2019 TOYOTA COROLLA — Problems, Recalls & Safety Data

The contact owns a 2019 Toyota Corolla. The contact stated that while driving at various speeds, the steering wheel became difficult to turn in either direction. The hazard, power steering, and LDA warning lights were illuminated. The message "Lane Departure Alert Malfunction - Visit your Dealer" was displayed. The contact stated that when the LDA was deactivated, a red power steering warning light was intermittently illuminated. The vehicle was taken to a local dealer, where a battery replacement was performed. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken back to the same local dealer; however, the vehicle was not diagnosed or repaired due to the cost. The vehicle was towed to a local independent mechanic, where it remained for further investigation. The manufacturer was not made aware of the failure. The failure mileage was approximately 1,488.

While the vehicle was parked and powered off, a fire originated inside the driver seat area. There was no collision, no aftermarket electrical equipment installed, and no heated seat or accessory usage at the time of the incident. The vehicle was stationary when the fire began. The fire damage was concentrated within the driver seat assembly, consistent with a suspected electrical failure involving seat wiring, seat-mounted components, or associated harnesses. This is not consistent with owner misuse or external ignition sources. The insurer (Allstate Insurance Company) declared the vehicle a total loss but declined further fire-origin or electrical defect investigation. The vehicle is at risk of being sold or dismantled through a salvage auction, which would destroy critical evidence related to a potential manufacturer defect. The vehicle is currently listed on Copart (Lot# 99091095 highlighted as ‘Run and Drive’) I have completed a Power of Attorney (HSMV 82053) per Allstate requirement, along with a limited conditions notification for evidence preservation however Allstate is refusing to accept the conditions stating their intent to sell it as salvage. This incident presents a serious safety concern involving spontaneous ignition within the passenger compartment. Similar failures pose a risk of injury, death, or property damage, particularly if ignition occurs while occupied. I am requesting that NHTSA review this incident for potential electrical system or seat assembly defects and preserve this complaint as part of any pattern or trend analysis involving Toyota vehicles.

While the vehicle was parked and powered off, a fire originated inside the driver seat area. There was no collision, no aftermarket electrical equipment installed, and no heated seat or accessory usage at the time of the incident. The vehicle was stationary when the fire began. The fire damage was concentrated within the driver seat assembly, consistent with a suspected electrical failure involving seat wiring, seat-mounted components, or associated harnesses. This is not consistent with owner misuse or external ignition sources. The insurer (Allstate Insurance Company) declared the vehicle a total loss but declined further fire-origin or electrical defect investigation. The vehicle is at risk of being sold or dismantled through a salvage auction, which would destroy critical evidence related to a potential manufacturer defect. The vehicle is currently listed on Copart (Lot# 99091095 highlighted as ‘Run and Drive’) I have completed a Power of Attorney (HSMV 82053) per Allstate requirement, along with a limited conditions notification for evidence preservation however Allstate is refusing to accept the conditions stating their intent to sell it as salvage. This incident presents a serious safety concern involving spontaneous ignition within the passenger compartment. Similar failures pose a risk of injury, death, or property damage, particularly if ignition occurs while occupied. I am requesting that NHTSA review this incident for potential electrical system or seat assembly defects and preserve this complaint as part of any pattern or trend analysis involving Toyota vehicles.

While the vehicle was parked and powered off, a fire originated inside the driver seat area. There was no collision, no aftermarket electrical equipment installed, and no heated seat or accessory usage at the time of the incident. The vehicle was stationary when the fire began. The fire damage was concentrated within the driver seat assembly, consistent with a suspected electrical failure involving seat wiring, seat-mounted components, or associated harnesses. This is not consistent with owner misuse or external ignition sources. The insurer (Allstate Insurance Company) declared the vehicle a total loss but declined further fire-origin or electrical defect investigation. The vehicle is at risk of being sold or dismantled through a salvage auction, which would destroy critical evidence related to a potential manufacturer defect. The vehicle is currently listed on Copart (Lot# 99091095 highlighted as ‘Run and Drive’) I have completed a Power of Attorney (HSMV 82053) per Allstate requirement, along with a limited conditions notification for evidence preservation however Allstate is refusing to accept the conditions stating their intent to sell it as salvage. This incident presents a serious safety concern involving spontaneous ignition within the passenger compartment. Similar failures pose a risk of injury, death, or property damage, particularly if ignition occurs while occupied. I am requesting that NHTSA review this incident for potential electrical system or seat assembly defects and preserve this complaint as part of any pattern or trend analysis involving Toyota vehicles.

Clutch stopped working while driving. Car has 61,000 miles.