1996 SATURN SL Engine And Engine Coolingengine Problems

I AM LOSING A LOT OF OIL. I SPOKE WITH MY MECHANIC HE STATED THAT A LOT OF TIMES IT IS THE VALVE COVER GASKET, SO HE CHANGED IT. THE CAR IS STILL LOSING A LOT OF OIL. ABOUT A QUART EVERY 400 MILES. I STARTED RESEARCHING ON MY OWN AND HAVE FOUND THAT SEVERAL SATURN OWNERS ARE COMPLAINING ABOUT THE SAME ISSUE. *JB

1. HIGH REVVING ON IDLE MANUAL TRANS 2. FRONT END NOISE MANUAL TRANS P/S SIMILAR TO OTHER RECALL WORN OUT ? *NM

1996 SATURN SL-1 CYLINDER HEAD CRACKED. A KNOWN DEFECT TO THE SATURN CORPORATION.$2400 TO FIX! MY "CHECK ENGINE SOON" LIGHT COMES ON OFTEN. SATURN FINDS NOTHING! HTTP://WWW.CARSURVEY.ORG/VIEWMORECOMMENTS_REVIEW_5215_1.HTML SIMPLY "GOOGLE" SATURN + CYLINDER + HEAD HTTP://WWW.CONSUMERAFFAIRS.COM/AUTOMOTIVE/SATURN_ENGINE.HTML

THERE WAS A CLICKING SOUND IN THE ENGINE; WHEN I TRIED TO PRESS THE GAS IT JUST REVVED THE ENGINE BUT HAD A HARD TIME GETTING UP TO SPEED; I WAS DRIVING HOME WITH MY TWO DAUGHTERS; GOING ABOUT 30 MPH AND I HEARD A LOUD NOISE AND THEN STUFF FALLING UNDER MY CAR....THE CAR DIED. I PUSHED THE CAR ABOUT A BLOCK AND HALF TO MY HOUSE. MY CHILDREN AND I THEN WENT TO PICK UP THE PIECES OF THE ENGINE...ONE OF THE PISTONS HAD BLOWN OUT OF THE BLOCK. THERE WAS A HUGE WHOLE ON THE LOWER RIGHT OF THE ENGINE. I HAD SEVERAL MECHANICS COME LOOK AT IT AND THEY SAID IT WAS A "FREAK" ACCIDENT. THERE WAS STILL OIL IN THE ENGINE SO I HAD NOT RAN IT OUT OF OIL. THE NOISE JUST STARTED AND IMMEDIATELY THE ENGINE WAS BAD. I BOUGHT IT WITH 113000...

FOR THE 4TH TIME, THE HEAD GASKET IS BLOWN AND THE HEAD IS WARPED. THIS IS THE RESULT OF A FACTORY DESIGN DEFECT IN THE ENGINE AND WAS REPAIRED THE FIRST TIME WITHOUT CHARGE BY SATURN. HOWEVER, THE REPAIRS DO NOT LAST AND THE HEAD BLOWS APPROXIMATELY EVERY 30,000 MILES. THERE IS NO ENGINE BUILT THAT SHOULD ONLY LAST 30,000 MILES! SATURN REFUSES TO HELP WITH THESE REPAIRS EVEN THOUGH THE CAR HAS BEEN DUTIFULLY MAINTAINED AND SERVICED AT THE SATURN DEALER. THE ESTIMATE FOR REPAIRS IS $2,140 WITH A RECOMMENDATION OF NEW RODS AND BEARINGS AT THIS TIME ALSO. WE HAD NEW RINGS, RODS AND BEARINGS IN EARLY 2002. IF SATURN ADMITTED TO THE DESIGN DEFECT THE FIRST TIME, AND IT CONTINUES TO OCCUR, SHOULDN'T SATURN BE HELD RESPONSIBLE FOR THE REPAIRS?

IN SUMMER OF 2002, I PAID OVER $1500 TO HAVE A HEAD GASKET REPAIRED ON MY SATURN. LAST THURSDAY, THE CAR WAS HAVING THE SAME ISSUES AND IT WAS DETERMINED THAT IT HAS A CRACKED ENGINE CYLINDER. THIS IS AN ITEM ON A TSB ISSUED FROM SATURN, I REALIZED TODAY. NOW I AM FACING OVER $2000 TO HAVE THE CYLINDER REPLACED, PUTTING MY TOTAL COST FOR REPAIRS OVER $3700 ON AN ISSUE THAT SATURN HAS BEEN AWARE OF FOR SOME TIME, YET NEVER NOTIFIED ITS CUSTOMERS.

MY WIFE AND I OWN A 1996 SATURN SL1 WITH 69001 MILES ON IT. I NOTICE THAT OIL WAS IN THE COOLANT RESERVOIR. CONTACTED SATURN OF CORPUS CHRISTI AND ASKED IF THEY HAD AN IDEA OF THE PROBLEM. MAYBE A BAD HEAD GASKET AND GAVE ME AN ESTIMATE OF $840 PLUS $2.30/MILE TO TOW IT IN. LIVING OUTSIDE OF BEEVILLE 65 MILES AWAY A TOTAL OF 13O MILES. CONTACTED MY MECHANIC TOLD HIM THE PROBLEM AND HE GAVE ME AN ESTIMATE OF $900 SAVING ON TOWING FEE, I WENT TO HIM. HE LOOKED AT IT AND TOLD ME THAT MY CYLINDER HEAD WAS ALSO CRACKED. HE THEN SHOWED ME A TECHNICAL SERVICE BULLETIN #96-T-65B THAT SATURN SENT OUT IN MAY 1999 DOCUMENTING THIS PROBLEM WITH THE CYLINDER HEADS CRACKING. HE THEN SHOWED ME THAT MY CYLINDER HEAD WAS CRACKED JUST LIKE THE DIAGRAMS ON PAGE 2 OF THE BULLETIN SHOWED....

ENGINE OIL LEAKING INTO COOLANT RESULTING IN A CRACKED HEAD GASKET. *JB

CRACKED CYLINDER HEAD. *JB

ABOUT THREE WEEKS AGO THE ENGINE OVERHEATED. THE ENGINE OIL AND COOLANT MIXED TOGETHER BECAUSE THE HEAD GASKET WAS CRACKED. *AK *TS *JB

1996 SATURN - ENGINE OIL LEAKS INTO COOLANT. DEALER SAID THERE WAS A MANUFACTURING DESIGN FLAW. 1997'S UNDER 100,000 MILES SATURN WOULD PAY TO HAVE IT FIXED, BUT NOT 1996'S. *NLM

I PURCHASED MY SATURN SL2 NEW IN 1996. AFTER 70,000 MILES IT STARTED USING AN INORDINATE AMOUNT OF OIL. OIL CONSUMPTION STARTED TO ECLIPSE 1 QT. FOR EVERY 500 MILES. MY OIL CHANGE SERVICE SAID SATURN ENGINES WERE NOTORIOUS FOR BAD RINGS. I TOOK TO SATURN DEALERSHIP. THEY WANTED SEVERAL THOUSAND DOLLARS FOR A NEW ENGINE. I REPLACED ENGINE WITH A SATURN ENGINE WITH 23,000 MILES. AFTER ANOTHER 40,000 MILES THE REPLACEMENT ENGINE EXHIBITED THE EXACT SAME BEHAVIOR. I NOW NEED TO PURCHASE A THIRD ENGINE.

THERE IS A CRACKED CYLINDER HEAD AND OIL IS LEAKING FROM VEHICLE. CONTACTED DEALER, AND THE DEALER IS NOT WILLING TO DO ANYTHING.*AK

ENGINE HAD A CRACKED HEAD WHICH WAS CAUSING LOSS OF OIL. DEALER CONTACTED. *AK THE HEAD GASKET WAS REPLACED AND WAS LEAKING. CONSUMER IS REQUESTING A REFUND FOR THE COST OF REPAIR. *YH

CRACKED HEAD CYLINDER CAUSED BY OIL MIXING WITH COOLENT. SATURN REFUSED TO HONOR SUPPLIMENTAL WARRANTY PROVIDED IN TSB 99P01. *AK

THIS VEHICLE WAS PREVIOUSLY REPAIRED APPROX. 1 1/2 YEARS AGO. THE ENGINE WAS REBUILT BECAUSE OF A CRACKED CYLINDER WHICH ALLOWED THE OIL AND COOLANT TO MIX. THIS NOVEMBER 2001 THE SAME PROBLEM OCCURRED ONCE MORE. A CRACKED CYCLINDER HEAD, OIL AND COOLANT MIXED. SATURN CORP. PAID FOR 1/2 ($720) THE COST OF THE REPAIR BUT THE DEALERSHIP REFUSED TO PAY THE OTHER HALF. HAS THIS PROBLEM BEEN REPORTED WITH OTHER SAME OR SIMILAR MODELS?*AK

LOSS OF COOLANT DUE TO A BLOWN HEAD GASKET. DEALER AND MANUFACTURER WERE NOTIFIED, AND INFORMED CONSUMER THAT IT WAS NOT COVERED UNDER A RECALL. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION CONCERNING THIS MATTER.*AK

VEHICLE EXPERIENCED OVERHEATING, DEALER REPLACED CYLINDER HEAD. *SLC

ENGINE OIL LEAKED INTO COOLANT SYSTEM CAUSE OVERHEATING AFTER ENGINE RAN OUT OF OIL. CRACKED CYLINDER HEAD WAS THE CAUSE AFTER TALKED TO DEALER. ALSO FOUND THERE WERE QUITE A FEW COMPLAINTS ABOUT EXACTLY THE SAME PROBLEM.

THE CYLINDER HEAD CRACKED WHILE I WAS COMMUTING HOME FROM WORK. IT COST ME 2000.00 PLUS TO REPAIR. SATURN TOLD ME THEY WOULD COVER THE REPAIR UP TO 100,000 MILES. OF COURSE I WAS ABOUT 7,000 OVER THAT. I NEVER RECEIVED ANY INFO ON ANY PROBLEMS TO LOOK OUT FOR FROM THE DEALER. PRIOR TO THIS I DID NOTICE MY COOLANT WAS DISCOLORED SO I HAD THE FLUID REPLACED. I DID NOT SUSPECT ANY INTERENAL ENGINE PROBLEMS. I WANT TO KNOW WHO I CAN GET IN CONTACT WHITH TO GET A REFUND OF MY MONEY. I. *AK

VEHICLE LUNGES WHEN PUT IN REVERSE AND GEARS AREN'T SHIFTING CORRECTLY, DEALER REPLACED VALVE BODY. *SLC

I NEED TO KNOW IF THERE IS OR WILL THERE BE A RECALL ON THE MOTOR MOUNT FOR THE SATURN SL COUPE 1996. *AK

WHILE DRIVING AT LOW SPEED SAW WATER AND OIL COMING OUT OF THE ENGINE. A TECHNICIAN STATED THAT THIS WAS DUE TO A BLOWN ENGINE HEAD GASKET. DEALER FOUND THE PROBLEM TO BE A CRACKED CYLINDER HEAD. OWNER TOLD THAT THIS WAS A MANUFACTURE DEFECT AND SATURN WOULD PAY REPAIRS COST. *AK *ML

PROBLEM DIAGNOSED BY SATURN OF THOUSAND OAKS AS A CRACKED CYLINDER HEAD; AS A RESULT, COOLANT AND COOLANT SYSTEM WAS CONTAMINATED WITH OIL; ALL HAD TO BE REPLACED. DESPITE COMMENT BY SATURN OF THOUSAND OAKS SERVICE REPRESENTATIVE THAT THERE WAS A PROBLEM WITH "THE PROCESS" WITH 1996 SATURNS, SATURN CORP. DENIES CAUSE IS MANUFACTURER'S DEFECT. I KNOW OF AT LEAST ONE OTHER 1996 SL1 PURCHASED AT THE SAME DEALERSHIP WHICH EXPERIENCED THE SAME PROBLEM IN JUNE/98. BOTH CARS WERE PURCHASED NEW AND WERE LESS THAN 3 YEARS OLD AT THE TIME OF THE PROBLEM. *AK

CONSUMER BACKED OUT DRIVEWAY. ON RIGHT SIDE OF DRIVEWAY WHERE THE FRONT OF VEHICLE WAS SITTING, THERE WAS BROWN OIL/WATER MIXTURE. WHEN SHE OPENED THE HOOD AND LOOKED INTO THE RESERVOIR THERE WAS A COLORED LIQUID. MECHANIC DISCOVERED A CRACKED ENGINE CYLINDER. CHECKED COMPUTER AND FOUND A BULLETIN--ID. #96-T-65A--ISSUED FEB. 1997,THAT DEALS WITH THIS PROBLEM. *AK

THE ENGINE HEAD HAS AN INTERNAL CRACK IN IT WHICH ALLOWS THE ENGINE OIL TO LEAK INTO THE COOLANT. I REALIZED THIS BECAUSE THERE WAS OIL IN THE COOLANT RESERVOIR. I WENT TO SATURN OF FT. LAUDERDALE, WHERE I BOUGHT THE CAR AND WAS TOLD THAT IT IS NO LONGER UNDER WARRANTY(I HAVE53,000MILES). I WAS ALSO TOLD IF I WANTED THEM TO FIX IT THEY WOULD CHARGE ME $300 TO DIAGNOSE THE PROBLEM, AND IF IT WAS A CRACKED HEAD, IT WOULD COST ME AT LEAST $1200. IF I DIDN'T LIKE THEIR DIAGNOSES I WOULD HAVE 24 HOURS TO HAVE THE CAR TOWED OFF THEIR PROPERTY , DISASSEMBLED. THIS WAS TOLD TO ME BY DENNY MCGEE (954)760-6340, SERVICE MANAGER FOR SATURN. I WAS ALSO TOLD THAT IF I HAD NOT FOLLOWED EVERY SERVICE REQUIREMENT THAT SATURN DESCRIBES IN THEIR HAND BOOK I WOULD NOT BE ELIGIBLE FOR ANY COMPENSATION. AT...

HEAD GASKET CRACKED.

VALVES REPLACED.

OIL PAN FAILED CAUSING LEAKING.

CRACKED ENGINE CYLINDER HEAD. *AK

ENGINE STALLS DUE TO VALVES STICKING.

WHILE DRIVING AT SPEED OF 55MPH, THE ENGINE LIGHT CAME ON AND THE VEHICLE DECREASED ITS SPEED DOWN TO 10MPH, THEN INCREASED ITS SPEED BACK TO 55MPH. CAUSE UNKNOWN.