2006 KIA SORENTO Engine Problems

SYSTEM WAS IN THE SHOP FOR ROUTINE MAINTENANCE I.E. NEW SPARK PLUGS, DRIVE BELTS, AND SPARK PLUG WIRES. PICKED UP THE VEHICLE AND DROVE FINE FOR A DAY. UPPER CAT CONVERTER GOT CLOGGED... THINGS JUST WENT DOWN HILL FROM THERE. CRANKSHAFT SEAL BUSTED, OIL PUMP FAILED, WATER PUMP HAD TO BE REPLACED. ENGINE RODS STARTED KNOCKING. ENGINE HAS TO BE REBUILT. HAVE BEEN UNABLE TO DRIVE MY SORENTO SINCE MARCH 2013. BOUGHT THE SORENTO IN OCTOBER 2012. JUST HAD THE SORENTO IN THE SHOP FOR ENGINE REBUILD. HAD MONEY SET ASIDE FROM TAX RETURNS. I PAID THE ORIGINAL QUOTED AMOUNT TO HAVE THE REBUILD DONE. IT IS COSTING ME $2000 IN ADDITION TO THE BASE COST THAT WAS ORIGINALLY QUOTED. I DON'T HAVE THAT KIND OF MONEY JUST LAYING AROUND FOR THOSE TYPES OF REPAIRS. OH WELL... GUESS I WON'T BE DRIVING MY CAR FOR ANOTHER WHOLE YEAR. OH... ONE...

TL* THE CONTACT OWNS A 2006 KIA SORRENTO. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE VEHICLE STALLED AS THE CHECK ENGINE WARNING LAMP ILLUMINATED. THE CONTACT MENTIONED THAT ONCE THE VEHICLE STALLED, HE LOST CONTROL OF THE STEERING WHEEL AND CRASHED INTO A TREE. A POLICE REPORT WAS FILED AND NO INJURIES WERE REPORTED. THE VEHICLE WAS TAKEN TO THE DEALER BUT THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 106,000.

2006 KIA SORENTO COMPLAINT: ENGINE , STEERING, ELECTRICAL SYSTEM , EXTERIOR LIGHTING ,THROTTLE POSITION SENSOR I AM CHANGING THE HEAD LIGHTS EVERY 4-5 MONTH AND I THINK IT NEEDS TO BE LOOKED AT. WAS DRIVING 35 MPH WHEN THE ENGINE LIGHT AND BRAKE LIGHT CAME ON WITH NO WARNING. AND JUST LAST WEEK 2/2/2014 THE ENGINE STOPPED AND I HAD NO POWER STEERING AND ALSO NO BRAKES. I WAS ABLE TO COAST TO A SIDE ROAD AND BARELY GOT THE VEHICLE TO STOP. THE VEHICLE WAS TAKEN TO AN MECHANIC, WHO DIAGNOSED AND HAD TO REPLACE A THROTTLE POSITION SENSOR AND A MASS AIR FLOW METER AND AIR FILTER AND THE HARMONIC BALANCER. THIS IS CRAZY THESE PROBLEMS AND REQUIRES EXTENSIVE AND EXPENSIVE REPAIR TO THE ENGINE. THIS INDICATES TO US A MANUFACTURER'S DESIGN FLAW AND PROBABLE SAFETY ISSUE THAT SHOULD BE ADDRESSED BY KIA WORLDWIDE. IT'S DISTURBING WITH HOW...

WIFE WAS DRIVING 40 MPH WHEN THE ENGINE LIGHT AND BRAKE LIGHT CAME ON WITH NO WARNING. THE ENGINE STOPPED AND SHE HAD NO POWER STEERING AND ALSO NO BRAKES. SHE WAS ABLE TO COAST TO A SIDE ROAD AND BARELY GOT THE VEHICLE TO STOP. THE STEERING WAS VERY DIFFICULT. IF IT WOULD HAVE BROKE ANOTHER 200 FEET AHEAD SHE WOULD NOT HAVE BEEN AS LUCKY SINCE THERE IS A VERY SHARP AND DANGEROUS CURVE. THE CURVE HAS A SINGLE GUARD RAIL THAT SHE MORE IN LIKELY WOULD HAVE WENT THROUGH RESULTING IN A 400 FOOT DROP DOWN A STEEP HILL. POSSIBLY RESULTING IN A FATAL CRASH.THE VEHICLE WAS TOWED TO COUGHLIN KIA DEALERSHIP IN NEWARK OHIO. WE WERE INFORMED THAT THE CRANKSHAFT BOLT HAD BROKE IN THE MOTOR. THIS CAUSED THE TIMING PULLING AND MAIN PULLEY TO BREAK OFF. THE RESULT WAS MAJOR ENGINE DAMAGE.THE SERVICE MANAGER CONTACTED...

WE ARE THE ORIGINAL OWNERS OF THIS VEHICLE.THE ENGINE SHUTS DOWN-QUITS AT ANY SPEED (EVEN IDLE) LAST TIME AT 60 MILES AN HOUR ON THE FREEWAY. LUCKILY WAS ABLE TO GET TO THE SHOULDER W/O BEING REAR ENDED. THE VEHICLE REFUSED TO START FOR ABOUT 10 MINUTES. THEN I GOT IT STARTED AND RAN ROUGH A COUPLE OF MINUTES THEN CLEARED UP THE REST OF THE WAY. ANOTHER OCCASION THE ENGINE QUIT IN THE MIDDLE OF AN INTERSECTION IN 5:00 TRAFFIC, CAUSING BAD CONJESTION. THE ENGINE LIGHT IS TRIGGERED OCCASIONALLY BUT NO REPAIR CODES ARE SEEN WHEN THE COMPUTER IS HOOKED UP. THIS IS HAPPENING ABOUT EVERY 3 -4 DAYS AND MAYBE 2 X'S IN A DAY. THIS HAS HAPPENED EVER SINCE THE DEALER CHANGED THE TIMING BELT-REGULAR MAINTENENCE ABOUT 80,0000 MI. THE VEHICLE WAS RUNNING AND SOUNDING JUST GREAT BEFORE THE KIA DEALER DID THIS. ON THE WAY HOME,...

I WAS MERGING ONTO A HIGHWAY WHEN ALL OF A SUDDEN I HEARD A LOUD THUD AND MY BATTERY LIGHT & E BRAKE LIGHT CAME ON AND I LOST POWER STEERING. I WAS ABLE TO DRIVE THE VEHICLE TO A LOCAL MECHANIC WHO INFORMED ME THAT THE HARMONIC BALANCER HAD FALLEN OFF DUE TO THE CRANKSHAFT BOLT SHEARING OFF. ONCE IT WAS FIXED BY AN ASE CERTIFIED MECHANIC, APPROXIMATELY 8000 MILES LATER I WAS DRIVING TO WORK AND THE CAR STARTED SHAKING LIKE I WAS DRIVING ON RUMBLE STRIPS. I TOOK IT BACK TO A SERVICE GARAGE AND AFTER REPLACING THE HARMONIC BALANCER AND CRANKBOLT AGAIN THEY CAME TO THE CONCLUSION THAT THE CRANKSHAFT WAS BENT. THE GARAGE SUGGESTED REPLACING THE ENTIRE CRANKSHAFT AND BALANCER AND THEN HAVING THE ENGINE REBALANCED OR A COMPLETE ENGINE REPLACEMENT BOTH OF WHICH ARE GREATER THAN $3500 TO REPAIR ON A VEHICLE THAT'S WORTH...

TL* THE CONTACT OWNS A 2006 KIA SORENTO. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE BRAKE AND BATTERY LIGHTS ILLUMINATED AS THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART MOMENTS LATER. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT A BOLT IN THE CRANK SHAFT WAS FRACTURED AND THE ENGINE WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 99,440. 8/26/13 *CN THE CONSUMER ALSO STATED THE BELTS AND CRANK PULLEY BROKER

FROM 9/2011 TO 7/2013 MY 2006 KIA HAS HAD THIS PROBLEM 3 TIMES AND IS CURRENTLY IN THE SHOP. WHILE DRIVING I HEAR A WEIRD NOISE AND THEN ALL THE DASHBOARD WARNING LIGHTS COME ON AND I LOSE POWER STEERING. WHEN CHECKING UNDER THE HOOD, THE BELTS HAVE ALL FALLEN OFF, A PULLEY IS LAYING UNDER ENGINE AS IS A BOLT. THE LAST TIME THE BOLT HAD BROKEN OFF CAUSING THE PULLEY TO FALL OFF. MECHANIC FOUND THAT THE CRANKSHAFT SPROCKET WAS BROKEN. I'M NOT SURE ABOUT TODAY AS THE CAR IS AT THE SHOP WITH THE BOLT LAYING UNDER THE ENGINE, BUT THE DRIVE PIN THAT GOES INTO THE SPROCKET OF THE PULLEY FELL OUT THE BOTTOM WHEN BEING LIFTED ONTO THE TOW TRUCK. *TR

I WAS DRIVING AND NOTICED THE 4-WHEEL LIGHT CAME ON. I STOPPED THE CAR AND WAITED A FEW MINUTES. WHEN I TURNED THE CAR BACK ON IT WAS MAKING A NOISE. UPON FURTHER INVESTIGATION, I FOUND THE CRANKSHAFT VERY LOOSE. THE CAR IS PRESENTLY AT THE REPAIR GARAGE AWAITING AN ESTIMATE. *TR

MY 22 YEAR OLD DAUGHTER WAS DRIVING THE CAR AT COLLEGE WHEN IT SUDDENLY LOST POWER STEERING AND THEN SHUT DOWN IN TRAFFIC IN THE MIDDLE OF AN INTERSECTION. LUCKILY SHE WAS NOT ON A CURVY ROAD WHEN THE POWER STEERING WENT OUT. WE HAD THE CAR TOWED AND AFTER MECHANIC'S INSPECTION WERE TOLD THAT THE CRANKSHAFT BOLT "WOBBLED" LOOSE AND DISRUPTED THE TIMING BELT ASSEMBLY SHUTTING DOWN THE ENGINE. THIS $2 BOLT HAS CAUSED AN ESTIMATED $3500 REPAIR BILL OR EVEN AN ENGINE REPLACEMENT. OUR RESEARCH HAS UNCOVERED TO US THAT THIS IS A COMMON PROBLEM WITH THIS 3.5L ENGINE. THIS BOLT EITHER BREAKS OR WOBBLES OUT OF IT'S THREADING TO CAUSE TIMING BELT PROBLEMS AND REQUIRES EXTENSIVE AND EXPENSIVE REPAIR TO THE ENGINE. THIS INDICATES TO US A MANUFACTURER'S DESIGN FLAW AND PROBABLE SAFETY ISSUE THAT SHOULD BE ADDRESSED BY KIA WORLDWIDE. *TR

TL* THE CONTACT OWNS A 2006 KIA SORENTO. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE MOTOR PULLEY FAILED ON THE ENGINE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CURRENT AND FAILURE MILEAGE WAS 78,000.

TL* THE CONTACT OWNS A 2006 KIA SORENTO. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE ALTERNATOR, BRAKE AND TEMPERATURE WARNING LIGHTS ILLUMINATED AND THE POWER STEERING FAILED. THE VEHICLE WAS MOVED TO THE SHOULDER. UPON INSPECTION, THE CONTACT NOTICED THAT THE CRANKSHAFT BOLT FRACTURED AND CAUSED THE FAN BELT AND THE WATER PUMP TO BECOME INOPERABLE. THE VEHICLE WAS NOT TAKEN TO A MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND ADVISED THE CONTACT TO TAKE THE VEHICLE TO THE DEALER FOR DIAGNOSTICS. THE FAILURE MILEAGE WAS 83,500. UPDATED 3/20/13 *CN THE CONSUMER STATED THE ALTERNATOR AND ENGINE LIGHTS ILLUMINATED AND THE POWER STEERING FAILED. THE CRANK SHAFT BOLT BROKE AND CAUSED THE STEERING DAMPER TO SHIFT SIDEWAYS, WHICH CAUSED THE TWO BELTS ON THE DAMPER PULLEY TO BE THROWN OFF.

TL* THE CONTACT OWNS A 2006 KIA SORENTO. THE CONTACT STATED WHILE TRAVELING 40 MPH THE ALL OF THE WARNING LIGHTS ON THE INSTRUMENT PANEL ILLUMINATED. WHEN THE POWER STEERING MALFUNCTIONED THE BRAKES FAILED TO STOP THE VEHICLE WHEN THEY WERE APPLIED. THE CONTACT MERGED ONTO THE EMERGENCY LANE; HOWEVER, HE WAS ABLE TO CONTINUE DRIVING TO HIS DESTINATION WHERE THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTIC TESTING. THE DEALER CONFIRMED THAT THE BOLT TO THE HARMONIC BALANCER FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED. THE FAILURE AND CURRENT MILEAGE WERE 59,800. UPDATED 10/02/12*LJ

TL* THE CONTACT OWNS A 2006 KIA SORENTO. THE CONTACT STATED WHILE DRIVING 40 MPH THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO PULL TO THE SIDE OF THE ROAD AND ATTEMPTED TO RESTART THE VEHICLE BUT THE VEHICLE WOULD NOT TURN OVER. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHO SUGGESTED THE CONTACT TAKE THE VEHICLE TO AN AUTHORIZED DEALER. THE VEHICLE WAS THEN TOWED TO THE DEALER WHO STATED THAT THE CRANK SHAFT BOLT WAS FRACTURED, AS WELL AS THE PUSH RODS. THE DEALER ADVISED THAT THE ENGINE NEEDED TO BE REPLACED. THE CONTACT DID NOT HAVE THE ENGINE REPLACED. THE FAILURE MILEAGE WAS 46,400.

DRIVING 65MPH ON TURNPIKE HEARD A LOUD SCREECHING NOISE BRAKES WERE HARD TO APPLY STEERING WAS DIFFICULT AND DASH BOARD LITE UP PULL TO THE SIDE OF THE ROAD AND WAS TOWED TO THE NEAREST KIA DEALERSHIP TO BE TOLD THAT CRANK SHAFT BOLT BROKE. AT 60000 MILES WE DID THE REQUIRED MAINTENANCE TO THE TUNE OF 663.65 AND HAD THE TIMING BELT REPLACED. THERE WAS ALSO A MEMO TO THE DEALERSHIPS TO REPLACE THE BOLT WHEN REPLACING THE TIMING BELT. ACCORDING TO MY ITEMIZED STATEMENT THE BOLT WAS NOT REPLACED. I FEEL THIS SHOULD BE COVERED SINCE I FOLLOWED THE RULES AND GOT THE REQUIRED SERVICE THEY WERE NEGLIGENT NOT REPLACING THE BOLT. HOWEVER THEY REFUSE TO ACCEPT RESPONSIBILITY FOR THERE MISTAKE. NOW I AM STUCK WITH A CONSIDERABLE BILL. *TR

TL* THE CONTACT OWNS A 2006 KIA SORENTO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THE ENGINE STALLED WITHOUT PRIOR WARNING. THE ENGINE RESTARTED AFTER WAITING A FEW MOMENTS. THE FAILURE OCCURRED TWO TIMES. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 64,000.

AT 60,000 MILES TOOK MY 2006 SORENTO IN FOR MANUFACTURER'S RECOMMENDED SERVICE - CHANGE TIMING BELT AND NEW PLUGS, ETC., NEVER HAD A PROBLEM BEFORE THEN. GOT THE SUV BACK FROM MECHANIC AND THE FOLLOWING DAY, THE BELTS CAME OFF, LOST POWER, OVERHEATED. CRANK SHAFT BOLT CAME LOOSE. NOW AT 82,290 MILES, BOLT BROKE, HARMONIC BALANCER CAME LOOSE AND CHEWED UP THE END OF THE CRANKSHAFT. $3200 FIX. SUV HAS BEEN IN SHOP FOR 5 WEEKS AND WILL REMAIN THERE FOR AT LEAST 5 MORE UNTIL I CAN GET THE MONEY TO FIX IT. KIA SHOULD RECALL THIS MODEL AS WELL, THEY ALREADY RECOGNIZED THE PROBLEM IN 2003 AND 2004 MODELS. I AM A SINGLE MOM, RAISING BOYS WITHOUT THE BENEFIT OF CHILD SUPPORT OR ANY OTHER HELP. KIA SHOULD STAND BEHIND THEIR WORKMANSHIP!