2005 MAZDA MAZDA6 — Problems, Recalls & Safety Data
N/A
Safety Rating
180
Owner Complaints
6
Recalls
6
Service Bulletins
0
Investigations
Overview of the 2005 MAZDA MAZDA6
The 2005 MAZDA MAZDA6 has received a total of 180 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There have been 6 recall campaigns affecting this vehicle, covering issues with AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE, AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE. 6 technical service bulletins have been issued by Mazda Motor Corp. for this model year. The most commonly reported problems involve the Air Bags (73 complaints), Electrical System (11 complaints), and Power Trainautomatic Transmission (11 complaints).
Recalls for the 2005 MAZDA MAZDA6
NHTSA has recorded 6 recalls for the 2005 MAZDA MAZDA6, potentially affecting up to 725,722 vehicles.
Recall 19V781000 — AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
| 47,006 vehicles affected
Defect: Mazda North American Operations (Mazda) is recalling certain 2003-2008 Mazda6, 2004-2005 MPV, 2004 RX-8, and 2006-2007 Mazdaspeed6 vehicles. These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. Mazda will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. The recall began December 3, 2019....
View full details →Recall 18V402000 — AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
| 308,591 vehicles affected
Defect: Mazda North America Operations (Mazda) is recalling certain 2003-2008 Mazda6, 2006-2007 Mazdaspeed6 and 2004 MPV vehicles nationwide. Mazda is also recalling 2005-2006 MPV vehicles in Alabama, Arizona, Arkansas, California, Delaware, the District of Columbia, Florida, Georgia, Hawaii, Illinois, Indiana, Kansas, Kentucky, Louisiana, Maryland, Mississippi, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, South Carolina, Tennessee, Texas,...
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. Mazda will notify owners, and dealers will replace the front passenger air bag inflator with an alternate inflator, free of charge. The recall began July 6, 2018....
View full details →Recall 17V474000 — AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
| 308,992 vehicles affected
Defect: Mazda North American Operations (Mazda) is recalling certain model year 2003-2008 Mazda6, 2004-2008 RX-8, and 2006-2007 Mazdaspeed6 vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion and other factors, including manufacturing variability that, over time, could cause the inflator to rupture.
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. Mazda will notify owners, and dealers will replace the driver's frontal air bag inflator with an alternate inflator, free of charge. The recall began on September 12,...
View full details →Recall 09E025000 — EXTERIOR LIGHTING:HEADLIGHTS
| 42,540 vehicles affected
Defect: DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
View full details →Recall 09E012000 — EXTERIOR LIGHTING
| 16,270 vehicles affected
Defect: SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
View full details →Recall 09E011000 — EQUIPMENT
| 2,323 vehicles affected
Defect: THULE, INC. IS RECALLING 2,323 OWNER-INSTALLED ROOF-MOUNTED FIT KITS, MODELS 3068 AND 3069, MANUFACTURED BETWEEN JANUARY 1, 2008 AND FEBRUARY 28, 2009 THAT ARE USED WITH THULE PODIUM FOOT PACKS, MODELS 460 AND 460R. THESE FIT KITS WERE SOLD AS AFTERMARKET EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE BOLT(S) USED TO SECURE THE FOOT TO THE VEHICLE WAS...
Consequence: THIS MAY RESULT IN THE BOLT(S) SNAPPING OFF DURING USE OR WITHOUT A LOAD. THE UNSECURED RACK AND LOAD CAN THEN COME LOOSE WHILE DRIVING CREATING A POTENTIAL ROAD HAZARD, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: THULE WILL MAIL A RETRO FIT KIT ALONG WITH REPAIR INSTRUCTIONS TO OWNERS FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE APRIL 13, 2009. OWNERS MAY CONTACT THULE TOLL-FREE AT 1-800-238-2388.
View full details →Owner Complaints for the 2005 MAZDA MAZDA6
180 complaints have been filed with NHTSA for the 2005 MAZDA MAZDA6. Below is a breakdown by vehicle component.
Most Recent Complaints
I NOTICED MY VEHICLE WAS STARTING TO DRIVE FUNNY. I KEEP UP ON IT VERY WELL, ROUTINE MAINTENANCE, WASH IT OFTEN, FRESH ALIGNMENTS, NEW TIRES WHEN NEEDED. SO I THOUGHT SOMETHING WAS UP AND TOOK IT INTO A GARAGE. I WAS CALLED THE NEXT DAY AND WAS TOLD I HAD A HOLE IN MY PASSENGER SIDE RIGHT SUBFRAME. I WAS VERY SURPRISED BY THIS BECAUSE THE CAR IS VERY CLEAN UNDERNEATH FOR THE YEAR AND IN GOOD CONDITION COMPARED TO THE USUAL NEW YORK RUST. I DID SOME RESEARCH AND THIS IS A ONGOING PROBLEM WITH THESE CARS AROUND MY YEAR AND SADLY MANY PEOPLE HAVE EXPERIENCED THIS. MY VEHICLE HAS NO RECALLS AND MAZDA DOESN'T WANT TO TAKE CARE OF THE BILL SO SADLY I'M STUCK WITH A CAR THAT SHOULD BE RECALLED. *TR
I NOTICED MY VEHICLE WAS STARTING TO DRIVE FUNNY. I KEEP UP ON IT VERY WELL, ROUTINE MAINTENANCE, WASH IT OFTEN, FRESH ALIGNMENTS, NEW TIRES WHEN NEEDED. SO I THOUGHT SOMETHING WAS UP AND TOOK IT INTO A GARAGE. I WAS CALLED THE NEXT DAY AND WAS TOLD I HAD A HOLE IN MY PASSENGER SIDE RIGHT SUBFRAME. I WAS VERY SURPRISED BY THIS BECAUSE THE CAR IS VERY CLEAN UNDERNEATH FOR THE YEAR AND IN GOOD CONDITION COMPARED TO THE USUAL NEW YORK RUST. I DID SOME RESEARCH AND THIS IS A ONGOING PROBLEM WITH THESE CARS AROUND MY YEAR AND SADLY MANY PEOPLE HAVE EXPERIENCED THIS. MY VEHICLE HAS NO RECALLS AND MAZDA DOESN'T WANT TO TAKE CARE OF THE BILL SO SADLY I'M STUCK WITH A CAR THAT SHOULD BE RECALLED. *TR
I NOTICED MY VEHICLE WAS STARTING TO DRIVE FUNNY. I KEEP UP ON IT VERY WELL, ROUTINE MAINTENANCE, WASH IT OFTEN, FRESH ALIGNMENTS, NEW TIRES WHEN NEEDED. SO I THOUGHT SOMETHING WAS UP AND TOOK IT INTO A GARAGE. I WAS CALLED THE NEXT DAY AND WAS TOLD I HAD A HOLE IN MY PASSENGER SIDE RIGHT SUBFRAME. I WAS VERY SURPRISED BY THIS BECAUSE THE CAR IS VERY CLEAN UNDERNEATH FOR THE YEAR AND IN GOOD CONDITION COMPARED TO THE USUAL NEW YORK RUST. I DID SOME RESEARCH AND THIS IS A ONGOING PROBLEM WITH THESE CARS AROUND MY YEAR AND SADLY MANY PEOPLE HAVE EXPERIENCED THIS. MY VEHICLE HAS NO RECALLS AND MAZDA DOESN'T WANT TO TAKE CARE OF THE BILL SO SADLY I'M STUCK WITH A CAR THAT SHOULD BE RECALLED. *TR
TCM UNIT FAULTY, CAR ONLY HAS 82K MILES, READING ONLINE THIS SEEMS TO BE A FAR TOO COMMON PROBLEM, I BELIEVE THE UNIT IS FAULTY!
Safety Rating for the 2005 MAZDA MAZDA6
NHTSA has not yet tested the 2005 MAZDA MAZDA6 in its New Car Assessment Program.
Technical Service Bulletins for the 2005 MAZDA MAZDA6
Mazda Motor Corp. has issued 6 technical service bulletins (TSBs) for the 2005 MAZDA MAZDA6. TSBs are notices sent by manufacturers to their dealers describing a known issue and the recommended repair procedure.
01-003-08 — ENGINE AND ENGINE COOLING:ENGINE
MAZDA: ENGINE STALLS WHEN DRIVING AT LOW SPEED. *PE
0102205 — VEHICLE SPEED CONTROL
DELAYED THROTTLE RESPONSE DURING LOW SPEED ACCELERATION. *TT
01012006 — EQUIPMENT:APPLIANCE:AIR CONDITIONER
RECIRC AIR FUNCTION INOPERATIVE. *TT
11012005 — EQUIPMENT:ELECTRICAL
INFORMATION DISPLAY FUNCTIONS. *TT
0520 — POWER TRAIN:AUTOMATIC TRANSMISSION
AUTOMATIC TRANSMISSION FLUID. *SC
0800505 — SEAT BELTS
DEACTIVATION OF SEAT BELT MINDER. *SC
NHTSA Investigations for the 2005 MAZDA MAZDA6
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the MAZDA MAZDA6
- 2002 MAZDA MAZDA6 — 40 complaints
- 2003 MAZDA MAZDA6 — 245 complaints
- 2004 MAZDA MAZDA6 — 196 complaints
- 2005 MAZDA MAZDA6 (current)
- 2006 MAZDA MAZDA6 — 207 complaints
- 2007 MAZDA MAZDA6 — 183 complaints
- 2008 MAZDA MAZDA6 — 121 complaints
- 2009 MAZDA MAZDA6 — 526 complaints
- 2010 MAZDA MAZDA6 — 317 complaints
Other MAZDA Models
- MAZDA MAZDA3 — 3,974 total complaints
- MAZDA 626 — 3,877 total complaints
- MAZDA CX-5 — 3,005 total complaints
- MAZDA TRIBUTE — 2,830 total complaints
- MAZDA CX-9 — 1,786 total complaints
- MAZDA CX-7 — 1,539 total complaints
- MAZDA PROTEGE — 1,377 total complaints
- MAZDA MPV — 1,156 total complaints