUL RESEARCH INTO THE PROBLEM WITH THE 3-WAY CONTROL VALVE ON THE PRIUS I HAD LEARNED THAT THIS IS A WIDE SPREAD PROBLEM.APPARENTLY THE VALVE TENDS TO STICK CAUSING NO FLOW OF THE COOLANT FLUID. I FEEL TOYOTA SHOULD FIX THIS PROBLEM BEFORE SOMEONE GETS HURT EITHER BY GETTING BURNED...

TL* THE CONTACT OWNS A 2005 TOYOTA PRIUS. THE CONTACT STATED WHEN THE VEHICLE STALLED ALL OF THE WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT STATED THE DEALER REPROGRAMMED THE COMPUTER, BUT THE VEHICLE ONLY FUNCTIONED NORMALLY FOR ONE MONTH. THE CONTACT STATED THE FAILURE WAS BEING DIAGNOSED BY THE DEALER FOR ONE WEEK. THE FUEL PRESSURE WAS ALSO BEING CHECKED TO SEE IF IT MET SPECIFICATIONS. THE FAILURE MILEAGE WAS UNKNOWN, BUT THE CURRENT MILEAGE WAS 75,500.

INCIDENT = ON 1/19/11 MY 2005 PRIUS BEGAN TO SHAKE WHILE DRIVING ON SURFACE STREETS. I PULLED OVER CHECKED THE CAR BUT SAW NOTHING THAT WOULD CAUSE THE SHAKING. I THEN STARTED THE CAR AND BEGAN TO DRIVE. THE SHAKING STARTED AGAIN LIKE AN UNBALANCED WASHER. I TOOK THE CAR TO HOLLYWOOD TOYOTA. TOYOTA CHECKED THE CAR AND INDICATED THAT 2 SPARK PLUGS HAD GONE BAD AND THAT 2 IGNITION COILS HAD SHORTED OUT. AS A RESULT THE ENGINE HAD CARBON DEPOSITS AND NEEDED EXTENSIVE CLEANING. I HAVE DONE ALL SCHEDULED MAINTENANCE TO TOYOTA SPECIFICATION. AS A RESULT I CONTACTED TOYOTA'S OFFICES TO VOICE SAFETY CONCERNS. WERE THERE ANY OTHER SIMILAR REPORTED INCIDENTS AND DO THEY CONSIDER ANY SAFETY ISSUES. DIDN'T GET A CLEAR ANSWER AT ALL FROM THEM. TOYOTA ONCE AGAIN IS IN DENIAL WITH PRIUS PROBLEMS. DAMAGE RESULTING = COST WAS $989.81. I FEEL THAT TOYOTA NEEDS TO...

TL* THE CONTACT OWNS A 2005 TOYOTA PRIUS. WHILE DRIVING APPROXIMATELY 10 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE CONTACT WAS AWAITING DIAGNOSTIC TESTING TO DETERMINE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 164,000.

TL* THE CONTACT OWNS A 2005 TOYOTA PRIUS. THE CONTACT WAS DRIVING APPROXIMATELY 25-30 MPH WHEN THE VEHICLE BEGAN TO SHAKE ABNORMALLY VIOLENT. THE CONTACT INSPECTED THE VEHICLE BUT COULD NOT LOCATE A CAUSE FOR THE FAILURE YET THE FAILURE PERSISTED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS ADVISED THAT TWO SPARK PLUGS HAD FAILED, TWO OF THE IGNITION COILS HAD SHORTED OUT AND THAT CARBON WAS BUILT UP ON THE ENGINE AS A RESULT OF THE FAILURE. THE DEALER REPLACED THE SPARK PLUGS, IGNITION COILS AND CLEANED THE CARBON FROM THE ENGINE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 78,646 AND THE CURRENT MILEAGE WAS 78,746. UPDATED 03/02/11 *BF

TL*THE CONTACT OWNS A 2005 TOYOTA PRIUS. WHILE DRIVING 65 MPH THE VEHICLE SUDDENLY SHUT OFF. THE VEHICLE WAS TOWED TO THE CONTACTS RESIDENCE. THE CONTACT CALLED THE MANUFACTURER WHO ADVISED HIM TO TAKE IT TO THE DEALERSHIP FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT INSPECTED OR REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 187,000.

I DRIVE A 2005 TOYOTA PRIUS. MY CAR HAS 26,000 MILES ON IT; WHICH IS VERY LOW MILEAGES. WHILE I WAS ON THE HIGHWAY, MY CAR`S LIGHTS ON THE DASHBOARD STARTS TO FLASH. THE BRAKE SYSTEM WARNING LIGHT AND BUZZER COMES ON ALONG WITH THE ABS WARNING LIGHT AND THE MALFUNCTION INDICATOR LAMP. I HAD NOWHERE TO PULL ASIDE. AFTER TWO MINUTES THE WARNING SIGNS SHUT OFF SO I KEPT DRIVING. FIVE MINUTES LATER, ALL THE WARNING LIGHTS COME ON SO I DECIDE TO GET OFF THE HIGHWAY TO TAKE IT TO THE KNOXVILLE TOYOTA DEALER. AS I`M EXITING THE HIGHWAY, I IMMEDIATELY REALIZED THAT I HAD NO BREAKS (WHEN I PRESSED THE BRAKE PEDAL WITH MY FOOT IT AUTOMATICALLY TOUCHED THE GROUND)! I REMEMBERED THAT MY DAD ALWAYS TOLD ME THAT IN CASE OF A BRAKE EMERGENCY TO PUMP THE PADDLE UNTIL THE BREAKS WORK. I ALMOST CRASHED INTO...

TL*THE CONTACT OWNS A 2005 TOYOTA PRIUS. WHILE DRIVING 55 MPH THE MASS AIR FLOW SENSOR FAILED CAUSING THE VEHICLE TO SHUT OFF. THE CONTACT TOWED THE VEHICLE TO THE DEALER TO HAVE THE MASS AIR FLOW SENSOR REPLACED. THE ABS WARNING LIGHTS ALSO FLASHED ON THE DASH BOARD CAUSING THE BRAKES TO FAIL WHILE DRIVING 40 MPH. THE CONTACT DROVE THE VEHICLE TO THE DEALER TO HAVE THE ABS BRAKE ACTUATOR REPLACED. THE FAILURE MILEAGE WAS 18,461. UPDATED 11/10/10 *BF UPDATED 11/18/10

I WAS INVOLVED IN AN ACCIDENT WITH MY 2005 PRIUS ON 3/29/2006. THE CAUSE OF THE ACCIDENT REMAINS A MYSTERY. I WAS SITTING AT AN INTERSECTION, WAITING FOR TRAFFIC TO CLEAR. WITNESSES REPORTED THAT I PULLED OUT INTO THE ONCOMING TRAFFIC, RESULTING IN A COLLISION WITH ANOTHER VEHICLE. DUE TO THE INJURIES I SUFFERED (A MINOR CONCUSSION RESULTING IN RETROGRADE AMNESIA), I HAD NO RECOLLECTION OF THE PERIOD PRIOR TO ARRIVING AT THE INTERSECTION UP UNTIL THE PARAMEDICS REMOVED ME FROM THE VEHICLE. AS SUCH, I CAN'T EXPLAIN EXACTLY WHAT HAPPENED. WHILE I HAVE NO PROOF OF THIS, IT SEEMS THAT A POSSIBILITY WOULD BE AN ISSUE WITH THE STUCK ACCELERATOR THAT'S BEING REPORTED RELATING TO THE PRIUS. I'VE BEEN AT A LOSS TO EXPLAIN WHY I WOULD HAVE PULLED OUT IN FRONT OF ONCOMING TRAFFIC AT AN INTERSECTION THAT I WAS VERY FAMILIAR WITH. WHEN I HEARD OF THE...

2005 TOYOTA PRIUS STALLED WHILE DRIVING AND IN MOTION. I OWN A 2005 TOYOTA PRIUS THAT I HAD JUST DRIVEN ON HIGHWAY ABOUT 25 MILES AND THEN WAS ON LOCAL ROAD. THE VEHICLE STALLED WITHOUT ANY WARNING AND ALL LIGHTS CAME ON. THE CAR WAS NOT RESPONSIVE TO GAS AND ENGINE WAS SHUT. SO I HAD TO PULL OVER. THE CAR WILL NOT START AND HAD TO BE TOWED TO THE DEALER. FORTUNATELY, IT WAS DURING OFF PEAK TIME AND I WAS ON LOCAL ROAD. IF IT HAD BEEN DURING PEAK TIME AND ON HIGHWAY, THE CONSEQUENCES WOULD HAVE BEEN SIGNIFICANTLY DIFFERENT. THE DEALER HAD NO TECHNICAL DETAILS AS TO WHY THIS HAPPENED. HE SAID IT WAS SOFTWARE ISSUE. *TR

I HAVE A 2005 TOYOTA PRIUS WITH 255K MILES. I SERVICE MY CAR REGULARLY (ABOUT EVERY 5 WEEKS). WHEN I STARTED MY CAR AFTER WORK, NONE OF THE DASHBOARD LIGHTS CAME ON. I PUT MY CAR IN DRIVE AND THE CAR MOVED FORWARD. I DROVE MY CAR ABOUT 60 MILES AND STOPPED BY THE STORE. I BECAME ALARMED WHEN THE CAR WOULDN'T SHUT OFF. I PRESSED THE "POWER" BUTTON SEVERAL TIMES BUT THE CAR WOULD NOT TURN OFF. I DROVE THE CAR TO THE STAFFORD TOYOTA AT APPROXIMATELY 7:30PM AND REQUESTED ASSISTANCE FROM THE SALES MANAGER (SINCE THE SERVICE DEPARTMENT WAS CLOSED). THE SALES MANAGER CONFIRMED THAT THE CAR WAS NOT SUPPOSED TO OPERATE WITHOUT THE DASHBOARD LIGHTS BECAUSE THERE WAS NO WAY TO DETERMINE IF THE CAR WAS ON AND WHETHER THE CAR WAS IN PARK, REVERSE OR DRIVE. AFTER NUMEROUS ATTEMPTS OF HOLDING DOWN THE "POWER" BUTTON, THE...

FIRE AND TOTAL LOSS OF 2005 TOYOTA PRIUS, 19,300 MILES AFTER RETURNING FROM WORK, THE VEHICLE WAS PARKED AS USUAL WITH ENGINE POWER CUT IN THE OWNER'S DRIVEWAY. A FEW MINUTES LATER, SMOKE WAS NOTICED INSIDE THE CAR WITH FLAMES SHOWING FROM UNDERNEATH THE VEHICLE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE ABOUT 10 MINUTES AFTER IT WAS FIRST NOTICED. THE MAIN DAMAGE IS IN THE REAR LEFT (DRIVER'S SIDE) OF THE VEHICLE, WITH THE CARGO COMPARTMENT COMPLETELY DESTROYED, TIRE COMPLETELY MELTED, ALL PLASTIC IN THE AREA MELTED, DOOR BLACKENED, THE REAR BENCH DESTROYED, THE CEILING CARPET DESTROYED AND BIG HEAT MARKS ON THE ROOF OF THE CAR. THE VEHICLE WAS NOT MODIFIED AS A "PLUG-IN HYBRID" WHICH HAVE BEEN REPORTED IN AT LEAST ONE INCIDENT OF FIRE. THE EXTERNAL TEMPERATURE WAS MODERATE, AROUND 70-75 DEGREES. *TR UPDATED 06/05/09*JB

THE ENGINE SHUT DOWN WITHOUT WARNING IN THE MIDDLE OF A BUSY STREET, CREATING AN UNSAFE SITUATION WITH CARS COMING UP BEHIND IN A SINGLE LANE. *TR

CONSUMER COMPLAINT CONCERNING 2005 PRIUS ENGINE STALLING. *TS *JB

ENGINE STALLS. *JB

2005 TOYOTA PRIUS WENT INTO A SUDDEN ENGINE STALLING MODE. I DO REALIZE THAT TOYOTA HAS A RECALL ON SUCH VEHICLES, BUT THE TOYOTA DEALERSHIP THAT I TOOK IT TO, THE SAME PLACE WHERE I BOUGHT THE VEHICLE, THAT HAD A "PRIUS EXPERT" HAS BEEN DIAGNOSING THIS PROBLEM FOR A DAY WITH NO ANSWERS / ANTICIPATED FIX DATE. THIS IS ANNOYING TO SAY THE LEAST, AS TOYOTA DOES NOT SEEM TO HAVE TAKEN THE TIME TO TRAIN IT'S DEALERSHIPS ON THEIR OWN RECALL INFORMATION. I COULD STEER AND OPERATE THE VEHICLE IN ELECTRIC ONLY MODE. PRESSING THE POWER KEY WOULD NOT POWER OFF THE CAR. HENCE THE BATTERY STARTED TO DRAIN. OPENING THE PASSENGER DOOR AND PRESSING THE POWER KEY, SEEMED TO HAVE BEEN ABLE TO STOP THE CAR, NOT SURE WHETHER THIS WAS TIMING, OR SOME COINCIDENCE. STARTING THE CAR AGAIN, MADE THE GASOLINE ENGINE COME ON FOR THE...

I TOOK MY TOYOTA PRIUS IN FOR THE RECALL NOTED IN PE05029 AND SINCE HAVE LOST 8 MILES PER GALLON IN PERFORMANCE. I CONTACTED TOYOTA CUSTOMER SERVICE TO LET THEM KNOW AND ASKED IF THEY COULD TELL ME IF OTHER CUSTOMERS WERE EXPERIENCING THE SAME PROBLEM. THE REPLY WAS THAT CUSTOMER SERVICE INFORMATION IS PROPRIETARY AND THAT THEY WOULD RECORD MY COMPLAINT BUT COULD GIVE ME NO FURTHER INFORMATION. I AM NOT SURE THE CAR WOULD STILL MEET THE EPA MILEAGE RATING ORIGINALLY GIVEN. *NM

I WAS DRIVING ON HIGHWAY AT 70 MPH AND VEHICLE STALLED. I COASTED OVER TO ROAD SHOULDER, TURNED OFF VEHICLE POWER AND RESTARTED VEHICLE WITHOUT ISSUE. CALLED TOYOTA DEALER AND WAS TOLD MY VIN WAS NOT PART OF THE SOFTWARE RECALL FOR SOFTWARE PROBLEM FOR STALLING ENGINES. THIS COULD HAVE CAUSED A SERIOUS PROBLEM IF I WAS NOT IN THE RIGHT LANE AND ABLE TO MOVE TO SHOULDER, CLEARING TRAFFIC IMMEDIATELY. *JB

TOYOTA PRIUS; DRIVING ON INTERSTATE 287 IN NEW JERSEY WHEN THE ENGINE CUT OUT AND WOULD NOT RESTART. *NM

PURCHASED 2005 TOYOTA PRIUS - VIN # JTD KB2 OU1 530 793 29 ON JULY 20, 2005 -REGISTERED IT TO MY WIFE KRISTA GOTTLIEB. ON JULY 22, 2005 WHEN THIS CAR HAD ABOUT 80 MILES ON IT, I WAS DRIVING IT ON THE HIGHWAY IN TRAFFIC AT ABOUT 50 MPH - WHEN SUDDENLY I LOST COMPLETE POWER. BY THAT, I MEAN THAT THE ACCELERATOR PEDAL WAS COMPLETELY UNRESPONSIVE. I AM NOT AWARE OF WHAT THE INSTRUMENTS INDICATED AS I WAS PREOCCUPIED WITH THE TRAFFIC (FOR MORE DETAILS - I SENT A VERY DETAILED E-MAIL ABOUT THE FAILURE TO OUR DEALER CULLIGAN TOYOTA, AMHERST, NY ON JULY 24, 2005 - I HAVE ALSO SENT ADDITIONAL FOLLOW-UP E-MAILS TO CULLIGAN SINCE THAT DATE. ). AS A RESULT OF THE JULY 24 MESSAGE, I ARRANGED TO LEAVE THE CAR WITH CULLIGAN TOYOTA SERVICE ADVISOR STEPHEN DESOTELL ON WEDNESDAY, JULY 27, 2005 TO BE...

POSSIBLY RELEVANT TO CURRENT PRIUS SOFTWARE RELIABILITY INVESTIGATION NUMBER : PE05029 I SPOKE TO GILLES LABELLE OF WESTBORO TOYOTA IN WESTBOROUGH MASSACHUSETTS REGARDING THE TOYOTA PRIUS (THIS WAS A PRE-SALES CONVERSATION; I DO NOT AT PRESENT OWN A PRIUS THOUGH UNTIL THIS CONVERSATION I WAS VERY CLOSE BUYING ONE; NOW I FIND MYSELF TAKING A STEP BACK TO ENSURE I'VE DONE MY OWN DUE DILIGENCE). HE MENTIONED THE USE OF A RESET SEQUENCE TO "REBOOT" THE CAR IN THE EVENT OF PROBLEMS AS A WAY TO AVOID THE NEED TO HAVE THE CAR SERVICED; I ASKED HIM HOW OFTEN HE HAD TO REBOOT HIS OWN PRIUS; HE DIDN'T ANSWER DIRECTLY BUT INSTEAD SAID THAT HE HAD HELPED ABOUT 100 CUSTOMERS THROUGH THE REBOOT PROCESS. I AM A OPERATING SYSTEMS SOFTWARE ENGINEER BY PROFESSION AND WAS ALARMED AT THIS "JUST HIT RESET" ATTITUDE TOWARDS SYSTEMS FAILURES; IDEALLY CRASHES IN THE FIELD...

I WAS DRIVING MY TOYOTA PRIUS ON THE FREEWAY AND THE VEHICLE DIED AT 55 MPH. THE ENGINE LIGHT ILLUMINATED AND THERE WAS NO POWER TO THE ACCELERATOR. FORTUNATELY, TRAFFIC WAS LIGHT AND I WAS ABLE TO COAST TO A SECURE SPOT ON THE SIDE OF THE ROAD. THIS HAPPENED ON THE APPROACH TO THE BAY BRIDGE, WHICH WOULD HAVE BEEN A POTENTIAL DISASTER HAD IT DIED ON THE BRIDGE ITSELF. THE CAR DID NOT START AGAIN ON MY FIRST ATTEMPT, BUT IT DID START 5 MINUTES LATER. I TOOK THE CAR TO THE TOYOTA DEALER AND THEY SAID THEY INSTALLED NEW INFORMATION INTO THE COMPUTER. I WANT TO KNOW WHY, IF THEY KNOW IT NEEDS NEW INFORMATION, DID I NOT RECEIVE A LETTER ASKING ME TO COME IN FOR SERVICE? THIS COULD HAVE BEEN REALLY DISASTROUS, AND I FEAR THAT IT WILL BE FOR SOMEONE ELSE. *JB

2005 TOYOTA PRIUS, WHEN COASTING AT HIGH SPEEDS, THE ENGINE CUTS OUT SO IT IS IMPOSSIBLE TO ACCELERATE.

DEAR NHSTA, ON MAY 20 OF 2005 I WAS DRIVING MY 2005 TOYOTA PRIUS WHEN ALL OF A SUDDEN THE GAS ENGINE STOPPED WORKING AND 4 DASH WARNING/FAULTS LIGHTS CAME ON (RED TRIANGLE; CHECK ENGINE; BRAKE FAULT; VEHICLE STABILITY CONTROL FAULT). I CONTINUED DRIVING FOR 3 MILES ON THE ELECTRIC MOTOR UNTIL THE BATTERY CHARGE LIGHT INDICATED NEAR COMPLETE BATTERY DISCHARGE. I TURNED OFF THE CAR, WAITED 30 SECONDS AND TURNED THE CAR BACK ON. IMMEDIATELY THE GASOLINE ENGINE STARTED AND THE BATTERY BEGAN TO CHARGE. AT THIS POINT ONLY THE CHECK ENGINE AND RED TRIANGLE LIGHTS CAME ON. I DROVE TO THE TOYOTA DEALER WHO SAID THAT MY PROBLEM SOUNDED LIKE THE STALLING PROBLEMS WITH THE 33 REPORTED CASES OF 2004/05 PRIUS STALLING. TOYOTA UPGRADED THE ENGINE ECU AND THE CAR HAS BEEN FINE EVER SINCE. HOWEVER, I WANTED TO LET NHSTA KNOW SO THAT THEY KNOW THAT THIS...

I WAS DRIVING 20MPH WHEN A RED ALERT LIGHT CAME ON THE SCREEN ON MY PRIUS; IT SAID GPS UNDERNEATH IT SO I IGNORED IT, THINKING I WOULD BE OK SINCE I DID NOT NEED MY GPS SYSTEM. I SPED UP TO ABOUT 30MPH AND SUDDENLY WAS NOT ABLE TO ACCELERATE ALTHOUGH I WAS PRESSING DOWN ON MY ACCELERATOR. I CAME TO A STOP AT THE TRAFFIC LIGHT ON A GREEN; LUCKILY THERE WAS NO COLLISION. THE ELECTRIC MODE REMAINED INTACT FOR THE NEXT 2.5HRS UNTLI THE CAR WAS TOWED SO I COULD STILL TURN THE CAR ON.

WITH APPROXIMATELY 7100 MILES ON MY CAR ON FRIDAY MARCH 25, 2005 I WAS DRIVING ON LOCAL ROADS BETWEEN 20 TO 40 MILES PER HOUR WHEN THE CAR BEGAN BUCKING VERY BADLY .. SHORTLY THEREAFTER THE CHECK ENGINE LIGHT TURNED ON. WORRIED THAT THE VEHICLE MAY COMPLETELY STALL AND QUIT ON THE OPEN ROAD I RETURNED HOME AND CALLED MY LOCAL ARLINGTON TOYOTA DEALER. I BROUGHT THE CAR IN THE FOLLOWING MORNING (SATURDAY MARCH 26,2005) TO CHECK OUT THE PROBLEM.THEY HAD THE CAR ALL DAY AND STILL COULD NOT IDENTIFY WHY THE CAR WAS STALLING. SINCE I WAS SCHEDULE TO BE AWAY THE FOLLOWING WEEK (TRIP TO LAS VEGAS). I GAVE PERMISSION FOR TECHS TO KEEP CAR ALL WEEK IF NECESSARY. ON MONDAY OF THE FOLLOWING WEEK, I RECIEVED A CALL FROM TECH AT MY HOTEL THAT THEY HAD FIXED THE PROBLEM. HE CLAIMED IT WAS A MISFIRE IN #1...

REPORTED INCIDENT TO TOYOTA CUSTOMER SUPPORT -- INCIDENT: 050412-000111 RESPONSES RECEIVED FROM TOYOTA WAS THAT THE COMPUTER WAS FIXED BASED ON A TECHNICAL SERVICE BULLETIN. NO RECURRENCE SINCE THE FIX. TO: TOYOTA CUSTOMER SUPPORT SIR OR MADAM: I BOUGHT MY 2005 PRIUS NEW FROM MECHANICSVILLE TOYOTA ON DECEMBER 1, 2004 AND GENERALLY WAS QUITE SATISFIED WITH THE CAR AND THE GREAT GAS MILEAGE IT PROVIDES. HOWEVER, LAST THURSDAY, 4/7/05, WITH 4738 MILES ON THE ODOMETER, WHILE DRIVING HOME FROM WORK, ALL THE LIGHTS ON THE DASH WENT ON INCLUDING THE MASTER WARNING LIGHT, CHECK ENGINE LIGHT, VSC LIGHT, AND THE MULTI INFORMATION DISPLAY IS SHOWING THE RED HYBRID SYSTEM WARNING LIGHT. THE CAR LOST POWER AND I HAD TO LIMP IT HOME. THE ENERGY CONSUMPTION DISPLAY FOR THE BATTERY PACK SHOWED ONE RED BAR AND THE FUEL GAUGE HAD TWO BARS LEFT. I CALLED TOYOTA ROADSIDE ASSISTANCE WHICH PROMPTLY DISPATCHED...

MY 2005 TOYOTA PRIUS FAILED WITH ENGINE SHUTDOWN AT 65 MPH ON FLORIDA TURNPIKE. AFTER RESTARTING ON SHOULDER, VEHICLE WOULD ONLY ACHIEVE 52 MPH, THEN FAILED AGAIN.

DT: WHILE DRIVING 2005, TOYOTA PRIUS HYBRID AT SPEEDS BETWEEN 15-20 MPH ON A 2 LANE ROAD THE ENGINE DIED. AFTER A SHORT TIME IT DID RESTART. *AK

I WAS DRIVING THE VEHICLE TO A GAS STATION ON A MAJOR ROAD WHEN THE ENGINE DIED AND THE VEHICLE SHIFTED TO BATTERY POWER. I WAS ABLE TO GET TO THE GAS STATION AND IT WAS CLEAR I HAD NOT RUN OUT OF GAS. THE VEHICLE HAS BEEN FINE SINCE SO I DIDN'T THINK ABOUT IT UNTIL THE MEDIA REPORTS CAME OUT.

GAS MOTOR STALLED WHILE DRIVING ON HIGHWAY AT 55 MPH. ELECTRIC MOTOR CONTINUED TO OPERATE UNTIL THE BATTERY WAS DEPLETED, ABOUT 1 OR 2 MILES. I WAS UNABLE TO PULL THE CAR OVER BECAUSE I WAS IN A CONSTRUCTION ZONE. IT WAS DIFFICULT TO TURN THE CAR OFF, BECAUSE OF THE LACK OF A KEY, BUT ONCE I DID RESTART IT, IT WORKED FINE.

THE CONSUMER HAD THE VEHICLE FOR 2 WEEKS AND HAD AN EPISODE WHERE THE ENGINE STALLED ON THE HIGHWAY. THE CONSUMER BELIEVED IT MAY HAVE BEEN CAUSED BY A MOMENTARY EVENT TO SHIFT IT INCORRECTLY FROM THE BRAKING MODE. WHEN THE CONSUMER FIRST ATTEMPTED TO PUT IT IN REVERSE, IT WOULDN'T TAKE THEN, AND IT WOULD NOT TAKE INTO THE PROPER DRIVE MODE EITHER. THE ENGINE HAD STALLED, AND WOULD NOT GO INTO DRIVE. THE CONSUMER STOPPED THE VEHICLE, AND WAS ABLE TO RESTART IT. THE CONSUMER HAD NOT EXPERIENCED PROBLEMS SINCE THEN. THE CONSUMER CALLED AND REPORTED THE PROBLEM TO TOYOTA. *AK GASOLINE ENGINE ON HYBRID VEHICLE FAILED TO KICK IN OR STALLED. *SC *JB

DT: WITHOUT WARNING THE CHECK ENGINE LIGHT KEEPS COMING ON. CONSUMER HAS TAKEN CAR TO DEALER FOUR TIMES FOR THE SAME PROBLEM. DEALER REPLACED DIFFERENT PARTS AND THE PROBLEM WAS THERE AFTER THREE ATTEMPTS TO FIX IT. CONSUMER JUST GOT VEHICLE BACK FOR THE FOURTH TIME. MANUFACTURER WILL BE CALLED TODAY. CONSUMER WAS TOLD THEY HAVE NEVER SEEN THIS PROBLEM IN ANY OTHER CAR. *TT

I WAS TRAVELING AT ABOUT 70 MPH ON THE INTERSTATE, WHEN THE ENGINE STALLED. I WAS CLOSE TO AN OFF-RAMP AND WAS ABLE TO COAST OFF OF THE EXIT. AT THE BOTTOM ON THE EXIT I WAS ABLE TO START UP AGAIN BY SHIFTING INTO DRIVE.

I HAD BEEN DRIVING MY 2005 TOYOTA PRIUS AT 40MPH WHEN I ACCELERATED TO PASS A CAR AND THEN HAD TO STOP BRIEFLY AT A TRAFFIC LIGHT. WHEN I PULLED AWAY FROM THE LIGHT I NOTICED THAT THE CAR FELT VERY SLUGGISH AND WOULDN'T ACCELERATE OVER 40 MPH. I THEN REALIZED THAT I WAS DRIVING ON THE HYBRID SYSTEM ONLY AND THAT THE ENGINE HAD STALLED. A BIG RED EXCLAMATION POINT LIT UP ON THE DASH AND I WAS ABLE TO COAST INTO A PARKING PLACE OFF THE HIGHWAY. WHEN I ATTEMPTED TO RESTART THE CAR IT DID NOTHING. I CALLED TOYOTA SERVICE AND EXPLAINED MY PROBLEM AND HE ARRANGED A TOW TRUCK PICK UP MY CAR BUT TOLD ME THAT SINCE IT WAS 5PM THEY WOULDN'T BE ABLE TO LOOK AT IT UNTIL THE MORNING. THE NEXT MORNING THEY TOLD ME THAT THE CAR STARTED WITHOUT INCIDENT AND ALTHOUGH...