2003 MERCURY SABLE Structure Problems

MERCURY SABLE WAGON 2003 LEAKS INTO PASSENGER CABIN WHEN IT RAINS. THIS IS A PROBLEM NUMEROUS OTHER SABLE AND TAURUS OWNERS HAVE HAD. CABIN FLOODS WHEN IT RAINS. *TR

I OWN A 2003 MERCURY SABLE, IN 2007, I NOTICED THE PAINT ON THE PASSENGER REAR WHEEL-WELL WAS STARTING TO BUBBLE RUST, MY HUSBAND AND I MADE NUMEROUS COMPLAINTS TO THE DEALERSHIP, AT THE TIME, THEY WERE UNDERGOING A BUYOUT AND WE HAD A DIFFICULT TIME GETTING ANY ANSWERS FROM ANYONE, ONCE THE BUYOUT HAPPENED, WE WERE THEN TOLD ALL THE COMPUTER FILES WERE BEING UPDATED, THEY DID NOT HAVE ANY RECORD OF THE ISSUES WE REPORTED TO THE PREVIOUS OWNERS, SO WE STARTED OVER...IN JULY OF 2008, FINALLY GOT THE MANUFACTURER TO SHARE IN THE EXPENSE OF THE REPAIRS AS THIS HAD NOW PASSED THE WARRANTY TIMEFRAME, HOWEVER, WHEN THE ORIGINAL PROBLEM WAS REPORTED, WE WERE QUOTED A REPAIR ESTIMATE OF $250.00, BY THE TIME WE RECEIVED APPROVAL FROM FORD TO GO AHEAD WITH THE REPAIRS AND THEY STATED THE REPAIR ESTIMATE HAD INCREASED TO $ 550.00 BECAUSE THE...

WHENEVER THE CAR IS RAINED UPON, WATER RUNS INTO THE FAN MOTOR AIR INTAKE, THEN INTO THE FAN BLOWER MOTOR, WHICH IS INSIDE THE CAR BEHIND THE GLOVE BOX, AND THEN RUNS OUT ONTO THE RIGHT FRONT PASSENGER FLOORBOARD. I HAVE HAD TO REPLACE ONE BLOWER MOTOR THAT SHORTED OUT FROM THE WATER IN IT, AND HAVE TO PULL THE CARPET UP SO IT CAN DRY OUT. ALSO, AFRAID OF THE POSSIBILITY OF MOLD GROWING EITHER IN THE AIR VENTS OR IN THE CARPET. I TOOK THE CAR TO THE DEALERSHIP AND THE SERVICE REPRESENTATIVE TOLD ME HE HAS SEEN OTHER CARS LIKE MINE HAVING THE SAME PROBLEM. THE DEALERSHIP SELLS A PART TO INSTALL UNDER THE HOOD OVER THE AIR BLOWER INTAKE TO CHANNEL WATER AWAY TO CORRECT THE PROBLEM. *TR

WATER LEAKED INTO CAR INTERIOR FOOT AREA AND SHORTED OUT AC/HEATER BLOWER MOTOR. *TR

FORD TAURUS AND THE MERCURY SABLE'S HAVE A PROBLEM WITH WATER LEAKING INTO THE HEATER CORE BOX WHICH EVENTUALLY CAUSES THE HEATER MOTOR AND STOP WORKING. I UNDERSTAND FROM READING POST ON THE INTERNET THAT IS APPARENTLY A DESIGN FLAW. MY CAR HAD 44,000 MILES AT THE POINT WHERE THE MOTOR QUIT WORKING. THE BILL TO REPAIR THE CAR WAS $471.28. THE WARRANTY HAD OBVIOUSLY EXPIRED BUT I FELT LIKE FORD MOTOR CO SHOULD RE-IMBURSE THE COST OF THE REPAIR SINCE IT IS A VERY COMMON PROBLEM. THEY DECLINED TO HELP WITH THE COST OF THE REPAIR. *TR

MERCURY SABLE 2003 LEAKS WATER ONTO THE PASSENGER FLOOR BOARD ALSO CAUSING MY AC BLOWER MOTOR TO SHORT OUT. *TR

WATER AND RAIN LEAK INTO BLOWER HOUSING AND THEN ONTO PASSENGER FLOOR. IN HEAVY RAIN THE BLOWER CAN BE HEARD AGITATING THE WATER. THERE ARE MANY REPORTS THAT THIS WILL EVENTUALLY DISABLE THE BLOWER MOTOR AND THEREFORE THE VEHICLE WILL HAVE NO DEFROSTER, CREATING A POTENTIAL HAZARD. *JB

DT*: THE CONTACT STATED WATER LEAKED INTO THE FRONT RIGHT SIDE OF THE VENTILATION SYSTEM, ONTO THE FLOOR, AS THE VEHICLE WAS DRIVEN AT 45 MPH, WHILE IT WAS RAINING. THE SERVICE DEALER HAS BEEN MADE AWARE OF THE PROBLEM, BUT THE MANUFACTURER WAS NOT NOTIFIED.*AK

WATER LEAK IN THE FRONT PASSENGER COWL AND HAS CAUSED MY BLOWER MOTOR TO SHORT AND AM NO LONGER ABLE TO USE IT. *JB

NO EVENTS LEADING UP TO INCIDENT. WHENEVER IT RAINS, WATER LEAKS ONTO THE FRONT PASSENGER SIDE FLOORBOARD. WATER ALSO LEAKS ONTO BLOWER MOTOR AND RESISTOR CAUSING FAILURE. CAUSED BY A MANUFACTURER DESIGN FLAW IN A PLASTIC COWLING IN ENGINE COMPARTMENT. *NM

WATER COLLECTED IN THE HEATER BLOWER MOTOR CAUSING IT NEED REPALCEMENT. I HAVE HEARD THIS IS A DESIGN FLAW. *NM

CONSUMER HAS PROBLEMS SEEING THROUGH WINDSHIELD WHEN THE SUN IS SHINING. THE REFLECTION IS SO BAD THAT IT DISTORTS VISION. WHEN LOOKING THROUGH THE WINDSHIELD, INSTEAD OF SEEING WHAT IS ON THE OUTSIDE, THE CONSUMER SEES THE REFLECTION OF THE DASHBOARD. THE REFLECTION IS VERY STRONG. *AK *TS *NLM