2016 MERCEDES-BENZ METRIS — Problems, Recalls & Safety Data

Fuel smell in the engine compartment and visible leaking fuel on the lower hoses per NHTSA Campaign Number 18V837000. I previously complained about this in April 2025 (ID 11669847). Dealer inspected in April 2025 and replaced the lower hose, but I still would smell fuel. After a lot of my own troubleshooting over the last six months, I have determined that when the car has sat un-used for over 24 hours, the rubber fuel lines shrink just enough that the next time the fuel system is primed (pre-start routine when you unlock the car, or start the car), a small amount of fuel leaks out at the connection. If the car sits for weeks and then you start it up, fuel will visibly leak out of the rubber connection (I have video). Once the rubber line swells up again due to the fuel in the line, it will slow the leak. So, if you use the car daily, you will be less likely to notice a leak. If you use the car infrequently, you will be more likely to have a leak.

How does the digital display suddenly disappear from your dashboard? Mercedes has lost its respect for being a High Quality brand. Too many recalls,. Too many issues that vehicles less costly never have such as 1. Out of alignment at 0 mileage resulting in worn out tires at 12k miles. Realignment that was useless at mb specs resulting in third set of tires. 2. Pcv regulator valve triggers engine code p052e which means a $3000 repair bill that's not covered on commercial vans but covered on passenger vans with the same engine. 3. Digital display on dashboard gone. Yet cars in the 60's with digital screens still working. Thanks Mercedes for the Quality and commitment you have to your customers.

It has been two years after posting an issue with engine light on indicating the error code p052e which is a known problem on many models mercedes has. This metris van is not a passenger van but a commercial van. It has however the SAME engine and SAME error code as all the models mercedes having this engine. It is stated that it is under warranty by mercedes up to 150k, with the exception of the commercial van. This is ludicrous and a failure to correct a known defect and expecting the customer to pay the bill. It is also disturbing that the NHTSA does not communicate to the complaint or direct mercedes to FIX the problem. What happened to Quality and Customer care?

It has been two years after posting an issue with engine light on indicating the error code p052e which is a known problem on many models mercedes has. This metris van is not a passenger van but a commercial van. It has however the SAME engine and SAME error code as all the models mercedes having this engine. It is stated that it is under warranty by mercedes up to 150k, with the exception of the commercial van. This is ludicrous and a failure to correct a known defect and expecting the customer to pay the bill. It is also disturbing that the NHTSA does not communicate to the complaint or direct mercedes to FIX the problem. What happened to Quality and Customer care?

The contact owns a 2016 Mercedes-Benz Metris. The contact stated that while driving at 40 MPH, the steering wheel seized, and the vehicle became difficult to maneuver. The contact stated that the failure occurred immediately after driving over a speed bump, and the message "Power Steering Assist Malfunction" was displayed. The contact pulled over into a parking lot, and the vehicle was towed to a body shop to be diagnosed. The contact was informed that the power steering wire had overheated, causing a failure. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 17V595000 (Steering); however, the VIN was not included. The manufacturer was not made aware of the failure. The failure mileage was approximately 75,000.