2004 MAZDA RX-8 Suspension Problems

ELECTRIC-ASSIST POWER STEERING, RANDOMLY IN THE PARKING LOT THE WHEEL WILL TURN ALL BY ITSELF, ONE WAY TURNS EASIER THAN THE OTHER, SOMETIMES YOU HAVE NO POWER STEERING AND OTHER TIMES YOUR STEERING WHEEL TURNS LIKE BUTTER, I LIVE IN THE MOUNTAINS WITH A VERY WINDY AND DANGEROUS ROADS, I'VE TAKEN IT TO SEVERAL MECHANICS FINALLY ONE MECHANIC JUST UNPLUG THE WIRING HARNESS SO THERE IS NO POWER STEERING. IT IS VERY SCARY TO DRIVE ESPECIALLY WITH A NEWBORN BABY. THERE ARE A LOT OF CARS ON THE ROAD WITH THIS ISSUE I KNOW 10 DIFFERENT PEOPLE THAT HAVE SOME SORT OF POWER STEERING ISSUE. THIS IS VERY DANGEROUS AND I'M SURPRISED THERE IS NOT A RECALL YET ON IT. I'VE HAD TWO FRIENDS THAT ARE CLOSE TO ME THAT HAVE THIS ISSUE AS WELL, ONE FRIEND WRECKED HIS CAR THE OTHER FRIEND SOLD IT I BELIEVE TO PICK-N-PULL SO...

WHILE DRIVING AT APPROXIMATELY 45 MILES PER HOUR ON A RURAL ROAD, THE FRONT PASSENGER BALL JOINT SEPARATED FROM THE LOWER CONTROL ARM, CAUSING THE CONTROL ARM TO FIRST DROP ONTO THE INSIDE SURFACE OF THE FRONT PASSENGER WHEEL AND THEN ONTO THE GROUND AS THE WHEEL MOVED OUT OF ITS NORMAL POSITION. IN THE PROCESS, THE PASSENGER SIDE INNER TIE ROD WAS SEVERELY BENT, THE INSIDE SURFACE OF THE WHEEL WAS BADLY SCORED, THE TIRE SURFACE (WHICH CONTACTED THE FENDER) WAS DAMAGED, AND THE PASSENGER FRONT FENDER WAS BENT WHEN THE TIRE CONTACTED IT. I SPOKE WITH MAZDA USA, WHO PUT ME IN CONTACT WITH A LOCAL DEALER. I TOWED THE CAR TO THE DEALER AND DROPPED IT OFF. THEY HAVE REPLACED BOTH CONTROL ARMS (PER THE RECALL) AS WELL AS THE BENT TIE ROD AND PASSENGER FRONT WHEEL BEARING. THEY ALSO PERFORMED AN ALIGNMENT. MECHANICALLY, THEY HAVE REPAIRED...

ON SEPTEMBER 15TH, 2016 I HAD STOPPED TO VACUUM OUT MY CAR AT A CAR WASH ON HIGHWAY 11 IN ATTALLA, AL. UPON LEAVING THE CAR WASH I TURNED LEFT ONTO PLEASANT VALLEY RD AT A SLOW SPEED IN FIRST GEAR. AS I WAS TURNING I SHIFTED INTO SECOND GEAR I HEAR A BREAKING NOISE AND THE STEERING WHEEL ABRUPTLY SPUN TO THE LEFT AS THE CAR WENT IN A DEEP DITCH FLIPPING ONTO ITS ROOF, THEN HITTING A SMALL CULVERT AND LANDING ON IT'S SIDE. AS I WAS INSPECTING THE VEHICLE TO SEE WHAT MIGHT HAVE HAPPENED, THE PASSENGER LOWER CONTROL HAD BROKEN AND THE BALL JOINT HAD SEPARATED FROM THE CONTROL ARM.

TL* THE CONTACT OWNS A 2004 MAZDA RX-8. THE CONTACT TOOK THE VEHICLE TO THE LOCAL DEALER (MODERN MAZDA DODGE RAM, 68 WATERBURY RD, THOMASTON, CT, 06787, 860-283-4304) TO BE SERVICED PER NHTSA CAMPAIGN NUMBERS: 17V355000 (SUSPENSION), 16V793000 (FUEL SYSTEM), AND 17V354000 (FUEL SYSTEM). THE CONTACT WAS INFORMED THAT THE RECALL REPAIRS WOULD TAKE ONE DAY TO COMPLETE; HOWEVER, IT TOOK FOUR DAYS. THE CONTACT RETRIEVED THE VEHICLE AND, WHILE THE ACCELERATOR PEDAL WAS DEPRESSED, THE VEHICLE FAILED TO ACCELERATE AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE CONTACT TOOK THE VEHICLE BACK TO THE DEALER AND WAS INFORMED THAT THEY WOULD REPAIR THE FAILURE. ONE WEEK LATER, THE DEALER STATED THAT THE CONTACT COULD RETRIEVE THE VEHICLE, BUT THEN DIAGNOSED THAT THE COMPRESSOR FAILED AND IT WOULD ONLY LAST APPROXIMATELY TWO MORE YEARS. THE DEALER STATED THAT THE ENGINE NEEDED TO BE REPLACED. WHEN THE CONTACT RETRIEVED THE VEHICLE AGAIN,...

TL* THE CONTACT OWNS A 2004 MAZDA RX-8. WHILE DRIVING AT VARIOUS SPEEDS, THE CONTACT NOTICED STRONG EXHAUST FUMES IN THE VEHICLE. IN ADDITION, WHILE MAKING A LEFT TURN AT A LOW SPEED, THE CONTACT HEARD A LOUD NOISE UNDERNEATH THE VEHICLE. IN ADDITION, THE CONTACT STATED THAT THE VEHICLE FAILED TO REMAIN IN POSITION. THE CONTACT HAD TO CONTINUOUSLY MANEUVER THE STEERING WHEEL IN ORDER TO MAKE THE VEHICLE REMAIN IN POSITION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE VEHICLE WAS THEN TAKEN TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBERS: 05V325000 (SUSPENSION) AND 05V317000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 82,000.

TL* THE CONTACT OWNS A 2004 MAZDA RX-8. WHILE DRIVING APPROXIMATELY 35 MPH AND MAKING A RIGHT TURN, THE CONTACT HEARD A LOUD NOISE AND THE BALL JOINTS SEPARATED AND FRACTURED. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 05V325000 (SUSPENSION). THE DEALER INSPECTED THE VEHICLE AND DETERMINED THAT THE RECALL REMEDY WAS NOT REQUIRED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS PENDING THE MANUFACTURER'S APPROVAL FOR THE RECALL REPAIR. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 66,000.

DRIVER CAME UPON A DEER AND SLAMMED THE BRAKES, MISSING THE DEER. WHILE SLAMMING THE BRAKES THE FRONT END COLLAPSED UPON THE LEFT FRONT WHEEL CAUSING SEVERE FRONT END DAMAGE AND MAKING THE CAR INOPERABLE. THE FRONT END REQUIRED NEW LEFT LOWER CONTROL ARM, STABILIZER BAR CONTROL LINK, NEW SHOCK/STRUT ASSEMBLY, NEW TIE RODS (INNER AND OUTER), NEW SWAY BAR LINK AND 4 WHEEL ALIGNMENT. THE ORIGINAL CAUSE OF THIS DAMAGE WAS A CRACK IN THE LEFT LOWER CONTROL ARM. THE LOWER CONTROL ARM WAS THE SUBJECT OF RECALL # 36261. I WAS NOT NOTIFIED OF THIS RECALL. UPON TALKING WITH MAZDA ([XXX]... FILE #[XXX]) ON MAY 14, 2013 I WAS INFORMED THAT WHILE THIS RECALL DID AFFECT OTHER RX8'S OF THE SAME YEAR, MY RX8 WAS NOT COVERED. I BELIEVE MY RX8 SHOULD HAVE BEEN COVERED UNDER THIS RECALL FOR THE SIMPLE FACT THAT THE DAMAGE WAS CAUSED BY...

TL*THE CONTACT OWNS A 2004 MAZDA RX8. THE VEHICLE HAS BRIDGESTONE ALL SEASON TIRES. THE CONTACT WAS CONCERNED ABOUT THE AIR PRESSURE IN THE TIRES AND NOTIFIED THE MANUFACTURER. MAZDA SUGGESTED THAT HE TAKE THE VEHICLE TO A DEALER FOR INSPECTION. THE VEHICLE WAS TAKEN TO THE DEALER FOUR TIMES, BUT NO REPAIRS WERE MADE. THE DEALER ONLY PLACED AIR IN THE TIRES. ON ONE OCCASION, WHILE DRIVING ALMOST 60 MPH, THE CONTACT FELT A VERY ROUGH VIBRATION IN THE VEHICLE. HE ATTEMPTED TO MOVE THE VEHICLE OFF THE ROAD AND THE REAR PASSENGER SIDE TIRE EXPLODED. THE TIRE AND VEHICLE MANUFACTURERS WERE NOT NOTIFIED OF THE BLOW OUT. THE DOT NUMBER AND TIRE SIZE WERE UNKNOWN. THE FAILURE MILEAGE WAS 14,000 AND CURRENT MILEAGE WAS 23,000. THE TAIL LIGHTS WOULD FILL WITH WATER. THERE WAS A STRANGE CLICKING NOISE COMING FROM THE FRONT OF THE VEHICLE. THE VEHICLE MAY...

TL*THE CONTACT OWNS A 2004 MAZDA RX8. WHILE DRIVING 15 MPH, THE VEHICLE MADE A CREAKING NOISE WHENEVER THE STEERING WHEEL WAS TURNED. HE TOOK THE VEHICLE TO A LOCAL REPAIR SHOP AND THE MECHANIC STATED THAT THERE WAS A TEAR LINE CRACK IN THE LOWER CONTROL ARM IN THE SUSPENSION. THE CONTACT RECEIVED A RECALL NOTICE IN 2005 FOR NHTSA CAMPAIGN ID NUMBER 05V325000 (SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT) AND THE MANUFACTURER REPAIRED THE VEHICLE FOR FREE. THE FAILURE HAS RECURRED, BUT THE MANUFACTURER REFUSES TO REPAIR THE VEHICLE ACCORDING TO THE RECALL. HE BELIEVES THAT THE COMPONENT THAT WAS USED TO PREVIOUSLY REPAIR THE VEHICLE WAS FAULTY; THEREFORE, THE MANUFACTURER SHOULD BE RESPONSIBLE FOR THE REPAIRS. THE CHECK ENGINE INDICATOR WOULD RANDOMLY ILLUMINATE WHILE DRIVING VARIOUS SPEEDS. A LOCAL MECHANIC STATED THAT THE VEHICLE EXPERIENCED A RUPTURED OIL COOLING LINE. DURING THE REPAIR, THE TECHNICIAN NOTICED THAT THE OIL...