2021 KIA TELLURIDE Unknown Or Other Problems

Sunroof bracket broke off when opening

1) What component or system failed or malfunctioned, and is it available for inspection upon request? The panoramic sunroof assembly — specifically the sunroof panel and its track/mechanism — failed. The sunroof panel came off its track and damaged related components (e.g., guide rails/wind deflector arms). The damaged sunroof and broken parts are available for inspection upon request. 2) How was your safety or the safety of others put at risk? The sunroof panel dislodged unexpectedly during normal use. This could have caused objects or glass to fall into the cabin or onto the roadway, presenting a risk of injury to occupants or other road users. Sudden failure of the sunroof mechanism also poses a distraction while driving. 3) Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. The dealership/service center inspected the vehicle and confirmed the sunroof panel was off its track and...

My stationary sunroof exploded with no Impact while driving. You can tell from. Photos the hole is inside to outside. This happened May 1st, I had it repaired with OEM glass on 5/10 and from day 1 after the repair had the shade vented to alleviate hot air getting trapped as they say they could be a factor. Well then it happened again today on Dec. 17th !! Something is wrong with either frame or the glass KIA is using !

On 11/01/2025, while traveling on the highway traveling at a speed of 80mph, my vehicle suddenly would not accelerate beyond 60 mph. I managed to exit safely, but this created a dangerous situation for both me, my daughter and other motorists . The next day, Firestone inspected the vehicle and informed me the engine contained zero oil—yet no oil light, check-engine light, temperature warning, or sensor alerts were triggered at any point. There were no visible oil leaks, suggesting internal oil consumption, which I had reported to Kia in October of 2024. On 10/21/2024, I paid $3,300 for a flywheel/ignition repair at a Kia dealership. When I dropped off the vehicle for that repair, I specifically reported abnormal oil consumption and requested it be checked. Kia did not diagnose or remedy the concern. The combination of: -Complete oil loss -No warning indicators -Sudden loss of power and inability to accelerate...

I tried to open the sunroof and it made a loud "popping" sound then would not close. I took it to the Kia Service center in SC (Fred Anderson Kia Greenville, SC)and the tech informed me this would be a $7000 fix. They also informed me to report this incident since they have also had numerous sunroof issues with this make and model. KIA also released a technical service bulletin " This bulletin provides information to perform a partial replacement of the sunroof wind deflector and mechanism arms on some 2019-2022MY Telluride (ON) vehicles produced from February 15, 2019 through January 19, 2022. The affected vehicles may experience the sunroof open/close operation inoperative and/or the sunroof wind deflector function inoperative. " A this is a known defect, this should be issued recall as it could result in sunroof glass break, causing injury to drivers, passengers.

The trim pieces on the outside of the doors are not properly on and are flapping.

I opened up my sunroof it became lodged, sideways and cracked

While driving at highway speed, The moon roof cracked and blew outward with out any reason.

I drive a Kia Telluride and while driving down the highway two pieces of plastic fell down into the passenger seat. Next the window flew up into the air. I had to physically hold the window down while driving with children in the back seat. No warranty will cover the sunroof and I was quoted $6000 to fix it. Upon searching this information I found that this has happened to multiple people and Kia is not trying to fix it. I spent all of my savings on this car to be able to transport my family safely. This did not happen.

Sunroof fails to close. Problem is known as there are multiple reports stating that the sunroof deflector breaks within a few years on Kia Telluride. Vehicle cannot be driven as you cannot lock the vehicle when a window is open/weather impacts drive-ability..

The rear frame of my 2021 Kia Telluride has a broken weld. This is a structural failure that compromises the safety and integrity of the vehicle. The Kia dealership mechanic who inspected it confirmed the weld was defective and also stated they have heard other Tellurides with the same issue. A broken frame weld poses a serious risk to vehicle occupants in the event of a crash and may affect handling, towing, and long-term durability. This appears to be a recurring defect and should be investigated as a potential safety hazard. After several trips to the dealership, for the loud metal to metal type bang, they have replaced struts, rear stab links and shock absorbers. On 9/17/2025 the mechanic was given a list of items to inspect and the dealership informed me that one of the items on the list was to check the frame welds. I was informed that...

ON SUNDAY, AUGUST 31, AT APPROXIMATELY 12PM, I WAS DRIVING SOUTH ON UNION BLVD., COLORADO SPRINGS, CO, BETWEEN ACACIA DR. AND CIRCLE DR., WHEN I HEARD A LOUD EXPLOSION COMING FROM MY ROOF. I DID NOT FEEL ANYTHING HIT MY CAR AND DID NOT SEE ANYTHING OR ANYBODY THAT COULD BE RESPONSIBLE FOR THE LOUD SOUND. I DROVE TO A SAFE PLACE AND GOT OUT OF MY CAR TO DISCOVER A HOLE IN AND SHATTERED GLASS FROM MY SUNROOF. FORTUNATELY, THE SUNSHADE WAS CLOSED, KEEPING THE GLASS FROM FALLING INTO MY CAR AND DAMAGING ITS INTERIOR OR HURTING ME. IT WAS A CLEAR 74-DEGREE DAY WITH NO TRAFFIC IN FRONT, OR TO EITHER SIDE OF ME. THERE WAS NO INDICATION THAT SOMETHING HIT THE SUNROOF. -WHAT FAILED OR MALFUNCTIONED: THE SUNROOF. -HOW WAS MY SAFETY PUT AT RISK: HAD THE SUNVISOR BEEN OPENED, SHATTERED GLASS COULD HAVE HURT OR CAUSED...

My sunroof won't open anymore

Sunroof has failed to close. A sunroof that does not close 1. Could allow for build up of moisture within the the vehicle causing mold which could cause respiratory issues. 2. An open sunroof could lead to theft of the vehicle The dealer has stated that sun roof fell off the track and will need to replaced. The Kia dealer completed a diagnostic review. There were no warnings

Tried to open sunroof and it would not open. Seems to be a common issue on 20-22 tellurides. Please make this a recall so people don’t have to pay out of pocket for a repair, like the dealership is telling me.

I was driving at approximately 65-70 mph on the freeway at around 7:40 AM when the sunroof glass spontaneously exploded above me. The sound was terrifying...literally like an explosion or gunshot going off. Thankfully, I did not jerk the wheel at this high speed from the scare and the sunroof shade was closed, preventing glass shards from falling on top of me. The sunroof was not hit by any debris and was not near any large trucks, so it was a huge surprise when it happened.

The sunroof button is defective. It allows both the “vent” and “slide open” functions to activate at the same time, which should not be mechanically possible. This causes the sunroof to jam and break the track system. It’s a design flaw that leads to physical damage and could easily become a safety issue if the sunroof fails while driving or during a storm. This needs to be addressed before more owners end up with broken hardware from a faulty control system.

The sun roof exploded driving on a busy interstate highway, fortunately the sun visor was closed otherwise we and our dogs would have been wearing the glass. Lots of glass coming off the roof on cars behind us. Dealer has confirmed other failures. Dealer is servicing now at no charge. No warning of this failure and should be a recall as many of these early model KIA Tellurides have this issue.

My wife was driving with my kids when there sounded like an explosion and the sunroof exploded. There was nothing around that hit the glass and we haven't been involved in any accidents that may have compromised the integrity of the glass. The sound sounds like an explosion and luckily when it scared my wife while driving, she didn't jerk the wheel and flip the vehicle. Also, thankfully the sunroof shade was closed otherwise glass would have exploded everywhere inside the vehicle hitting my kids and wife. It appears that it explodes up and in the middle of the sunroof by looking at how the glass was missing. It seems this is a common occurrence with the 2021 kia telluride. There's no warning, no cracking, no signs of it going to bust; it just does it. I'm going rounds with Kia to get it fixed but the keep sending me...

Upon attempting to open the sunroof, a loud pop was heard on opening and sliding backward, and it was determined the air deflector arm had broken. The sunroof will not fully close nor fully open now, it is stuck partially open. The dealer confirmed the issue and has to order the part with no idea on ETA to get it. The vehicle inside is exposed to the elements when driving and the rear of the sunroof is elevated which is a risk to objects.

I let the sunroof back and it pretty instantly snapped and a piece of the traction for the sunroof broke off. I don’t use the sunroof often (maybe 6 times total since buying the car). I let it back occasionally to make sure it doesn’t stop working from use. Now the back of the sunroof is titled upwards and will not close.

Vibration at highway speeds Most noticeable when accelerating up an incline at around 70-77mph car vibrated strongly. Had tires balanced and after few days problem persisted. Vibration was not as strong with balanced tires but still noticeable. To reduce vibration I have had to reduce speed and move to slower lanes.

Opened sunroof and arm popped out/off track. Sunroof is stuck open.

I have a well-maintained 2021 Kia Telluride, however the paint on the roof of the car is peeling off. In my research, I have found that many owners are experiencing the same issue especially in SNOW PEARL WHITE color. I have contacted my local dealership but they are refusing to address the issue and have quoted me $2,470.74 to repaint the roof. I've had vehicles for decades and never had paint issues.

The sunroof, which is hardly used, opened and will not close. It has gone off of the track.

I’ve taken my vehicle to Kia a few times about my transmission sputtering and the first time they told me I needed a transmission flush, I paid $250.00 to have it done just to have it continue to happen and every time I bring it there they say they aren’t seeing or feeling anything. It’s still doing it. Also I opened my sunroof and it hasn’t been used much since I bought it in 2022 and now it’s stuck open. Took to the dealer just for them to tell me I have to pay $140 diagnosis fee and my warranty most likely won’t cover to fix it. I purchased the platinum bumper to bumper warranty!

Opened the sunroof today for the first time in over a year. The sunroof opened with no problem. Tried to close sunroof, and it will not close all the way. Tried multiple times to open and close without success.

The pearl white paint on my vehicle started to delaminate (confirmed by Wallace Kia Collision center). It started at approximately 24,000 miles, approximately 9 months past Kia's 3 year paint warranty. This is a known issue with the paint - pearl white, with many manufacturers affected. Kia, thus far, has refused to cover the repair.

While driving, opened sunroof and it got off track and exploded the sunroof.

Sunroof Deflecter broke. The small side arms plastic snapped on both sides. Sunroof won’t close flush.

Was opening the sunroof and heard a popping sound. Wind deflector arm broke and now the sunroof will not close all the way leaving the risk of interior of car getting wet and creating mold since I live in an already humid climate.

I have it so the doors do not automatically unlock when I arrive somewhere. When I arrive at a destination and put the car in park, the people in the backseat cannot pull the handle to get out. If the child safety lock (which is a button on the door handle with the window and lock buttons) is ON, the back windows and the door latches do NOT work. If the child safety lock is OFF, the windows work but the door still cannot be opened using the latch. This seems like a safety issue to me, since most people will reach for the latch in an emergency, but they can't get out. I have to push the unlock button form the driver door. If it is pushed on the front passenger door, it will not unlock the back doors.

Sunroof is stuck open. Some plastic has broken off inside the track while simply opening the sunroof. It cannot be closed. The dealer said 'sorry we can't close it. For $4,000 we can replace the entire sunroof". This is a safety issue. I have seen on other forums this happening a lot with this model. The glass can shatter, it can fly off the tracks. This is clearly a mfg issue and not an user issue. It should be recalled or at the very least warrantied.

The sunroof will not close. Kia published a technical service bulletin (#319) in July 2023 related to this issue. The plastic wind deflector and track appear to have broken. We are unable to drive the vehicle due to inability to close (electronically or mechanically) the sunroof during any inclement weather.

The barely used sunroof made a clicking noise, and now will not open or close. It looks askew and now cannot drive in inclement weather. There seem to be many people with this issue when you google it online and deserves a recall. Thanks.

I closed the sunroof and heard a noise. The sunroof would not close and looks to have came out of the track. Now it is stuck partially open. I am not able to drive in the rain. I have tried to self diagnose and it looks like the bug deflector broke and caused the sunroof to misalign.

I don’t ever use my sunroof but noticed it was slightly open bc I saw light coming through. I tried to close it and it came off it’s track on one side. Given that the vehicle has had several recalls having to do with electronic features causing fires, I worry about this issue causing a fire. Also, it’s unsafe to drive during a storm.

We were driving down Hwy 321 going approximately 65 mph and the sunroof just exploded. There were no other vehicles close for it to be hit my a rock. It sounded like a gunshot and glass went everywhere. Very dangerous and scary!

Sunroof jammed open and was unable to be closed. There were no warning lights associated with this issue. I took the sunroof apart and found the bug deflector springs wedged themselves in the sunroof track, causing it to overload itself and break its mechanism.

The panoramic sunroof hinges on my vehicle snapped and a part of the assembly fell and hit me in the head while I was driving.

The vehicle had approx 10k miles and I simply tried to open the sunroof before leaving my driveway and something snapped. The Sunroof was then stuck in the open position, I could not close it. I called my regular dealership for help as it was under warranty and practically new. The dealership said they are too busy to help me, I have no garage and there was rain in the forecast. I called other dealerships and was able to find one who would take it in for a look. I was told it might take a few days and left the car. After a few days the dealership said they needed to order parts, that the entire sunroof track has to be replaced and it may take weeks. They were able to close the roof and I picked up the car, I had to take it back as wind was...

My sunroof hinges cracked and my sunroof will not close

The sunroof wind deflector broke while closing the sunroof while parked. This dislodged the sunroof mechanism from its tracks and prevents the sunroof from closing.

I am concerned with the solution to the vehicle recall. After taking care of the recall . You now have to disengage the parking break before driving the vehicle. What damage is happening if you do not do this or what potentially could happen if you do not disengage in the long run. Why was the engine not replaced?

Sunroof will not close. Arm malfunctioned. Taken to local dealer and awaiting instructions on further steps.

Sunroof exploded while driving on the highway.

Sunroof on Kia Telluride will not close completely. Will begin closing and then will not set down into the closed position.

Windshield cracked sitting in driveway for no reason, nothing that impacted it.

On Saturday, [XXX], while driving my 2021 Kia Telluride [XXX} from Laredo to San Antonio, Texas, my husband (passenger) and I (driver) heard a loud, explosion-like sound. This made me swerve onto the other traveling lane. Thank God there were no vehicle near us or next to us because it would have been catastrophic. We quickly realized that our sunroof had exploded/shattered as we could hear all the shattered glass being blown away. Luckily, the sliding sunroof panel was closed and no glass went inside our vehicle. These must definitely get investigated since it is a public safety issue. Upon doing research, we learned that there are several other people that have experience this same issue with Kia Tellurides and it’s windshield/sunroof quality. I note that there was no vehicles near us and we were traveling 75 mph. Kia needs to recall this ASAP before there is a fatality! INFORMATION...

We were driving on the highway and the sunroof was partially open in the angle as a wind deflector. When the sunroof made a pop noise and started flapping in the wind, we were so concerned that the sunroof is gonna come flying off and hit a car behind us. We end up taping it down and taking it to Kia of Daytona or they told us it was $5000 to repair, they had said the mechanism that holds the window up a plastic finger broke. Apparently they do not manufacture a quality product for something so crucial as such a sunroof, we were so fearful that the sunroof glass part was gonna fly out. We had to drive from Jacksonville, all the way to Daytona, with a flapping in the wind.