2005 MAZDA MAZDA6 Power Trainautomatic Transmission Problems

2005 MAZDA 6S 3 LITER V6 WITH AUTOMATIC TRANSMISSION (AISIN WARNER). APPLICATION OF THROTTLE TO ACCELERATE IN 5TH OR 6TH GEAR CAUSES JERK, SELECTS NEUTRAL THEN EVENTUALLY SELECTS AN APPROPRIATE GEAR. VERY DANGEROUS ON UPHILL FREEWAYS DUE TO SUDDEN LOSS OF ANY POWER. MAZDA HAS A SERVICE BULLETIN ON THIS # 05-016/06 THAT PROVES THIS CONDITION IS NOT ISOLATED. *TR

THE VEHICLE IS EQUIPPED WITH AN AUTOMATIC TRANSMISSION. WHEN THE VEHICLE WAS PARKED FOR OVER 8 HOURS OUTDOORS IN DIRECT SUNLIGHT, THE VEHICLE WOULD NOT SHIFT OUT OF PARK. FAILURE OCCURS ONLY ON EXTREMELY HOT DAYS - TEMPERATURES OVER 95 DEGREES AND ONLY WHEN ALL THE WINDOWS & SUNROOF WERE COMPLETELY CLOSED. VEHICLE WAS ALLOWED TO SIT WITH THE ENGINE RUNNING AND AIR CONDITIONER ON HIGH FOR ROUGHLY 15-20 MINUTES. WHEN INTERIOR TEMPERATURE OF CAR LOWERED, THE CAR WAS ABLE TO SHIFT OUT OF PARK. THE PROBLEM REPLICATED SPORADICALLY BUT ON AT LEAST 10 DIFFERENT OCCASIONS OVER THE COURSE OF 2 YEARS. THE VEHICLE WAS BROUGHT TO DEALERSHIP ON NUMEROUS OCCASIONS WHERE THEY WERE UNABLE TO REPLICATE THE PROBLEM. DURING ONE SERVICE VISIT A MECHANIC CLEANED THE MICROSWITCH RESPONSIBLE FOR THE SHIFT INTERLOCK. THAT DID NOT REMEDIATE THE PROBLEM. *TR

: I HAVE A 2005 MAZDA 6 WAGON BOUGHT NEW OFF THE DEALER'S LOT. 4 YEARS LATER, IN SEPT. 2009 WITH 22K MILES ON IT, I WAS COMING OFF A CURVING EXIT RAMP WHEN I STEPPED ON THE GAS TO MERGE INTO TRAFFIC AND NOTHING HAPPENED - NO PICKUP - I JUST STARTED COASTING. THIS HAPPENED A FEW TIMES BEFORE IN THE PREVIOUS YEARS (MAYBE 4-5 TIMES), BUT THOSE TIMES IT FELT MORE LIKE A BELT SLIPPING AND IT "CAUGHT" AGAIN VERY QUICKLY, LIKE IN A SPLIT SECOND. THE RAMP EXPERIENCE WAS MORE PRONOUNCED AND LASTED LONGER, LIKE A FULL 2 SECONDS, WHICH WAS MORE SCARY AND POTENTIALLY MORE HAZARDOUS. TURNED OUT THE TCM (TRANSMISSION COMPUTER MODULE) HAD TO BE REPLACED. IT WOULD HAVE COST $1400+ BUT LUCKILY I BOUGHT AN EXTENDED WARRANTY WHEN I BOUGHT THE CAR SO IT COVERED THAT COST. ITS HAPPENING AGAIN, SO I HAVE TO...

THE MAZDA 6 JERKS WHEN SHIFTING FROM 1ST GEAR TO SECOND. DID THIS A COUPLE TIMES WHILE IN TRAFFIC ALMOST CAUSING AN ACCIDENT. IT FEELS LIKE THE CAR IS HESITANT TO SHIFT AND THEN SHIFTS AND JERKS YOU FORWARD WHEN THERE ARE POSSIBLY OTHER CARS IN FRONT AND YOU NEED TO STOP. I BROUGHT THE CAR IN MULTIPLE TIMES TO THE DEALER AND THEY "COULD NOT REPLICATE THE PROBLEM". *TR

AUTOMATIC TRANSMISSION FAILURE IN 4TH GEAR ON 2005 MAZDA 6. WE BOUGHT THE CAR NEW AND 2YEARS LATER THE TRANSMISSION STARTED SLIPPING IN 4TH GEAR. I COMPLAINED TO THE DEALER AND THEY SAID THEY FOUND NOTHING. THE THIRD YEAR IT BECAME PRONOUNCED AND STILL THEY SAID THEY FOUND NOTHING. I FOUND OUT LAST YEAR THAT MAZDA KNEW ABOUT THE PROBLEM IN THE TRANSMISSIONS AND NEVER CONTACTED US ABOUT A REPLACEMENT TRANSMISSION. I WENT TO THE DEALERSHIP WHEN I FOUND OUT LATE LAST YEAR AND I WAS TOLD THAT THEY COULD NO DO ANYTHING ABOUT IT AS THE CAR WAS OVER THE MILEAGE. I STRONGLY FEEL THAT MAZDA KNEW THE TRANSMISSIONS WERE DEFECTIVE AND NEVER NOTIFIED OWNERS. WE ARE THE ONLY REGISTERED OWNERS OF THE VEHICLE AND IT IS AN ACCIDENT WAITING TO HAPPEN BECAUSE ONCE THE VEHICLE GETS IN THE 4TH GEAR IT VIBRATES AND SHAKES THE WHOLE CAR VIOLENTLY.*TR

I HAVE A 2005 MAZDA 6 WAGON BOUGHT NEW OFF THE DEALERS LOT. 4 YEARS LATER, IN SEPT. 2009 WITH 22K MILES ON IT, I WAS COMING OFF A CURVING EXIT RAMP WHEN I STEPPED ON THE GAS TO MERGE INTO TRAFFIC AND NOTHING HAPPENED - NO PICKUP - IT WAS LIKE I JUST STARTED COASTING. THIS HAPPENED A FEW TIMES BEFORE IN THE PREVIOUS YEARS (MAYBE 4-5 TIMES), BUT THOSE TIMES IT FELT MORE LIKE A BELT SLIPPING AND IT "CAUGHT" AGAIN VERY QUICKLY, LIKE IN A SPLIT SECOND. THE RAMP EXPERIENCE WAS MORE PRONOUNCED AND LASTED LONGER, LIKE A FULL 2 SECONDS, WHICH WAS MORE SCARY AND POTENTIALLY MORE HAZARDOUS. TURNED OUT THE TCM (TRANSMISSION COMPUTER MODULE) HAD TO BE REPLACED. IT WOULD HAVE COST $1400+ BUT LUCKILY I BOUGHT AN EXTENDED WARRANTY WHEN I BOUGHT THE CAR SO IT COVERED THAT COST. IT'S HAPPENING AGAIN, SO I...

LEASED 2005 MAZDA 6 IN JULY 2005. SEPTEMBER 2005: TOOK IN FOR SERVICE FOR CHECK ENGINE LIGHT. DEALERSHIP REPLACED A PURGE CANISTER VALVE. WHILE DRIVING VEHICLE AFTER REPAIRS WERE MADE, I HEARD A HIGH-PITCHED WHIRRING NOISE FROM THE ENGINE AND RETURNED THE VEHICLE TO THE DEALERSHIP FOR SERVICE. TECH DETERMINED NOISE WAS COMING FROM TRANSMISSION. TRANS. WAS REPLACED TWO TIMES; NOISE DID NOT GO AWAY. TECH THEN DETERMINED IT WAS THE FUEL PUMP. THAT WAS REPLACED BUT NOISE REMAINED. TECH THEN SUSPECTED THE FUEL LINES WERE VIBRATING, ADDED A CLIP TO PREVENT RUBBING AND NOISE DISAPPEARED. THAT TOOK 28 DAYS. DAY AFTER VEHICLE LEFT DEALERSHIP, FUEL TANK LEAKED FUEL UPON STARTING THE VEHICLE. DEALERSHIP DETERMINED THAT A CAP HAD NOT BEEN TIGHTENED. CAP WAS TIGHTENED AND CAR WAS RETURNED BUT SMELLED AWFUL. DEALERSHIP SHAMPOOED INTERIOR. JUNE 2006: WHILE DRIVING, TACHOMETER SUDDENLY BOUNCED AND VEHICLE DID NOT RESPOND TO ACCELERATOR BEING...

2006 MAZDA6 GRAND TOURING HESITATED WHEN ACCELERATING AND DE-ACCELERATING. THE GEARS ALSO BECAME STUCK. *KB THE VEHICLE HAS BEEN TAKEN TO THE DEALER MULTIPLE TIMES FOR AIR CONDITIONING/HEATER PROBLEMS., RADIO/CD AND CONDENSATION ON THE INSIDE OF THE WINDSHIELD.

2005 GRAND TOURING GETS STUCK IN GEAR WHILE DRIVING. *TS THE VEHICLE BECAME STUCK IN GEAR THREE TIME WHILE DRIVING ON THE FREEWAY. THE CONSUMER TOOK HER FOOT OFF THE ACCELERATOR YET THE VEHICLE CONTINUED TO MOVE AT 60 MPH. THE CONSUMER PRESSED THE BRAKE PEDAL BUT THE VEHICLE CONTINUED AT 60 MPH. THE CONSUMER PUT THE CAR IN MANUAL 6 SPEED AND THE VEHICLE BUCKED THEN WORKED NORMALLY. AS SOON AS THE VEHICLE WAS PUT BACK INTO AUTOMATIC MODE THE GEARS BECAME STUCK. THE VEHICLE WAS TAKEN TO THE DEALER BUT THEY WERE UNABLE TO DUPLICATE THE PROBLEM. THE CONSUMER NOTICED CONDENSATION ON THE INSIDE BOTTOM OF THE WINDSHIELD. THE CHECK ENGINE LIGHT ILLUMINATED DUE TO FAILED THROTTLE BODY. THE RADIO EXPERIENCED PROBLEMS. THE LEFT REAR WHEEL WAS BENT AND CAUSED VIBRATION WHILE DRIVING. *NM

AFTER A MODEST ACCELERATION TO PULL INTO TRAFFIC, I HAD TO STOP SUDDENLY DUE TO A LIGHT AND THE CAR BEGAN TO REV UP TO 1500 AND BACK DOWN OVER AND OVER. I HAD TO PULL OVER IMMEDIATELY WHERE IT CONTINUED TO REV AND DIE DOWN, REGARDLESS IF I WAS IN A GEAR OR PARK. IT IS AN AUTOMATIC. I TURNED OFF THE CAR AND RESTARTED, THE PROBLEM WENT AWAY BUT THE ENGINE LIGHT REMAINED ON FOR TWO DAYS. I PLAN ON TAKING TO THE DEALER. IT IS ONLY 7 MONTHS OLD, I BOUGHT IT NEW. *NM

DT: CONSUMER SAYS HE IS HAVING PROBLEM WITH TRANSMISSION. TRANSMISSION WILL DROP GEARS ON ITS OWN, CONSUMER JUST HAD VEHICLE AT DEALER FOR TRANSMISSION SLIPPAGE AND HARSH SHIFTING. CONSUMER SAID THAT DEALER DID A SOFTWARE CALIBRATION ON THE TRANSMISSION CONTROL MODULE. CONSUMER SAYS NOW WHEN HE IS TRAVELING ON HIGHWAY AND CONSUMER TRIES TO ACCELERATE TRANSMISSION WILL DROP FROM 4TH GEAR TO 3RD GEAR BY ITSELF AND THIS MAKES ACCELERATION VERY DIFFICULT. WHILE DRIVING VEHICLE IN CITY CONSUMER SAYS THAT TRANSMISSION WILL DROP FROM 4TH TO 2ND WHILE TRYING TO ACCELERATE. CONSUMER NOTICES WHICH GEAR BY THE INDICATOR LIGHT LOCATED ON DASH. CONSUMER SAYS THAT SLIPPAGE AND HARSH SHIFTING IS NOW CORRECTED, BUT HE IS HAVING PROBLEM WITH TRANSMISSION DROPPING GEARS. CONSUMER SAYS HE HAS AN EMAIL THAT HE SOMEHOW COME INTO POSITION OF, THIS EMAIL IS FROM FORD AND SAYS THAT THERE IS A PROBLEM WITH THIS TRANSMISSION IN...