1996 SATURN SL Engine And Engine Cooling Problems

TL*THE CONTACT OWNS A 1996 SATURN SL. THE VEHICLE WAS LEAKING OIL ON THE GROUND AND ALL OVER THE COOLING SYSTEM. THE TEMPERATURE GAUGE KEPT FLUCTUATING INTO THE RED ZONE. THE CHECK ENGINE SOON LIGHT ILLUMINATED INTERMITTENTLY AND THE VEHICLE BEGAN TO DRIVE DIFFERENTLY. THE DEALER STATED THAT THE CAUSE OF THE FAILURE WAS A CRACKED CYLINDER HEAD. THE COST TO REPAIR THE VEHICLE WAS $2,257. THE CONTACT RECEIVED A SPECIAL POLICY LETTER FROM SATURN IN JUNE OF 1999 CONCERNING A CRACKED CYLINDER HEAD. THE LETTER STATED THAT THERE WAS NO RECALL CAMPAIGN AND IT WAS UNNECESSARY TO TAKE THE VEHICLE TO A DEALER. THE CURRENT MILEAGE WAS 73,000 AND FAILURE MILEAGE WAS 63,000. UPDATED 05/06/08. *LJ UPDATED 05/06/08. *JB

TL*THE CONTACT OWNS A 1996 SATURN SL2. THE CONTACT STATED THAT THE VEHICLE HESITATED INTERMITTENTLY AND WAS TAKEN TO THE DEALER. THE DEALER DISCOVERED THAT THE SPARK PLUGS WERE SET AT DIFFERENT SPECIFICATIONS, WHICH WAS THE CAUSE OF FAILURE. THE SPEED WAS UNKNOWN. THE CURRENT MILEAGE WAS 175,000 AND FAILURE MILEAGE WAS 148,000.

PURCHASED THE SATURN SL1 IN SEPT 24 OF 2004 WITH 94,32 0MILES. I HAD THE OIL CHANGED THAT VERY SAME DAY. I 'VE KEPT UP ON ALL FLUIDS AND SERVICE RELIGIOUSILY. AT 96910 MILES THE CAR WOULD NOT GO INTO 1ST, 3RD OR REVERSE WITHOUT FORCE. ON 9/10/03 I HAD THE CLUTCH REPLACED AND THE SLAVE CABLE. THEN IS WHEN IT STARTED HAVING PROBLEMS OVERHEATING, MECHANIC DID TWO DIFFRENT DIAGNOSTIC TEST BOTH CAME BACK WITH NO CONCLUSIONS. THE CAR STILL HEATS UP EVERYDAY ,BUT I HAVE NO OTHER CAR TO DRIVE. THERE IS NO POWER IN THE CAR NOW AND THE OIL IS SLUDGE FILLED. I'VE PURCHASED TEMPERATURE SENDING UNITS, BOTH O2 SENSORS, THERMOSTAT, COOLANT,CLUTCH,RELAYS,ETC...TO TRY TO SOLVE THE PROBLEM OF THE OVER HEATING. PRETTY MUCH IT'S A MATTER OF TIME BEFORE I'M LIKE THE OTHER 1996 SATURN DRIVERS WHO WILL HAVE TO PAY THE $ 1000.00-2000.00 TO FIX MY...

CRACKED HEAD CYLINDER - MANUFACUTURER HAS "SECRET WARRANTY" ON THIS PART FOR 1994-1996 SATURNS. SATURN WOULDN'T COVER WHOLE REPLACEMENT BECAUSE THE "SECRET WARRANTY EXPIRED IN JUNE 2002" ON MY CAR. REASON I BELIEVE THEY SHOULD PAY FOR ALL OF IT: (1) KNOWN DESIGN DEFECT WITH ENGINE (2) MY CAR WAS IN THE DEALERSHIP GARAGE FOR ENGINE WORK DURING THE SECRET WARRANTY TERM AND DURING MY WARRANTY COVERAGE, FOR AN OIL CONSUMPTION PROBLEM. ENGINE WAS REBUILT BUT HEAD CYLINDER WAS NEVER CHECKED FOR KNOWN PROBLEM AND I WASN'T NOTIFIED OF THE KNOWN PROBLEM. NOW BOTH WARRANTIES ARE EXPIRED SO THEY WANTED ME TO PAY THE WHOLE BILL. I REFUSED BUT THEY ONLY OFFERED TO COVER HALF. I HAVE PUT A COMPLAINT INTO THE ATTORNEY GENERAL'S OFFICE AND THE BETTER BUSINESS BUREAU.

THE VEHICLE'S HEAD GASKET CRACKED CAUSING THE OIL FROM THE ENGINE TO POURS INTO THE RADIATOR COOLANT. THIS CAUSES THE ENGINE TO OVER HEAT. *MR

THE ENGINE OIL AND THE ANTIFREEZE IS MIXING TOGETHER IN THE VEHICLE. THIS CAUSES THE ENGINE TO OVERHEAT WHILE DRIVING. HAD TAKEN VEHICLE TO DEALERSHIP AND WAS INFORMED BY THE MECHANIC THE ENGINE CYCLINDER BEAD WAS CRACKED AND NEEDED TO BE REPAIRED OR REPLACED.*AK

CONSUMER STATES THAT WHILE CAR WAS RUNNING THE ENGINE CAUGHT ON FIRE, FIRE STARTED UNDER THE HOOD.

DRIVE BELT AND SERPENTINE BELT FAILED, VALVE BODY COVER AND GASKET WERE REPLACED. *YH

DRIVE BELT AND SERPENTINE BELT FAILED, VALVE BODY COVER AND GASKET WERE REPLACED. *YH